Weber Burner Bedienungsanleitung
PERFORMER™
Serial Number
Please use this number in
registering your warranty and any
correspondence with the factory.
200200
200
200
200
200
200
200
200
200
200
®®
Owner’s Manual
TOUCH-N-GO™IGNITION
WARNING: Do not try to light this
appliance without reading "Lighting"
instructions section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
NOTICE TO INSTALLER: These
instructions must be left with the owner
and the owner should keep them for
future use. FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, immediately call
your gas supplier or your fire
department.
FOR YOUR SAFETY
1. Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
2. An LP tank not connected for use shall
not be stored in the vicinity of this or
any other appliance.
WARNING: Follow all leak check
procedures carefully in this manual prior
to barbecue operation. Do this even if
barbecue was dealer assembled.
3994601 11/96
WARNINGS
■Do not store a spare or disconnected LP tank under or near this barbecue.
■Improper assembly may be dangerous. Please follow the assembly instructions in this manual.
■Combustible materials should never be within 24 inches of the top, bottom, back or sides of the barbecue.
■Do not put a barbecue cover or anything flammable on or in the storage area under the barbecue.
■Do not use lava or char rocks in your barbecue.
■Never lean over the barbecue when lighting the gas burner.
■Barbecue should be thoroughly cleaned on a regular basis.
■Do not use gasoline, liquid fire starter or alcohol on the charcoal at any time. Do not use any form of self-
lighting charcoal at any time.
■Infants, children and pets should never be left unattended near the barbecue.
■Make sure ash catcher is in place when using the barbecue.
■Always remove the lid before lighting the gas burner, either manually or with the igniter. Lid must remain
OFF until charcoal is fully ignited.
■Always put charcoal in Char-Baskets or on top of the lower (charcoal) grate. Do not put charcoal directly in
the bottom of the bowl.
■Remove ashes from the ash catcher only after all coals have been fully extinguished.
■Never touch grates (charcoal and cooking), ashes or coals to see if they are hot.
■Do not use water to control flare-ups or extinguish coals, as it may damage the porcelain finish; slightly
close bottom air vents (dampers) and use the lid. To extinguish coals when finished cooking, close all vents
(dampers) after putting lid on the bowl.
■Barbecue mitts should always be worn while cooking, adjusting air vents (dampers), adding charcoal, and
handling the thermometer or lid.
■Never dump hot coals where they might be stepped on or be a fire hazard. Never dump ashes or coals before
they are fully extinguished. Do not store barbecue until ashes and coals are fully extinguished.
■After a period of storage and/or nonuse, check for gas leaks and burner obstructions before using. See
instructions in this manual for correct procedures.
■Do not operate the barbecue if a gas leak is present.
■Do not use a flame to check for gas leaks.
■Should the burner go out at any time during operation, turn tank valve off. Remove lid and wait five minutes
before attempting to relight, using the lighting instructions in this manual.
■The conversion or attempted use of natural gas in this barbecue is dangerous and will void your warranty.
■Do not attempt to disconnect the gas regulator from the tank or any gas fitting while the barbecue is in use.
■Use only the LP gas regulator that is supplied with your barbecue.
■A dented or rusty LP tank may be hazardous and should be checked by your liquid propane supplier. Do not
use an LP tank with a damaged valve.
■Although your LP tank may appear to be empty, it may still contain gas. The tank should be transported and
stored accordingly.
■If you see, smell or hear gas escaping from the LP tank:
1. Get away from the LP tank.
2. Do not attempt to correct the problem yourself.
3. Call your fire department.
■Use only the LP tank supplied with your barbecue. Do not connect anything larger than a 5 lb cylinder.
■You should exercise reasonable care when operating your barbecue. It will be hot during cooking and/or
cleaning, and should never be left unattended.
DANGER
Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s
Manual may result in serious bodily injury or death, or in a fire or an explosion causing
damage to property.
2
3
Weber Stephen Products Co. (Weber) hereby
warrants to the ORIGINAL RETAIL
PURCHASER of this Weber Barbecue that if it
is assembled and operated in accordance with
the printed instructions accompanying it then
for a period of one (1) year from the date of
purchase, the cooking grate, charcoal grate,
Char-Basket™ Fuel Holders and the tank shall
be free from defects in material and
workmanship; and for three (3) years from the
date of purchase, the burner assembly, igniter,
hose, test valve and regulator shall be free
from defects in material and workmanship; and
for five (5) years from the date of purchase all
other parts shall be free from defects in
material and workmanship.
Weber may require reasonable proof of your
date of purchase. THEREFORE, YOU
SHOULD RETAIN YOUR SALES SLIP OR
INVOICE AND RETURN THE WEBER
LIMITED WARRANTY REGISTRATION CARD
IMMEDIATELY.
This Limited Warranty shall be limited to the
repair or replacement of parts which prove
defective under normal use and service and
which on examination shall indicate, to
Weber's satisfaction, they are defective.
Before returning any parts, contact Weber-
Stephen Products Co. Customer Service
Center. If Weber confirms the defect and
approves the claim, Weber will elect to replace
such parts without charge. If you are required
to return defective parts, transportation
charges must be prepaid. Weber will return
parts to the purchaser, freight or postage
prepaid.
This Limited Warranty does not cover any
failures or operating difficulties due to accident,
abuse, misuse, alteration, misapplication,
improper installation or improper maintenance
or service, or failure to perform normal and
routine maintenance, including but not limited to
damage caused by insects within the burner
tubes, as set out in this owner's manual.
There are no other express warrants except as
set forth herein and any applicable implied
warranties of merchantability and fitness are
limited in duration to the period of coverage of
this express written Limited Warranty. Some
states do not allow limitation on how long an
implied warranty lasts, so this limitation may not
apply to you.
Weber is not liable for any special, indirect or
consequential damages. Some states do not
allow the exclusion or limitation of incidental or
consequential damages, so this limitation or
exclusion may not apply to you.
Weber does not authorize any person or
company to assume for it any other obligation or
liability in connection with the sale, installation,
use, removal, return, or replacement of its
equipment; and no such representations are
binding on Weber.
This Warranty applies only to products sold at
retail.
WEBER-STEPHEN PRODUCTS CO.
Customer Service Center
250 South Hicks Road
Palatine, IL 60067-6241
(800) 446-1071
WARRANTY
4
© 1996 Weber. Weber, , the kettle configuration, One-Touch and
Performer are registered U.S. trademarks; Char-Basket, CharBin,
Touch-N-Go and Tuck-Away are U.S. trademarks of Weber-
Stephen Products Co., 200 East Daniels Road, Palatine, IL
60067-6266. U.S.A. The Performer is covered under the following
patent nos.: U.S.A.: #RE33,091; #D327,390; #4,777,927;
#4,941,817; #4,966,125; #5,036,832; #5,076,252; #5,215,075 and
other patents pending; Canada: #1,168,124 and #1,283,586.
Printed in the U.S.A.
PATENTS AND TRADEMARKS
5
Contents
WARNINGS................................................................ 2
Warranty & Patents.................................................. 3-4
General Instructions.................................................... 6
Assembly............................................................... 7-17
Operating Instructions
Lighting........................................................ 18-19
Cooking............................................................ 20
Cleaning........................................................... 21
Storage............................................................. 21
LP Tank Information.................................... 21-23
Troubleshooting & Maintenance
Troubleshooting................................................ 24
Maintenance................................................ 25-27
Parts Listing.............................................................. 29
FEATURES:
a) Exclusive Touch-N-Go™ Gas Ignition System takes
the hassle out of lighting charcoal briquets. Simply
push a button and the system's gas burner ignites,
starting the charcoal for you. No dangerous liquid
starters to use or store, and no more liquid starter
aftertaste.
b) The 5 lb LP tank that is provided with your barbecue
will last for approximately 150 lightings at normal
use
(each lighting lasting 3 to 5 minutes)
.
c) CharBin™ Storage Container holds over 20 lbs of
charcoal within easy reach.
d) Stainless steel CharBin lid serves as a great work
area and covers the CharBin Storage Container to
keep briquets dry.
e) Stainless steel cooking grate holder.
f) Convenient bottom rack for storage.
g) High-capacity ash catcher locks in place, eliminating
blowing ashes.
h) One-Touch® Cleaning System easily sweeps out
ashes, or opens and closes the vents.
i) Patented Dual-Purpose Thermometer monitors the
cooking temperature inside the grill and can also be
used as a probe to quickly check the doneness
of food.
j) Tuck-Away™ Lid slides back into the stainless steel
lid holder and acts as a windshield when lighting
briquets.
k) Hinged access flaps swing open on cooking grate
for easy addition of briquets or wood chips during
cooking.
l) Char-Basket™ Fuel Holders allow convenient
Indirect and concentrated Direct cooking flexibility
with wood or charcoal.
IMPORTANT NEW FEATURES:
Your Weber Gas Barbecue is equipped with a new
and improved LP tank connection, that has
additional safety features. They are:
1. The connection of the barbecue to the LP tank can
be made without the use of tools.
2. The new connection will not permit the flow of gas
until a positive gas connection is made.
3. If an accidental fire occurs at the LP tank
connection, the flow of gas is stopped by a
temperature activated shutoff.
4. If the LP supply hose becomes damaged, cut,
punctured, or accidentally fire damaged, the
barbecue connection is equipped with an excess
flow control that will limit the flow of gas if leakage or
a fire occurs.
abc
d
e
f
g
h
ij
k
l
6
General Instructions
Your Weber Performer Grill with Touch-N-Go Gas
Ignition is a portable outdoor cooking appliance. You
can grill, barbecue, roast and bake with results that are
difficult to duplicate with indoor kitchen appliances.
The Performer Grill is portable so you can easily change
its location in your yard or on your patio. Portability
means you can take your Weber Charcoal Barbecue
with you if you move.
■These instructions will give you the minimum
requirements for assembling your Performer Grill.
Please read the instructions carefully before using
your grill. Improper assembly can be dangerous.
■Not for use by children.
■The pressure regulator supplied with the Weber
Barbecue must be used. This regulator is set for
10.5 inches of water column (pressure).
■The Weber Performer Grill with Touch-N-Go Gas
Ignition is designed for use with liquid propane (LP)
gas only. Do not use with natural (piped in city) gas.
The valves, orifices, hose and regulator are for LP
gas only.
Storage
■The gas must be turned OFF at the LP tank when
the grill is not in use.
■When the Performer Grill is stored indoors, the gas
supply MUST BE DISCONNECTED and the LP
tank stored outdoors in a well-ventilated space.
■LP tanks must be stored outdoors in a well-
ventilated area out of the reach of children.
Disconnected LP tanks must not be stored in a
building, garage or any other enclosed area.
■When the LP tank is not disconnected from the
Performer Grill, the appliance and LP tank must be
kept outdoors in a well-ventilated space.
■Check that the areas around the tank, hose and
burner assembly are free from debris that might
obstruct the air flow of gas or air.
Operating area
WARNING: Only use this barbecue outdoors in a
well-ventilated area. Do not use in a garage,
building, breezeway or any other enclosed area.
■Never use your Performer Grill under an
unprotected combustible roof or overhang.
■Your Weber Gas Barbecue is not intended to be
installed in or on recreational vehicles and/or boats.
■Do not use combustible materials within 24 inches
of the top, bottom, back or sides of the grill.
■The entire barbecue gets hot when in use. Do not
leave unattended.
■Keep any electrical supply cord and the fuel supply
hose away from any heated surface.
■Keep the cooking area clear of flammable vapors
and liquids, such as gasoline, alcohol, etc., and
combustible materials.
LP Tank
The LP tank manufacturer is responsible for the materials,
workmanship and performance of the tank. If the tank has a
defect, malfunctions, or you have a question regarding the
tank, call the tank manufacturer's customer service center.
The phone number is on the warning decal which is
permanently attached to the tank. If the tank manufacturer
has not resolved the issue to your satisfaction, then call
Weber-Stephen Products Co., Customer Service Center.
7
Tools needed
Phillips screwdriver
7/16 inch and 7/8 inch or an adjustable wrench
Pliers
Hammer
Block of wood
Supplies needed
Your LP tank is shipped empty for safety. You will
need to fill it (See Step "Fill LP tank").
You will need a soap and water solution to check for gas
leaks.
Packages
Your Weber Performer Grill comes in a large box
(shipper) which includes a top box, and bottom carton.
There is a hardware pack of small parts and hardware
that will be found in the bottom carton.
Note - The hardware size of nuts, bolts and screws is
given. For example "1/4-20 x 1/2 inch bolt" means a bolt
1/4 inch in diameter with 20 threads to the inch, 1/2 inch
long. On a small screw, "8-18 x 5/8 inch screw" means a
number 8 screw, with 18 threads to the inch, 5/8 inch
long.
Check package contents
The following item will be found in the top box.
Bottom rack
The following items will be found in the large box
(shipper).
CharBin Storage Container
Bowl assembly
Lid assembly
ASSEMBLY INSTRUCTIONS
While we give much attention to our products,
unfortunately an occasional error may occur. If a part
is missing, do not go back to the store. Call the Weber
Customer Service Center toll free 1-800-446-1071 to
receive immediate assistance. Have your owner’s
manual and serial number available for reference.
Ash catcher assembly
Two Char-Basket
Fuel Holders
Tank holder assembly
Control panel
Bowl panel
Charcoal grate
Hinged cooking grate
Burner cleaning tool/ match holder
8
LP tank
Filler adapter
The following items will be found in the bottom
carton.
Wheel frame
Two bottom connectors
Front panel
Caster frame assembly
Top frame assembly
W
E
B
E
R
W
E
B
E
R
W
E
B
E
R
W
E
B
E
R
Two wheels
Axle
9
The following items will be found in the
hardware pack.
Sixteen nylon washers
(actual size)
Four aluminum washers
(actual size)
Eight 1/4-20 x 1 3/4 inch bolts
(actual size)
Four 1/4-20 acorn nuts
(actual size)
Four 1/4-20 x 1/2 inch bolts
(actual size)
Three tool holders
Three hubcaps
Figure 1
Step 1
Assemble wheels
You will need: axle, two wheel hubcaps, two wheels,
wheel frame, hammer and a block of wood.
Place one end of the axle on the block of wood (or other
protected surface). Tap on one hubcap.
Put one wheel on the axle, WEBER side toward the
hubcap. Slide the axle through the frame. Add the other
wheel, WEBER side out. Tap on the hubcap. Figure 1.
W
E
B
E
R
W
E
B
E
R
10
Step 2
Remove protective packaging
Protective cardboard inserts must be removed from the
bowl before assembly. Figure 2. DO NOT
FORCEFULLY REMOVE THE INSERTS.
a) Remove cardboard insert from ash catcher ring. Be
careful when removing the cardboard not to bend
the ash catcher ring.
b) Tear cardboard along the perforations at leg
couplings and pull downward.
c) Peel off the protective plastic covering from the
nameplate on the ash catcher ring.
(a)
(b)
(c)
(b)
Figure 2
Figure 3
Step 3
Assemble the frame
You will need: top frame assembly, wheel frame
assembly and caster frame assembly.
Note - Work on soft surface (grass, or carton inserts) to
protect the finish during frame assembly.
Set the top frame on the ground so the leg tabs point
up. Fit the wheel frame assembly onto the leg tabs at
the open end of the top frame. Figure 3.
Fit the caster frame assembly onto the leg tabs at the
other end of the top frame. Figure 3.
The tabs must be on the inside of the frame tubes when
the joints are closed. Figure 3 (a).
(a)
Tab on the inside
of frame tube
Andere Handbücher für Burner
1
Inhaltsverzeichnis
Andere Weber Brenner Handbücher
Weber
Weber Summit 89796 Bedienungsanleitung
Weber
Weber Burner Bedienungsanleitung
Weber
Weber Summit 42376 Bedienungsanleitung
Weber
Weber Summit 42377 Bedienungsanleitung
Weber
Weber Summit Series Installationsanleitung
Weber
Weber Summit 56070 Bedienungsanleitung
Weber
Weber Genesis 2000 Bedienungsanleitung
Weber
Weber Summit 56069 Bedienungsanleitung
