Viking VSLT240-MH Bedienungsanleitung

Solar Light Tower

VSLT240-MH

OPERATION AND MAINTENANCE

MANUAL

This manual covers the following machines:

SN No. Production Date

Operating/Parts Information

You must be familiar with the operation of this machine before you attempt to

troubleshoot or repair it. Basic operating and maintenance procedures are

described in the Operator’s Manual supplied with machine. Keep a copy of the

Operator’s Manual with the machine at all times. If you are missing the

document, please contact us to order a replacement.

Damage caused by misuse or neglect of the unit should be brought to the

attention of the operator to prevent similar occurrences from happening inthe

future.

This manual provides information and procedures to safely repair and maintain

the S4 solar lighting tower. For your own safety and protection from injury,

carefully read, understand, and observe all instructions described in this

manual. THE INFORMATION CONTAINED IN THIS MANUAL IS BASED ON

MACHINES MANUFACTURED UP TO THE TIME OF PUBLICATION.

HARBINGER RESERVE THE RIGHT TO CHANGE ANY PORTION OF THIS

INFORMATION WITHOUT NOTICE.

Foreword

All rights, especially copying and distribution rights, are reserved.

No part of this publication may be reproduced in any form or by any means,

electronic or mechanical, including photocopying, without express written

permission from HarbinGer.

Any type of reproduction or distribution not authorized by maker HarbinGer

represent an infringement of valid copyrights, and violators will be prosecuted.

We expressly reserve the right to make technical modifications, even without

due notice, which aim at improving our machines or their safety standards.

Foreword

1. Safety Information

1.1 Operating Safety........................................................................................5

1.2 Towing Safety.............................................................................................6

1.3 Service Safety............................................................................................7

2. Control Box

2.1 Battery coulometer.....................................................................................8

2.2 Circuit breaker............................................................................................9

2.3 Solar panel charge and discharge controller..............................................9

2.4 Charging and discharging steps...............................................................10

2.5 Lift and Tilt button.....................................................................................10

2.6 Junction box and light cable.....................................................................11

3. Battery.......................................................................................................13

4. LED Light..................................................................................................14

5. Solar panel................................................................................................16

6. Mast...........................................................................................................18

7. Axle and Towing system..........................................................................20

8. Maintenance .............................................................................................22

9. Caution .....................................................................................................23

Table of Contents

1. Safety Information

This manual contains DANGER, WARNING, CAUTION, NOTICE and NOTE

callouts which must be followed to reduce the possibility of personal injury,

damage to the equipment, or improper service.

The followings are the safety alert words. It is used to alert you to potential

personal injury hazards. Obey all safety messages that follow this symbol to

avoid possible injury or death.

DANGER indicates a hazardous situation which,if not avoided, will result in

death or serious injury.

WARNING indicates a hazardous situation which, if not avoided, could result in

death or serious injury.

CAUTION indicates a hazardous situation which, if not avoided, could result in

minor or moderate injury.

NOTICE: Used without the safety alert symbol, NOTICE indicates a hazardous

situation which, if not avoided, could result in property damage.

Note: Contains additional information important to a procedure.

Safety Information

1.1 Operating Safety

WARNING: Familiarity and proper training are required for the safe operation

of the machine. Machines operated improperly or by untrained personnel can

be dangerous. Read the operating instructions carefully and familiarize

yourself with location and proper use of all controls. Inexperienced operators

should receive instruction from someone familiar with the machine before

being allowed to operate it.

1.1.1 The area immediately surrounding the Light Tower should be clean,

neat, and free of debris.

1.1.2 ALWAYS be sure the machine is on a firm, level surface and will not tip,

roll, slide or fall while operating.

1.1.3 NEVER start a unit in need of repair.

1.1.4 Lower the tower when not in use, or if high winds or electrical storms

are expected in the areas.

1.1.5 ALWAYS make certain the machine is well-grounded and securely

fastened to a good earthen ground per national and local regulations.

1.1.6 The tower extends up to 8.5m(27.9ft.). Make sure the area above the

trailer is open and clear of overhead wires and obstructions.

1.1.7 Keep the area behind the trailer clear of people while raising and

lowering the mast.

1.1.8 The trailer must be leveled and the outriggers extended before raising

the tower. The outriggers must remain extended while the tower is up.

1.1.9 If for any reason any part of the mast hangs up or the cable develops

slack while raising or lowering the tower, STOP immediately!

1.1.10 NEVER remove the mast locking pin while the tower is up!

1.1.11 NEVER use the machine if the insulation on the electrical cord is cut

or worn through.

1.1.12 NEVER operate the lights without the protective lens cover in place or

with a lens cover that is cracked or damaged!

1.1.13 NEVER adjusts the mast while the unit is operating.

1.1.14 NEVER raise the mast or operate the machine in high winds.

Safety Information

1.2 Towing Safety

WARNING: Towing a large trailer requires special care. Both the trailer and

vehicle must be in good condition and securely fastened to each other to

reduce the possibility of an accident.

1.2.1 ALWAYS check that the hitch and coupling on the vehicle are rated

equal to, or greater than, the trailer’s “gross vehicle weight rating”(GVWR).

1.2.2 ALWAYS inspect the hitch and coupling for wear or damage. DO NOT

tow the trailer using defective parts.

1.2.3 ALWAYS make sure the coupling is securely fastened to the vehicle.

1.2.4 ALWAYS check the tires on the trailer for tread wear, inflation, and

condition. Replace worn tires.

1.2.5 ALWAYS connect the safety chains.

1.2.6 ALWAYS make sure directional and trailer lights are connected and

working properly.

1.2.7 ALWAYS check that the lug nuts holding the wheels are tight and that

none are missing.

1.2.8 The maximum recommended speed for highway towing is 72km/hour

(45MPH). Recommended off-road towing speed is not to exceed 16 km/hour

(10MPH) or less depending on terrain.

1.2.9 ALWAYS refer to the applicable Department of Transportation

regulations before towing.

Safety Information

1.3 Service Safety

Only a qualified electrician should troubleshoot or repair electrical problems

occurring with this equipment.

1.3.1 ALWAYS replace the safety devices and guards after repairs and

maintenance.

1.3.2 Before servicing the Light Tower, make sure the circuit breakers are

open(off), and the negative terminal on battery is disconnected. NEVER

perform even routine service(hydraulic oil changes, cleaning, etc.) unless all

electrical components are shut down.

1.3.3 DO NOT allow water to accumulate around the base of the machine. If

water is present, move the machine and allow the machine to dry before

servicing.

1.3.4 DO NOT service the machine if your clothing or skin is wet.

1.3.5 ALWAYS keep the machine clean and labels legible. Replace all

missing and hard-to-read labels. Labels provide important operating

instructions and warn of dangers and hazards.

1.3.6 ALWAYS make sure slings, chains, hooks, ramps, jacks and other

types of lifting devices are attached securely and have enough weight-bearing

capacity to lift or hold the machine safely.

Always remain aware of the location of other people around when lifting the

machine.

1.3.7 Always turn off the light circuit breakers before disconnecting the light

fixtures or changing the light bulbs.

Safety Information

2. Control Box

2.1 Battery coulometer

2.1.1 Connection of coulometer.

We can accurately get the battery capacity information through the parameters

on the coulometer.

Control Box

2.2 Circuit breaker

2.2.1 Solar panel charging control circuit breaker.

We can use this circuit breaker to control whether the solar panels charge the

batteries.

2.2.2 Battery discharge control circuit breaker.

We can use this circuit breaker to control whether the batteries supply power to

the load.

2.2.3 LED light switch control circuit breaker.

We can use this circuit breaker to control the lighting on and off of the LED

lights.

2.3 Solar panel charge and discharge controller

2.3.1 Charging controller wiring system

Control Box

Inhaltsverzeichnis

Andere Viking Solarpanel Handbücher

Viking

Viking L50 Bedienungsanleitung

Beliebte Solarpanel Handbücher anderer Marken

Navitron

Navitron HFC-2 Bedienungsanleitung

AXITEC

AXITEC 60-CELL Bedienungsanleitung

thermital

thermital TSOL 20 N BLU Bedienungsanleitung

AZO Digital

AZO Digital MPPT-3000 Bedienungsanleitung

Clenergy

Clenergy PV-ezRack SolarTripod Bedienungsanleitung

Beretta

Beretta SCF-20N Bedienungsanleitung

moovo

moovo KSM001 Produkthandbuch

solarwatt

solarwatt EasyIn 60M Series Bedienungsanleitung

Solarland

Solarland Portable Series Handbuch

Ubiquiti

Ubiquiti sunMAX Bedienungsanleitung

Lippert

Lippert Furrion FSFP37MW-BL Bedienungsanleitung

Sonnenkraft

Sonnenkraft GK5-HP Bedienungsanleitung

REC

REC TwinPeak 2S Mono 72 Series Bedienungsanleitung

Sunforce

Sunforce 50039 Bedienungsanleitung

Flexsolar

Flexsolar C100 Leitfaden

Süd Solar

Süd Solar 03005 Bedienungsanleitung

Kodak

Kodak SP21 Bedienungsanleitung

Carmanah

Carmanah Go Power! Solar Flex GP-FLEX-30 Bedienungsanleitung