Worcester R29 Bedienungsanleitung

Users Instructions and

Customer Care Guide

R 29 / R 40 HE conventional Condensing

boiler

6720 610 577-01.10

ZB 7-28 R 29 HE GC-Number: 41 311 60

ZB 11-40 R 40 HE GC-Number: 41 311 61

6 720 611 138 GB (03.11) TD

Contents

6 720 611 138 GB (03.11)

Contents

Excellence comes as standard 3

Safety precautions 4

1General notes 6

2Controls 8

3Operating the Appliance 9

3.1 Preparation 9

3.2 Switching the Appliance On/Off 10

3.3 Switching on the System 11

3.4Controlling 11

3.5 Setting the Hot Water Temperature of a Cylinder 11

3.6 Frost protection 12

3.7 Fault Condition 12

4Tipsonsaving energy 13

5General Information 14

6Maintaining your appliance 15

7Servicecentres 15

8Faultorbreakdown 16

9YourBoschguarantee 17

10 Guarantee registration 18

11 Operating Instructions Quick Reference 19

Excellence comes as standard

6 720 611 138 GB (03.11)

Excellence comes as standard

Thank you for purchasing a Worcester Greenstar condensing

appliance.

The Worcester Greenstar Series has been developed by the

Bosch Group and the strictest quality control standards are

demanded throughout every stage of production.

Indeed, the Bosch Group have led the field in innovative appliance

design and performance for many years.

The result is that your new Greenstar appliance offers you the very

best of everything – quality, efficiency, economical running costs,

proven reliability and value for money.

What’s more, you also have the assurance of our no nonsense

2yearparts and labour guarantee.

And it’s backed up by Worcester Care Call a complete mainte-

nance scheme to keep your boiler operating at peak condition and

efficiency.

No wonder that more and more people are agreeing that when it

comes to gas, it has to be a Worcester Bosch appliance.

Benchmark

The “Benchmark” initiative is the new code of practice to encour-

age the correct installation, commissioning and servicing of

domestic central heating boilers and system equipment.

The “log-book” is a vital document that must be completed by the

installer at the time of installation. It confirms that the boiler has

been installed and commissioned according to the manufacturers

instructions and is one of the methods of demonstrating

compliance with the Building Regulations.

Without the completion of the “log-book”, manufacturers may

refuse to respond to a call–out from a householder, who will be

advised that he or she must call back the installer, who has not ful-

filled his obligations to record the information required by the ini-

tiative.

Safety precautions

6 720 611 138 GB (03.11)

Safety precautions

Gas Safety (Installation and Use) Regulations

It is the law that all gas appliances are installed by a competent

person in accordance with the above regulations. Failure to install

appliances correctly could lead to prosecution. It is in your inter-

est, and that of safety, to ensure compliance with the law.

If you smell gas:

BTurn off gas service cock at the meter.

BOpen all doors and windows.

BDo not operate any electrical switches.

BDo not smoke.

BExtinguish any naked flames.

BCall your gas company.

If you smell fumes from the appliance:

BSwitch off appliance.

BOpen windows and doors.

BInform your heating engineer.

Fitting and modifications

BFitting of the appliance or any modifications to the appliance

may only be carried out by a competent person.

BFlue systems must not be modified in any way.

Maintenance

BWe recommend that you take out a maintenance contract

with a competent installer and have the appliance serviced at

regular intervals.

BEnsure that your Service Engineer uses only genuine spare

parts!

Combustible materials

BDo not store or use any combustible materials (paper, thin-

ners, paints etc.) in the vicinity of the appliance.

Safety precautions

6 720 611 138 GB (03.11)

Health and safety

BThis appliance contains no asbestos products.

BThere is no potential hazard due to the appliance being electri-

cally unsafe.

BThere are no substances used in the construction that are a

potential hazard in relation to the COSHH Regulations (Con-

trol of Substances Hazardous to Health Regulations).

Combustion Air/Ambient Air

BKeep combustion air/ambient air free of corrosive substances

(e.g. halogenated hydrocarbons which contain chlorine or flu-

orine compounds). In this way corrosion can be prevented.

General notes

6 720 611 138 GB (03.11)

1General notes

To get the best from your appliance please read these instructions

carefully.

Central heating systems

During the first few hours of operation of the central heating sys-

tem, check that all radiators are being heated at an even rate. If the

top of a radiator is at a lower temperature than the bottom then it

should be vented by releasing air through the venting screw at the

top of the radiator. Ask your installer to show you how this is done.

Repeated venting will reduce the quantity of water in the system

and this must be replenished for safe and satisfactory operation of

the appliance. An open vented system will re-fill automatically.

Should water leaks be found in the system or excessive venting is

required then a service engineer must be contacted to inspect the

installation and rectify any fault.

Only additives that are compatible with aluminium may be used in

the system. Any incompatible additive used will invalidate the

guarantee. Contact Fernox or Sentinel for further details.

Condensate drain

This is a condensing appliance and the terminal will, at times, give

out a plume of water vapour. This is quite normal.

The appliance produces quantities of condense which is dis-

charged regularly through the siphon.

Ventilation

This is a room sealed appliance and does not require any air for

combustion from inside the house. If the appliance is fitted into a

cupboard or a compartment is built around the appliance after

installation then the compartment must be separated from the

boiler space by a perforated non-combustible partition as

described in BS6798.

Notwithstanding the requirements of BS6798, there is no need

for ventilation openings to be provided in the compartment

because of the low heat loss from the casing.

Do not allow the flue terminal fitted on the outside wall to become

obstructed or damaged.

General notes

6 720 611 138 GB (03.11)

Clearances

Your installer will have provided adequate space around the appli-

ance for safety and servicing access. Do not restrict this space

with the addition of cupboards, shelves etc. next to the appliance.

Room thermostat

A room thermostat should be fitted to control the central heating.

Refer to the instructions supplied with the thermostat for informa-

tion on siting and setting.

Thermostatic radiator valves

It is recommended that this type of valve is fitted to all the radia-

tors. It is a requirement that they are fitted, at least, in the sleeping

areas.They should conform to the requirements of BS2767:10.

Time Control

Separate time control of the space heating and the hot water sys-

tem is required using a twin-channel programmer or two or more

separate timers.

Cylinder Thermostat

A cylinder thermostat must be fitted to the cylinder which, when

used with a motorised valve, will give close control of the water

temperature.

Left-hand side 10 mm

Right-hand side 10 mm

In Front 600 mm

Above Casing (Vertical Flue) 200 mm

Above Flue Turret 30 mm

Below 200 mm

Table 1

Controls

6 720 611 138 GB (03.11)

2Controls

61 Reset button

135 Master switch

136 Boiler temperature control

170 Service valves in boiler flow and return

172 Gas isolation valve (open)

295 Identification sticker

310 Function control (Service only)

317 Display

363 Indicator lamp for “burner on”

364 Indicator lamp for “off/on”

365 “Chimney sweep” button

366 Service button

367 No function

365 61 317 366 367

ECO

310

364

135

295

136

170

363

172 170

6 720 611 138-01.1O

Operating the Appliance

6 720 611 138 GB (03.11)

3Operating the Appliance

3.1 Preparation

Turn on the gas cock (172).

BPress in the handle and turn it anti-clockwise as far as the stop

(when handle is in line with direction of flow, the cock is open).

Central heating system valves (170)

BUsing a spanner, turn square nut until groove is in line with

direction of flow (see detail).

Groove at right angles to direction of flow = off.

170

172

6 720 611 138-02.1O

Operating the Appliance

6 720 611 138 GB (03.11)

3.2 Switching the Appliance On/Off

Switching on

BSwitch on the appliance at the master switch (I).

The indicator lamp shows green and the display will show the

primary flow temperature.

The trap filling programme ensures that the condensation trap is

filled after the appliance has been installed or after the appliance

has been out of use for a long period. For that reason, the appli-

ance remains at minimum heating output for 15 minutes.

Switching off

BSwitch off the appliance at the master switch (0).

The green indicator lamp goes out.

If the display alternates between -II- and the boiler

flow temperature, the trap filling programme is

active.

6 720 610 333-04.1O

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Worcester Kessel Handbücher

Worcester

Worcester Greenstar Heatslave II External 12/18 Bedienungsanleitung

Worcester

Worcester DANESMOOR UTILITY 12-14 Bedienungsanleitung

Worcester

Worcester GREENSTAR UTILITY 32/50 Bedienungsanleitung

Worcester

Worcester Greenstar Danesmoor 25kW Bedienungsanleitung

Worcester

Worcester Greenstar Si Compact ErP Series Bedienungsanleitung

Worcester

Worcester Greenstar i System ErP Series Benutzerhandbuch

Worcester

Worcester Greenstar Heatslave II External 12/18 Bedienungsanleitung

Worcester

Worcester GB162 Bedienungsanleitung

Worcester

Worcester 280 RSF Betriebsanleitung

Worcester

Worcester GREENSTAR 24i junior Bedienungsanleitung

Worcester

Worcester Greenstar 8000 Life Series Bedienungsanleitung

Worcester

Worcester Greenstar Ri Compact Bedienungsanleitung

Worcester

Worcester GREENSTAR CDi CLASSIC REGULAR ErP Bedienungsanleitung

Worcester

Worcester GREENSTAR 30CDi Classic System ErP 41-406-37 Benutzerhandbuch

Worcester

Worcester greenstar heatslave 18 Bedienungsanleitung

Worcester

Worcester GREENSTAR 24i junior Bedienungsanleitung

Worcester

Worcester danesmoor 15/19 Bedienungsanleitung

Worcester

Worcester Greenstar FS 42CDi Regular Bedienungsanleitung

Worcester

Worcester Greenstar i Series Benutzerhandbuch

Worcester

Worcester Greenstar CDi Bedienungsanleitung

Worcester

Worcester GREENSTAR 24i junior Bedienungsanleitung

Worcester

Worcester Greenstar 8000 Style Series Bedienungsanleitung

Worcester

Worcester Highflow 400 RSF Benutzerhandbuch

Worcester

Worcester 12/18 Bedienungsanleitung

Beliebte Kessel Handbücher anderer Marken

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Bedienungsanleitung

Radijator

Radijator BIO max 23.1 Bedienungsanleitung

Brunner

Brunner BSV 20 Bedienungsanleitung

Buderus

Buderus Logamax GB062-24 KDE H V2 Bedienungsanleitung

Potterton

Potterton 50e Datenblatt

UTICA BOILERS

UTICA BOILERS TriFire Bedienungsanleitung

Joannes

Joannes LADY Series Handbuch

ECR International

ECR International UB90-125 Gebrauchsanweisung

Froling

Froling FHG Turbo 3000 Bedienungsanleitung

Froling

Froling P4 Pellet 8 - 105 Bedienungsanleitung

U.S. Boiler Company

U.S. Boiler Company K2 Bedienungsanleitung

Henrad

Henrad C95 FF Bedienungsanleitung

NeOvo

NeOvo EcoNox EF 36 Bedienungsanleitung

Potterton

Potterton PROMAX SL 12 Bedienungsanleitung

Eco Hometec

Eco Hometec EC 25 COMPACT Bedienungsanleitung

Viessmann

Viessmann VITODENS 200 Leitfaden

Baxi

Baxi Prime 1.24 Bedienungsanleitung

REXNOVA

REXNOVA ISA 20 BITHERMAL Bedienungsanleitung