Advantech SPC-520 Series Bedienungsanleitung

SPC-520

Rackmount Server PC

This document is copyrighted, September 1999 , by Advantech Co., Ltd. All rights are reserved. Advan-

tech Co., Ltd. reserves the right to make improvements to the products described in this manual at any

time without notice.

No part of this manual may be reproduced, copied, translated or transmitted in any form or by any

means without the prior written permission of Advantech Co., Ltd. Information provided in this manual

is intended to be accurate and reliable. However, Advantech Co., Ltd. assumes no responsibility for its

use, nor for any infringements of the rights of third parties which may result from its use.

Acknowledgments

SPC-520, SPC-520MB, SPC-520P4, SPC-520P7, SPC-520MB-UW, SPC-520MB-U2 series and PCA-

6109P4, PCA-6109P7 are the trademark of Advantech Co., Ltd.

NOTE:

The information in this document is provided for reference only. Advantech does not assume any liability arising

out of the application or use of the information or products described herein. This manual is subject to change

without notice.

Part No. 2002052000 1st Edition

Printed in Taiwan October 1999

Contents

Chapter 1 General Information..................................................................1

1.1 Introduction................................................................................................................. 1

1.2 Model List..................................................................................................................1

1.3 Specifications ............................................................................................................ 1

1.4 Dimensions................................................................................................................ 4

Chapter 2 System Setup ............................................................................5

2.1 RemovingtheCover..................................................................................................5

2.2 RemovingtheHandles...............................................................................................6

2.3 TheCoolingFans.......................................................................................................6

2.4 InstallingtheDiskDrives.............................................................................................7

2.5 TemperatureSetting..................................................................................................7

2.6 InstallingthePowerSupplyUnit..................................................................................8

Appendix A Passive Backplane......................................................................................9

Appendix B Exploded Diagrams.....................................................................................10

AppendixC Safety Instructions......................................................................................12

SPC-520 User's Manual 1

Chapter 1 General Information

1.1 Introduction

The SPC-520P7 / SPC-520MB are PC/AT-compatible computer designed for high relibility applications,

not only easily installation and maintain for mission critical applications and harsh environment use, is a

high-end rackmount Fault Resilient IPC chassis. The SPC-520P7 includes a 7PCI/1ISA/1PICMG-slot

PC-bus compatible passive backplane and 400-watt ATX redudnant power supply. The SPC-520MB

can be installed ATX mother board and includes one 400-watt ATX power supply. Both SPC-520P7/MB

provide three hot-swappable fan cooling system and accepts up to ten front-accessable half-heigh disk

drives.

SPC-520P7/MB feature an advanced fault detection and alarm notification system to monitor its own

hardware status. It is dangerous and will cause a lot of loss if your PC system shuts down without any

warning in advance.

1.2 Model List

rebmuNledoMenalpkcaBylppuSrewoPCD-CAttaw-004

7P025-CPStols-GMCIP1/ASI1/ICP7ylppuSrewoPtnandudeRXTAttaw-004

BM025-CPS rofecapsehtevreseR(*** )draobrehtoMXTA )ezis2/SP(ylppuSrewoPXTAttaw-004

1.3 Specifications

Construction: Heavy-duty steel chassis

Disk drive capacity: Front-accessible eight half-height drives (vertical), and two half-height drives

(Horizontal)

Cooling system: Three 86 CFM cooling fans inside the chassis

Controls: Power On/Off switch on power supply module in rear panel, Alarm Reset botton, ATX

Soft-Switch and system reset botton on the front panel

Indicators: Bi-color LEDs (green and red) for Power failure, fan failure and overheating. LED

indicator (green) for system power on/off.

Buzzer: One buzzer for audio alarm / volumn control on board

Dimensions: 19"(W) x 8.75"(H) x 26"(D), 482mm(W) x 222.25mm(H) x 660mm(D)

Net Weight: RAID-520MB : 37.4 lb (17 Kg), RAID-500P7 : 44 lb (20 Kg)

Paint color: (Front panel) Pantone Black 4C 2X, (Chassis) Brushed finish, Ni

Operating temperature: 0 to 50oC (32 to 122oF)

Relative humidity: 20% to 90%

CE Compliant

2SPC-520 User's Manual

Passive Backplane: PCA-6109P7 (for SPC-520P7)

Slots: 1 ISA/7 PCI/1 PICMG-slot

PC Board: 4-layer PCB with ground and power planes for reduced noise and ower power supply

impedance

Indicators: LEDs for +3.3V, +5 V, -5 V, +12 V and -12 V

Hot-swappable AC-DC 400-watt ATX Redundant Power Supply (RPS-400ATX)

Output rating: 400 watts (Max.)

Input voltage: 90 to 132 VAC or 180 to 264 VAC @ 47~63 Hz, switchable

Output voltages: +5 V @ 42 A, +3.3V @ 20A, +12 V @ 14 A, -5 V @ 1 A, -12 V @ 1 A

+5Vsb @ 0.75A(+5V /+3.3V Total: 210Watt)

Minimum load: +5 V @ 2 A, +3.3V @ 0.3A, +12 V @ 0.5 A

MTBF: 100,000 hours at 25oC, 70% Load

Safety: UL/C-UL/TUV/CE Approved

AC-DC 400-watt ATX Power Supply PS/2-size (PS-400ATX)

Output rating: 400 watts (Max.)

Input voltage: 90 to 132 VAC or 180 to 264 VAC @ 47~63 Hz, switchable

Output voltages: +5 V @ 42 A, +3.3V @ 20A, +12 V @ 14 A, -5 V @ 1 A, -12 V @ 1 A

+5Vsb @ 0.75A (+5V /+3.3V Total : 210Watt)

Minimum load: +5 V @ 2 A, +3.3V @ 0.3A, +12 V @ 0.5 A

Minimum load: +5 V @ 3 A, +12 V @ 1 A

MTBF: 100,000 hours at 25oC, 70% Load

Safety: UL/C-UL/TUV/CE Approved

SPC-520 User's Manual 3

Fault Detection and Alarm Notification

Power failure: It works only when you install the redundant power supply (RPS-400ATX)

If either of the two power modules fails, the dedicated LED (PWR) changes color from green to red

also audio alarm. The dedicated LED remains red for failed power module until it fixed.

Fan failure: If either of the three cooling fans fails, the dedicated LED (Fan 1 or Fan 2) changes

color from green to red also audio alarm. The dedicated LED remains red for failed fan set until it

fixed.

The fan ass'y can be hot-swap if either fan is fail Dual fans for redundant application

High Temperature:If the chassis interior temperature exceeds 65oC(149oF)(standard setting), the

LED changes color from green to red also audio alarm. The LED remains red until the temperature

goes below 63oC

Temperature Select: The temperature can be set on four status by adjust the switch on alarm

board : 65oC (Default setting) , 55oC , 70oC and 75oC

Audible Alarm: Buzzer on board is activated (continous beep)as soon as a malfunction is detected

and sounds until the alarm reset button is pressed. The alarm reset button is on the front panel. Howev-

er, the alarm indicator will stay red until the fault condition is resolved.

Self-Test: Press the Alarm reset button for 8 senconds, the alrm board will self-test automatically

for all functions. The alarm board also can monitor the temperature's sensor IC. If the sensor is failed

or no connection, the buzzer will alarm as " Beep x Beep x ...".

The Controls for System

The SPC-520 provides one soft-switch and one system reset botton to re-boot the PC system on the

front panel. See figure as following :

System Reset Botton

Soft Switch

4SPC-520 User's Manual

1.4 Dimensions Unit = mm

SPC-520P7

SPC-520MB

SPC-520 User's Manual 5

2.1 Remov the cover

Chapter 2 System Setup

The SPC-520 is a ATX-compatible computer designed for industrial applications. This rugged chassis

meets the EIA RS-310C 19" rackmount standard.

Setting up your SPC-520 requires only a screwdriver and a small amount of time. Before you begin,

you should also gather together all of the cards you plan to install, as well as the disk drives you plan

to use.

WARNING:Disconnect all power from the chassis before you install

the CPU cards. Unplug the power cord from the wall,

don't just turn off the power switch. If you are not sure

what to do, take the job to an experienced professional.

2.1 Removing the Cover

There are screws near the top along the sides and on the rear secure the cover to the chassis. Remove

them, and then slide the cover toward the rear chassis. See figure 2.1 below:

6SPC-520 User's Manual

2.2 Removing the Handles

The handles and mounting ears for the front panel can be removed as follows. Please see figures 2.2

below

2.3 The Cooling Fans

There are three cooling fans inside the chassis. To replace the fans for maintainence : open the top

cover as the figure 2.1 and loosen the thumbscrews, then plug the whole fan ass'y. please refer to figure

2.3 below.

2.3 Cooling fans

2.2 Removing the handles

SPC-520 User's Manual 7

2.4 Removing the disk drive bay

2.4 Installing the Disk Drives

1. Open the top cover as figure2.1. There are two independent disk drive bays on the both sides.

Remove the four outer screws which mount the drive-bay to the chassis. See figure 2.4 below

2. Slide the drive-bay toward the rear chassis and lift it free of the chassis. Remove the cover of the

drive bay front and insert the drives into their proper locations in the drive bay. See figure 2.5

2.5 Inserting the drives into the drive bay

2.5 Temperature Setting

If the chassis interior temperature exceeds 65oC(149oF)(default setting), the LED changes color from

green to red also audio alarm. The LED remains red until the temperature goes below 63oC

Temperature also can be selected (SW1) on the alarm board inside the chassis :

SW1

1 2 TEMP

OFF OFF 65oC

OFF ON 55oC

ON OFF 70oC

ON ON 75oC

2.6 Alarm board

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Advantech Server Handbücher

Advantech

Advantech EKI-1500 Series Bedienungsanleitung

Advantech

Advantech B+B SmartWorx ABDN-SE-IN5410 Bedienungsanleitung

Advantech

Advantech EKI-1351 Bedienungsanleitung

Advantech

Advantech MIC-6314 Series Bedienungsanleitung

Advantech

Advantech SKY-8132S Bedienungsanleitung

Advantech

Advantech VESR900 Series Bedienungsanleitung

Advantech

Advantech sky-8100 Bedienungsanleitung

Advantech

Advantech PCE-5B12-00A1E Installations- und Betriebshandbuch

Advantech

Advantech SKY-8101D Bedienungsanleitung

Advantech

Advantech BB-VESP211-232 Bedienungsanleitung

Advantech

Advantech ASMB-622 Bedienungsanleitung

Advantech

Advantech FWA-6510 Bedienungsanleitung

Advantech

Advantech BB-VESR90 Series Bedienungsanleitung

Advantech

Advantech ADAM-4571 Bedienungsanleitung

Advantech

Advantech DMS-SA21 Installations- und Betriebshandbuch

Advantech

Advantech FWA-5070 Bedienungsanleitung

Advantech

Advantech DVG-1100 Bedienungsanleitung

Advantech

Advantech ISV-1320-ISC Bedienungsanleitung

Advantech

Advantech SKY-642 Bedienungsanleitung

Advantech

Advantech SKY-7210 Installations- und Betriebshandbuch

Advantech

Advantech EKI-1528-DR Bedienungsanleitung

Advantech

Advantech PAC-4010 Bedienungsanleitung

Advantech

Advantech BB-VESR902D Bedienungsanleitung

Advantech

Advantech ARK-1122 Bedienungsanleitung

Beliebte Server Handbücher anderer Marken

HP AlphaServer ES47 Bedienungsanleitung

Dell

Dell PowerEdge R410 Bedienungsanleitung

PowerNAS

PowerNAS CMA Bedienungsanleitung

Supero

Supero FatTwin F617R3-FT Bedienungsanleitung

MSI

MSI P1-109N-L70 Bedienungsanleitung

Dell

Dell PowerEdge XE9640 Handbuch

Dell

Dell PS4100 Montageanleitung

EtroVISION

EtroVISION EV3151 Bedienungsanleitung

NEC

NEC Express5800/T110j Bedienungsanleitung

HP ProLiant Gen9 Bedienungsanleitung

Compaq

Compaq ProLiant 3000 Handbuch

Dell

Dell PowerEdge 3YPMN Bedienungsanleitung

iRobo

iRobo IPC2U Bedienungsanleitung

Nortel

Nortel 1000 Con?guration guide Bedienungsanleitung

Asus

Asus AP7500 Bedienungs- und Wartungshandbuch

Avid Technology

Avid Technology AirSpeed 5000 Bedienungsanleitung

HP Integrity rx2600 Installationsanleitung

Milestone

Milestone Husky IVO 350T Bedienungsanleitung