Auber Instruments KIT-CUBE2S Bedienungsanleitung

AuberInstruments v1.2 6/12/2019

1



KIT-CUBE2S Installation Guide



1. Enclosure

Disassemblingallthescrewsandtheenclosurewillbespittedintofourpieces:



Figure1.TopandBodyofQbox1.



Figure2.RearPlateofQbox1.

AuberInstruments v1.2 6/12/2019

2



Figure3.FrontPlateofQbox1.



Figure4.BottomPlateofQbox1.



Tips:Duetothespaceinsidetheenclosureislimited,werecommendyoutostartwith

theinstallationofheatsink,SSR,fuseholdersandminirelaysfirst,andthencomplete

thewiringfortheparts.Duringallthewiringprocess,theenclosureshouldbekept

upsidedown;thebottomplateshouldbeassembledbacklastly.

AuberInstruments v1.2 6/12/2019

3



2. HeatSinkandSolid‐StateRelay(SSR)



Thereare(4)M6screwsofferedtomounttheheatsinkonthetopofCUBEbox.

Figure5.Topviewofheatsinkinstallation.

Figure6.Bottomviewofheatsinkinstallation.

HeatSink

AuberInstruments v1.2 6/12/2019

4



Figure7.ApplySiliconGreaseuniformlybeforemountingtheSSR.

Figure8.Using(2)M4screwsprovidedtomounttheSSRontheheatsink.



Apply silicon

grease at this

area.

SSR

AuberInstruments v1.2 6/12/2019

5



3. FuseHoldersandMiniRelays.

NOTE:TwopairsofM3screwandnutsareprovidedtomounteachfuseholderintheKIT.



Figure9.(2)pairsofM3screwandnutsareprovidedformountingeachminirelay,(1)pairof

M3scewandnutsareprovidedformountingeachfuseholder.



Figure10.Locatethe(8)smallholespre‐drilledandstarttomountyour(2)minirelaysand(2)

fuseholders.

AuberInstruments v1.2 6/12/2019

6



Figure10.OutsideView(Screwcapshouldbefacingoutside).



Figure11.Insideview(allnutsshouldbeinstalledinside).

Tips:ifyouhaverivets

andrivetgun,youcan

alsouseittomountthe

fuseholderinsteadof

usingM3screwandnut.

AuberInstruments v1.2 6/12/2019

7



4. WirePreparation



Table1.Thetotallengthofeachwireneeded.

WireColor 10AWG 14AWG 22AWG

Green 2ft 2ft 0ft

White 0ft 3ft 3ft

Black 3ft 5ft 3ft

Red 3 ft 0ft 1ft

Yellow 0ft 0ft 1ft

RTDExtensionWire ThisisofferedinthekitandsolderedwithblackXLRmaleconnector.



Table2.Thetotalnumberofconnectorsneeded.

ConnectorTypes QTY For

YellowStudRingTerminal(12‐10AWG) 4 Ground

RedInsulatedFemaleDisconnectSquare(22‐18AWG) 8 5‐15Rsocket&MiniRelay

BlueInsulatedFemaleDisconnectSquare(16‐14AWG) 4 MiniRelay

Blue#6StudLockingSpade/ForkTerminal(22 ‐ 18 AWG) 8 Controllerand SSRinput

Yellow#8StudLockingSpade/ForkTerminal(12‐10AWG) 2 SSROutput

BlueVinylFullyInsulatedFemaleWireDisconnect(16–14AWG)4 Fuseholder



Pleasecutandstripyourwiretorecommendedlength,andcrimpthemwithappropriate

connectors.

 Figure13.Groundandneutralwires. 

AuberInstruments v1.2 6/12/2019

8



Figure14.10‐AWGhotwires.



Figure15.14‐AWGhotwires.

AuberInstruments v1.2 6/12/2019

9



Figure16.Othercontrolwires.



Figure17.Wiringharnessofilluminatedswitches.Removetheunnecessarygreenwiresbyinsertapairof

tweezersintothecorrespondingslots(forgreenwires)andpullthemoutgentlybyhandatthesametime.

Ifthewirescannotberemovedeasily,thatmeansthetweezersmaynotbeinsertedintotherightslots.

AuberInstruments v1.2 6/12/2019

10



5. PartsWiring.



Figure17.Rearplateassemblyandgroundwiring.(Note:L6‐30Rheateroutputshouldbemountwith

the(2)M4screws;XLRCON‐M connectorneeds (2)pairsofM3screwsandnuts.)



Figure18.Continuewithhotandneutralwireslikethephoto.Leavethehotwirestobeconnected

later.

Note:using8‐32nutas

GroundingPost.

L6‐30R

Heater

Outlet

XLRCON‐M

Connector

Andere Auber Instruments Controller Handbücher

Auber Instruments

Auber Instruments SYL-3615 Bedienungsanleitung

Auber Instruments

Auber Instruments DSPR300 Bedienungsanleitung

Auber Instruments

Auber Instruments WS-1500A Administratorhandbuch

Auber Instruments

Auber Instruments AW-SYL-2352 Bedienungsanleitung

Auber Instruments

Auber Instruments EZboil DSPR320 Bedienungsanleitung

Auber Instruments

Auber Instruments WS-1500EPM Administratorhandbuch

Auber Instruments

Auber Instruments Auberins KIT-GGP Bedienungsanleitung

Auber Instruments

Auber Instruments Cube 5E Bedienungsanleitung

Auber Instruments

Auber Instruments SYL-2362B Bedienungsanleitung

Auber Instruments

Auber Instruments DSPR400 Bedienungsanleitung

Auber Instruments

Auber Instruments KIT-RSPb Bedienungsanleitung

Auber Instruments

Auber Instruments EZboil DSPR120 Bedienungsanleitung

Auber Instruments

Auber Instruments EZboil DSPR310 Bedienungsanleitung

Auber Instruments

Auber Instruments KIT-Cube5E Bedienungsanleitung

Auber Instruments

Auber Instruments TH220A Bedienungsanleitung

Auber Instruments

Auber Instruments EZboil DSPR310D Bedienungsanleitung

Auber Instruments

Auber Instruments SYL-53 2P Series Bedienungsanleitung

Auber Instruments

Auber Instruments HD220 Bedienungsanleitung

Auber Instruments

Auber Instruments SYL-2615 Bedienungsanleitung

Auber Instruments

Auber Instruments SYL-2381-SSR Bedienungsanleitung

Auber Instruments

Auber Instruments HD330 Bedienungsanleitung

Auber Instruments

Auber Instruments EZboil DSPR310D Bedienungsanleitung

Auber Instruments

Auber Instruments RDK-300B Bedienungsanleitung

Auber Instruments

Auber Instruments AUB6500 Bedienungsanleitung

Beliebte Controller Handbücher anderer Marken

Digiplex

Digiplex DGP-848 Betriebsanleitung

YASKAWA

YASKAWA SGM series Bedienungsanleitung

Sinope

Sinope Calypso RM3500ZB Bedienungsanleitung

Isimet

Isimet DLA Series Style 2 Installationshandbuch

LSIS

LSIS sv-ip5a Bedienungsanleitung

Rockwell Automation

Rockwell Automation 1769-L31 Bedienungsanleitung

Airflow

Airflow Uno hab Bedienungsanleitung

ABB

ABB ACS580-01 drives Bedienungsanleitung

Panasonic

Panasonic GM1 Series Bedienungsanleitung

Emerson

Emerson SW93 Bedienungsanleitung

AutoAqua

AutoAqua Smart ATO micro SATO-120P Bedienungsanleitung

Panasonic

Panasonic FP? Positioning Unit RTEX Bedienungsanleitung

Samson

Samson Type 5824 Service-Handbuch

Alpha IP

Alpha IP MIOB 21001 Bedienungsanleitung

Siemens

Siemens OpenAir GMA 1 Series Bedienungsanleitung

Surecom

Surecom SR-629 Bedienungsanleitung

Fishman

Fishman TriplePlay Bedienungsanleitung

Regulus

Regulus SRS1 T Bedienungsanleitung