BE BE-3100PR Bedienungsanleitung

operation manual

table of contents

Introduction

4 Using the Operators Manual

Product Identification

5 Generator

5 Engine

Safety

6 Safety Rules

6 Hazard Symbols and Meanings

9 Ground Fault Circuit Interrupter Protection

Generator Components

13 3500W Component Chart

14 6500W Component Chart

15 9000W Component Chart

Preparing the Generator

16 Grounding the Generator

Pre-Operation Checklist

17 Engine Oil

17 Fuel

18 General Recommendations

18 Fuel Type

18 Gasoline/Alcohol Blends

18 Gasoline/Ether Blends

18 Check Component Parts

19 Check Generator Surroundings

Starting the Generator

19 Recoil Start

21 Electric Start

table of contents

Introduction

4 Using the Operators Manual

Product Identification

5 Generator

5 Engine

Safety

6 Safety Rules

6 Hazard Symbols and Meanings

9 Ground Fault Circuit Interrupter Protection

Generator Components

13 3500W Component Chart

14 6500W Component Chart

15 9000W Component Chart

Preparing the Generator

16 Grounding the Generator

Pre-Operation Checklist

17 Engine Oil

17 Fuel

18 General Recommendations

18 Fuel Type

18 Gasoline/Alcohol Blends

18 Gasoline/Ether Blends

18 Check Component Parts

19 Check Generator Surroundings

Starting the Generator

19 Recoil Start

21 Electric Start

Operation

22 Using Electric Power

22 AC Application

23 DC Application

23 Connection of Cable

23 Safety Precautions While Charging

24 Wattage Information

25 Spark Arrester

25 How To Remove The Spark Arrester

25 Clean The Spark Arrester Screen

Stopping the Generator

26 Stopping the Generator

26 Oil Sensor

Troubleshooting

27 Troubleshooting Chart

Maintenance

28 Maintenance Schedule

28 Daily Inspection

28 Periodic Maintenance

29 Changing Engine Oil

29 Servicing The Air Cleaner

29 Cleaning and Gapping Spark Plug

29 Cleaning Fuel Strainer

29 Periodic Operation and Inspection

Transporting

30 Transporting

Storage

31 Preparation for Storage

Using the Operator’s manual

The operating manual is an important part of your generator and should

be read thoroughly before initial use, and referred to often to make sure

adequate safety and service concerns are being addressed.

Reading the owner’s manual thoroughly will help avoid any personal injury

or damage to your machine. By knowing how best to operate this

machine you will be better positioned to show others who may also

operate the unit.

This manual contains information for the complete range of BE

generators, and was written to take you from the safety requirements

to the operating functions of your machine. You can refer back to the

manual at any time to help troubleshoot any specific operating functions,

so store it with the machine at all times.

Attention: Read through the complete

manual prior to the initial use of your

generator.

introduction

product identification

Record Identification Numbers

Generator

If you need to contact an Authorized Dealer or Customer Service line

(1-866-850-6662) for information on servicing, always provide the

product model and identification numbers.

You will need to locate the model and serial number for the machine and

record the information in the places provided below.

Date of Purchase:

Dealer Name:

Dealer Phone:

Product Identification Numbers

Model Number:

Serial Number:

The safety alert symbol ( ) is used with a signal word (DANGER,

CAUTION, WARNING), a pictorial and/or a safety message to alert you

to hazards.

DANGER indicates a hazard which, if not avoided, will result in death or

serious injury.

WARNING indicates a hazard which, if not avoided, could result in death

or serious injury.

CAUTION indicates a hazard which, if not avoided, might result in minor

or moderate injury.

NOTICE indicates a situation that could result in equipment damage.

Follow safety messages to avoid or reduce the risk of injury or death.

Hazard Symbols and Meanings

Save these Instructions

Safety Rules

safety

This is the safety alert symbol. It is used

to alert you to potential personal injury

hazards. Obey all safety messages that

follow this symbol to avoid possible

injury or death.

explosion

kickback read manual

fire electric shock

toxic fumes

safety

WARNING

Generator exhaust contains carbon monoxide, a

poisonous gas that can kill you.

You CANNOT smell or see this gas.

• Use the generator outdoors, away from open windows, vents, or

doors that could allow the carbon monoxide gas to come indoors.

Keep the generator at least 1 meter (3 feet) away from any structure

or building during use.

• NEVER use a generator indoors, including in homes, garages,

basements, crawl spaces, and other enclosed or partially-enclosed

areas, even with ventilation. Opening doors and windows or using

fans will not prevent carbon monoxide build-up in the home.

• NEVER use a generator in enclosed or partially-enclosed spaces.

Generators can produce high levels of carbon monoxide very quickly.

When you use a portable generator, remember that you cannot smell

or see carbon monoxide. Even if you can’t smell exhaust fumes, you

may still be exposed to carbon monoxide.

• NEVER operate the generator in an explosive atmosphere, near

combustible materials or where ventilation is not sufficient to carry

away exhaust fumes. Exhaust fumes can cause serious injury or death.

• If you start to feel sick, dizzy, or weak while using a generator, get

to fresh air RIGHT AWAY. DO NOT DELAY. The carbon monoxide

from generators can rapidly lead to full incapacitation and death.

• If you experience serious symptoms, get medical attention

immediately. Inform medical staff that carbon monoxide poisoning

is suspected. If you experienced symptoms while indoors, have

someone call the fire department to determine when it is safe to

re-enter the building.

safety

WARNING

Fuel and its vapors are extremely flammable and

explosive.

Fire or explosion can cause severe burns or death.

When Adding or Draining Fuel

• Observe all safety regulations for the safe handling of fuel. Handle

fuel in safety containers. If the container does not have a spout, use

a funnel.

• Do not overfill the fuel tank, leave room for the fuel to expand.

• Do not refill fuel tank while the engine is running. Before refueling the

generator, turn it off and let it cool down. Gasoline spilled on hot

engine parts could ignite.

• Fill the tank only on an area of bare ground. While fueling the tank,

keep heat, sparks and open flame away. Carefully clean up any spilled

fuel before starting engine.

• Always fill fuel tank in an area with plenty of ventilation to avoid

inhaling dangerous fumes.

• NEVER store fuel for your generator in the home. Gasoline, propane,

kerosene, and other flammable liquids should be stored outside of

living areas in properly-labeled, non-glass safety containers. Do not

store them near a fuel-burning appliance, such as a natural gas water

heater in a garage. If the fuel is spilled or the container is not sealed

properly, invisible vapors from the fuel can travel along the ground and

can be ignited by the appliance’s pilot light or by arcing from electric

switches in the appliance.

safety

WARNING

The GFCI may not function unless the generator is properly

grounded. Follow the correct procedure specified in the section

labeled GROUNDING INSTRUCTIONS.

Ground Fault Circuit Interrupter Protection

These generators are equipped with a GFCI (Ground Fault Circuit

Interrupters) 120V duplex receptacles for protection against the hazards

of electrical shock from defective attachments such as, tools, cords,

and cables.

A GFCI is a device that interrupts electricity from either the utility or

generator by means of a special type of circuit breaker that determines if

a current flow to the ground occurs.

A GFCI can be used only with generators that have the neutral wire

internally bonded to the frame, and the frame properly grounded to the

earth. A GFCI will not work on generators that do not have the neutral

wire bonded to the frame, or on generators which have not been properly

grounded. All BE generators have internally bonded ground wires.

safety

DANGER

Improper grounding can result in a risk of electrocu-

tion. Check with a qualified electrician for your local

requirements if you are in doubt as to whether the unit

is properly grounded.

This generator is equipped with a grounding terminal for added

protection. Using the ground path from the generator to an

external ground source as instructed in the section labeled “Grounding

Instructions” in the Preparation section of this manual can be

necessary. Please consult a qualified electrician for local regulations.

The generator is a potential source of electrical shock if not kept dry.

Keep the generator dry and do not use in rain or wet conditions. To

protect from moisture, operate it on a dry surface under an open,

canopy-like structure. Dry your hands if wet before touching the

generator.

Plug appliances directly into the generator. Or, use a heavy duty,

outdoor-rated extension cord that is rated (in watts or amps) at least

equal to the sum of the connected appliance loads. Check that the

entire cord is free of cuts or tears and that the plug has all three

prongs,especially a grounding pin.

NEVER try to power the house wiring by plugging the generator into

a wall outlet, a practice known as “back feeding”. This is an extremely

dangerous practice that presents an electrocution risk to utility workers

and neighbors served by the same utility transformer. It also bypasses

some of the built-in household circuit protection devices.

If you must connect the generator to the house wiring to power

appliances, have a qualified electrician install the appropriate

equipment in accordance with local electrical codes.

This product has been designed with internal grounding or floating

bonded neutral. If it should malfunction or breakdown, grounding pro-

vides a path of least resistance for electric current to reduce the risk of

electric shock.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere BE Tragbarer Generator Handbücher

BE BE9400DFS Bedienungsanleitung

BE BE3600IE Bedienungsanleitung

BE BE7500iD Bedienungsanleitung

BE BE1200I Bedienungsanleitung

BE I3000R Bedienungsanleitung

BE BE3500IP Bedienungsanleitung

BE I3500L Bedienungsanleitung

BE BE12000ES Bedienungsanleitung

BE Deluxe Series Bedienungsanleitung

BE BE-12000ER Bedienungsanleitung

BE I2000L Bedienungsanleitung

BE BE-12000ER Bedienungsanleitung

Beliebte Tragbarer Generator Handbücher anderer Marken

Kohler

Kohler 20EORZ Bedienungsanleitung

Powerhorse

Powerhorse 83171 Bedienungsanleitung

HURST

HURST ML-630-SI Bedienungsanleitung

ETQ

ETQ TG4000 Bedienungsanleitung

Briggs & Stratton

Briggs & Stratton 40265 Einrichtungshandbuch

evertz

evertz 7700 Series Bedienungsanleitung

Firefly

Firefly Cygnus CYG2400/460/24 Bedienungsanleitung

Owon

Owon Waveform Generator Bedienungsanleitung

Draper

Draper PG950S Firmware-Update

SDMO

SDMO SH 4000 Bedienungsanleitung

EINHELL

EINHELL STE 5500 Bedienungsanleitung

Wanco

Wanco WI3000P Bedienungsanleitung

Full Boar

Full Boar FBT-3300 Bedienungsanleitung

Dwyer Instruments

Dwyer Instruments ASG Bedienungsanleitung

Westinghouse

Westinghouse WH1000i Series Bedienungsanleitung

Wallenstein

Wallenstein GF5000A Bedienungsanleitung

Leroy-Somer

Leroy-Somer LSA 49.1 Bedienungsanleitung

Yamakoyo

Yamakoyo SH2900DX Bedienungsanleitung