Airwell SXV009 Bedienungsanleitung

INSTALLATION MANUAL

MODELS

Floor/Ceiling unit

SXV 007 SXV 009

SXV 012 SXV 015

SXV 018 SXV 021

SXV 024

SAFETY PRECAUTIONS

Part NO:468050100/02

● Readthefollowing"SAFETYPRECAUTIONS"carefullybeforeinstallation.

● Carryouttestrunningtoconrmthatnoabnormalityoccursafter the installation.Then,explaintousertheoperation,careandmaintenance asstatedin

instructions.Pleaseremindthecustomertokeeptheoperatinginstructionsforfuturereference.

Thisindicationshowsthepossibilityofcausingdeathorseriousinjury.

WARNING

Thisindicationshowsthepossibilityofcausingharmordamagetheequipment.

CAUTION

WARNING

1)Usequaliedinstallerandfollowcarefullythisinstructions.Otherwiseitwillcauseelectricalshock,waterleakage,orestheticproblem.

2)Installatastrongandrmlocationwhichisabletowithstandtheset'sweight.Ifthestrengthisnotenoughorinstallationisnotproperlydone,theset

willdropandcauseinjury.

3)Forelectricalwork,followthelocalnationalwiringstandard,regulationandthisinstallationinstruction.Anindependentcircuitandsingleoutletmust

beused.Ifelectricalcircuitcapacityisnotenoughordefectfoundinelectricalwork,itwillcauseelectricalshockorre.

4)Usethespeciedcableandconnecttightlyforindoorconnection.Connecttightlyandclampthecablesothatnoexternalforcewillbeactedonthe

terminal.Ifconnectionorxingisnotperfect,itwillcauseheat-uporreattheconnection.

5)Wireroutingmustbeproperlyarrangedsothatcontrolboardcoverisxedproperly.Ifcontrolboardcoverisnotxedperfectly,itwillcauseheat-up

atconnectionpointofterminal,reorelectricalshock.

6)Whencarryingoutpipingconnection,takecarenottoletairsubstancesotherthanthespeciedrefrigerantgointorefrigerationcycle.Otherwise,it

willcauselowercapacity,abnormalhighpressureintherefrigerationcycle,explosionandinjury.

7)Donotdamageoruseunspeciedpowersupplycord.Otherwise,itwillcausereorelectricalshock.

8)Thisequipmentmustbeearthed.Itmaycauseelectricalshockifthegroundingisnotperfect.

9)Donotinstalltheunitatplacewhereleakageofammablegasmayoccur.Incasegasleaksandaccumulatesatsurroundingoftheunit,itmay

causere.

CAUTION

1)Selectionoftheinstallationlocation.

Selectainstallationlocationwhichisrigidandstrongenoughtosupportorholdtheunit,andselectalocationforeasymaintenance.

2)Donotreleaserefrigerant.

Donotreleaserefrigerantduringpipingworkforinstallation,reinstallationandduringrepairingarefrigerationparts.Takecareoftheliquidrefrigerant.

itmaycausefrostbite.

3)Itmayneedtwopeopletocarryouttheinstallationwork.

4)Donotinstallthisapplianceinalaundryroomorotherlocationwherewatermaydripfromtheceiling,etc.

5)Carryoutdrainagepipesasmentionedininstallationinstructions.Ifdrainageisnotperfect,watermayentertheroomanddamagethefurniture.

IM_SXV_1 A 1 _GB

1SELECT THE BEST LOCATION

2INSTALLATION Of uNIT SuppOrT

Requiredtoolsforinstallationworks

Attachedaccessories

No. Accessoriesparts Qty. No. Accessoriesparts Qty. No. Accessoriesparts Qty.

Mountingplate

1 2

Tubelocatingtemplate

1 3

Unitoperationmanual

Installationmanual

�Thereshouldnotbeanyheatsourceorsteamneartheunit.

�Thereshouldnotbeanyobstaclesblockingtheaircirculation.

�Aplacewhereaircirculationintheroomisgood.

�Aplacewheredrainagecanbeeasilydone.

�Donotinstalltheunitnearthedoorway.

�Recommendedinstallationheightforindoorunitshallbeatleast2.3m(forceilingunit).

�InstallthewallsupportoftheSXVusingtheinstallationtemplatesuppliedwiththeunit.(Fig1)

�Thecut-outsfortheunitareshownonthistemplate.

�ReminderofMINIMUMclearancestobeprovided.(Fig2)

�CoolantconnectionscanbemadeontheLHside,ontheRHsideorattherear.(Fig3)

�Condensateevacuationpossibilities:right,left,rearandfrontinthecaseofaceilingmountedunit.(2condensateoutputsareavailableontherecoverytray).

80mm

190mm

900mm

200mm

50mm:ceilingmounted

20mm:ooringmounted

630mm

Liquidpipe

ModelSXV007/009/012A=820mmB=660mm

ModelSXV015/018/021/024A=1200mmB=1040mm

Indoorunitdimensions=A

Fixingboltpitch=B

Fixingboltpitch=300mm

Freshairintake

ConnectiontotheSXVtobe

MANDATORILYinsulated

RHoutput

Outputtorear RHandLHoutputsofcondensate

recoverytray

Condensateoutputinthecaseof

aceilingmountedunit

LHoutput

Fig 1

Fig 2

Fig 3

1.Screwdriver 4.Hexagonalwrench 7.Knife

2.Electricdrill,holecoredrill(60mm) 5.Pipecutter 8.Measuringtape

3.Spanner 6.Reamer 9.Torquewrench

INSTALLATION

�RemovethewallsupportmountedtherearofyourSXV.

�Toinstallthewallsupport,locatethetemplateinordertoobservethecorrectdistancebetweenmountingholesmarkedonit.

�Securethewallsupportwith4screws(notsupplied).

NOTE for ooring installation:

Afterdeterminingtheoutletforthecondensate

evacuation(LH,RH,rear),

takecaretoinstallwithapositiveslopfor

condensatedrainage.

Condensatesevacuation

Locationofthreadedrods(Dia8mmmax)forceilinginstallations.Mountingholesforwallinstallation

3pIpE SELECTION ANd prE-INSTALLATION

�ThemainadvantageofyourSXVproductsistogivethepossibilityoflocatingthecoolanttubingonthewallsupportbeforeinstallingtheunit(usingthe

templatesupplied).

�Placethetubelocatingtemplateonthewallsupport.(Fig7-1,Fig7-2)

�Afterchoosingyourcoolanttubinginputlocation(right,leftorrear),youcansetupyourtubing.Todothis,usetheinstallationtemplateinordertoform

thetubecorrectlyandthusfacilitateconnection.

�Locatetheliquidpipeabovethegaspipe. Press

Slideunder

bracket

Locationof

tubingclamps

Pressfully

home

Recessfor

FLAREnuts

All4must

supportthe

part

ΦLiquidPipe ΦGasPipe

SXV 007 1/4" 1/2"

SXV 009 1/4" 1/2"

SXV 012 1/4" 1/2"

SXV 015 1/4" 1/2"

SXV 018 1/4" 1/2"

SXV 021 3/8" 5/8"

SXV 024 3/8" 5/8"

Fig 4

Fig 5 Fig 6

Fig7-1 Fig7-2 Fig7-3

Fig 8

�Fitthenutsofthe(formed)tubingintotherecessprovidedonthetemplate.(Fig7-2)

�Securethetubingwiththeclampsprovided.(Fig9)

�Removethetubingtemplate;youcannowinstallyourunitonitssupport.

NOTE

output from the rear

�Theslantedholepreventscondensatesorrainfromenteringtheunit.

�FitaDia.70mmsleeveintothehole.

Insulatedliquidpiping Insulatedgaspiping Securethepipingwith

theclampsprovided

WARNING

Thepipingmustbe

closedtoprevent

impuritiesfromentering

Removethetemplate

4uNIT INSTALLATION

A Install the unit to wall support

FOR THE AIR INLET GRILL:

 1Pullthegrillforwards.

 2Removethetwoendscrews.

 3Unscrewthecentralscrew,butdonotremoveitcompletely.

 4Unhookthegrid.

FOR THE SIDE PANELS:

 5Removethesidepanels(downwardmovement).

IMPERATIVE

- For ceiling mounting, install the two clamp

screws (provided) for the unit on the support.

B Installation of the SXV on the wall support

● Refertothediagrambelow,forinstallationoftheSXV.

● Ceilingmounting(refertotheNOTEbelow).

Fig 9

Fig 10

Fig 11

Fig 12

Fig 13

A Connect the drain pipe

●Watercondensationmustbeevacuateddirectlytotheoutside;observeanappropriateslopefortheevacuationduct,whichshouldslopedownwardsthe

caseofaconnectiontothewastewatersystem(2.5cm/mslope).

●AnS-bendmustbeinstalledontheevacuationduct,belowtheleveloftherecoverytrayoftheunit.

●Provideinsulationfortheevacuationpipinginthecaseofariskoffreezingorcondensation.

●Evacuationwithpumpkit:(refertoinstructionsprovidedwithkit).

 a.Theunitissuppliedwithanevacuationpiping.

 b.Therightandleftoutletsareblockedoffbyaplug.Donotforgettoremovethisplugbeforeconnectingtheevacuationpiping.

●Inthecaseofaceilingmountedinstallation,runtheevacuationpipingdownalongthesidepanelandsecureitwithclampsasshownbelow.Alsobreak

thepreformedcut-outintheconeroftheintakegrid.

Condensate recovery

tray

Evacuation

tube

Gas tube

7ELECTrICAL WIrING CONNECTION

Tighteningtorquefortheterminalscrews

Use the correctscrewdriver for tightening the terminal

screws.Ifthebladeofscrewdriveristoosmall,thehead

ofthescrewmightbedamaged,andthescrewwillnotbe

properlytightened.Iftheterminalscrewsaretightened

toohard,screwsmightbedamage.Refertothetable

rightforthetighteningtorqueoftheterminalscrews.

Terminal Size Tighteningtorque

Terminalblock M3.5 0.8~1.0N.m

5drAINAGE pIpE CONNECTION

Fig 14 Fig 15 Fig 16

Fig 17

Liquid

tube

B Drainage test

Pouraglassofwaterintothedraintray-styrofoam,ensurethatwaterowsoutfromdrainhose

oftheindoorunit,alongof1minisallowedbeforedischarging,accordingtothelengthofthe

drainpipe,andcheckwhetherwaterleaksfromthejoints.

CAUTIONS: Ifthereisanymalfunction,pleaseresolveitimmediately.

6HEIGHT COMpENSATION SETTING

InstallationHeight HeightCode DS11 DS12

2.3-2.7(m) H0 OFF OFF

2.7-3.1(m) H1 OFF ON

3.1-3.5(m) H2 ON OFF

>3.5(m) H3 ON ON

Note

1.Pleasedisconnecttheunitfrompower

supplywhenchangethesesettings.

2.Ifyoufeeltoonoisy,pleasesetDS11and

DS12tolowerheightcodelevel.

Thecompensationsettingaccordingtoinstallationheightcanbedonebyusingthedipswitch11and12oncontrollerPCB.

Powersupplywiring MainbuscommunicationandR/Cwiring

1.Unscrewandremovetheelectricalboxcover.

2.Connectthepowersupplywiringstothepowersupply

terminalblock.

3.Whendoingthis,pressthepowersupplywirings

cunderthewireclip.

1.Unscrewandremovetheelectricalboxcover.

2.ConnectR/CwiringstoR1,R2terminalblockandthe

mainbuswiringstoF1,F2terminalblock.

3.Pressthewiringsunderthewirecliptightly.

NOTE:

Forhowtocnnectthepowerwireandcommunicationwirebetweenoutdoorunitandindoorunits,pleaserefertochapter9

“Fieldwiring”inoutdoorunitinstallationmanual.

ELB:ElectricityLeakageBreaker.

AH:Assistantheater.

Electricalcharacteristics

SpecicationsforeldsuppliedELBandwire

Unit Powersupply Fanmotor

Model Hz Volts MCA MFA KW FLA

SXV007

50 220~240

0.37 16 0.06 0.18

SXV009 0.37 16 0.06 0.18

SXV012 0.37 16 0.06 0.18

SXV015 0.68 16 0.13 0.41

SXV018 0.68 16 0.13 0.41

SXV021 0.68 16 0.13 0.41

SXV024 0.68 16 0.13 0.41

Model Powersupplywiring Remotecontrollerwiring

communicationwiring

FieldELB WireandSize Wire Size

SXV007

16A

Mustcomply

withmaximum

currentandlocal

codes(0.75mm2)

Twisted-pairwires 1.0mm2

SXV009

SXV012

SXV015

SXV018

SXV021

SXV024

NOTE:

�Allfieldsuppliedpartsandmaterialsand

electricsworksmustconformtolocalcodes.

�Usecopperwireonly.

�Allwiringmustbeperformedbyanauthorized

electrician.

�Everyindoorunitmusthaveasubcircle

breakerandthewholesystemmusthavea

maincirclebreaker.

�Besuretogroundtheairconditioner.

�

Theapplianceshallbeinstalledinaccordance

withnationalwiringregulations,andshallbe

providedtoensureall-poledisconnectionfrom

thesupplymains,anddistancebetweenthe

polesshallbemorethan3mm.

MCA:Min.CircuitAmps(A)

MFA :Max.FuseAmps(A)

KW :FanMotorRatedoutput(KW)

FLA :FullLoadAmps(A)

CHECK ITEMS

NOTE:

Forthepipingandwiringmethods,leakagetest,vacuumprocessandinstallationsetting

throughHMI,pleaserefterto“OutdoorunitInstallationManual”.

Powersupply Main R/C

BusWiring

BEFORE POWER ON

■Isthereanygasleakageatflarenutconnections?

■Hastheheatinsulationbeencarriedoutatflarenutconnection?

■Istheconnectingcablebeingfixedtoterminalboardfirmly?

■Istheconnectingcablebeingclampedfirmly?

■Isthedrainageok?(Referto"Drainagetestsection)

■Istheearthwireconnectionproperlydone?

■Istheindoorunitproperlyhookedtotheinstallationplate?

■Isthepowersupplyvoltagecompliedwithratedvalue?

AFTER POWER ON

■Isthereanyabnormalsound?

■Isthecoolingoperationnormal?

■Isthethermostatoperationnormal?

■Istheremotecontrol'sLCDoperationnormal?

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Airwell Klimaanlage Handbücher

Airwell

Airwell VVFA-220R-01T32 Bedienungsanleitung

Airwell

Airwell FBF030 Bedienungsanleitung

Airwell

Airwell DFO 5 - 9 - 17 Bedienungsanleitung

Airwell

Airwell MAY 90RCE Bedienungsanleitung

Airwell

Airwell Flow Logic II Series Bedienungsanleitung

Airwell

Airwell AW-FWDB018-N91 Bedienungsanleitung

Airwell

Airwell AWSI-HGF009-H11 Bedienungsanleitung

Airwell

Airwell FVVA-025N-01M22 Leitfaden

Airwell

Airwell AW-YHDM024-H91 Bedienungsanleitung

Airwell

Airwell VRF Series Installations- und Betriebshandbuch

Airwell

Airwell Trio Dakota 5.2 DCI Bedienungsanleitung

Airwell

Airwell MAY 90 Bedienungsanleitung

Airwell

Airwell FSF045 Bedienungsanleitung

Airwell

Airwell EDS25 Bedienungsanleitung

Airwell

Airwell AWSI-CFV007-N11 Bedienungsanleitung

Airwell

Airwell AWAU-YUDA060-H13 Bedienungsanleitung

Airwell

Airwell DDMX-035N-09M25 Bedienungsanleitung

Airwell

Airwell K XLN24 RC 3PH Bedienungsanleitung

Airwell

Airwell WFD 009 Bedienungsanleitung

Airwell

Airwell ELECTRA JKD DCI Series Bedienungsanleitung

Airwell

Airwell MAF Bedienungsanleitung

Airwell

Airwell WAP Series Bedienungsanleitung

Airwell

Airwell YBZE218-324-430 Bedienungsanleitung

Airwell

Airwell ECF 9 A RC Bedienungsanleitung

Beliebte Klimaanlage Handbücher anderer Marken

Panasonic

Panasonic CS-E12HKEW Bedienungsanleitung

nedis

nedis ACMB1WT7 Bedienungsanleitung

Daikin

Daikin FCFV50A Bedienungsanleitung

Fujitsu

Fujitsu Inverter ASBA30JFC Bedienungsanleitung

Toshiba

Toshiba RAS-M10SMUV-E Bedienungsanleitung

Daikin

Daikin FXLQ20MAVE Bedienungsanleitung

CIAT

CIAT Magister 2 Series Leitfaden

Bestron

Bestron AAC6000 Bedienungsanleitung

Frigidaire

Frigidaire FFRE0533S1E0 Bedienungsanleitung

Samsung

Samsung AS09HM3N Bedienungsanleitung

Frigidaire

Frigidaire CRA073PU11 Betriebsanleitung

Soleus Air

Soleus Air GB-PAC-08E4 Bedienungsanleitung

McQuay

McQuay MCK020A Bedienungsanleitung

Webasto

Webasto Frigo Top 25 DS Bedienungsanleitung

Frigidaire

Frigidaire FAZ12ES2A Bedienungsanleitung

Mitsubishi Electric

Mitsubishi Electric MSC-GE20VB Bedienungsanleitung

Mitsubishi Electric

Mitsubishi Electric PLA-M100EA Bedienungsanleitung

Daikin

Daikin Split Sensira R32 Bedienungsanleitung