ADC AD-360X2 Bedienungsanleitung

AD-360X2 Installation Manual

Phase 7

ADC Part No. 113234-3

American Dryer Corporation

88 Currant Road

Fall River MA 02720-4781 USA

Telephone: +1 (508) 678-9000 / Fax: +1 (508) 678-9447

e-mail: techsupport@amdry.com

www.amdry.com

AVERTISSEMENT: Assurez-vous de

bien suivre les instructions données

dans cette notice pour réduire au

minimum le risque d’incendie ou

d’explosionoupourévitertoutdommage

matériel, toute blessure ou la mort.

—Ne pas entreposer ni utiliser d’essence

ni d’autres vapeurs ou liquides

inflammables à proximité de cet

appareil ou de tout autre appareil.

—QUE FAIRE SI VOUS SENTEZ UNE

ODEUR DE GAZ:

●Ne pas tenter d’allumer d’appareils.

●Ne touchez à aucun interrupteur. Ne

pas vous servir des téléphones se

trouvant dans le bâtiment.

●Évacuez la pièce, le bâtiment ou la

zone.

●Appelez immédiatement votre

fournisseur de gaz depuis un voisin.

Suivez les instructions du fournisseur.

●Si vous ne pouvez rejoindre le

fournisseur de gaz, appelez le service

des incendies.

—L’installation et l’entretien doivent être

assurés par un installateur ou un

service d’entretien qualifié ou par le

fournisseur de gaz.

WARNING: For your safety the

information in this manual must be

followed to minimize the risk of fire or

explosion and to prevent property

damage, personal injury or death.

— Do not store or use gasoline or other

flammable vapors and liquids in the

vicinity of this or any other appliance.

— WHAT TO DO IF YOU SMELL GAS:

●Do not try to light any appliance.

●Do not touch any electrical switch;

do not use any phone in your

building.

●Clear the room, building or area of

all occupants.

●Immediately call your gas supplier

from a neighbor’s phone. Follow

the gas supplier’s instructions.

●If you cannot reach your gas

supplier, call the fire department.

— Installation and service must be

performed by a qualified installer,

service agency or the gas supplier.

Retain This Manual In ASafe Place For Future Reference

AmericanDryerCorporationproducts embody advanced concepts in engineering, design, and safety. If this product is properly

maintained, it will provide many years of safe, efficient, and trouble free operation.

ONLY qualified technicians should service this equipment.

OBSERVE ALL SAFETY PRECAUTIONS displayed on the equipment or specified in the installation manual included with

the dryer.

The following “FOR YOUR SAFETY” caution must be posted near the dryer in a prominent location.

“IMPORTANT NOTE TO PURCHASER”

Information must be obtained from your local gas supplier on the

instructionstobe followedif theusersmells gas. These instructionsmust

be posted in a prominent location near the dryer.

We have tried to make this manual as complete as possible and hope you will find it useful. ADC reserves the right to

make changes from time to time, without notice or obligation, in prices, specifications, colors, and material, and to

change or discontinue models. The illustrations included in this manual may not depict your particular dryer exactly.

Important

For your convenience, log the following information:

DATE OF PURCHASE _______________________________ MODEL NO. __________________________________________

RESELLER’S NAME _______________________________________________________________________________________

Serial Number(s) ________________________________________________________________________________________

________________________________________________________________________________________

Replacement parts can be obtained from your reseller or the ADC factory. When ordering replacement parts from the

factory, you can FAX your order to ADC at (508) 678-9447 or telephone your order directly to the ADC Parts Department

at (508) 678-9000. Please specify the dryer model number and serial number in addition to the description and part

number, so that your order is processed accurately and promptly.

AD-360X2 Phase 7

POUR VOTRE SÉCURITÉ

Ne pas entreposer ni utiliser d’essence

ni d’autres vapeurs ou liquides

inflammables à proximité de cet

appareil ou de tout autre appareil.

FOR YOUR SAFETY

Do not store or use gasoline

or other flammable vapors

and liquids in the vicinity of

this or any other appliance.

WARNING

CHILDREN SHOULD NOT BE ALLOWED TO PLAY ON OR NEAR THE

DRYER(S).

CHILDREN SHOULD BE SUPERVISED IF NEAR DRYERS IN OPERATION.

CAUTION

DRYERS SHOULD NEVER BE LEFT UNATTENDED WHILE IN OPERATION.

IMPORTANT

YOU MUST DISCONNECTAND LOCKOUTTHE ELECTRIC SUPPLYANDTHE

GAS SUPPLY OR THE STEAM SUPPLY BEFORE ANY COVERS OR GUARDS

ARE REMOVED FROM THE MACHINE TOALLOWACCESS FOR CLEANING,

ADJUSTING, INSTALLATION, OR TESTING OF ANY EQUIPMENT PER OSHA

(Occupational Safety and Health Administration) STANDARDS.

“Caution: Label all wires prior

to disconnection when servicing

controls.Wiring errors can cause

improper operation.”

«Attention:Aumoment del’entretien des commandes,

étiquetez tous les fils avant de les débrancher. Des

erreurs de câblage peuvent entraîner un

fonctionnement inadéquat et dangereux.»

Proposition 65

Use of this product could expose you to substances from fuel combustion

that contain chemicals known to the State of California to cause cancer,

birth defects and other reproductive harm.

▲ WARNING

Inthe Stateof Massachusetts,thefollowinginstallationinstructions apply:

■Installationsand repairs mustbe performed by a qualifiedor licensed contractor,

plumber,orgasfitterqualifiedorlicensed by the State of Massachusetts.

■Ifusinga ball valve, it shall be aT-handle type.

■Aflexiblegasconnector, when used, must not exceed 3 feet.

WARNING

The dryer must never be operated with any of the back guards, outer tops, or service

panels removed. PERSONALINJURY OR FIRE COULD RESULT.

IMPORTANT

PLEASEOBSERVEALLSAFETYPRECAUTIONSdisplayedontheequipmentand/

or specified in the installation manual included with the dryer.

WARNING

DRYER MUST NEVER BE OPERATED WITHOUT THE LINT FILTER/SCREEN

IN PLACE, EVEN IFAN EXTERNAL LINT COLLECTION SYSTEM IS USED.

Dryer must not be installed or stored in an area where it will be exposed to water or

weather.

The wiring diagram for the dryer is located in the front electrical control box area.

IMPORTANT

Dryer must be installed in a location/environment, which the ambient temperature

remains between 40° F(4.44° C) and 130° F (54.44° C).

WARNING

UNDER NO CIRCUMSTANCES should thedryerdoorswitches,lintdrawerswitches,

or heat safety circuit ever be disabled.

FORYOURSAFETY

DONOTDRYMOPHEADSINTHEDRYER.

DONOTUSEDRYERINTHEPRESENCEOFDRYCLEANING FUMES.

SECTION I

SAFETY PRECAUTIONS.......................................................................................... 3

SECTION II

SPECIFICATIONS...................................................................................................... 5

SECTION III

INSTALLATION PROCEDURES............................................................................. 7

A. Unpacking/Setting Up............................................................................................................... 7

B. Location of the Dryer ............................................................................................................... 8

C. Dryer Enclosure Requirements ................................................................................................. 8

D. FreshAir Supply Requirements ................................................................................................ 9

E. Exhaust Requirements ............................................................................................................ 10

F. Electrical Information ............................................................................................................. 15

G. Gas Information ...................................................................................................................... 18

H. Preparation For Operation ...................................................................................................... 21

I. Preoperational Tests................................................................................................................ 22

J. Shutdown Instructions ............................................................................................................ 23

SECTION IV

PREOPERATIONAL INSTRUCTIONS................................................................. 24

A. Coin Mode .............................................................................................................................. 24

B. Free Mode............................................................................................................................... 24

SECTION V

SERVICE/PARTS INFORMATION ....................................................................... 25

A. Service .................................................................................................................................... 25

B. Parts ........................................................................................................................................ 25

Table of Contents

SECTION VI

WARRANTY INFORMATION ............................................................................... 26

A. ReturningWarrantyCards......................................................................................................... 26

B. Warranty.................................................................................................................................. 26

C. Returning Warranty Parts........................................................................................................ 26

SECTION VII

ROUTINE MAINTENANCE ................................................................................... 28

A. Cleaning .................................................................................................................................. 28

B. Adjustments ............................................................................................................................ 29

C. Lubrication.............................................................................................................................. 29

SECTION VIII

DATA LABEL INFORMATION .............................................................................. 30

SECTION IX

PROCEDURE FOR FUNCTIONAL CHECK

OF REPLACEMENT COMPONENTS .................................................................. 32

SECTIONI

SAFETYPRECAUTIONS

WARNING: Foryoursafety,the informationin thismanualmustbefollowedtominimizetheriskof

fireor explosion ortoprevent property damage,personalinjury, or lossoflife.

WARNING: Thedryermust never be operatedwithanyof the backguards, outer tops,or

servicepanels removed. PERSONALINJURYORFIRECOULD RESULT.

1. DO NOT store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other

appliance.

2. Purchaser/user should consult the local gas supplier for proper instructions to be followed in the event the

user smells gas. The instructions should be posted in a prominent location.

3. WHAT TO DO IF YOU SMELL GAS:

a. DO NOT try to light any appliance.

b. DO NOT touch any electrical switch.

c. DO NOT use any phone in your building.

d. Clear the room, building, or area of ALLoccupants.

e. Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

f. If you cannot reach your gas supplier, call the fire department.

4. Installation and service must be performed by a qualified installer, service agency, or gas supplier.

5. Dryer(s) must be exhausted to the outdoors.

6. Although ADC produces a very versatile dryer, there are some articles that, due to fabric composition or

cleaning method, should not be dried in it.

WARNING: Dryonly water washed fabrics. DONOT dry articles spotted or washed indrycleaning

solvents,a combustibledetergent,or“allpurpose”cleaner.

EXPLOSIONCOULDRESULT.

WARNING: DONOT dry rags or articles coated orcontaminatedwithgasoline,kerosene, oil, paint,

orwax.

EXPLOSIONCOULDRESULT.

WARNING: DONOT dry mop heads. Contaminationbywax or flammablesolventwillcreate a fire

hazard.

WARNING: DONOTuseheatfordrying articles that containplastic,foam,spongerubber,or

similarlytexturedrubbermaterials. Dryingina heatedbasket (tumbler)may damage

plasticsorrubberand may be a fire hazard.

7. A program should be established for the inspection and cleaning of lint in the heating unit area, exhaust

ductwork, and inside the dryer. The frequency of inspection and cleaning can best be determined from

experience at each location.

WARNING: Thecollectionof lintinthe burnerareaandexhaust ductworkcancreate apotentialfire

hazard.

8. For personal safety, the dryer must be electrically grounded in accordance with local codes and/or the

National Electrical Code ANSI/NFPA NO. 70-LATEST EDITION or in Canada, the Canadian Electrical

Codes Parts 1 & 2 CSA C22.1-1990 or LATEST EDITION.

NOTE: Failureto electricallyground thedryerproperlywillVOIDTHEWARRANTY.

9. UNDER NO CIRCUMSTANCES should the dryer door switches, lint drawer switches, or heat safety

circuit ever be disabled.

WARNING: PERSONALINJURYORFIRECOULDRESULTshould the dryer door switch,

lintdoor switch, orheatsafety circuit everbedisabled.

10. This dryer is not to be used in the presence of dry cleaning solvents or fumes.

11. Remove articles from the dryer as soon as the drying cycle has been completed.

WARNING: Articlesleftinthedryer afterthedrying andcoolingcycles havebeen completedcan

createafire hazard.

12. READ AND FOLLOW ALL CAUTION AND DIRECTION LABELS ATTACHED TO THE

DRYER.

13. For safety, proper operation, and optimum performance, the dryer must not be operated with a load less

than sixty-six percent (66%), 39 lbs (17 kg) of its rated capacity.

WARNING: YOUMUSTDISCONNECTANDLOCK OUTTHEELECTRICSUPPLY

ANDTHE GAS SUPPLYBEFOREANYCOVERSORGUARDSARE

REMOVEDFROMTHE MACHINETOALLOWACCESS FOR CLEANING,

ADJUSTING,INSTALLATION,ORTESTINGOFANYEQUIPMENTPER

OSHA(OccupationalSafety andHealthAdministration)STANDARDS.

IMPORTANT: Dryer must be installed in a location/environment, which the ambient

temperatureremainsbetween 40º F (4.44ºC)and 130º F (54.44ºC).

SECTIONII

SPECIFICATIONS

Shaded areas are stated in metric equivalents. 12/16/03

* 30 lbs (13.6 kg) each pocket/tumbler.

** Size of piping varies with installation conditions. Contact factory for assistance.

NOTE: ADCreservestherighttomake changesinspecifications atanytime withoutnoticeor

obligation.

MAXIMUM CAPACITY*

(

DRY WEIGHT

)60lbs 27.2 kg

BASKET

(

TUMBLER

)

DIAMETER 30” 76.2 cm

BASKET

(

TUMBLER

)

DEPTH 26-1/8” 66.4 cm

BASKET

(

TUMBLER

)

MOTOR (

2 PLACES

)1/4hp 0.186 kW

BLOWER (

FAN

)

MOTOR

(

2 PLACES

)1/4hp

0.186 kW

DOOR OPENING

IAMETER

) 21-1/2” 54.6 cm

BASKET

(

TUMBLER

)

VOLUME (

PER POCKET

)10.7cuft 0.304 cu m

DRYERS PER 20’/40’ CONTAINER 11/22

DRYERS PER 48’/53’ TRUCK 27/30

VOLTAGE AVAILABLE 120-240 / 1ø / 2w / 60 Hz

APPROX. NET WEIGHT 790 lbs 358.3 kg

APPROX. SHIPPING WEIGHT 850 lbs 385.6 kg

HEAT INPUT 176,000 Btu/hr 44,352 kcal/hr

AIRFLOW (

TOTAL BOTH BASKETS

) 1,040 cfm 29.5 cmm

INLET PIPE CONNECTION** 3/4” F.N.P.T.

Gas

NOTE: ADCreservestherighttomake changesinspecifications atanytime withoutnoticeor

obligation.

Specifications

Inhaltsverzeichnis

Beliebte Trockner Handbücher anderer Marken

Bosch

Bosch WTA79200GB Bedienungsanleitung

Amana

Amana W10233410A Bedienungsanleitung

Miele

Miele TWH 780 WP Bedienungsanleitung

Asko

Asko T760 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 25 Series Bedienungsanleitung

Bosch

Bosch Logixx 10 WTB76556GB Technisches Datenblatt

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Bedienungsanleitung

Electrolux

Electrolux EW2H328R2 Bedienungsanleitung

Beko

Beko DS8433RX1M Bedienungsanleitung

Dawlance

Dawlance Spinner DS 6000 C Bedienungsanleitung

Electrolux

Electrolux TP5080TW Bedienungsanleitung

AEG

AEG TR838P4OB Bedienungsanleitung

Indesit

Indesit IDV 75 Bedienungsanleitung

Infiniton

Infiniton SD-DG85C Bedienungsanleitung

BOMANN

BOMANN WT 5019 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems TMB795C Bedienungsanleitung

Asko

Asko T793C Bedienungsanleitung

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Bedienungsanleitung