Asus G1S Bedienungsanleitung
Disassembly procedure
2 - 1
Disassembly Procedure
Please follow the information provided in this section to perform the complete
disassembly procedure of the notebook. Be sure to use proper tools described
before.
SUS G1S Series Notebook consists of various modules. This chapter describes the
procedures for the complete notebook disassembly. In addition, in between procedures,
the detailed disassembly procedure of individual modules will be provided for your service
needs.
The disassembly procedure consists of the following steps:
•Battery Module
•CPU Module
•Memory Module
•HDD Module
•Optical Drive Module
•Keyboard Module
•Top Case Module
•LCD Module
•Motherboard Module
•WLAN Module
Chapter
2
A
Disassembly procedure
2 - 2
Battery Module
The illustration below shows how to remove the battery module.
Remove battery module
1．Slide the battery latch 1 to open battery lock
2．Slide the battery latch 2 and pull the whole battery away from the system.
CPU Module
The illustrations below show how to remove the CPU module from the notebook.
Replacement CPU
1. Remove 2 screws (M2*4) and take the CPU door away.
BATTERY
CPU MODULE
REMOVAL
3
1 2
3
M2*4
Disassembly procedure
2 - 3
2. Remove the Mylar.
3. Remove 4 screws (M2*5) aside the CPU. And take away the heat sink..
4. Turn the non-removable screw here 180 degrees counter-clockwise to loosen the CPU.
M2*5
Disassembly procedure
2 - 4
5. Squeeze the vacuum handling pump and use it to lift the CPU away.
Memory Module
The illustration shows how to remove the memory module form the notebook.
Removing Memory module
1. Remove 2 screws on the memory cover and then remove the cover.
2. Unlock two latches to pop up the memory at 45 angles then pull out the memory at that angle.
MEMORY
MODULE
MEMORY
REMOVAL
Disassembly procedure
2 - 5
WLAN Module
The illustrations below show how to remove the WLAN module from the notebook.
Remove WLAN module
1. Disconnect 3 antenna cables, remove 1 piece of tape and remove the antennas out of cable guide;
then unlock two latch and take WLAN out of system;
WLAN
MODULE
Disassembly procedure
2 - 6
HDD Module
The illustrations below show how to remove the HDD module from the notebook.
Removing HDD Module
1. Remove 2 screws (M2*5) here, open HDD door by the tweezers and then take away the HDD
door.
2. Remove the sponge and pull the hard disk module toward the direction of the arrow and lift it up
and take it out.
Optical Drive Module
1. Unlock and hold the latch, and remove the ODD module.
HDD
MODULE
HDD
MODULE
REMOVAL
OPTICAL
DRIVE
REMOVAL
Disassembly procedure
2 - 7
Keyboard Module
The illustration of below shows how to remove the keyboard
Removing Keyboard
1. Remove 2 screw (M2*5) here, and then turn over the notebook.
2. Push the 3latches in (F1, F8, Ins) with a pair of tweezers or a single-slotted screwdriver
and lift the keyboard plate up.
3. Lay the keyboard down over the Top case. *Do not remove the keyboard yet.
The keyboard cable is still attached.
KEYBOARD
Disassembly procedure
2 - 8
4. Disconnect the FPC connector by a pair of tweezers and then remove the keypad plate.
Removing Keyboard Cable
1. Use a flexible connector tool to unlock the cable connector on both ends (no. 1).
2. Carefully pull out the keyboard cable (no. 2) with a pair of tweezers.
3. Lock the connector (no. 3) again to avoid possible breakage.
Top Case Module
The illustrations below show how to disassemble and remove the top case module of the notebook.
The module contains the top case itself.
Removing Top Case Module
1. Remove 6 screws (M2*8; M2*5) here
1. Unlock
2. Cable out
3.
1. Unlock
3.
TOP CASE
MODULE
TOP CASE
REMOVAL
Disassembly procedure
2 - 9
2. Remove the both hinge covers.
3. Remove 2 screws in hames cover, then take the hames cover away.
4. Remove 1 piece of tape fixing the table and then remove 1 screw here, and disconnect the LCD
cable
Disassembly procedure
2 - 10
5. Remove 1 screw here, and disconnect the cable.
6. Remove 2 screws on both end
7. Remove 2 screws beside the system.
Andere Handbücher für G1S
1
Inhaltsverzeichnis
Andere Asus Laptop Handbücher
Asus
Asus W2V Bedienungsanleitung
Asus
Asus 1000HA - Eee PC - Atom 1.6 GHz Bedienungsanleitung
Asus
Asus N75SF Bedienungsanleitung
Asus
Asus FX505DY Series Bedienungsanleitung
Asus
Asus G751J Leitfaden
Asus
Asus GL552J Leitfaden
Asus
Asus P84SG Bedienungsanleitung
Asus
Asus Eee PC 900 Linux Bedienungsanleitung
Asus
Asus E9396 Leitfaden
Asus
Asus Eee PC 1000HAE Bedienungsanleitung
Asus
Asus G1S Gebrauchsanweisung
Asus
Asus E12726 Bedienungsanleitung
Asus
Asus ZenBook 14 Bedienungsanleitung
Asus
Asus S1B Gebrauchsanweisung
Asus
Asus ZenBook Flip 14 Bedienungsanleitung
Asus
Asus Eee PC 1001PQ Series Bedienungsanleitung
Asus
Asus ZenBook Pro Duo UX581GV Bedienungsanleitung
Asus
Asus VX1 Gebrauchsanweisung
Asus
Asus B43S Bedienungsanleitung
Asus
Asus F102BA Leitfaden
