Westerbeke Universal M-50 Bedienungsanleitung

SERVICE

MANUAL

M-

MODELS

M-

200154

M-

CONTENTS

NOTE: Refer to the beginning ofthe individual sections for a cqrnplete table

contents forthat section.

SECTION I - SPECIFICATIONS

....................................................

1-18

SECTION

-PREVENTIVE MAINTENANCE

........................................

19-24

SECTION III -CONSTRUCTION AND FUNCTION

....................................

25-30

SECTION IV -LUBRICATION, COOLING, AND FUEL

SySTEMS

.......................

31-49

SECTION V - ELECTRICAL SYSTEM

..............................................

51-82

SECTION VI -DISASSEMBLY AND REASSEMBLY

.................................

83-130

SECTION VII -DYNAMO AND REGULATOR

......................................

132-147

TROUBLESHOOTING

.........................................................

148-157

NOTES

---

---------

-_i----~-,J

SECTION

SPECIFICATIONS

Model M-30

......................................................................

2,3

Model M-40

.....................................................................

4,5

Model .M-50

..................................................

..................

6,7

Parts Specifications .

.............................................................

8-15

Bolt Torques.

.................................................................

.16-18

UNIVERSAL MODEL M-30 SPECIFICATIONS

Horsepower

No.

of Cylinders

Bore x Stroke

Cubic Inch

Maximum

R.P.M.

Cruising Range (Approx.)

Compression Ratio

Electrical Equipment

Lubrication (Eng. Approx. Qts)

24 @ 2800

3.00 x 3.23

2800

2000-2400 R.P.M.

21:1

Volt -

Amp W/Glow Plugs

5.0

5.5

(SAE 30

HD.

(CD) or 10W40) CAUTION: FILL ONLY

FULL MARK ON DIPSTICK

Lubrication (Trans.) FILL

FULL RING ON DIPSTICK

(Type

AFT.

"/1\'

or GM-DEXRON -

Do not mix different oils)

Transmission Reduction

Coolant FWC (50/50 Solution Approx.)

Exhaust Flange

Fuel

Type

Fuel Filter

Oil Filter

Eng. Operating

Temp.

Degrees

Propeller Rotation

We.ight

(Ibs.)

Injection Nozzle

2:1

6 qts.

1 V4"

N.P.T.

Diesel

298854

300209

Right Hand

4251bs.

298787 & 298788

Engine is governorcontrolled to prevent overspeed. It is recommended to carry the following extra parts should

the need arise: V-Belt, Sea Water Pump Impeller, Fuel & Lube Oil Filters, 1

Qt.

of Trans. Oil, 2 Qts. Lub. Oil

and 1 Gal. 50/50 Coolant.

All pictorial views and specifications subject to change without notice.

GLOW

PLUG~-

____

SEA WATER OVERBOARD

HEAT

EX.

DRAIN &

ZINC_

TRANS. DIP STICK

OIL FILL HOLE

---

SHIFT LEVER

ENGINE COUPLIN

UNIVERSAL MODEL M-30

FUEL LINES

TIMING PORT

AIR BREATHER

FUEL AIR

LEED VALVE

c---_

STOP LEVER

'----OIL

FILTER

BLOCK COOLANT DRAIN

COOLANT AIR BLEED VALVE COOLANT FILL CAP

THERMOSTAT HSG.

F.W. CIRCULATING

PUMP

---,

ALTERNATOR

SEA WATER PUMP

V·BELT

DIP STICK OIL PAN

MANIFOLD

AUST FLANGE

MANIFOLD DRAIN

HEAT EXCHANGER

HEAT

EX.

CLEAN·OUT

COVERS

----DRAIN

AND ZINC

TRANSMISSION

n_'I"~_

DRAIN PLUG

UNIVERSAL MODEL M-40 SPECIFICATIONS

Horsepower

No.

Cylinders

Bore x Stroke

Cubic Inch

Maximum

R.P.M.

Cruising Range (Approx.)

Compression Ratio

Electrical Equipment

Lubrication (Eng. Approx. ats.)

32 @ 2800

3.00 x 3.23

2800

2000/2500

P.M.

21:1

12 Volt -

Amp WIGlow Plugs

8.0

8.5

(SAE 30

HD.

(CD) or 10W40) CAUTION: FILL ONLY

FULL MARK ON DIPSTICK

Lubrication (Trans.) FILL

FULL RING ON DIPSTICK

(Type

AFT.

"1\' or GM-DEXRON -

Do not mix different oils)

Transmission Reduction

Coolant FWC (50/50 Solution Approx.)

Exhaust Flange

Fuel Type

Fuel Filter

Oil Filter

Eng. Operating

Temp.

Degrees

Propeller Rotation

Weight (Ibs.)

Injection Nozzle (Prior to

Ser.

#315023)

(After

Ser.

#315023)

2:1

8 qts.

V4"

N.P.T.

Diesel

298854

299927

Right Hand

5451bs.

299517 &299518

299567

Engine is governorcontrolled to prevent overspeed. It is recommended to carry the following extra parts should

the need arise: V-belt, Sea Water Pump Impeller, Fuel & Lube Oil Filters, 1

at.

of Trans. Oil, 2 Ots. Lub. Oil

and 1 Gal. 50/50 Coolant.

All pictorial views and specifications subject to change without notice.

FUEL RETURN

GLOW

PLUGS-

____

SEA WATER OVERBOARD

HEAT

EX.

DRAIN & ZIN

TRANS. DIP STICK

OIL FILL HOLE

---

ENGINE

COUPLING/

UNIVERSAL MODEL M-40

FUEL LINES

TIMING PORT

AIR BREATHER

FUEL AIR

BLEED VALVE

---THROTTLE

STOP LEVER

--OIL

FILTER

BLOCK COOLANT DRAIN

MOUNTS

COOLANT AIR BLEED VALVE COOLANT FILL CAP

THERMOSTAT HSG

F.W. CIRCULATING

PUMP

---'

ALTERNATOR

SEA WATER PUMP

V·BELT

DIP STICK OIL PAN

MANIFOLD

MANIFOLD DRAIN

HEAT EXCHANGER

HEAT

EX.

CLEAN·OUT

COVERS

----

DRAIN AND ZINC

TRANSMISSION

RANS. DRAIN PLUG

UNIVERSAL MODEL M-50 SPECIFICATIONS

Horsepower 44 @ 3000

No.

of Cylinders 4

Bore x Stroke

3.35

3.23

Cubic Inch

115

Maximum

R.P.M.

3000

Cruising Range (Approx.) 2000/2500

R.P.M.

Compression Ratio

21:1

Electrical Equipment

Volt

Amp WIGlow Plugs

Lubrication (Eng. Approx.

Ots.)

8.5

(SAE

HD.

(CD)

10W40)

CAUTION: FILL

ONLY

FULL MARK

DIPSTICK

Lubrication

(Trans.)

FILL

FULL

RING

DIPSTICK

Transmission Reduction

1.9:1

Coolant

FWC

(50/50 Solution Approx.) 8 qts.

Exhaust Flange 1

1/4"

N.P.T.

Fuel

Type

Diesel

Fuel Filter

298854

Oil Filter

299927

Eng. Operating

Temp.

Degrees

165

0 to

195

Propeller Rotation Right Hand

Weight

(Ibs.)

545

Ibs.

Injection Nozzle

299567

Engine

governor controlled

prevent overspeed. It

recommended

carry the following extra parts should

the need arise: V-Belt, Sea Water Pump Impeller, Fuel & Lube Oil Filters, 1

at.

Trans.

Oil, 2

Ots.

Lub.

Oil

and 1 Gal. of 50/50 Coolant.

All pictorial views and specifications subject

change without notice.

UNIVERSAL MODEL M-50

FUEL LINES

FUEL RETURN

GLOW

PLUGS-

____

SEA WATER OVERBOARD

HEAT

EX.

DRAIN &

ZINC_

TRANS. DIP STICK

OIL FILL HOLE

SHIFT LEVER

ENGINE

COUPLING/

TIMING PORT

COOLANT AIR BLEED VALVE

THERMOSTAT HSG.

F.W. CIRCULATING

PUMP

---

ALTERNATOR

SEA WATER PUMP

V·BELT

DIP STICK

AIR BREATHER

INJECTOR PUMP

FUEL AIR

--,

...

EED

VALVE

------

ROTTLE

,..---

STOP LEVER

~-OIL

FILTER

BLOCK COOLANT DRAIN

LEX MOUNTS

COOLANT FILL CAP

MANIFOLD

EXHAUST FLANGE

/ LD DRAIN

HEAT

EX.

CLEAN·OUT

COVERS

. DRAIN AND ZINC

NS. DRAIN PLUG

STARTER

OIL PAN

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Westerbeke Motor Handbücher

Westerbeke

Westerbeke 65A-FOUR Bedienungsanleitung

Westerbeke

Westerbeke 20B TWO Bedienungsanleitung

Westerbeke

Westerbeke W35B Bedienungsanleitung

Westerbeke

Westerbeke 27a Bedienungsanleitung

Westerbeke

Westerbeke 44 A FOUR-35C THREE Bedienungsanleitung

Westerbeke

Westerbeke 10TWO Bedienungsanleitung

Westerbeke

Westerbeke 58 Bedienungsanleitung

Westerbeke

Westerbeke 14088 Bedienungsanleitung

Westerbeke

Westerbeke 44A FOUR - 35C THREE Bedienungsanleitung

Westerbeke

Westerbeke 12C- TWO Bedienungsanleitung

Westerbeke

Westerbeke W-70GA Bedienungsanleitung

Westerbeke

Westerbeke W-52 Bedienungsanleitung

Westerbeke

Westerbeke 10.0 KW-60Hz SBEG Bedienungsanleitung

Westerbeke

Westerbeke 27 Bedienungsanleitung

Westerbeke

Westerbeke 12.5KW-60Hz Bedienungsanleitung

Westerbeke

Westerbeke 44A FOUR-35 C THREE Bedienungsanleitung

Westerbeke

Westerbeke 35B THREE Bedienungsanleitung

Westerbeke

Westerbeke 40NA Bedienungsanleitung

Westerbeke

Westerbeke M3-20B Bedienungsanleitung

Westerbeke

Westerbeke Four-236 Bedienungsanleitung

Westerbeke

Westerbeke 60 Bedienungsanleitung

Westerbeke

Westerbeke PERFORMER-SIX Bedienungsanleitung

Westerbeke

Westerbeke WPDS-20 Bedienungsanleitung

Westerbeke

Westerbeke 82B FOUR Bedienungsanleitung

Beliebte Motor Handbücher anderer Marken

Rotax

Rotax 125 senior MAX evo Bedienungsanleitung

Kohler

Kohler K361 Bedienungsanleitung

MTD

MTD OHV Series Bedienungsanleitung

Kohler

Kohler COMMAND CH18-745 Bedienungsanleitung

Mercury

Mercury D4.2L D-Tronic Bedienungsanleitung

Selve

Selve SE Plus-RC Series Bedienungsanleitung

Perkins

Perkins 1206E-E66TA Bedienungsanleitung

Skov

Skov DA 174 Handbuch

Rossi

Rossi TX11 Series Bedienungsanleitung

Siemens

Siemens SIMOTICS T-1FW3 Merkblatt

AL-KO

AL-KO PRO 350 Bedienungsanleitung

MTU

MTU 12 V 4000 Lx4 Bedienungsanleitung

Nanni

Nanni N3.30 Gebrauchsanweisung

Nanni

Nanni N5.160 CR2 Bedienungsanleitung

KSB

KSB SuPreme Series Montageanleitung

Hiwin

Hiwin EM1 Series Bedienungsanleitung

Rotax

Rotax 912 i series Betriebsanleitung

Siemens

Siemens SIMOTICS XP 1MB1 Bedienungsanleitung