Alpha Alpha CB50 Boiler Stücklistenhandbuch

Instructions for replacing the electrically

operated automatic flow regulator with

the mechanical flow regulator valve

Alpha CB50 Boiler

1. GENERAL

Ensure that the following instructions are carried out before replacement begins.

a. Isolate the electrical and gas supplies to the boiler and turn off the mains water supply.

b. Gain access behind the case and to the PCB as described in the Installation and Servicing instructions.

c. Connect a hose to the cylinder drain valve and drain the cylinder to outside.

2. REMOVETHE ELECTRICALLY OPERATED FLOW REGULATOR

a. Disconnect the flow regulator plug and socket located within the PCB enclosure. Unplug the wiring connectors

M1 and M13 from the PCB, see Fig. 2.

b. Remove the two white wires from the connectors M1 and M13. This can be achieved by pressing the tab in the

side of the plug and at the same time pulling the wire from its socket, see Fig. 2.

c. Remove the regulator's thermostat (located behind the DHW expansion vessel) and cable by removing the lower

front right hand side casing screw and sliding the thermostat to the right, releasing it from the retaining clip on the

cylinder, see Fig. 3.

d. Replace the connectors M1 and M13 into position on the PCB and re-assemble the control panel rear cover.

e. Secure the right hand side casing panel with the screw previously removed.

f. Disconnect the mains inlet valve and cylinder union connections from the regulator valve and remove the

regulator. Remove the filter from the regulator and retain, see Fig. 4.

NOTE: All parts removed must be returned to Alpha detailing the CB50 boiler serial number which is located

on the hinged control panel cover.

Fig. 1 - Kit Contents

Union bend (A)

Fig. 2

Fig. 3

Flow

regulator

thermostat

DHW

expansion

vessel

07/04/D163

Fig. 4 - CB50 fitted with flow regulator on inlet

Fig. 5 - CB50 fitted with new type flow regulator on outlet

3. FIT THE MECHANICAL FLOW VALVE

a. Fit the union bend (A in Fig. 1) supplied, in the position where the regulator was removed from using the new

washers supplied, see Fig. 5.

Note: Before fitting the union bend, position the filter (previously removed from the regulator) into the manifold, see Fig. 5.

b. Remove the DHW outlet pipe by offering the new flow valve and pipe assembly supplied, upto the DHW outlet pipe

and mark where the existing pipework needs to be cut. Cut the pipe and remove it from the cylinder.

c. Fit the new valve and outlet pipe assembly to the cylinder and DHW pipework using the new washers supplied, see Fig 5.

d. Turn on the electrical, gas and water supplies, refill the cylinder and test the operation of the new valve.

e. Re-assemble all the remaining parts to complete re-assembly of the boiler.

Compiled and designed by Publications 2000, Tel (01670) 356211

These guidelines have been carefully prepared but we reserve the right to

alter the specification at any time in the interest of product improvement.

Alpha Therm Limited.

NepicarHouse,LondonRoad,WrothamHeath,

Sevenoaks, Kent TN15 7RS

Technical Helpline: 0870 3001964

email: info@alphatherm.co.uk

website: www.alpha-innovation.co.uk

Andere Handbücher für Alpha CB50 Boiler

Inhaltsverzeichnis

Andere Alpha Kessel Handbücher

Alpha

Alpha Alpha Twin Pipe Flue Systems Bedienungsanleitung

Alpha

Alpha al357i-b Bedienungsanleitung

Alpha

Alpha Alpha CombiMax 350 Bedienungsanleitung

Alpha

Alpha Alpha CombiMax 350 Merkblatt

Alpha

Alpha GasSaver GS-1 Benutzerhandbuch

Alpha

Alpha Alpha C23 Benutzerhandbuch

Alpha

Alpha Alpha CB Boilers Bedienungsanleitung

Alpha

Alpha Alpha 240 Boiler Range Benutzerhandbuch

Alpha

Alpha Alpha CB Boiler Bedienungsanleitung

Alpha

Alpha Alpha CB Boiler Bedienungsanleitung

Alpha

Alpha Alpha HE25 Benutzerhandbuch

Alpha

Alpha Alpha CB24 Bedienungsanleitung

Alpha

Alpha Alpha 240X Bedienungsanleitung

Alpha

Alpha Evoke 28NX Bedienungsanleitung

Alpha

Alpha CD Easy-Flue Series Bedienungsanleitung

Alpha

Alpha Alpha 240X Benutzerhandbuch

Alpha

Alpha InTec 50CS Benutzerhandbuch

Alpha

Alpha Alpha HE25 Bedienungsanleitung

Alpha

Alpha Alpha CD Bedienungsanleitung

Alpha

Alpha Pro Tec Plus 50 Benutzerhandbuch

Alpha

Alpha 30C Benutzerhandbuch

Alpha

Alpha Alpha CD13R Benutzerhandbuch

Alpha

Alpha Alpha CB24 Benutzerhandbuch

Alpha

Alpha Alpha C Boiler Bedienungsanleitung

Beliebte Kessel Handbücher anderer Marken

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Bedienungsanleitung

Radijator

Radijator BIO max 23.1 Bedienungsanleitung

Brunner

Brunner BSV 20 Bedienungsanleitung

Buderus

Buderus Logamax GB062-24 KDE H V2 Bedienungsanleitung

Potterton

Potterton 50e Datenblatt

UTICA BOILERS

UTICA BOILERS TriFire Bedienungsanleitung

Joannes

Joannes LADY Series Handbuch

ECR International

ECR International UB90-125 Gebrauchsanweisung

Froling

Froling P4 Pellet 8 - 105 Bedienungsanleitung

Froling

Froling FHG Turbo 3000 Bedienungsanleitung

U.S. Boiler Company

U.S. Boiler Company K2 Bedienungsanleitung

Henrad

Henrad C95 FF Bedienungsanleitung

NeOvo

NeOvo EcoNox EF 36 Bedienungsanleitung

Potterton

Potterton PROMAX SL 12 Bedienungsanleitung

Eco Hometec

Eco Hometec EC 25 COMPACT Bedienungsanleitung

Viessmann

Viessmann VITODENS 200 Leitfaden

Baxi

Baxi Prime 1.24 Bedienungsanleitung

REXNOVA

REXNOVA ISA 20 BITHERMAL Bedienungsanleitung