Wolf HL-95 Handbuch
Wolf Hazard Lamp HL-95
Operation and maintenance Instructions
EU Declaration of Conformity
T e Wolf Hazard Lamp HL-95 meets all relevant provisions of t e
2014/34/EU (ATEX Equipment) Directive, by virtue of t e issued EU
Type Examination Certificate, demonstrating compliance wit all
relevant armonised standards and essential ealt and safety
requirements.
T e Wolf Hazard Lamp is a self-contained warning lamp, wit an LED
lig t source and powered by a special air depolarised primary
battery. T e enclosure is moulded in ig impact plastic. T e lamp is
approved as Group II, category 1 equipment for use in zone 0, 1 or 2
potentially explosive gas, vapour or mist atmosp eres, w ere t e T4
temperature class permits.
Only use t e specified HL-3155X battery.
Do not open in t e EX area.
Static Hazard – clean only wit a damp clot .
Approval Codes/Certification:
II 1G Ex ia op is IIC T4 Ga
T
a
=-10
o
C to 40
o
C
Notified Body:
SGS FIMKO OY. P.O. Box 30 (Särkiniementie 3)
00211 HELSINKI. Finland
Notified body number: 0598
EU Type examination certificate:
BAS99ATEX1044X
Special Conditions of Use (X Condition)
T e metal label and grill can generate a electrostatic c arge under
certain extreme conditions. T e user s all ensure t e Hazardlamp is
not placed in a location w ere t e external conditions are conducive
to t e build up of an electrostatic c arge.
Harmonised standards applied:
EN IEC 60079-0: 2018, EN60079-11: 2012, EN60079-28: 2015
Ingress protection level: IP21, to EN60529:1992,
Caution – Polycarbonate lens, c eck suitable for atmosp ere in Ex
area.
T e HL-95 is compliant wit t e 2014/30/EU EMC Directive to t e
following armonized standards:- EN 61000-6-2:2005 and
EN 61000-6-3:2007+A1:2011.
Alex Jackson – Managing Director
Wolf Safety Lamp Company Ltd.
Use of Wolf Hazard Lamp HL-95
Users s ould consult EN60079/IEC60079, or national equivalent, for
advice on t e selection and maintenance of electrical apparatus for
use in potentially explosive atmosp eres.
A damaged Hazard Lamp s ould be wit drawn, inspected and
repaired in accordance wit t ese instructions, before being put
back into service.
T e Wolf Hazard Lamp must not be opened in t e azardous area.
No modifications are permitted to t is product.
C eck ambient temperature for intended use, t e battery
performance is reduced in temperatures below -5
o
C
To Fit Battery
Remove locking screw and separate t e lamp front from rear.
Fit battery into lamp front and attac connector, ensure t e
connector is firmly attac ed to bot terminals.
Re-assemble two alves of lamp and locking screw, ensure wires
are not trapped.
Operation
External switc provides output selection as follows:
on static – off – on flas ing.
Internal switc on t e LED circuit board allows selection of daylig t
‘cut-out mode’, automatically turning t e lamp off in daylig t,
extending t e battery life.
T e flas rate may increase if t e lamp is operated near radio
frequency emissions in t e range 100MHz to 115MHz.
Spare Parts
Description Order Code
Circuit assembly HL-13A (amber LED)
LED colours for pre 2018 models are still available on request
Lock screw HL-25
Lock Key HL-05
Battery HL-3155X
In t e event of circuit failure, only t e complete circuit assembly is
supplied.
T e Wolf Safety Lamp Co as a policy of continuous
product development. C anges in design detail may be
made wit out prior notice
WOLF SAFETY LAMP COMPANY
Saxon Road Works, S effield S8 0YA, England
Tel: +44 114 255 1051 Fax: +44 114 255 7988
E-mail: info@wolfsafety.com Website: www.wolfsafety.com
HL-15 Issue 9 DF528
Wolf Hazard Lamp HL-95
WOLF SAFETY LAMP COMPANY
Saxon Road Work , Sheffield S8 0YA
44
114
255
1051
44
114
255
7988
!"#
info@wolf afety.com
$%&
www.wolf afety.com
HL-15DF528
'()*+,"-$-./&012
HL-95 !2014"34"EU#$%
ATEX!&'()*+',-./0!123#4567829!:
23#429,;$#3:2&3<2(=2'
->8?!@!ABC;@'LED2:!DEF
2G2=B2:CH!<IJKLCM(!N)*DO.<>.!
2P32Q2R N-$S$129:*,TU(0V1V2>&,23!9
-;J22P,7=WJXYV-;U!&VE! (T4<
"(3',4!56,
HL-3155X
78*!+
,.9:-/;+'%
(
<
EX
7<
:=>'3?@7AB/#9(C%3B'D
*2,8*EF*&G
II 1 G Ex ia op i IIC T4 Ga
C
o
10-=
a
TZJ40
C
o
!0
SGS FIMKO OY.P.O. Box 30
(Särkiniementie 3) 00211 HELSINKI,
*3*,
[$HOAC
0598
[!&'K!2U)*+',-./
BAS99ATEX1044X
9EHI5J=,K
X
L
2($NR\F*C2$2OF2*'/];^_$!,2O;.S-*<!
, )8 ;` @ HV TU= S\ HV 0 ];^ , R= HO
<2O;.S2*'/AS;Z3R2U
[29:29,;$
EN IEC 60079-0: 2018, EN60079-11: 2012, EN60079-28: 2015
2'2[
P21
$3a9,EN60529:19921
*b29:*, 3#!;SN2R*#$2B(Nc9'AEX <
HL-95c!:2014"30"EU EMC[229,;$3a9,
EN 61000-6-2:2005
EN 61000-6-3:2007+A1:2011<
H=SdOVeL;
ةدودا ب فوو ر
4!5=
Wolf Hazard Lamp HL-95
$Z?);NU=Z3RE*EN60079/IEC60079V3'$
Df23!C>V,TU(-$2B!;.O-g.&2G,!/;(
< (
h@.a9,J(?',@0'0 #3$DC-R?
U<
7,TR0 Wolf Hazard Lamp<-;:Uci*,
($LV>;j!7=K<k*@Z3R#
>V_U*WJ1. .,TU=29:*32:'-;'2Nc9'
NDCV-;'#,2:-5
C
o
"(3#M
<3UNN&>g D,lQ=2j!AC
N&>g ,2:0SDHVNS\DD!AC
<TOJj!N,;:(O!D
<-F';`m(&HVNS\lQ=Bg0S;RV
[2#GK;,U
l!fDEFb]9?b_DEF
2JZ3R3G7=-LED>8,nDonG!
;R2i?Z3RR=.*>8,aB93DEFCL@1.*
<2:
p:*!;#/?NX;9!DEFA4?_2R;gC
100MHzZ?115MHz<
($3%
I&
M3N-(
2$ -
HL-13A%LEDNH35;&
l7!HVLEDDC#;:201803:*R-;,
lQ=
HL-25
lQ
HL-05
2:
HL-3155X
D:R2J,-1gADO!2$ -<
EO
Wolf Safety Lamp
"&3==
PIQ2R!%7S:6
.#6-(3?0*
Andere Wolf Arbeitsleuchte Handbücher
Beliebte Arbeitsleuchte Handbücher anderer Marken
PowerSmith
PowerSmith PWLD080T Bedienungsanleitung
MaxLite
MaxLite 73683 Bedienungsanleitung
Heitronic
Heitronic Trend 27867 Bedienungsanleitung
Monzana
Monzana Gore MZCL10 Bedienungsanleitung
EINHELL
EINHELL TE-CL 18/2000 LiAC Bedienungsanleitung
Bayco
Bayco NIGHTSTICK Dual-Light Xtreme Lumens... Bedienungsanleitung