Volvo 30756864 Bedienungsanleitung
Instruction No
Version
Part. No.
30756865
1.2
30756864, 31373137
Electric engine heater, 230 V, 5
-
cyl. diesel
IMG-
247803
Instruction No
Version
Part. No.
30756865
1.2
30756864, 31373137
Electric engine heater, 230 V, 5
-
cyl. diesel
IMG-
247803
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Electric engine heater, 230 V, 5
-
cyl. diesel
-
30756865
-
V1.2
Page 1 / 32
Equipment
A0000162
IMG-
239660
IMG-
239664
IMG-
239667
IMG-
332913
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Electric engine heater, 230 V, 5
-
cyl. diesel
-
30756865
-
V1.2
Page 2 / 32
IMG-
333598
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Electric engine heater, 230 V, 5
-
cyl. diesel
-
30756865
-
V1.2
Page 3 / 32
IMG-
364592
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Electric engine heater, 230 V, 5
-
cyl. diesel
-
30756865
-
V1.2
Page 4 / 32
IMG-
265776
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Electric engine heater, 230 V, 5
-
cyl. diesel
-
30756865
-
V1.2
Page 5 / 32
INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
1
IMG-
316263
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Electric engine heater, 230 V, 5
-
cyl. diesel
-
30756865
-
V1.2
Page 6 / 32
2
J8000359
Applies to the S40/V50
Remove the seven screws from the engine splash guard.
3
J8601130
Remove the left front wheel.
Remove the five screws holding the bumper cover in the wing
liner on the left and right-hand sides.
4
IMG-
265763
Remove the four screws.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Electric engine heater, 230 V, 5
-
cyl. diesel
-
30756865
-
V1.2
Page 7 / 32
5
J8601087
Push in the centre of the five clips (1). Remove the clips.
Remove the two screws (2).
6
J8601084
Remove the covers for the nozzles for the headlamp washers
on the right and left-hand sides. Carefully grip the cover. Pull the
cover out until the catch becomes accessible.
7
J8903376
Press the catch up. Remove the cover. Do not damage the
painted surfaces or the washer nozzles
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Electric engine heater, 230 V, 5
-
cyl. diesel
-
30756865
-
V1.2
Page 8 / 32
8
J8601086
Detach the ends of the bumper shell on the left and right-hand
sides. Grasp the end of the bumper shell inside the fender liner.
Carefully pull the end of the bumper shell so that the two catches
on the inside release.
Remove the bumper cover and air baffle. Pull the bumper cover
and air baffle forwards until the remaining catches under the
lamps release.
Disconnect the connectors for the fog lamps and parking
assistance if applicable.
9
IMG-
265777
Cut out the template by cutting along the outer edges of the
dotted and solid line.
place the template with the dotted section on the existing marking
(perforation) on the bumper. Mark according to the new, slightly
recessed marking.
Cut off the upper dotted section of the template and finish the
new marking all the way around.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Electric engine heater, 230 V, 5
-
cyl. diesel
-
30756865
-
V1.2
Page 9 / 32
10
IMG-
265778
Using a sharp knife, first make a thin cut along the edges of the
new marking inside of the bumper cover. Then carefully cut out
the bumper cover hole.
Cut off the upper dotted section of the template and finish the
new marking all the way around.
Install the protective cover for the front engine block heater
socket from the kit. Check that it aligns. Adjust the hole using a
knife or file as necessary.
Smooth off the hole edges. Remove any swarf.
Warning!
Cut carefully. It is easy to slip with the knife and move outside
the markings.
11
IMG-
265779
Take the protective cover from the kit and press it into the hole
cut in the bumper cover.
Take the cable for the front engine block heater socket with
ground lead from the kit and thread them through the protective
cover.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
©
Volvo Car Corporation
Electric engine heater, 230 V, 5
-
cyl. diesel
-
30756865
-
V1.2
Page 10 / 32
Dieses Handbuch passt für folgende Modelle
1
Andere Volvo Heizung Handbücher
Beliebte Heizung Handbücher anderer Marken
Empire Heating Systems
Empire Heating Systems WCC65 Bedienungsanleitung
Wetekom
Wetekom 92 86 43 Bedienungsanleitung
Desa
Desa SPC170-F Bedienungsanleitung
Watlow
Watlow Watrod Electric Tubular Heaters Bedienungsanleitung
Haverland
Haverland ECO-DRY GPS Series Stücklistenhandbuch
Stelpro
Stelpro ASILVC2060 Series Bedienungsanleitung