Advantech IPC-602 Bedienungsanleitung

IPC-602

Industrial PC Chassis

All manuals and user guides at all-guides.com

all-guides.com

This document is copyrighted, July 1999, by Advantech Co., Ltd. All rights are reserved. Advantech

Co., Ltd. reserves the right to make improvements to the products described in this manual at any time

without notice.

No part of this manual may be reproduced, copied, translated, or transmitted in any form or by any

means without the prior written permission of Advantech Co., Ltd. Information provided in this

manual is intended to be accurate and reliable. However, Advantech Co., Ltd. assumes no responsibili-

ty for its use, nor for any infringements of the right of third parties which may result from such use.

Acknowledgments

IPC-602 and PCA-6106VP3 are trademarks of Advantech Co., Ltd.

Note: The information in this document is provided for reference only. Advantech does

not assume any liability arising out of the direct or indirect use of the information

or products described herein.This manual is subject to change without notice.

Part No. 2002060200

1st Edition Printed in Taiwan July 1999

All manuals and user guides at all-guides.com

Contents

Chapter 1 General Information..................................................... 1

1.1 Introduction .............................................................................................................. 1

1.2 Specifications .......................................................................................................... 1

1.3 Dimensions .............................................................................................................. 3

Chapter 2 System Setup ............................................................... 4

2.1 Removing the Cover ................................................................................................ 4

2.2 Adding Disk Drives .................................................................................................. 5

2.4 Replacing the Fan ................................................................................................... 6

2.3 Installing Plug-in Cards ............................................................................................ 6

2.5 Replacing the Filter .................................................................................................. 7

Appendix A Passive Backplane ................................................................................... 8

Appendix B Exploded Diagram .................................................................................... 9

Appendix C Parts Ordering Guide.............................................................................. 10

Appendix D Safety Instructions.................................................................................. 11

D.1 English ........................................................................................................................... 11

D 2 German - Wichtige Sicherheishinweise ......................................................................... 12

All manuals and user guides at all-guides.com

IPC-602 User's Manual

Chapter 1 General Information

1.1 Introduction

The IPC-602 is a compact rugged 19" 2U-height rackmount chassis designed for space-limited applica-

tion. With its rugged, sturdy and well-cooled steel chassis specially designed to withstand heavy

shocks and thick dust, the IPC-602 can be used in the harshest of environments. It is ideal for

low-density CT or network system configurations that require high availability within a limited space,

such as computer telephony and networking systems.

1.2 Specifications

Construction: Heavy-duty steel

Disk drive capacity: One 5.25" and two 3.5" drive bays

Indicators: LEDs for power On/Off, HDD and 3.3 V

Controls: Power On and Reset switches on front panel

Cooling fan: Two 42 CFM fans on front panel, with air filters

Weight: 9.8 kg (21.8 lbs)

Dimensions (W x D x H): 481.2 x 449.5 x 88 mm (19" x 17.7" x 4")

Interior paint color: Black 2U, 2X; Fabric Texture

Passive backplane (PCA-6106VP3)

Slots: 2 ISA / 3 PCI / 1 PICMG

PC board: 6-layer PCB with ground and power planes for reduced noise and low power-supply

impedance

Indicators: LEDs for +5 V, +12 V, -5 V, -12 V, +3.3 V

Power supply (PS-250X-DPS)

Output rating: 250 watts max.

Input rating: 90 ~ 135 Vac or 180 ~ 265 Vac @ 47 ~ 63 Hz, switchable

Output voltage: +5 V @ 25 A, +12 V @ 8 A, -5 V @ 0.5 A, -12 V @ 0.8 A, +3.3 V @ 14 A,

+5 VSB @ 1 A

Minimum load: +5 V @ 1.5 A, +12 V @ 0.2 A

MTBF: 100,000 hours @ 90% load

Safety: UL/TUV/Nordic approved

EMI: Meets FCC/VDC Class B

All manuals and user guides at all-guides.com

IPC-602 User's Manual

Power supply (PS-260)

Output rating: 260 watts max.

Input rating: 85 ~ 130 Vac or 180 ~ 260 Vac @ 47 ~ 63 Hz, switchable

Output voltage: +5 V @ 25 A, +12 V @ 9 A, -5 V @ 0.5 A, -12 V @ 2 A,

Minimum load: +5 V @ 1 A, +12 V @ 0.1 A

MTBF: 200,000 hours @ 70% load

Safety: UL/CSA/TUV approved

EMI: Meets FCC/VDE Class B

Power supply (PS-30XDC48-BPS)

Output rating: 300 watts max.

Input rating: -40 ~ 56 Vdc @ 47 ~ 63 Hz

Output voltage: +5 V @ 30 A, +12 V @ 12 A, -5 V @ 0.5 A, -12 V @ 1 A, +3.3 V @ 20 A,

+5 VSB @ 1.5 A

Minimum load: +5 V @ 3 A, +12 V @ 1 A

MTBF: 119,122 hours @ 75% load

Safety: UL/TUV

EMI: Meets FCC/VDC Class A

Environmental specifications

Operating temperature: 0 ~ 45° C (32 ~ 113° F)

Relative humidity: 10 ~ 95% @ 40° C, non-condensing

Safety: UL / CE approved

CE compliant

All manuals and user guides at all-guides.com

IPC-602 User's Manual

1.3 Dimensions

COMPACT

110V

RES ET

POW ER

3.3V

HDD

3.3V

POW ER

Unit: mm (inches)

All manuals and user guides at all-guides.com

all-guides.com

IPC-602 User's Manual

Chapter 2 System Setup

The following procedures are provided to assist you in installing drives and plug-in cards into the

IPC-602.

2.1 Removing the Cover

Unscrew the six screws on the front and rear panels , and then slide the cover toward the rear chassis.

See Figure 2-1 below:

Figure 2-1: Removing the cover

Step 1

Step 3

Step 2

All manuals and user guides at all-guides.com

IPC-602 User's Manual

2.2 Adding Disk Drives

After removing the cover, you can easily install disk drives. Refer to Figure 2-2 below and do the

following:

1. Remove the four outer screws which mount the drive bay to the chassis.

2. Slide the drive bay about 1 cm. toward the rear, to a location where it is not obstructed by the upper

rim. Lift it free of the chassis.

3. Remove the cover of the front drive bay, and insert the drives into their proper locations in the drive

bay.

Figure 2-2: Adding disk drives

All manuals and user guides at all-guides.com

IPC-602 User's Manual

2.3 Installing Plug-in Cards

After removing the cover, you can easily install plug-in cards. See Figure 2-3 below:

Figure 2-3: Installing plug-in cards

2.4 Replacing the Fan

Unscrew the two screws on the fan, and slide the cover toward the rear chassis. See Figure 2-4 below:

Figure 2-4: Replacing the fan

Step 1 Step 2

All manuals and user guides at all-guides.com

IPC-602 User's Manual

2.5 Replacing the Filter

The filter is located next to the lockable door. If the IPC-602 is under continuous use, the filter should

be changed about once a month. To replace the filter, refer to Figure 2-5 below and do the following:

1. Open the lockable door.

2. Remove the filter by gently pulling the tab and sliding the filter to the right.

3. Slide a new filter in until it snaps into place.

4. Close and lock the lockable door.

Figure 2-5: Replacing the filter

All manuals and user guides at all-guides.com

Andere Handbücher für IPC-602

Andere Advantech Chassis Handbücher

Advantech

Advantech ACP-7000 Bedienungsanleitung

Advantech

Advantech HPC-8104 Bedienungsanleitung

Advantech

Advantech HPC-7400 Bedienungsanleitung

Advantech

Advantech IPC-7120 Bedienungsanleitung

Advantech

Advantech IPC-3012 Bedienungsanleitung

Advantech

Advantech ACP-2020 Bedienungsanleitung

Advantech

Advantech ACP-4001 Bedienungsanleitung

Advantech

Advantech ACP-2000 Bedienungsanleitung

Advantech

Advantech ACP-1000MB Bedienungsanleitung

Advantech

Advantech IPC-622MS Bedienungsanleitung

Advantech

Advantech ACP-4010 Bedienungsanleitung

Advantech

Advantech IPC-602 Bedienungsanleitung

Advantech

Advantech AIMB-C200 Bedienungsanleitung

Advantech

Advantech HPC-7484 Bedienungsanleitung

Advantech

Advantech IPC-3026 Bedienungsanleitung

Advantech

Advantech HPC-7120 Bedienungsanleitung

Advantech

Advantech EPD-B101 Bedienungsanleitung

Advantech

Advantech IPC-622MS Bedienungsanleitung

Advantech

Advantech ACP-4D00 Bedienungsanleitung

Advantech

Advantech IPC-601-SCA Bedienungsanleitung

Advantech

Advantech HPC-7000 Bedienungsanleitung

Advantech

Advantech IPC-623 Series Bedienungsanleitung

Advantech

Advantech HPC-5000 Bedienungsanleitung

Advantech

Advantech RMD-1150 Bedienungsanleitung

Beliebte Chassis Handbücher anderer Marken

IMC Networks

IMC Networks iMcV/18 Bedienungsanleitung

Chenbro

Chenbro RB13804N4WFT Bedienungsanleitung

Lenovo

Lenovo ThinkSystem SR665 V3 Bedienungsanleitung

Wuntronic

Wuntronic PCI4DRQ Bedienungsanleitung

EtherWAN

EtherWAN EMC400 Bedienungsanleitung

Overland Storage

Overland Storage SnapSAN S1000 Leitfaden

Philips

Philips LC4.1E A Bedienungsanleitung

Supermicro

Supermicro SCF418 Series Bedienungsanleitung

Chenbro

Chenbro RM437 Series Bedienungsanleitung

Pickering

Pickering 40-914 Bedienungsanleitung

HP A7503-S Montageanleitung

Supermicro

Supermicro SC823MTQ-R700LPB Bedienungsanleitung

SilverStone

SilverStone RMS08 Series Bedienungsanleitung

NI cRIO-FRC II Bedienungsanleitung

Pickering

Pickering 65-200 Bedienungsanleitung

Allied Telesis

Allied Telesis AT-MMCR18 Bedienungsanleitung

Hisense

Hisense MSD6586 Bedienungsanleitung

Cisco

Cisco Nexus 7010 Bedienungsanleitung