Alfalaval Unique SSV Bedienungsanleitung

ALFA LAVAL UNIQUE SSV Y-BODY VALVE INSTRUCTION MANUAL—REV 3/19

TD 461-803

ESE00690-ENUS5 2019-03

Original manual

Instruction Manual

Unique SSV Valve Y-body

ALFA LAVAL UNIQUE SSV Y-BODY VALVE INSTRUCTION MANUAL—REV 3/19

CONTACT CSI FOR MORE INFORMATION | CSIDESIGNS.COM | [email protected] | 417.831.1411

ALFA LAVAL UNIQUE SSV Y-BODY VALVE INSTRUCTION MANUAL—REV 3/19

Table of contents

The information herein is correct at the time of issue but may be subject to change without prior notice

1. EC Declaration of Conformity ....................................................................... 4

2. Safety .................................................................................................... 5

2.1. Important information ............................................................................. 5

2.2. Warning signs ..................................................................................... 5

2.3. Safety precautions ................................................................................ 6

3. Installation .............................................................................................. 8

3.1. Unpacking/delivery ............................................................................... 8

3.2. General installation ................................................................................ 9

3.3. Welding ............................................................................................ 11

3.4. Recycling information ............................................................................. 12

4. Operation ............................................................................................... 13

4.1. Operation .......................................................................................... 13

4.2. Troubleshooting ................................................................................... 15

4.3. Recommended cleaning ......................................................................... 16

5. Maintenance ........................................................................................... 18

5.1. General maintenance ............................................................................. 18

5.2. Dismantling of valve .............................................................................. 20

5.3. Plug Seal replacement ........................................................................... 20

5.4. Valve assembly .................................................................................... 21

5.5. Actuator bushing replacement .................................................................. 21

6. Technical data ......................................................................................... 22

6.1. Technical data ..................................................................................... 22

7. Parts list and Service Kits ........................................................................... 23

7.1. Unique SSV Valve - Y-body ...................................................................... 23

CONTACT CSI FOR MORE INFORMATION | CSIDESIGNS.COM | [email protected] | 417.831.1411

ALFA LAVAL UNIQUE SSV Y-BODY VALVE INSTRUCTION MANUAL—REV 3/19

1 EC Declaration of Conformity

Revision of Declaration of Conformity 2009-12-29

The Designated Company

Alfa Laval Kolding A/S

Company Name

Albuen 31, DK-6000 Kolding, Denmark

Address

+45 79 32 22 00

Phone No.

hereby declare that

Valve

Designation

Unique SSV PN10

Type

From serial number 1000000 to 70000000000

is in conformity with the following directive with amendments:

- Machinery Directive 2006/42/EC

- Regulation (EC) No 1935/2004

- Pressure Equipment Directive 97/23/EC category 1 and subjected to assessment procedure Module A.

The person authorised to compile the technical file is the signer of this document

Global Product Quality Manager

Pumps, Valves, Fittings and Tank Equipment

Lars Kruse Andersen

Title Name

Kolding 2016-12-03

Place Date Signature

4CONTACT CSI FOR MORE INFORMATION | CSIDESIGNS.COM | [email protected] | 417.831.1411

ALFA LAVAL UNIQUE SSV Y-BODY VALVE INSTRUCTION MANUAL—REV 3/19

2 Safety

Unsafe practices and other important information are emphasized in this manual.

Warnings are emphasized by means of special signs.

2.1 Important information

Indicates that special procedures must be followed to avoid serious personal injury.

Indicates that special procedures must be followed to avoid damage to the valve.

Indicates important information to simplify or clarify procedures.

2.2 Warning signs

General warning:

Caustic agents:

CONTACT CSI FOR MORE INFORMATION | CSIDESIGNS.COM | [email protected] | 417.831.1411

ALFA LAVAL UNIQUE SSV Y-BODY VALVE INSTRUCTION MANUAL—REV 3/19

2 Safety

All warnings in the manual are summarized on this page.

Pay special attention to the instructions below so that severe personal injury and/or damage to the valve are avoided.

2.3 Safety precautions

If support air is utilised:

- Shock in the actuator must N

occur

- Support air on high pressure actuator versions is N

allowed

To prevent shock in the actuator and to prevent exceeding 145 PSI (10 bar) product pressure, Alfa Laval recommends N

to exceed 43.5 PSI (3 bar) support air on the spring side in all the Unique SSV actuators.

If support air is connected always use the 43 PSI (3 bar) air relief fittings = 9611996094 (1/4” = 6,35 mm hose)

Using the 43.5 PSI (3 bar) air relief fitting also extends the service life of the actuator piston o-ring.

Obs. if using a 6 mm hose then use air relief fittings = 9611995903

2200-0168_1

Ø26 (Ø1”)

For actuators, manufactured year 2005-2018, with serial number from 1000000 - 5999999

and from 20000000000 - 59999999999 always use steel adapter (pos 5) = 9614065301

Tighten torque = 23 Ibf-ft (30 Nm)

Ø19 (Ø3/4”)

2200-0169_1

For actuators, manufactured year 2019 --> with serial number from 6000000 to 7000000 and

from 60000000000 to 70000000000 always use steel adapter (pos 5) = 9615374701

Tighten torque = 11 Ibf-ft (15 Nm)

TD 461-990_2

Alfa Laval recommends max. 43,5 PSI (3 bar) support air

Always use the 43,5 PSI (3 bar) air relief fittings” on support air.

Alfa Laval article number = 9611996094 (1/4” = 6,35 mm hose)

CONTACT CSI FOR MORE INFORMATION | CSIDESIGNS.COM | [email protected] | 417.831.1411

ALFA LAVAL UNIQUE SSV Y-BODY VALVE INSTRUCTION MANUAL—REV 3/19

2 Safety

All warnings in the manual are summarized on this page.

Pay special attention to the instructions below so that severe personal injury and/or damage to the valve are avoided.

read the technical data thoroughly (See chapter 6 Technical data) !

release compressed air after use

touch the moving parts if the actuator is supplied with compressed air

touch the valve or the pipelines when processing hot liquids or when sterilizing

dismantle the valve with valve and pipelines under pressure

dismantlethevalvewhenitishot

dismantle the valve with valve and pipelines under pressure !

dismantlethevalvewhenitishot

read the technical data thoroughly (See chapter 6 Technical data)

release compressed air after use

touch the valve or the pipelines when processing hot liquids or when sterilizing

touch the moving parts if the actuator is supplied with compressed air

rinse well with clean water after the cleaning

handle lye and acid with great care

read the technical data thoroughly (See chapter 6 Technical data) !

release compressed air after use

servicethevalvewhenitishot

service the valve with valve and pipelines under pressure

stick your fingers through the valve ports if the actuator is supplied with compressed air

touch the moving parts if the actuator is supplied with compressed air

CONTACT CSI FOR MORE INFORMATION | CSIDESIGNS.COM | [email protected] | 417.831.1411

ALFA LAVAL UNIQUE SSV Y-BODY VALVE INSTRUCTION MANUAL—REV 3/19

3 Installation

The instruction manual is part of the delivery. Study the instructions carefully.

The items refer to parts list and service kits section.

The valve is supplied as separate parts as standard (for welding).

The valve is assembled before delivery, if it is supplied with fittings.

3.1 Unpacking/delivery

Alfa Laval cannot be held responsible for incorrect unpacking.

1. Complete valve, shut-off valve (RA) or change-over

valve (RA) (see steps 2a and 2b).

2. Delivery note.

3. Instruction manual.

Complete actuator

1. Bonnet (20).

2. upper clamp (19).

3. Valve plug (36).

4. Valve body (22).

5. Lower clamp (61)

TD 461-775

Remove possible packing materials from the valve/valve parts.

Inspect the valve/valve parts for visible transport damages.

Avoid damaging the valve/valve parts.

CONTACT CSI FOR MORE INFORMATION | CSIDESIGNS.COM | [email protected] | 417.831.1411

ALFA LAVAL UNIQUE SSV Y-BODY VALVE INSTRUCTION MANUAL—REV 3/19

3 Installation

Study the instructions carefully and pay special attention to the warnings!

The valve has welding ends as standard but can also be supplied with fittings.

3.2 General installation

read the technical data thoroughly.

See chapter 6 Technical data

release compressed air after use.

Alfa Laval cannot be held responsible for incorrect installation.

touch moving parts if the actuator is supplied with

compressed air.

Air

TD 461-760

It is recommended to install the valve so that the flow is against

the closing direction to avoid water hammering. A

Inlet

TD 461-761

CONTACT CSI FOR MORE INFORMATION | CSIDESIGNS.COM | [email protected] | 417.831.1411

ALFA LAVAL UNIQUE SSV Y-BODY VALVE INSTRUCTION MANUAL—REV 3/19

3 Installation

Study the instructions carefully and pay special attention to the warnings!

The valve has welding ends as standard but can also be supplied with fittings.

Avoid stressing the valve.

- Vibrations.

- Thermal expansion of the pipelines.

- Overloading of the pipelines.

TD 461-762

Make sure that the leak detection hole in the valve body:

1. is visible, when mounting the valve vertically

2. always is downwards due to self-draining, when the valve is mounted horizontally.

2200-0172

***

* = Leakage detection hole

CONTACT CSI FOR MORE INFORMATION | CSIDESIGNS.COM | [email protected] | 417.831.1411

Inhaltsverzeichnis

Andere Alfalaval Steuereinheit Handbücher

Alfalaval

Alfalaval Unique Mixproof 3-body Bedienungsanleitung

Alfalaval

Alfalaval SMP-BC Bedienungsanleitung

Alfalaval

Alfalaval SMP-BCA Bedienungsanleitung

Alfalaval

Alfalaval LKB Series Bedienungsanleitung

Alfalaval

Alfalaval CSI SPC-2 Bedienungsanleitung

Alfalaval

Alfalaval Unique SSV PN10 Bedienungsanleitung

Alfalaval

Alfalaval SSV Bedienungsanleitung

Alfalaval

Alfalaval 5309 Bedienungsanleitung

Alfalaval

Alfalaval Unique DV-ST UltraPure Betriebsanleitung

Alfalaval

Alfalaval Tri-Clover LKB UltraPure Bedienungsanleitung

Alfalaval

Alfalaval Unique TO Bedienungsanleitung

Alfalaval

Alfalaval REMIND EPC 50 Bedienungsanleitung

Alfalaval

Alfalaval Unique PMO Plus CP HT Series Bedienungsanleitung

Alfalaval

Alfalaval SB Bedienungsanleitung

Alfalaval

Alfalaval Unique 7000 Series Bedienungsanleitung

Alfalaval

Alfalaval Unique PMO Plus Series Bedienungsanleitung

Alfalaval

Alfalaval Unique SSV Series Bedienungsanleitung

Alfalaval

Alfalaval Unique SSV PN10 Bedienungsanleitung

Alfalaval

Alfalaval Unique Mixproof LP Bedienungsanleitung

Alfalaval

Alfalaval Unique SSV Two Step Bedienungsanleitung

Alfalaval

Alfalaval S946 Benutzerhandbuch

Alfalaval

Alfalaval LKAP Bedienungsanleitung

Alfalaval

Alfalaval Unique TO Bedienungsanleitung

Alfalaval

Alfalaval Unique SSV PN10 Bedienungsanleitung

Beliebte Steuereinheit Handbücher anderer Marken

Festo

Festo Compact Performance CP-FB6-E Stücklistenhandbuch

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Bedienungsanleitung

JS Automation

JS Automation MPC3034A Bedienungsanleitung

JAUDT

JAUDT SW GII 6406 Series Kurzanleitung

Spektrum

Spektrum Air Module System Bedienungsanleitung

BOC Edwards

BOC Edwards Q Series Bedienungsanleitung

KHADAS

KHADAS BT Magic Bedienungsanleitung

Etherma

Etherma eNEXHO-IL Bedienungsanleitung

PMFoundations

PMFoundations Attenuverter Bedienungsanleitung

GEA

GEA VARIVENT Bedienungsanleitung

Walther Systemtechnik

Walther Systemtechnik VMS-05 Bedienungsanleitung

Altronix

Altronix LINQ8PD Montageanleitung

Eaton

Eaton Powerware Series Bedienungsanleitung

WAGO

WAGO 750-407/040-000 Bedienungsanleitung

Sony

Sony CCU-590 Bedienungsanleitung

Graco

Graco 25D614 Bedienungsanleitung

Task Force Tips

Task Force Tips YE-RF-900 Programmierhandbuch

Shini

Shini SPV-U Series Bedienungsanleitung