Alliance Laundry Systems Drying Tumbler 70278501R5EN Betriebsanleitung

Installation/Operation Supplement

www.comlaundry.com

Drying Tumblers

50 Pound Capacity

75 Pound Capacity

Refer to page 3 for Model Identification

Part No. 70278501R5EN

December 2007

Keep These Instructions for Future Reference.

(If this machine changes ownership, this manual must accompany machine.)

Installation/Operation Supplement

70278501 (EN) 1

Installation must conform with local codes.

IMPORTANT: Information must be obtained from

a local gas supplier on instructions to be followed if

the user smells gas. These instructions must be

posted in a prominent location. Step-by-step

instructions of the above safety information must

be posted in a prominent location near the tumbler

for customer use.

FOR YOUR SAFETY, the information in

this manual must be followed to minimize

the risk of fire or explosion or to prevent

property damage, personal injury or

death.

W033

• Do not store or use gasoline or other

flammable vapors and liquids in the

vicinity of this or any other appliance.

• WHAT TO DO IF YOU SMELL GAS:

– Do not try to light any appliance.

– Do not touch any electrical switch; do

not use any phone in your building.

– Clear the room, building or area of all

occupants.

– Immediately call your gas supplier

from a neighbor’s phone. Follow the

gas supplier’s instructions.

– If you cannot reach your gas supplier,

call the fire department.

• Installation and service must be

performed by a qualified installer,

service agency or the gas supplier.

W052

WARNING

FOR YOUR SAFETY

Do not store or use gasoline or other

flammable vapors and liquids in the

vicinity of this or any other appliance.

W053

To reduce the risk of fire, electric shock,

serious injury or death to persons when

using the tumbler unit, follow these basic

precautions:

• Read all instructions before using

tumbler.

• DO NOT tamper with controls.

• DO NOT bypass any safety devices.

• Always follow the fabric care

instructions supplied by the garment

manufacturer.

• Remove laundry immediately after the

tumbler stops.

• DO NOT reach into tumbler if cylinder is

revolving.

To avoid creating any flammable vapors

which may explode, ignite or cause

corrosive damage, DO NOT dry the

following materials:

• Articles that have been cleaned in,

soaked in, washed in or spotted with

gasoline, dry-cleaning solvents or other

flammable/explosive substances.

• Plastics or articles containing foam

rubber or similarly textured rubberlike

materials.

• Articles that have traces of flammable

substances like cooking oil, machine

oil, flammable chemicals or thinner.

• Articles containing wax or cleaning

chemicals.

• Fiberglass curtains or draperies (unless

the label says it can be done).

W440R1

WARNING

means without the expressed written consent of the publisher.

Installation/Operation Supplement

270278501 (EN)© Published by permission of the copyright owner – DO NOT COPY or TRANSMIT

Table of

Contents

Introduction......................................................................................... 3

Model Identification ............................................................................. 3

Wiring Diagram .................................................................................... 3

Serial Plate Location............................................................................. 4

Safety Information.............................................................................. 5

Important Safety Instructions ............................................................... 5

Installation........................................................................................... 7

Specifications and Dimensions............................................................. 7

Cabinet Dimensions ......................................................................... 8

Horizontal Exhaust Outlet Locations............................................... 9

Gas Connection Locations ............................................................... 10

Electrical Connection Locations ...................................................... 11

Steam Connection Locations ........................................................... 12

Position and Level the Tumbler............................................................ 13

Fire Suppression System....................................................................... 14

Water Requirements......................................................................... 14

Water Connections........................................................................... 14

Electrical Requirements ................................................................... 14

Auxiliary Alarm ............................................................................... 14

Gas Requirements................................................................................. 15

Natural Gas and Liquefied Petroleum.............................................. 15

European Gas ................................................................................... 16

Exhaust Requirements .......................................................................... 18

Make-Up Air.................................................................................... 18

Venting............................................................................................. 18

Electrical Requirements........................................................................ 19

Grounding Instructions .................................................................... 19

Steam Requirements ............................................................................. 20

Thermal Oil Prep .................................................................................. 20

Operation............................................................................................. 22

Emergency Stop Button on CE Models................................................ 22

Operating Instructions .......................................................................... 22

Step 1: Clean Lint Screen/Compartment ......................................... 22

Step 2: Load Laundry....................................................................... 22

Step 3: Determine Control Type and Temperature Setting ............. 22

Step 4: Remove Laundry ................................................................. 22

Control Instructions .............................................................................. 23

Electromechanical Coin Control...................................................... 23

Manual Timer Control ..................................................................... 24

Dual Digital Timer Control.............................................................. 25

Single Drop Control......................................................................... 26

DMP OPL Control ........................................................................... 27

DMP Coin Control........................................................................... 28

Ignition Control Operation ................................................................... 29

Disposal of Unit ................................................................................... 30

70278501 (EN)

Installation/Operation Supplement

Introduction

Model Identification

Information in this manual is applicable to these models:

Includes models with the following control suffixes:

Wiring Diagram

The wiring diagram is located in the junction or

contactor box.

Gas Steam/Thermal Oil Electric

50 Pound

CHD50G2-CU050L

CHD50G2-CU050N

DR50G2-BU050L

DR50G2-BU050N

BU050T

CHD50S2-CU050S

CU050T

DR50S2-BU050S

CHD50E2-CU050E

DR50E2-BU050E

75 Pound

CHD75G2-CU075L

CHD75G2-CU075N

DR75G2-BU075L

DR75G2-BU075N

BU075T

CHD75S2-CU075S

CU075T

DR75S2-BU075S

CHD75E2-CU075E

DR75E2-BU075E

3O – DX4 OPL

3V – DX4 vended

3X – DX4 prep for coin

CD – rotary coin drop

CX – prep for coin

DO – DMP OPL

DV – DMP vended

DX – DMP prep for coin

MT– manual timer

QT – dual digital timer

R3 – reversing DX4 OPL

RD – reversing DMP OPL

RQ – reversing dual digital timer

RT – reversing manual timer

SD – single drop

SX – single drop, prep for coin

Installation/Operation Supplement

70278501 (EN)

Serial Plate Location

TMB803N

1Serial Plate

TMB803N

4030

PUSH

START

HEAT COOL

DOWN

HIGH

TEMPERATURE

LOW

70278501 (EN)

Installation/Operation Supplement

Safety Information

Save These Instructions

Important Safety Instructions

1. Read all instructions before using the tumbler.

2. Refer to the GROUNDING INSTRUCTIONS

for the proper grounding of the tumbler.

3. Do not dry articles that have been previously

cleaned in, washed in, soaked in, or spotted with

gasoline, dry-cleaning solvents, or other

flammable or explosive substances, as they give

off vapors that could ignite or explode.

4. Do not allow children to play on or in the

tumbler. This appliance is not intended for use by

young children or infirm persons without

supervision. Young children should be

supervised to ensure that they do not play with

the appliance.

5. Before the tumbler is removed from service or

discarded, remove the door to the drying

compartment and the door to the lint

compartment.

6. Do not reach into the tumbler if the cylinder is

revolving.

7. Do not install or store the tumbler where it will

be exposed to water and/or weather.

8. Do not tamper with the controls.

9. Do not repair or replace any part of the tumbler,

or attempt any servicing unless specifically

recommended in the user-maintenance

instructions or in published user-repair

instructions that you understand and have the

skills to carry out.

10. Do not use fabric softeners or products to

eliminate static unless recommended by the

manufacturer of the fabric softener or product.

11. To reduce the risk of fire, DO NOT DRY plastics

or articles containing foam rubber or similarly

textured rubberlike materials.

12. Always clean the lint filter daily.

13. Keep area around the exhaust opening and

adjacent surrounding area free from the

accumulation of lint, dust and dirt.

14. The interior of the tumbler and the exhaust duct

should be cleaned periodically by qualified

service personnel.

15. If not installed, operated and maintained in

accordance with the manufacturer’s instructions

or if there is damage to or mishandling of this

product’s components, use of this product could

expose you to substances in the fuel or from fuel

combustion which can cause death or serious

illness and which are known to the State of

California to cause cancer, birth defects or other

reproductive harm.

16. Tumbler will not operate with the loading door

open. DO NOT bypass the door safety switch to

permit the tumbler to operate with the door open.

The tumbler will stop tumbling when the door is

opened. Do not use the tumbler if it does not stop

tumbling when the door is opened or starts

tumbling without pressing or turning the START

mechanism. Remove the tumbler from use and

call for service.

17. Tumbler will not operate with lint panel open.

DO NOT bypass lint panel safety switch to

permit the tumbler to operate with the lint panel

open.

18. Do not put articles soiled with vegetable or cooking

oil in the tumbler, as these oils may not be

removed during washing. Due to the remaining

oil, the fabric may catch on fire by itself.

19. To reduce the risk of fire, DO NOT put clothes

which have traces of any flammable substances

such as machine oil, flammable chemicals,

thinner, etc. or anything containing wax or

chemicals such as in mops and cleaning cloths, or

anything dry-cleaned at home with dry-cleaning

solvent in the tumbler.

20. Use the tumbler only for its intended purpose,

drying fabrics.

21. ALWAYS disconnect and lockout the electrical

power to the tumbler before servicing.

Disconnect power by shutting off appropriate

breaker or fuse.

Hazardous Voltage. Can cause shock, burn

or cause death. Allow machine power to

remain off for two minutes prior to working

in and around AC inverter drive.

W359

WARNING

Installation/Operation Supplement

70278501 (EN)

22. Install this tumbler according to the

INSTALLATION INSTRUCTIONS. All

connections for electrical power, grounding, and

gas supply must comply with local codes and be

made by licensed personnel when required.

23. Remove laundry immediately after tumbler stops.

24. Always read and follow manufacturer’s

instructions on packages of laundry and cleaning

aids. Heed all warnings or precautions. To reduce

the risk of poisoning or chemical burns, keep

them out of reach of children at all times

(preferably in a locked cabinet).

25. Do not tumble fiberglass curtains and draperies

unless the label says it can be done. If they are

dried, wipe out the cylinder with a damp cloth to

remove particles of fiberglass.

26. Always follow the fabric care instructions

supplied by the garment manufacturer.

27. Never operate the tumbler with any guards and/or

panels removed.

28. DO NOT operate the tumbler if it is smoking,

grinding, has missing or broken parts.

29. DO NOT bypass any safety devices.

30. Solvent vapors from dry-cleaning machines

create acids when drawn through the heater of the

drying unit. These acids are corrosive to the

tumbler as well as to the laundry load being

dried. Be sure make-up air is free of solvent

vapors.

31. Failure to install, maintain, and/or operate this

machine according to the manufacturer’s

instructions may result in conditions which can

produce bodily injury and/or property damage.

WARNING

To reduce the risk of serious injury, install

lockable door(s) to prevent public access

to rear of tumblers.

W055

70278501 (EN)

Installation/Operation Supplement

Installation

Specifications and Dimensions

Specifications 50 Pound 75 Pound

Noise level measured during operation at

operator position of 1 meter (3.3 feet) in front

of machine and 1.6 meters (5.2 feet) from

floor.

63 dBA 69 dBA

Net Weight (approximate):

kg (lbs.)

247

(545)

279

(615)

Cylinder Size:

mm (in.)

940 x 762

(37 x 30)

940 x 914

(37 x 36)

Cylinder Capacity (dry weight):

kg (lbs.)

22.7

(50)

(75)

Air Outlet Diameter:

mm (in.)

203

(8)

203

(8)

Maximum Static Back Pressure:

mbar (W.C.I.)

1.3

(0.5)

1.3

(0.5)

Maximum Airflow:

L/sec. (C.F.M.)

354

(750)

Gas/Steam 50 Hz 354 (750)

Gas/Steam 60 Hz 434 (920)

Electric 354 (750)

Motor Horsepower:

Nonreversing

Reversing

Fan

Cylinder

1/2

1/3

3/4

1/3

Gas Models

Gas Connection 1/2 in. NPT 1/2 in. NPT

Gas Burner Rating:

Mj/hr (Btu/hr)

126.6

(120,000)

174.1

(165,000)

Electric Models

Heating Elements Rating:

Kilowatts (kW)

21 kW (240 V/50 Hertz)

30 kW (other voltages)

30 kW

Steam Models

Steam Connection 3/4 in. NPT 3/4 in. NPT

Steam Coil Rating:

Btu/hr (Boiler Horsepower)

5.1

(177,500)

6.1

(210,300)

Installation/Operation Supplement

70278501 (EN)

Cabinet Dimensions

TMB2213N

ModelsABCDEFG

050

Gas and

Electric

781 mm

(30.75 in.)

717 mm

(28.25 in.)

1194 mm

(47 in.)

1946 mm

(76.625 in.)

981 mm

(38.625 in.)

838 mm

(33 in.)

749 mm

(29.5 in.)

050

Steam

781 mm

(30.75 in.)

717 mm

(28.25 in.)

1194 mm

(47 in.)

2032 mm

(80 in.)

981 mm

(38.625 in.)

838 mm

(33 in.)

749 mm

(29.5 in.)

075

Gas and

Electric

781 mm

(30.75 in.)

717 mm

(28.25 in.)

1346 mm

(53 in.)

1946 mm

(76.625 in.)

981 mm

(38.625 in.)

838 mm

(33 in.)

902 mm

(35.5 in.)

075

Steam

781 mm

(30.75 in.)

717 mm

(28.25 in.)

1346 mm

(53 in.)

2032 mm

(80 in.)

981 mm

(38.625 in.)

838 mm

(33 in.)

902 mm

(35.5 in.)

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Alliance Laundry Systems Trockner Handbücher

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumblers none Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems BDEE6BGS173CW01 Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems DRY683C Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems LES17A*M4588 Leitfaden

Alliance Laundry Systems

Alliance Laundry Systems DRY2030N Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems LEB07A*-1709 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems Speed Queen FF7009WN Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems SDE807 Leitfaden

Alliance Laundry Systems

Alliance Laundry Systems JCD32DG Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems SDE907 Leitfaden

Alliance Laundry Systems

Alliance Laundry Systems UniLinc 35 Series Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems AE Series Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems CA050L Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems HSA030N Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems ADE3SRGS173CW01 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 25 Pound Capacity Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems JE2870 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems DCB50EG Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems continuity Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 505828 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems TLW1991N Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems ADE3TFWS431AW01 Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumblers 50 Pound Capacity 75 Pound Capacity Model Identification Part No.... Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems M414904R8 Fehlerbehebungshandbuch

Beliebte Trockner Handbücher anderer Marken

Bosch

Bosch WTA79200GB Bedienungsanleitung

Amana

Amana W10233410A Bedienungsanleitung

Asko

Asko T760 Bedienungsanleitung

Bosch

Bosch Logixx 10 WTB76556GB Technisches Datenblatt

Electrolux

Electrolux EW2H328R2 Bedienungsanleitung

Beko

Beko DS8433RX1M Bedienungsanleitung

Dawlance

Dawlance Spinner DS 6000 C Bedienungsanleitung

Electrolux

Electrolux TP5080TW Bedienungsanleitung

AEG

AEG TR838P4OB Bedienungsanleitung

Indesit

Indesit IDV 75 Bedienungsanleitung

Infiniton

Infiniton SD-DG85C Bedienungsanleitung

BOMANN

BOMANN WT 5019 Bedienungsanleitung

Asko

Asko T793C Bedienungsanleitung

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Bedienungsanleitung

Frigidaire

Frigidaire CAQE7077KW0 Betriebsanleitung

Bosch

Bosch WTX8HKM9SN Bedienungsanleitung

Sharp

Sharp KD-NHH9S7GW2-PL Bedienungsanleitung

Samsung

Samsung DV431AEPXAC Bedienungsanleitung