Vetus M4.15 SOLAS Bedienungsanleitung

Operation manual

M4.15 M4.17

M4.15

M4.17

340202.03

Operation manual

Please enter the serial numbers here.

These numbers should be quoted when inquiring about Customer

Service, Repairs or Spare Parts (see page 6).

We reserve the right to make any changes without previous

notice.

Serial numbers

Engine serial number Vetus:

Mitsubishi:

Gearbox serial number:

Please read and observe the information given in this operation

manual. This will enable you to avoid accidents, preserve the

manufacturer’s warranty and maintain the engine in peak operat-

ing condition.

For the Guarantee Conditions, see the Vetus Diesel Service and

Warrantee Manual.

This engine has been built exclusively for the application speci-

fied in the scope of supply and is to be used only for the intended

purpose. Any use exceeding that scope is considered to be

contrary to the intended purpose. The manufacturer will not not

assume responsibility for any damage resulting therefrom. The

risks involved are to be borne by the user.

Use in accordance with the intended purpose also implies com-

pliance with the conditions laid down by the manufacturer for

operation, maintenance and servicing. The engine should only

be operated, maintained and serviced by persons which are

familiar with the former and the hazards involved.

The relevant accident prevention guidelines and other gener-

ally accepted safety and industrial hygiene regulations must be

observed.

Unauthorized engine modifications will invalidate any liability

claims against the manufacturer for resultant damage.

Manipulations of the injection and regulating system may also

influence the performance of the engine, and its emissions.

Adherence to legislation on pollution cannot be guaranteed

under such conditions.

Serial numbers 1

1 Introduction 4

2 Engine description

General 6

Identification of engine parts 8

Control panels 10

3 Use

General guidelines 11

First commissioning 12

Running-in 15

Starting 16

(Pre-heating) 17

Cruising 19

Stopping 20

4 Routine maintenance

Introduction 21

Maintenance schedule 22

5 Maintenance

Checking the oil level 23

Checking the coolant level 24

Checking and cleaning the

raw water strainer 25

Draining water from the water

separator/fuel filter 26

(Bleeding) 26

Changing the oil 28

Battery, cables and cable

connections 30

Checking the gearbox oil level 32

Changing the gearbox oil 33

Checking valve clearance 34

Replacing the fuel filter 36

Cleaning fuel lift pump 37

Checking the V-belt 38

Checking flexible engine mounts 39

Checking hose connections 39

Checking fastenings 39

Checking the raw water pump 40

Coolant replacement 42

Cleaning the heat exchanger 44

Checking engine rpm 47

6 Winter lay-up

Winter storage procedure 48

Recommissioning after winter

storage 51

7 Troubleshooting 54

8 Technical Data 60

9 Operating media

Lubrication Oil 63

Fuel 64

Coolant 65

10 Wiring Diagrams 66

11 Overall Dimensions 68

Contents

Dear customer,

Vetus diesel engines are designed both for pleasure and com-

mercial craft. Consequently, a wide range of variants are offered

to meet the requirements of specific cases.

Your engine is appropriately equipped for your vessel, which

means that not necessarily all components described in this

manual are mounted to your engine.

We have endeavoured to highlight any differences so that you

will able to locate the operating and maintenance instructions

relevant to your engine quickly and easily.

Please read this manual before starting your engine and always

observe the operating and maintenance instructions.

We are available to help with any additional inquiries.

Sincerely,

Vetus n.v.

Introduction

Safety measures

Introduction

All safety instructions in this manual are desig-

nated by the accompanying symbol. Please follow

them carefully.

Pass the safety instructions to other persons operating the

engine as well.

General regulations and laws for safety and accident prevention

must also be observed.

• Neverattempttotouchmovingpartswhentheengineisrun-

ning.

• Never touch hot parts of the engine, and keep flammable

materials well away from the engine.

• Alwaysstoptheenginebeforecheckingoradjustingcompo-

nents.

• Always stop the engine before checking or topping up the

coolant or oil.

•

Never

open cap on top of header tank when the engine is at

operating temperature.

• Alwayscarryoutmaintenancesafelybyonlyusingtoolswell

matched in size.

Engine data tag

The

vetus

engine serial number and per-

formance data are printed on the engine

data tag.

Model and engine serial number must be

given when ordering spare parts.

Engine data tag location

The

vetus

engine data tag is attached to

the valve cover.

Engine serial number

The

Mitsubishi

engine serial number is

stamped on the fuel injection pump.

Engine description General

VD01077 VD01048 VD01049

Cylinder numbering

Cylinders are numbered consecutively,

beginning at the front end.

Fuel pump seal

The manufacturer shall not be held liable

for damages resulting from adjustments

made to the fuel injection pump.

The maximum engine speed adjustment

screw has been sealed to prevent this.

Adjustments to the fuel pump

are to be carried out by author-

ized Vetus-Mitsubishi Service

specialists only.

General Engine description

VD00147 VD00145

Lead seal

Maximum

rpm adjust-

ment screw

1 Oil filler cap

2 Fuel pump air bleed nipple

3 Fuel supply pipe connection ø 8 mm

4 Fuel lift pump

5 Oil dipstick

6 Oil filter

7 Water separator/fuel filter drain plug

8 Water separator/Fuel filter

9 Gearbox filler cap

10 Gearbox oil dipstick

11 Electrical system connectoion box

12 Fuse

13 Fuel return pipe connection ø 8 mm

14 Water separator/fuel filter air bleed

nipple

15 Air inlet silencer

16 Manual operation of electric stop

17 Connection for throttle push-pull

cable

18 Cooling system air bleed nipple /

Connection for extra expansion

tank (Keel cooling model only)

19 Calorifier connection

20 Gearbox drain plug

21 Gearbox

Engine description Identification of engine parts

Service side

VD01050

Andere Handbücher für M4.15 SOLAS

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Vetus Motor Handbücher

Vetus

Vetus VF4.145 Installationshandbuch

Vetus

Vetus ELINE060 Bedienungsanleitung

Vetus

Vetus EP2200K Bedienungsanleitung

Vetus

Vetus EAIR050 48 VDC Bedienungsanleitung

Vetus

Vetus EAIR05024 Bedienungsanleitung

Vetus

Vetus m3.10 Bedienungsanleitung

Vetus

Vetus VF4.170E Bedienungsanleitung

Vetus

Vetus ELPS Bedienungsanleitung

Vetus

Vetus M3.28 SOLAS Bedienungsanleitung

Vetus

Vetus EAIR05024 Bedienungsanleitung

Vetus

Vetus ELINE050 Bedienungsanleitung

Vetus

Vetus M2.02 Bedienungsanleitung

Vetus

Vetus BOW PRO Thruster BOWA0902 Bedienungsanleitung

Vetus

Vetus M Series Bedienungsanleitung

Vetus

Vetus VF4 Bedienungsanleitung

Vetus

Vetus ELINE080 Bedienungsanleitung

Vetus

Vetus EAIR04024 Bedienungsanleitung

Vetus

Vetus ELINE050 Bedienungsanleitung

Vetus

Vetus DT4.70 Bedienungsanleitung

Vetus

Vetus EP2200K Bedienungsanleitung

Vetus

Vetus DEUTZ DT44 Bedienungsanleitung

Vetus

Vetus ELINE050 Fehlerbehebungshandbuch

Vetus

Vetus M2.C5 Bedienungsanleitung

Vetus

Vetus EAIR04024 Bedienungsanleitung

Beliebte Motor Handbücher anderer Marken

Rotax

Rotax 125 senior MAX evo Bedienungsanleitung

Kohler

Kohler K361 Bedienungsanleitung

MTD

MTD OHV Series Bedienungsanleitung

Kohler

Kohler COMMAND CH18-745 Bedienungsanleitung

Mercury

Mercury D4.2L D-Tronic Bedienungsanleitung

Selve

Selve SE Plus-RC Series Bedienungsanleitung

Perkins

Perkins 1206E-E66TA Bedienungsanleitung

Skov

Skov DA 174 Handbuch

Rossi

Rossi TX11 Series Bedienungsanleitung

Siemens

Siemens SIMOTICS T-1FW3 Merkblatt

AL-KO

AL-KO PRO 350 Bedienungsanleitung

MTU

MTU 12 V 4000 Lx4 Bedienungsanleitung

Nanni

Nanni N3.30 Gebrauchsanweisung

Nanni

Nanni N5.160 CR2 Bedienungsanleitung

KSB

KSB SuPreme Series Montageanleitung

Hiwin

Hiwin EM1 Series Bedienungsanleitung

Rotax

Rotax 912 i series Betriebsanleitung

Siemens

Siemens SIMOTICS XP 1MB1 Bedienungsanleitung