Waterway Clear water II Bedienungsanleitung

CARTRIDGE STANDARD SYSTEM

OWNER’S MANUAL

Our ClearWater II Cartridge Filter System is shipped fromWaterway

complete with everything you need right in the box. Assemble ﬁlter

system only after above-ground pool is installed. Fill pool with water.

Do not raise water level above pool return line.

The pool equipment should be located between pool skimmer and

return line. The ﬁltration system should not be closer than 2 ft. and not

further than 5 ft. from the pool. The ClearWater II Cartridge Filter System

needs to be on a completely ﬂat surface (e.g. patio block, cement slab,

etc.).The pump will require a 110 volt/20 amp service.

WARNING: A GFCI is required. Follow national and local

building and safety codes.

Before opening shipping carton, make sure box is in the upright

position. Inside the carton, you will ﬁnd:

1. One base

2. One pump (packaged in separate box)

3. One ﬁlter

4. Two lengths of 6 ft. hose

5. One bag with ﬁttings

WARNING! READ ALL INSTRUCTIONS AND WARNING

LABELS BEFORE OPERATING FILTER!

1. Place ﬁlter and base on a level, secure surface. Place the pump on

the base to the left of the ﬁlter. The pump should now be facing the

ﬁlter marked“Inlet”. There is no need to disassemble ﬁlter or pump

assemblies.

2. Open pump trap lid and remove 2" gasket. Place 2" gasket into union

nut. Hand tighten union nut to suction side of pump (Detail 5).

3. Secure pump to the base using the pin & anchor assemblies

(Detail 4).

4. Open ﬁttings bag and remove coupling assembly (Detail 2).

Assemble 2" gasket, coupling, coupling O-Ring, and 2" union nut,

and thread into inlet side of ﬁlter.

5. Thread 2" union nut to pump discharge (Detail 3). Thread hose

adapter with O-Ring, to pump trap suction side (Detail 1).

6. From the ﬁttings package, remove 1½" hose adapter and O-ring

(Detail 2). Thread into the outlet side of the ﬁlter tank.

7. Remove 4 hose clamps from the ﬁttings bag. Select one of the hose

lengths and slip one clamp over the end of hose adapter. Place the

end of the hose on to the hose adapter (pump suction) and the other

end to the hose adapter end of the pool skimmer. Repeat steps with

ﬁlter outlet to pool return.

8. Remove the Lid Handle (#4a) from the ﬁttings bag and attach it to

the top of the Lid Assembly (#4) as shown (Detail 6). Secure

ClearWater Filter to ClearWater Filter Base using #16a Phillips Head

Screws (2) (Detail 7 & 8). Fill pool until water level is halfway up

length of skimmer throat.

9. Open air release knob. Plug in and turn on pump. Air will pass out

of the ﬁlter through the air release knob. Once water discharges from

knob, close it.

NOTE: To remove Lid Assembly, take oﬀ Filter Nut (#6) insert Filter

Wrench (#9a) in notch between Filter Body (#9) and Lid Assembly

(#4) twist and separate as shown in Detail 7.

CLEARWATER II CARTRIDGE FILTER SYSTEM OWNER’S MANUAL

INSTALLATION INSTRUCTIONS

DETAIL 1 DETAIL 2 DETAIL 3

10 9

12a

16 15

11 14

4a 4b

111

1a 1b

12a

13a (2)

16 15

11 14

CLEARWATER II CARTRIDGE FILTER SYSTEM REPLACEMENT PARTS

Item Part No. Description

1 830-4000SS Pressure Gauge

1a 519-7431 Fitting Adapter - Pressure Gauge

1b 805-0117SD O-Ring

2 602-0201 Air Relief Plug

3 805-0207 O-Ring - Air Relief

4 511-7327 Lid Assembly - Small (75/100 sq. ft.)

511-7337 Lid Assembly - Large (150/200 sq. ft.)

4a 519-7601 Lid Handle

4b 819-9002 #12 x ¾" S/S Phillips Head Screw

5 805-0460 Lid O-Ring

6 718-7251 Filter Nut (sold with Lid Assembly only)

6a 519-7451 Handle Assembly (2)

7 519-7441 Wing Nut

8 817-0075P Cartridge - 75 sq. ft.

817-0100P Cartridge - 100 sq. ft.

817-0150N Cartridge - 150 sq. ft.

817-0200N Cartridge - 200 sq. ft.

9 515-7257 Body - Filter Bottom

9a 519-7470 FilterWrench (see Detail 7)

10 417-6240 1 ½" MPT x 1 ½" Male Smooth Hose Adapter

11 805-0224 O-Ring

12 500-5300 Drain Assembly

12a 505-2030 Drain Cap

13 672-7401 ClearWater II Base

13a 819-0004 #10 x 1" S/S Phillips-head Screw

14 415-5001 2" Union Nut

15 419-7241 Coupling

16 711-4010 2" Union Gasket

17 PH1100 1 HP - 1-Speed - Hi-Flo II Pump

PH1150 1 ½ HP - 1-Speed - Hi-Flo II Pump

PH1200 2 HP - 1-Speed - Hi-Flo II Pump

PH2100 1 HP - 2-Speed - Hi-Flo II Pump

PH2150 1 ½ HP - 2-Speed - Hi-Flo II Pump

PH2200 2 HP - 2-Speed - Hi-Flo II Pump

18 429-7221 Pin & Anchor Assembly

19 310-6500 6" Trap - 1 ½" Buttress x 2" Flange

20 319-4100 2-Piece 6" Pump Trap Lid Assembly

21 805-0436 O-Ring

22 319-3230 6" Basket Assembly

DETAIL 4 DETAIL 8

DETAIL 5

DETAIL 7

DETAIL 6

11 22

13a

If the pressure gauge on your ﬁlter reads 5 PSI or higher than the

original starting pressure, the ﬁlter needs to be cleaned. The ClearWater

II Cartridge Filter System features the exclusive 1-2-3 Safety Locking

System to ensure safe and simple ﬁlter maintenance.

1. Turn oﬀ pump. WARNING: Never attempt to clean ﬁlter while

pump is running. This is a pressurized vessel. It could cause

severe injury or harm to your person. Plug skimmer and pool

return lines or drain pool water level to below pool return line.

2. Slowly open the air release knob on top of ﬁlter until the pressure

gauge reads“0”. Open drain cap at bottom of ﬁlter and allow water

to ﬂow.

3. Press the yellow safety latch on the underside of the locking nut and

turn the nut counterclockwise to remove the lid. Rinse the cartridge

element with a garden hose. There is no need to remove the element

from the ﬁlter.

4. Reassemble lid and follow start-up procedures from original

instructions.

My Original Starting Pressure is ________ PSI (Pounds per

Square Inch). I should clean the ﬁlter at ________ PSI.

CLEANING INSTRUCTIONS

WARRANTY

For product registration visit: www.waterwayplastics.com.

For Warranty questions or claims please contact point of purchase.

810-0076.0618

2200 East Sturgis Road, Oxnard CA 93030 • Phone 805.981.0262 • Fax 805.981.9403

www.waterwayplastics.com • waterway@waterwayplastics.com

Designed,

Engineered &

Manufactured

in the USA.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Waterway Wasserfiltersystem Handbücher

Waterway

Waterway SVL56 Bedienungsanleitung

Waterway

Waterway Clear Water II Bedienungsanleitung

Waterway

Waterway 640-477x V Bedienungsanleitung

Waterway

Waterway Clear Water II Bedienungsanleitung

Waterway

Waterway 640-479X V Bedienungsanleitung

Waterway

Waterway 640-475x V Bedienungsanleitung

Waterway

Waterway Carefree FS016 Bedienungsanleitung

Waterway

Waterway Crystal Water Bedienungsanleitung

Waterway

Waterway ClearWater Series Bedienungsanleitung

Waterway

Waterway pro clean plus Bedienungsanleitung

Waterway

Waterway 640-476x V Bedienungsanleitung

Waterway

Waterway CLEARWATER II Bedienungsanleitung

Waterway

Waterway Crystal Water Bedienungsanleitung

Waterway

Waterway TWM Bedienungsanleitung

Waterway

Waterway 640-476x Bedienungsanleitung

Waterway

Waterway 640-479X V Bedienungsanleitung

Waterway

Waterway proclean plus PCCF-075 Bedienungsanleitung

Waterway

Waterway 640-472x V Bedienungsanleitung

Waterway

Waterway 640-477XV Bedienungsanleitung

Waterway

Waterway 640-134x V Bedienungsanleitung

Beliebte Wasserfiltersystem Handbücher anderer Marken

Wisy

Wisy LineAir 100 Bedienungsanleitung

Schaffner

Schaffner Ecosine FN3446 Series Betriebsanleitung

Pentair

Pentair FLECK 4600 SXT Benutzerhandbuch

H2O International

H2O International H20-500 Bedienungsanleitung

Renkforce

Renkforce 2306241 Bedienungsanleitung

Neo-Pure

Neo-Pure TL3-A502 Bedienungsanleitung

FLTR

FLTR OBF Bedienungsanleitung

STA-RITE

STA-RITE VERTICAL GRID DE FILTERS S7D75 Bedienungsanleitung

Applied Membranes

Applied Membranes W-G844EM Bedienungsanleitung

BEGA

BEGA 116 Bedienungsanleitung

WATA

WATA Standard Bedienungsanleitung

Price

Price FFU series Handbuch

Gaggenau

Gaggenau BRITA INTENZA 467873 Bedienungsanleitung

Brita

Brita SAFF-100 Bedienungsanleitung

HEISSNER

HEISSNER FPU24000-00 Bedienungsanleitung

BGS technic

BGS technic 1518 Bedienungsanleitung

Reverse Osmosis

Reverse Osmosis RF Series Bedienungsanleitung

ubbink

ubbink Filtramax Series Bedienungsanleitung

Waterway clear water II Bedienungsanleitung

Beliebte Wasserfiltersystem Handbücher anderer Marken