Advantech PCL-846 Series Bedienungsanleitung
PCL-846/847
4-Port RS-422/485
Interface Card
Copyright Notice
This documentation and the software included with this product are
copyrighted 1998 by Advantech Co., Ltd. All rights are reserved.
Advantech Co., Ltd. reserves the right to make improvements to the
products described in this manual at any time without notice.
No part of this manual or software may be reproduced, copied,
translated or transmitted, in any form or by any means without the
prior written permission of Advantech Co., Ltd. Information provid-
ed in this manual is intended to be accurate and reliable. However,
Advantech Co., Ltd. assumes no responsibility for its use, nor for any
infringements of rights of third parties which may result from its use.
Acknowledgments
PC-LabCard is a trademark of Advantech Co., Ltd. IBM, PC and
PC/XT/AT are trademarks of International Business Machines
Corporation. MS-DOS, MASM, QuickBASIC, Microsoft C and MS-
PASCAL are trademarks of Microsoft Corporation. Intel is a trade-
mark of Intel Corporation. Turbo C and Turbo PASCAL are trade-
marks of Borland International. MOXA is a trademark of Moxa
Technologies Inc.
Part No. 2000000300 1st Edition
Printed in Taiwan December 1998
Contents
Chapter 1: Introduction ................................................... 1
Description.................................................................................................2
Features......................................................................................................2
Specifications ............................................................................................. 3
Card Jumper Layout ................................................................................4
Chapter 2: Hardware Installation .................................... 7
Initial Inspection .......................................................................................8
Card Installation ....................................................................................... 9
Card Configuration ................................................................................10
Default Settings .......................................................................................10
RS-422/485 Selection (JP3, JP5, JP7, JP9) ..........................................10
I/O Address and Interrupt Setup .......................................................... 11
Speed Mode Selection .............................................................................17
Enable Mode Selection (JP4, JP6, JP8, JP10) .....................................18
Chapter 3: Software Installation ................................... 19
Operating Environment Selection.........................................................20
Driver Installation for DOS Users ........................................................20
Driver Installation for Windows 3.1 Users...........................................25
ICOM Utility Setup for Windows 95/98/NT Environments ...............26
Chapter 4: Wiring ........................................................... 29
Pin assignments .......................................................................................30
RS-422 signal wiring...............................................................................30
RS-485 signal wiring...............................................................................31
Appendix A: PC I/O Address Reference ......................... 33
PC I/O Address Usage ............................................................................34
Appendix B: Quick Reference ........................................ 35
1
Introduction
CHAPTER
2PCL-846/847 User's Manual
Description
PCL-846/847 series cards provide four independent RS-422/485 serial
ports on a card. Each port has a 16C550 UART with an on-chip 16-
byte FIFO buffer for reliable, high-speed serial I/O. The UART
buffers data into 16-byte packets before putting it on the bus. This
drastically reduces the CPU load and avoids data loss when the system
is busy and cannot process the interrupt quickly. The UART is
especially useful for high speed serial I/O under Windows.
PCL-846 cards differ from PCL-847 cards in that they utilize on-
board optical isolators to protect your PC and equipment against
damage from ground loops, increasing system reliability in harsh
environments. To further increase reliability, PCL-846B/847B cards
include surge protection technology, protecting your system from
abrupt high voltage surges (up to 2000 V). The PCL-846/847 series
has passed the CE test for environmental specifications.
An RS-485 Network with Automatic Data Flow Control Using RS-232
Software
The RS-485 mode automatically senses the direction of incoming data
and switches its transmission direction accordingly. This feature
means your network looks and acts just like an RS-232 network.
Application software written for half duplex RS-232 can be used
without modification. Moreover, you can simply and quickly build an
RS-485 network with just two wires.
Features
• Four independent RS-422/RS-485 serial ports
• Transmission speeds up to 921.6 Kbps
• Shared/Independent IRQ settings between each of the 4 serial ports
• Wide IRQ selection: 3, 4, 5, 6, 7, 9, 10, 11, 12 or 15
• Supports standard DOS COM1, COM2, COM3, and COM4
• Supports DOS/Windows 3.1 (PC-ComLIB), Windows 95, Windows NT
(ICOM Utility)
• Provides 1000 VDC isolation (PCL-846A/846B only)
Chapter 1 Introduction 3
• Provides 2000 VDC surge protection (PCL-846B/847B)
• Space reserved for termination resistors
• Supports 2 wire or 4 wire operation
• Supports Tx, Rx, RTS, and CTS signals
• Automatic RS-485 data flow control or RTS control
• RS-422 on Auto/RTS/On mode
Specifications
•Ports: 4
•UART: 4 x 16C550 with 16-byte FIFO
•Speed: 50 ~ 921.6 Kbps
•Parity: none, even, odd
•Signal support:
TxD+, TxD-, RxD+, RxD-, CTS+, CTS-, RTS+, RTS- and GND
•I/O address: From 200H to 3F8H
•IRQ: 3, 4, 5, 6, 7, 9, 10, 11, 12 or 15
•Isolation voltage: 1000 VDC (PCL-846A/846B only)
•Surge protection: 2000 VDC (PCL-846B/847B)
•Power consumption: PCL-847; +5 V @ 460 mA typical, 570 mA max.
PCL-846; +5 V @ 970 mA typical, 1200 mA max.
•Cables: 30-cm male DB-37 to four male DB-9 (DTE)
•Operating temperature: 0 ~ 60°C (32 ~ 140°F) (refer to IEC-68-1.2.3)
•Storage temperature: -25 ~ 80°C (-13 ~ 176°F)
•Dimensions: 185 mm x 100 mm (7.3" x 3.9")
•MTBF: PCL-847A 126630 hrs at 25°C Ground, Fixed environment
PCL-847B 120992 hrs at 25°C Ground, Fixed environment
PCL-846A 105014 hrs at 25°C Ground, Fixed environment
PCL-846B 101107 hrs at 25°C Ground, Fixed environment
• For technical support and service please visit our support website at
http://support.advantech.com
and visit the "Industrial Automation Support" and "FAQ" sections.
4PCL-846/847 User's Manual
Figure 1-1: PCL-847 switch and jumper layout
Card Jumper Layout
Chapter 1 Introduction 5
Figure 1-2: PCL-846 switch and jumper layout
6PCL-846/847 User's Manual
Dieses Handbuch passt für folgende Modelle
5
Inhaltsverzeichnis
Andere Advantech Computerhardware Handbücher
Advantech
Advantech MIO-5377 Bedienungsanleitung
Advantech
Advantech PCA-6751 Series Bedienungsanleitung
Advantech
Advantech SOM-9590 Bedienungsanleitung
Advantech
Advantech SOM-3565 Bedienungsanleitung
Advantech
Advantech PCM-23U1DG-CE Installations- und Betriebshandbuch
Advantech
Advantech AIMC-3421 Installations- und Betriebshandbuch
Advantech
Advantech PCA-6145B Bedienungsanleitung
Advantech
Advantech MIC-75M20 Installations- und Betriebshandbuch
Advantech
Advantech PCA-6184 Bedienungsanleitung
Advantech
Advantech PCL-818 Series Bedienungsanleitung
Advantech
Advantech MIO-5377 Installations- und Betriebshandbuch
Advantech
Advantech PCL-725 Bedienungsanleitung
Advantech
Advantech HPC-7420 Bedienungsanleitung
Advantech
Advantech SOM-4463 B2 Bedienungsanleitung
Advantech
Advantech MIC-3332 Bedienungsanleitung
Advantech
Advantech SOM-6897 Bedienungsanleitung
Advantech
Advantech PCA-6151 Bedienungsanleitung
Advantech
Advantech PCIE-1203 Bedienungsanleitung
Advantech
Advantech PCIE-1753 Bedienungsanleitung
Advantech
Advantech Watchdog Timer UNO-2171 Bedienungsanleitung
Beliebte Computerhardware Handbücher anderer Marken
EMC2
EMC2 VNX Series Betriebsanleitung
Panasonic
Panasonic DV0PM20105 Bedienungsanleitung
Mitsubishi Electric
Mitsubishi Electric Q81BD-J61BT11 Bedienungsanleitung
Gigabyte
Gigabyte B660M DS3H AX DDR4 Bedienungsanleitung
Raidon
Raidon iT2300 Bedienungsanleitung
National Instruments
National Instruments PXI-8186 Bedienungsanleitung
