Beta RS 4T 450 Bedienungsanleitung

1USA

RS 4T 400 - 450 - 520

Thanks for you preference, and have a good time! This hand-

book contains the information you need to properly operate and

maintain your motorcycle.

The data and speciﬁcations provided in this manual does not constitute an

engagement on the part of BETAMOTOR S.p.A. BETAMOTOR reserves the

right to make any changes and improvements to its models at any moment

and without notice.

USA

IMPORTANT

We recommend you to check all the tightenings after the ﬁrst one

or two hours’ ride over rough ground. Special attention should

be paid to the following parts:

•rear sprocket

•ensure that the footrests are properly ﬁxed

•front/rear brake levers/calipers/discs

•check that the plastics are properly fastened

•engine bolts

•shock absorber bolts/swingarm

•wheel hubs/spokes

•rear frame

•pipe connections

•tensioning the chain

IMPORTANT

For any servicing requirements, please get in contact with Beta-

motor’s authorized service network.

CONTENTS

3USA

CONTENTS

Operating instructions............................................................................. 5

Ecologic guide....................................................................................... 5

Riding safety .........................................................................................6

CHAPTER 1 GENERAL INFORMATION ..............................................7

Vehicle identiﬁcation data ....................................................................... 8

Tools kit ..............................................................................................10

Steering lock .......................................................................................11

Familiarizing with the vehicle.................................................................12

Moto-GPS “Voyager” (Trail Tech)............................................................ 16

Speciﬁcations ......................................................................................17

Electrical system...................................................................................20

Recommended lubricants and liquid .......................................................24

CHAPTER 2 OPERATION .................................................................. 25

Checks to be performed before each ride ...............................................26

Running-in ........................................................................................... 27

Engine start .........................................................................................28

Refuelling............................................................................................ 29

Fuel tank cap....................................................................................... 29

Fuel cock ............................................................................................29

CHAPTER 3 CHECKS AND MAINTENANCE .....................................31

Oil circuit............................................................................................ 32

Changing the gear and clutch oil ...........................................................35

Brakes ................................................................................................36

Tyres...................................................................................................39

Hydraulic clutch ................................................................................... 40

Fork oil ...............................................................................................41

Air Filter.............................................................................................. 44

Spark plug ..........................................................................................45

Carburettor .........................................................................................47

Coolant ..............................................................................................48

Chain .................................................................................................49

Battery................................................................................................50

Cleaning the vehicle............................................................................. 51

Scheduled maintenance vehicle .............................................................52

Prolonged inactivity..............................................................................54

CONTENTS

USA

CHAPTER 4 ADJUSTMENTS..............................................................55

Adjusting the home position of the front brake lever..................................56

Adjusting the home position of the brake pedal .......................................56

Adjusting the home position of the clutch lever.........................................56

Adjusting the handlebars ......................................................................56

Gas control adjustment ......................................................................... 57

Checking and adjusting the steering play................................................57

Adjusting fork ...................................................................................... 58

Shock absorber....................................................................................59

Tensioning the chain.............................................................................60

Adjusting the idle speed........................................................................ 61

CHAPTER 5 REPLACEMENTS ............................................................63

Replacing the brake pads .....................................................................64

Replacing the headlight bulbs................................................................66

Tail light..............................................................................................66

CHAPTER 6 TROUBLESHOOTING ....................................................67

Troubleshooting ...................................................................................68

5USA

OPERATING INSTRUCTIONS

•The vehicle must be accompanied by: number-plate, registration document, tax

disc and insurance.

•Do not carry animals, pets or loose objects that can stick out from the vehicle.

•Riding without a crash helmet is forbidden.

•Always ride with the low beam on.

•Any modiﬁcations of the engine or other parts resulting in a power and/or speed

increase are punishable by severe sanctions including the conﬁscation of the vehicle.

•To protect your safety and that of others, always drive carefully and with your helmet

on.

WARNING

Any modiﬁcations and tampering with the vehicle during the warranty period exempt

the manufacturer from all responsibility and invalidate warranty.

ECOLOGIC GUIDE

•Every vehicle powered by an internal combustion engine produces an amount of

noise (noise pollution) and gases (air pollution) which varies with the riding style.

•The abatement of noise and air pollution levels is the duty of everybody. Avoid

full-throttle starts, sudden acceleration and abrupt braking. This will reduce noise

emission as well as the wear and tear of the tyres and mechanical parts, and will

also allow a considerable reduction in fuel consumption.

USA

RIDING SAFETY

•Observe the Highway Code.

•Always put on and fasten a homologated helmet.

•Always ride with the low beam on.

•Always keep the crash helmet visor clean.

•Avoid wearing garments with hanging ends.

•Do not keep sharp or brittle objects in your pockets while riding.

•Properly adjust the rearview mirrors.

•Always ride in a seated position, with both hands on the handlebars and both feet

on the footrests.

•Always pay attention and do not allow anything to distract you while riding.

•Do not eat, drink, smoke, use a mobile phone, etc. while riding.

•Do not wear headphones to listen to music while riding.

•Never ride abreast with other vehicles.

•Do not tow and avoid being towed by other vehicles.

•Always keep a safe distance from other vehicles.

•Do not sit on the vehicle when it is on its stand.

•Do not start off while the vehicle is on its stand.

•Do not pull out the stand when the vehicle is facing downhill.

•Avoid swaying and wheelies as they are extremely dangerous for your own and

other people’s safety as well as for your vehicle.

•Always apply both brakes on dry roads with no gravel and sand. Using one brake

may be dangerous and cause uncontrolled skidding.

•To reduce the braking distance, always apply both brakes.

•On wet roads and in off-road riding, drive with care and at moderate speed. Take

special care in applying the brakes.

•Do not start the engine in closed places.

GENERAL INFORMATION

7USA

CHAPTER 1 GENERAL INFORMATION

CONTENTS

Vehicle identiﬁcation data ....................................................................... 8

Frame identiﬁcation ...........................................................................8

Engine identiﬁcation ..........................................................................8

Label location ...................................................................................9

Tools kit .............................................................................................. 10

Steering lock .......................................................................................11

Familiarizing with the vehicle.................................................................12

Main parts:.....................................................................................12

Clutch lever ....................................................................................13

Front brake lever ............................................................................. 13

Gearchange lever............................................................................13

Brake pedal....................................................................................13

Lights and key-switch........................................................................ 14

RH switch .......................................................................................14

LH switch........................................................................................14

Kickstart .........................................................................................15

Side stand ......................................................................................15

Canister ﬁlter system ........................................................................15

Moto-GPS “Voyager” (Trail Tech)............................................................16

Removing the lithium battery ............................................................. 16

Speciﬁcations ......................................................................................17

Weight........................................................................................... 17

Dimensions ..................................................................................... 17

Tyres..............................................................................................17

Capacities......................................................................................17

Front suspension..............................................................................17

Rear suspension ..............................................................................18

Front brake..................................................................................... 18

Rear brake ..................................................................................... 18

Engine ...........................................................................................18

Electrical system...................................................................................20

Electrical diagram ...........................................................................20

Legend electrical diagram ................................................................ 21

Battery ........................................................................................... 22

Fuse...............................................................................................23

Recommended lubricants and liquid .......................................................24

GENERAL INFORMATION

USA

VEHICLE IDENTIFICATION

DATA

FRAME IDENTIFICATION

Frame identiﬁcation data Aare stamped

on the right side of the steering head tube.

ENGINE IDENTIFICATION

Engine identiﬁcation data Bare stamped

in the area shown in the ﬁgure.

WARNING:

Tampering with the identiﬁcation numbers

is severely punished by law.

GENERAL INFORMATION

9USA

Label RS4T:

1 – Warnings plate

2 – Brake oil plate

3 – Technical plate and vapour recovery diagram

4 – Eco-plate

5 – Noise limit

6 – Liquid level check

LABEL LOCATION

This BETA exhaust system 2204185 meets U.S.EPA

noise emission requirements of 80dBa for model speciﬁc

code Beta 3867700497, 3867710497, 3867660497,

3867670497 and 3867680497

Installation of this exhaust system on motorcycles not

speciﬁed may violate U.S. federal law. USFS approved

spark arrester-Screen type ARROW screen type 5205007

GENERAL INFORMATION

USA

Get off the male end wrenches and hexa-

gon socket 3.

With these is possible to unscrew the

screw 4.

Pull the left cover of rear fender and unhook

two rubber band 5. Now the toolkit 6is

accessible.

To take the tool kit, push the button 1to

get off the saddle. Pull back the saddle.

Pull the rear side panel 2to disassemble it.

TOOLS KIT

The following items are supplied as stand-

ard: operation and maintenance manual,

tool kit (see photo).

Inhaltsverzeichnis

Andere Beta Fahrrad Handbücher

Beta

Beta EVO 80 Bedienungsanleitung

Beliebte Fahrrad Handbücher anderer Marken

RAMBO

RAMBO R1000X2M-FF-BFD Bedienungsanleitung

Vermeiren

Vermeiren SAFARI Bedienungsanleitung

Velec

Velec A2/36V Bedienungsanleitung

Cervélo

Cervélo S3 2019 Bedienungsanleitung

Festo

Festo EGSC-BS-KF Stücklistenhandbuch

Gio Electric

Gio Electric H1 Volt Bedienungsanleitung

GOGOBEST

GOGOBEST GM30 Bedienungsanleitung

DAHON

DAHON CIAO - 2009 Bedienungsanleitung

Aprimatic

Aprimatic ONDA 500 Kurzanleitung

MV Agusta

MV Agusta Lucky Explorer GRAVEL Gebrauchsanweisung

Greyp

Greyp G6 Series Bedienungsanleitung

Babboe

Babboe Carve-E Bedienungsanleitung

Huka

Huka orthros Bedienungsanleitung

Xtracycle

Xtracycle Stoker 2021 Bedienungsanleitung

APRILIA

APRILIA DORSODURO 750 ABS 2015 Bedienungsanleitung

Alien

Alien E-Bike Bedienungsanleitung

ISLABIKES

ISLABIKES luath pro series Bedienungsanleitung

ACID

ACID MUD ROOKIE SET 18 Bedienungsanleitung