Windsor Admiral ADM8 Bedienungsanleitung
Read these instructions before operating the machine
MODEL: ADM8
Operating Instructions
98628 08/19/03
HH
CARPET EXTRACTOR
TABLE OF CONTENTS
ADMIRAL 98628 10/19/02
1
Data Log/Table of Contents..............1
Safety Instructions............................2
Grounding Instructions .....................3
Controls............................................4-6
Operations........................................7-12
Troubleshooting................................13
Wiring Diagram.................................14
Maintenance .................................... 15-17
Technical Specifications................... 18
Service Schedule. ............................ 19
Parts Lists........................................ 21-34
Spare Parts/Notes............................ 35
Warranty ....................................... 36
INSPECTION
Carefully unpack and inspect your machine for shipping damage. Each unit is operated and thoroughly inspected
before shipping, and any damage is the responsibility of the carrier, who should be notified immediately.
MODEL
DATE OF PURCHASE
SERIAL NUMBER
SALES REPRESENTATIVE #
DEALER NAME
SAFETY INSTRUCTIONS
ADMIRAL 98628 12/14/98 2
IMPORTANT SAFETY INSTRUCTIONS
When using an electrical appliance, basic precaution
must always be followed, including the following:
READ ALL INSTRUCTIONS BEFORE USING THIS MACHINE.
This machine is for commercial use.
To reduce the risk of fire, electric shock, or injury:
Connect to a properly grounded outlet. See Grounding Instructions.
Do not leave the machine unattended. Unplug machine from outlet when not in use and before
maintenance or service.
Use only indoors. Do not use outdoors or expose to rain.
Do not allow machine to be used as a toy. Close attention is necessary when used by or near
children.
Use only as described in this manual. Use only manufacturer’s recommended components and
attachments.
Do not use damaged electrical cord or plug. Follow all instructions in this manual concerning grounding
the machine. If the machine is not working properly, has been dropped, damaged, left outdoors, or
dropped into water, return it to an authorized service center.
Do not pull or carry machine by electrical cord, use as a handle, close a door on cord, or pull cord
around sharp edges or corners.
Do not run machine over cord. Keep cord away from heated surfaces.
Do not unplug machine by pulling on cord. To unplug, grasp the electrical plug, not the electrical cord.
Do not handle the electrical plug or machine with wet hands.
Do not operate the machine with any openings blocked. Keep openings free of debris that may reduce
airflow.
This machine is intended for cleaning carpet only.
Do not vacuum anything that is burning or smoking, such as cigarettes, matches, or hot ashes.
This machine is not suitable for picking up health endangering dust.
Turn off all controls before unplugging.
Machine can cause a fire when operating near flammable vapors or materials. Do not operate this
machine near flammable fluids, dust or vapors.
This machine is suitable for commercial use, for example in hotels, schools, hospitals,
factories, shops and offices for more than normal housekeeping purposes.
Maintenance and repairs must be done by qualified personnel.
If foam or liquid comes out of machine, switch off immediately.
SAVE THESE INSTRUCTIONS
!
WARNING:
GROUNDING INSTRUCTIONS
ADMIRAL 98628 12/14/98
3
THIS PRODUCT IS FOR COMMERCIAL USE ONLY.
ELECTRICAL:
In the USA this machine operates on a standard
15 amp 115V, 60 hz, A.C. power circuit . The amp,
hertz, and voltage are listed on the data label found
on each machine. Using voltages above or below
those indicated on the data label will cause serious
damage to the motors.
GROUNDING INSTRUCTIONS:
This appliance must be grounded. If it should
malfunction or break down, grounding provides a
path of least resistance for electric current to
reduce the risk of electric shock. This appliance is
equipped with a cord having an equipment-
grounding conductor and grounding plug. The plug
must be inserted into an appropriate outlet that is
properly installed and grounded in accordance with
all local codes and ordinances.
This appliance is for use on a nominal 115-volt
circuit, and has a grounded plug that
looks like the plug in “Fig. A”. A temporary adaptor
that looks like the adaptor in “Fig . C” may be used
to connect this plug to a 2-pole receptacle as
shown in “Fig. B”, if a properly grounded outlet is
not available. The temporary adaptor should be
used only until a properly grounded outlet (Fig. A)
can be installed by a qualified electrician. The
green colored rigid ear, lug, or the like extending
from the adaptor must be connected to a
permanent ground such as a properly grounded
outlet box cover. Whenever the adaptor is used, it
must be held in place by a metal screw.
Improper connection
of the equipment-
grounding conductor
can result in a risk of electric shock. Check with a
qualified electrician or service person if you are in
doubt as to whether the outlet is properly
grounded. Do not modify the plug provided with the
appliance - if it will not fit the outlet, have a proper
outlet installed by a qualified electrician.
!
WARNING:
NOTE: In Canada, the use of a temporary adaptor is no
t
p
ermitted by the Canadian Electrical Cod
e
PROPER GROUNDING
Metal Screw
Adaptor
Grounded Outlet Box
Fig. A Fig. B
Fig. C
Tab For Grounding Screw
Grounded
Outlet
Grounding Pin
Adaptor
CONTROLS/COMPONENT LOCATIONS
ADMIRAL 98628 08/31/01 4
1. Main Handle. Used to pull and maneuver
machine.
2. Handle Adjustment. Used to adjust height of
handle.
3. Electrical Cord.
4. Solution Switch. Turns on pump. Continuous
position (bottom) activates electro-valve to
dispense solution to floor through jets.
Intermittent position (up) requires operator to
depress 1 of 3 trigger switches to dispense
solution. Center position is off.
5. Brush Motor Switch. Turns on brush motor.
6. Vacuum Motor Switch. Turns on vacuum
motor.
7. Trigger Switches. Activates electro-valve to
dispense solution to floor through jets when
solution switch is in the intermittent position.
8. Brush Motor Circuit Breaker. 6 amp.
Breaker protecting brush motor.
9. Vacuum Motor Circuit Breaker. 15 amp.
Breaker protecting vacuum motor.
10. Recovery Dump Hose. Facilitates draining
dirty cleaning solution.
11. Solution Dump Hose. Facilitates draining
excess cleaning solution from solution tank.
3
1
10
11
2
5
8946
7
CONTROLS/COMPONENT LOCATIONS
ADMIRAL 98628 12/14/98
5
1. Solution Accessory Tool Hookup. Used for
various auxiliary cleaning tools.
2. Vacuum Hose Door. Used to connect
various auxiliary 1 ½ inch cleaning tool
vacuum hoses.
3. Brush Height Adjustment. Used to regulate
brush height from storage position to various
carpet heights.
4. Recovery Tank. Used to collect dirty
cleaning solution.
5. Solution Tank. Used to hold cleaning
solution.
6. Recovery Tank Dome.
7. Vacuum Shoe.
8. Brush Housing.
9. Front Lifting Handle.
10. Cleaning Solution Filter.
11. Solution Tank Fill Hose.
4
5
6
7
8
3
2
1
10
9
11
CONTROLS/COMPONENT LOCATIONS
ADMIRAL 98628 12/14/98 6
1. Solution Intake Cover.
2. Vacuum Intake Cover.
3. Float Shut-Off.
4. Clean-Out Opening.
5. Pour Spout.
6. Lift Handle.
21
3
4
5
6
6
FILLING OPERATIONS
ADMIRAL 98628 12/14/98
7
FILLING THE ADMIRAL
NOTE: Use clean bucket of water to fill solution tank
Do not put defoamer, solvents, spotter or
prespray chemicals in the solution tank.
Do not allow water to spill into vacuum motor inlet. Dry
spillage from top of solution tank before replacing
recovery tank.
CHEMICALS
Suitable Chemicals Non-Compatible Chemicals
Alkalis Aldehydes
Detergents Aromatic Hydrocarbons
Hydroxides SP Butyls
Soaps Carbon Tetrachloride
Vinegar Clorox*
Chlorinated Bleaches
Chlorinated Hydrocarbons
Lysol*
Methyl Ethel Ketone (MEK)
Perchorethylene (perc)
Phenolics
Trichlorethylene
D-Limonene
STEP
1
STEP
2
STEP
3
STEP
4
RECOVERY TANK
SOLUTION
TANK
Remove recovery
tank
FILL LINE
Replace recovery
tank
A
dd cleaning
chemical
8 – 16oz.
(237ml – 473ml)
A
dd water
8 gal.
(30.3 ltr.)
140°F
(
60°C
)
or
OPERATIONS
ADMIRAL 98628 12/14/98 8
Remove electrical cord and literature
from recovery tank. Fill solution tank
(see filling instructions page 7).
A
djust brush to proper setting. Note:
For good operation the brush must
skim the carpet. If circuit breaker
trips raise brush to prevent damage
to motor or carpet.
Plug cord into grounded outlet. Note:
Be sure dome is seated on recovery
tank, and float shut-off is installed
correctly.
Turn on brush and vacuum motor
switches (“ON”=“I”). Turn on solution
switch for continuous spray or set
switch to intermittent to allow use of
trigger switches.
STEP
1
STEP
2
STEP
3
STEP
4
CORRECT
INCORRECT
1/8in
(3mm)
SOLUTION VACUUM
CONT
INT BRUSH ONON
OPERATIONS
ADMIRAL 98628 12/14/98
9
Select continuous setting to start
solution spray or select intermittent
setting to enable use of trigger
switches to start solution spray.
The intermittent setting requires the
operator to hold any one of the
three trigger switches in the “on”
position with the fingers, and is
typically used in small areas where
short cleaning passes are made.
The continuous setting allows the
operator to set the switch in the “on”
position with one touch, and is
typically used in large areas where
long cleaning passes are made.
Lower machine to floor.
A
djust handle to comfortable
operating position. Tip machine
back by main handle to move to
starting point.
STEP
5
STEP
6
STEP
7
INT
CONT
Inhaltsverzeichnis
Andere Windsor Bodenreinigungsmaschine Handbücher
Windsor
Windsor Dominator NWWU2250H Technische Daten
Windsor
Windsor Pivot Bedienungsanleitung
Windsor
Windsor Dominator 10070090 Bedienungsanleitung
Windsor
Windsor Escort ECS Bedienungsanleitung
Windsor
Windsor 1.005.293.0 Bedienungsanleitung
Windsor
Windsor LB2000I Bedienungsanleitung
Windsor
Windsor EXPERT Montageanleitung
Windsor
Windsor 10020430 Bedienungsanleitung
Windsor
Windsor Saber Compact 16SP Bedienungsanleitung
Windsor
Windsor Cadet CDT7IA Technische Daten
Windsor
Windsor Saber Glide 30 Bedienungsanleitung
Windsor
Windsor Chariot iScrub Bedienungsanleitung
Windsor
Windsor Clipper Duo Bedienungsanleitung
Windsor
Windsor Cadet 7 Bedienungsanleitung
Windsor
Windsor Chariot 2 iVac 24 AVT Bedienungsanleitung
Windsor
Windsor Lightning 1500 Bedienungsanleitung
Windsor
Windsor SCC172 Bedienungsanleitung
Windsor
Windsor M17XI Bedienungsanleitung
Windsor
Windsor Dri-Matic Bedienungsanleitung
Windsor
Windsor CLP12 Bedienungsanleitung
Beliebte Bodenreinigungsmaschine Handbücher anderer Marken
Nilfisk-Advance
Nilfisk-Advance Advance SC370 17B Bedienungsanleitung
Numatic
Numatic ET 4045 Bedienungsanleitung
HAWK ENTERPRISES
HAWK ENTERPRISES HP1513-180BRUTE Bedienungsanleitung
Mytee
Mytee 8070 Mytee-Lite Bedienungsanleitung
Kärcher
Kärcher B 140 R Bedienungsanleitung
Triple S
Triple S Ace 26T1 Bedienungsanleitung
