Avery Dennison TrafficJet Handbuch

Avery DennisonⓇⓇ

TrafficJet™ Purex Fume Extractor

Instructional Bulletin : # 9.17

Revision : # 02

Last Updated : June 2018



Contents

●Installation

●Control System

○Switch ON the Machine

○Adjust the Airflow

●Replacing the Filters

○Changing the Main Filter

○Changing the Pre-Filter

●Warning Alerts

○Warning Status

○Alarm Status

●Changing the Fuse

●Contact Information Purex



Instructional Bulletin IB# 9.17

TrafficJet™ Purex Fume Extractor

Page 1 of 6

reflectives.averydennison.com

Installation

1. Position the fume extractor as near as possible to the TrafficJet printer allowing for easy access to                

the control panel, filter replacement, exhaust, electrical, and hose connections. Once in place,            

lock all casters.

2. Connect the extraction hose to the intake of the fume extractor and the other end of the hose to                  

the supplied Maintenance Cover. Make sure all connections are properly sealed.

3. Remove the Left Maintenance Cover of the TrafficJet and replace it with the New Maintenance              

Cover connected to the fume extractor.



4. Connect the power supply cable to the fume extractor and plug in the extractor to a dedicated                

power source.

5. While the TrafficJet printer is not printing or cleaning, go to the user panel and select “Menu”.                

Scroll through until you reach “18 Exhaust Fan” and select “OFF”.



Turn OFF the Printer’s exhaust fan while the fume extraction system is running in order to achieve                

maximum efficiency.



Instructional Bulletin IB# 9.17

TrafficJet™ Purex Fume Extractor

Page 2 of 6

reflectives.averydennison.com

Control System

Switch ON the machine

Press the center button on the keypad. The center button will illuminate green and the motor-run-icon on                

the display will rotate. To turn the extractor off, press the center button again and the light will go off and                    

the icon will stop rotating.



Adjust the airflow

Press the UP and DOWN buttons together and both will begin to flash red. To increase the airflow rate                  

press UP, to decrease press DOWN.



Recommended airflow rate: 150 CFM / 255 m3/h. Setting this value higher, can disturb the airflow inside                

the machine in such a way, the printing process can be affected in a negative way.



Please note that this solution should be considered a recommendation and possible addition to reduce the               

fumes and odor. Additional extraction or adjustments might be required to be compliant with local health               

and safety regulations.



After a few seconds the buttons will stop flashing the airflow rate value will be stored. The fume extractor                  

will now maintain the correct airflow level without further user input during TrafficJet printing.



Instructional Bulletin IB# 9.17

TrafficJet™ Purex Fume Extractor

Page 3 of 6

reflectives.averydennison.com

Replacing the Filters

Filters should be replaced annually.



To avoid airflow false alerts, always check the extraction hose and air intakes for debris buildup before                

replacing filters.



In case the filters need replacement sooner or in between, the fume extractor will warn the user with                 

audible and visible alerts. Icons on graphic display will flash indicating the filters needing attention. Always               

wear protective gloves, eyewear, and masks when disposing of the used filters. Place the old filter into the                 

provided disposal bag.



Before replacing the filters



1. Make sure printing on the TrafficJet is stopped

2. Turn off the fume extractor



Changing the Main Filter



1. Turn the door lock on the front of the extractor and open the door.

2. Turn the filter locking handle 180º counterclockwise so it is horizontal. The filter should drop              

slightly to allow release.



3. Remove the filter by sliding it towards the user and remove it completely from the machine. Be                

careful as the filter may be heavy

4. Insert the new filter fully into the machine making sure that the airflow arrow on the label is                 

pointing up.



Instructional Bulletin IB# 9.17

TrafficJet™ Purex Fume Extractor

Page 4 of 6

reflectives.averydennison.com



Changing the pre-Filter

1. To remove the pre-filter pad, the main filter must be removed first and turned over

2. Remove the older pre-filter and replace it with a new one making sure the smooth side of the                 

pre-filter pad is facing the main filter

3. Turn the filter locking handle 180º clockwise so that it is horizontal

4. Close and lock the door. The machine may now be restarted



Warning alerts

Warning Status

An audible chime every 20 seconds while the keypad flashes red every 10 seconds is designed to give the

user advanced warning so that action can be taken.

Alarm Status

An audible chime and keypad flashing every 1 second means immediate action must be taken.



The three columns on the graphic display correspond to three alerts. The far left column is for “Filter

Blocked Warning”. The middle column above the respirator icon is for “gas sensor” and the right column

warning is for “Particulate Sensor”.



Please see the Purex Manual for further details.



Changing the Fuse

1. Make sure the machine is disconnected from the main power supply

2. Remove the fuse by unscrewing the fuse cap with a screwdriver counterclockwise and remove the              

fuse

3. Check the fuse holder for any damage. If there is damage contact Purex Technical Support

4. Replace with a new fuse of correct rating. Please contact Purex if there is a question of                

compatibility

5. Reattach the fuse cap and turn it 1¼ full turns clockwise



Instructional Bulletin IB# 9.17

TrafficJet™ Purex Fume Extractor

Page 5 of 6

reflectives.averydennison.com



Contact Information

Purex International Ltd (UK)

Purex House, Farfield Park, Manvers

Rotherham

South Yorkshire

S63 5DB

Web: www.purex.co.uk

Tel: +44 (0)1709 763000

Fax: +44 (0)1709 763001

E-mail: [email protected]



Hours of Operation

Monday-Thursday 8.00am to 5.30pm

Friday 8.00am to 2.00pm



Purex Inc.

2246 Palmer Drive, Suite 108

Schaumburg

Illinois 60173

United States

Web: www.purexinc.com

Tel: +001 866 360 5675

E-mail: [email protected]



Hours of Operation

Monday-Thursday 8.00am to 5.30pm

Friday 8.00am to 2.00pm



The above Avery Dennison literature provides information to the user for proper application, storage and other requirements. Please refer to Product Data

Bulletins or your local Avery Dennison Representative for warranty information. Find the latest information on the Avery Dennison website,

www.reflectives.averydennison.com. We encourage you to check our website periodically for updates.



All statements, technical Information and recommendations about Avery Dennison products are based upon tests and information believed to be reliable, but do

not constitute a guarantee or warranty of any kind. All Avery Dennison products are sold with the understanding that Purchaser has independently determined

the suitability of such products for its intended and other purposes.



For technical questions, please contact:



North America: [email protected]

Europe, Middle East & Africa: [email protected]

Asia Pacific: [email protected]

South America: [email protected]



Instructional Bulletin IB# 9.17

TrafficJet™ Purex Fume Extractor

Page 6 of 6

reflectives.averydennison.com

Andere Handbücher für TrafficJet

Inhaltsverzeichnis

Andere Avery Dennison Drucker Handbücher

Avery Dennison

Avery Dennison SNAP 700 Bedienungsanleitung

Avery Dennison

Avery Dennison Wireless Ethernet Print Server Monarch 7411 Bedienungsanleitung

Avery Dennison

Avery Dennison M09416 XLI Bedienungsanleitung

Avery Dennison

Avery Dennison SNAP 500 Bedienungsanleitung

Avery Dennison

Avery Dennison Monarch 9485 Bedienungsanleitung

Avery Dennison

Avery Dennison Monarch SIERRA SPORT4 9493 Bedienungsanleitung

Avery Dennison

Avery Dennison FRESHMARX 9416 Technisches Dokument

Avery Dennison

Avery Dennison Pathfinder 6059 Technisches Dokument

Avery Dennison

Avery Dennison AP7.t Bedienungsanleitung

Avery Dennison

Avery Dennison SNAP 500 Bedienungsanleitung

Avery Dennison

Avery Dennison Monarch Pathfinder Ultra Platinum 9462 Bedienungsanleitung

Avery Dennison

Avery Dennison AP 2.4 Bedienungsanleitung

Avery Dennison

Avery Dennison 686 HT Bedienungsanleitung

Avery Dennison

Avery Dennison SNAP 500 Betriebsanleitung

Avery Dennison

Avery Dennison Platinum 6039 Betriebsanleitung

Avery Dennison

Avery Dennison MONARCH 9416 XL Montage- und Bedienungsanleitung

Avery Dennison

Avery Dennison Monarch ADTP2 EcoCut Service-Handbuch

Avery Dennison

Avery Dennison SNAP 700 Bedienungsanleitung

Avery Dennison

Avery Dennison Monarch TC6039SA Service-Handbuch

Avery Dennison

Avery Dennison MonarchNet2 9855 Bedienungsanleitung

Avery Dennison

Avery Dennison Monarch 9493 SNP Service-Handbuch

Avery Dennison

Avery Dennison AP4.4 Fehlerbehebungshandbuch

Avery Dennison

Avery Dennison FreshMarx 9417 Service-Handbuch

Avery Dennison

Avery Dennison Monarch 9906 Bedienungsanleitung

Beliebte Drucker Handbücher anderer Marken

Lexmark

Lexmark 1400 Series Handbuch

Canon

Canon i70 Series Bedienungsanleitung

Evolis

Evolis Elypso Bedienungsanleitung

Kyocera

Kyocera FS-9530DN Bedienungsanleitung

Canon

Canon LASER SHOT LBP-1210 Bedienungsanleitung

Samsung

Samsung BIXOLON SRP-350plusF Bedienungsanleitung

Canon

Canon PIXMA PRO-1 Series Bedienungsanleitung

Canon

Canon PIXMA G3560 Einrichtungshandbuch

Dell

Dell Color Laser Printer 2130cn Bedienungsanleitung

Tektronix

Tektronix Phaser 840 Bedienungsanleitung

Epson

Epson ET-7750 Betriebsanleitung

Canon

Canon CLBR 460ps Bedienungsanleitung

Eltron

Eltron P210 Guide Bedienungsanleitung

Ricoh

Ricoh MD-P1 Bedienungsanleitung

Epson

Epson SC-F7100 series Bedienungsanleitung

Epson

Epson Stylus C40UX Bedienungsanleitung

Canon

Canon imagePASS-A2 Bedienungsanleitung

Canon

Canon S820D Bedienungsanleitung