Bosch WORCESTER GREENSTAR DANESMOOR WALL MOUNTED OIL... Bedienungsanleitung

GREENSTAR DANESMOOR

WALL MOUNTED OIL 12/18 & 18/25

WALL MOUNTED OIL FIRED CONDENSING BOILER

FOR FULLY PUMPED OPEN VENT OR SEALED CENTRAL HEATING

SYSTEMS AND DOMESTIC HOT WATER CYLINDERS

USER INSTRUCTIONS &

CUSTOMER CARE GUIDE

THIS BOILER IS USED WITH KEROSENE

(28 SECOND OIL) ONLY

USER INSTRUCTIONS &

CUSTOMER CARE GUIDE

PLEASE READ THESE INSTRUCTIONS

CAREFULLY BEFORE OPERATING YOUR

APPLIANCE.

THESE INSTRUCTIONS ARE

APPLICABLE TO THE WORCESTER,

BOSCH GROUP APPLIANCE MODEL(S)

STATED ON THE FRONT COVER OF THIS

MANUAL ONLY AND MUST NOT BE

USED WITH ANY OTHER MAKE OR

MODEL OF APPLIANCE.

IF YOU ARE IN ANY DOUBT CONTACT

THE WORCESTER, BOSCH GROUP

TECHNICAL HELPLINE.

PLEASE KEEP THESE INSTRUCTIONS

WITH THE INSTALLATION AND

SERVICING INSTRUCTIONS IN A SAFE

PLACE OR WITH THE APPLIANCE AFTER

INSTALLATION OR SERVICING.

DO NOT INTERFERE WITH ANY SEALED

COMPONENTS.

THIS APPLIANCE SHOULD ONLY BE

OPERATED BY RESPONSIBLE ADULTS

WHO HAVE BEEN INSTRUCTED IN, AND

UNDERSTAND ITS OPERATION AND ARE

AWARE OF ITS OPERATING

CONDITIONS AND EFFECTS.

THIS APPLIANCE SHOULD NOT BE

OPERATED BY CHILDREN.

USER INSTRUCTIONS &

CUSTOMER CARE GUIDE

GREENSTAR DANESMOOR WALL MOUNTED OIL 12/18 & 18/25

8 718 681 135a (08.08)

CONTACT INFORMATION

Worcester, Bosch Group:

Service call centres:

UK TEL: 08457 256206

FAX: 08457 757536

SCOTLAND ONLY FAX: 01506 441687

Other enquiries: TEL: FAX:

MAIN RECEPTION: 01905 754624 754619

TECHNICAL: 08705 266241

SPARES: 01905 752571

LITERATURE: 01905 752556

SALES: 01905 752640

WEBSITE: www.worcester-bosch.co.uk

WATER TREATMENT:

FERNOX 01799 550811

www.fernox.com

SENTINEL 0800 389 4670

www.sentinel-solutions.net

FLUE TERMINAL GUARDS:

WORCESTER, BOSCH GROUP

OIL FIRING TECHNICAL ASSOCIATION:

OFTEC 0845 6585080

www.oftec.org

CONTENTS

GREENSTAR DANESMOOR WALL MOUNTED OIL 12/18 & 18/25

8 718 681 135a (08.08)

INTRODUCTION

USING YOUR

APPLIANCE

MAINTENANCE ENERGY

SAVING

GUARANTEE

CONTENTS

INTRODUCTION

SAFETY PRECAUTIONS 2

EXCELLENCE COMES AS STANDARD 3

GENERAL INFORMATION 4

USING YOUR APPLIANCE

CONTROLS 5

OPERATING THE APPLIANCE

Switching the boiler on/off 6

Setting the heating temperature 6

Controlling central heating 6

Fault conditions 7

ENERGY SAVING

TIPS ON ENERGY SAVING 8-9

MAINTENANCE

MAINTAINING YOUR APPLIANCE 10

FAULT FINDING 11

FAULT OR BREAKDOWN 12

GUARANTEE

YOUR GUARANTEE 13

GUARANTEE REGISTRATION 14

NOTES

SAFETY PRECAUTIONS GREENSTAR DANESMOOR WALL MOUNTED OIL 12/18 & 18/25

8 718 681 135a (08.08)

SAFETY PRECAUTIONS

Any misuse or unauthorised modifications

to the appliance, flue or associated

components and systems could invalidate

the warranty. The manufacturer accepts no

liability arising from any such actions,

excluding statutory rights.

This appliance is suitable for use with

kerosene (28 second oil) only, no other

fuel must be used.

SERVICING:

The user must have the system regularly

serviced by a competent, qualified OFTEC

registered engineer using approved spares,

to help maintain the economy, safety and

reliability of the appliance.

The appliance should be serviced once

each year after installation unless the

installation conditions and usage demand

more frequent services.

DO NOT OPERATE THE APPLIANCE

WHEN:

The appliance, flue or system is

incorrectly fitted, faulty or damaged.

The flue terminal outlet fitted on the

outside wall or roof is obstructed or

damaged.

There are fumes, fuel leaks or fuel

smells from the fuel supply, appliance or

flue system.

The system is frozen, empty or if a

pressurised system is low on pressure.

The condensate pipe is blocked or

restricted.

The appliance clearances, as shown in

the installation manual, are inadequate.

The air supply is restricted or vents

damaged or blocked.

INTRODUCTION

OIL SMELLS, LEAKS OR FUMES FROM

THE APPLIANCE:

Extinguish any naked flames.

Open windows and doors.

Switch off the appliance electricity

supply.

Isolate the fuel supply to the boiler.

Contact boiler engineer.

HEALTH & SAFETY:

The appliance contains no asbestos and no

substances have been used in the

construction process that contravene the

COSHH Regulations (Control of

Substances Hazardous to Health

Regulations 1988). Where applicable, the

CE mark indicates compliance with relative

EU Directives.

COMBUSTIBLE AND CORROSIVE

MATERIALS:

Do not store or use any combustible

materials (paper, thinners, paints etc.)

inside or within the vicinity of the appliance.

The combustion air must be kept clear of

chemically aggressive substances which

can corrode the appliance and invalidate

any warranty.

FITTING & MODIFICATIONS:

Fitting the appliance and any controls to

the appliance may only be carried out by a

competent engineer in accordance with

the relevant Installation Regulations.

Flue systems must not be modified in any

way other than as described in the fitting

instructions.

EXCELLENCE COMES AS

STANDARD

GREENSTAR DANESMOOR WALL MOUNTED OIL 12/18 & 18/25

8 718 681 135a (08.08)

INTRODUCTION

EXCELLENCE COMES AS

STANDARD

Thank you for purchasing a Greenstar oil fired condensing boiler from Worcester,

Bosch Group. The company prides itself on manufacturing boilers to the strictest

quality control standards throughout every stage of production.

Worcester, Bosch Group has led the field in innovative appliance design and

performance for more than 40 years. This heritage means all products are of

exceptional quality and proven reliability.

The condensing range in particular, is extremely energy efficient, converting more of

the fuel consumed into heat offering you economical running costs and value for

money. It sits in SEBUK band A, at the top of the energy rated appliances available.

There is also the assurance of our no-nonsense parts and labour guarantee -

backed up by an optional servicing and maintenance contract to keep your boiler

operating at peak condition and efficiency.

To find out more about Worcester, Bosch Group, use the 'Contact Information'

shown on the inside front cover.

GENERAL INFORMATION

Regularly check the pressure is maintained

and contact your installer or maintenance

engineer if there is a noticeable, permanent

drop in pressure. If the system loses

pressure it should be repressurised and the

cause of the loss investigated.

CONDENSATE:

This is a high efficiency appliance using

condensing technology which will under normal

operation produce a regular discharge of

condensate to drain and at times, give out a

plume of water vapour from the flue terminal.

ROOM THERMOSTAT:

A room thermostat must be fitted to control the

central heating. Refer to instructions supplied

with the room thermostat for information on

siting and setting.

THERMOSTATIC RADIATOR VALVES:

It is recommended that this type of valve is fitted

to all but one of the radiators (or at least those in

the sleeping accommodation). The remaining

radiator, which must be where the room

thermostat is located, should be un-controlled

and must be left open.

GENERAL INFORMATION GREENSTAR DANESMOOR WALL MOUNTED OIL 12/18 & 18/25

8 718 681 135a (08.08)

INTRODUCTION

Read these instructions carefully to get

the best from your appliance.

CENTRAL HEATING SYSTEMS:

During the first few hours of operation of

the central heating system, check that all

radiators are being heated at an even rate.

If the top of a radiator is at a lower

temperature than the bottom then it should

be vented by releasing air through the

venting screw at the top of the radiator. Ask

your installer to show you how this is done.

Repeated venting will reduce the quantity

of water in the system and this must be

replenished for safe and satisfactory

operation of the appliance.

Vented systems:

When excessive venting or water leaks are

found in the system you must contact a

service engineer to inspect the installation

and rectify any fault.

Only use additives compatible with the

appliance and system. Use of incompatible

additives can cause damage and will

invalidate the appliance guarantee.

Frost protection:

Use a suitable anti-freeze/inhibitor at the

correct strength to protect against freezing.

A frost thermostat should be fitted to the

system if the system is exposed to low

temperatures.

Sealed heating systems:

Where the appliance is fitted to a sealed

heating system a pressure gauge should

be fitted to the system close to the

appliance. Your installer will inform you of

the minimum and maximum pressure which

must be indicated on the pressure gauge.

CONTROLS

TO GAIN ACCESS TO THE BOILER

CONTROLS, PUSH AT THE TOP OF

THE FLAP AND RELEASE

PUSH

CONTROLS

GREENSTAR DANESMOOR WALL MOUNTED OIL 12/18 & 18/25

8 718 681 135a (08.08)

USING YOUR

APPLIANCE

1. POWER SWITCH

2. TEMPERATURE CONTROL

3. POWER INDICATOR

4. BURNER LOCKOUT INDICATOR

5. FLUE OVERHEAT RESET BUTTON

6. BOILER OVERHEAT RESET

BUTTON

7. BURNER LOCKOUT RESET

BUTTON

8. POSITION FOR OPTIONAL

PROGRAMMER

2 3

456

OPERATING THE BOILER

SWITCHING THE BOILER ON/OFF

Switching on



Switch on the boiler by pressing the

power button.

The indicator light shows blue

Switching off



Switch off the boiler by pressing the

power button

The blue indicator light goes out.

SETTING THE TEMPERATURE



Turn the temperature control to the

desired level, between 55°C and 81°C

CONTROLLING CENTRAL HEATING



Set the timer to the correct time.



Set room thermostat to the desired

room temperature.



Set the thermostatic radiator valves to

the desired settings.

FROST PROTECTION



Leave power button on.



Add a suitable anti-freeze fluid to the

water in the central heating system.



If remote pipework is likely to be

subjected to freezing conditions, ensure

that the installer has fitted a frost

thermostat in the area to protect the

pipework.

OPERATING THE BOILER GREENSTAR DANESMOOR WALL MOUNTED OIL 12/18 & 18/25

8 718 681 135a (08.08)

USING YOUR

APPLIANCE

FAULT CONDITIONS:

NORMAL OPERATION:

POWER INDICATOR (3) ON, (if there

is a central heating or hot water

demand there will be a light illuminated

on the programmer).

BURNER LOCKOUT:

LOCKOUT INDICATOR (4) ON

1. Check oil level in the oil storage tank.

2. Press button (7). Boiler should fire.

3. If no response, wait 2 minutes -

press reset button (7) again.

4. If lockout light stays on, do not

attempt further resets. Contact your

service engineer for advice.

OPERATING THE BOILER

GREENSTAR DANESMOOR WALL MOUNTED OIL 12/18 & 18/25

8 718 681 135a (08.08)

USING YOUR

APPLIANCE

2 3

456

OVERHEAT TRIPPED OUT:

POWER INDICATOR (3) ON,

LOCKOUT INDICATOR (4) OFF,

demand displayed on the programmer,

no heating/hot water.

1. Check the setting of the room

thermostat/tank thermostat.

2. Press the reset buttons (5 &6).

Boiler should fire.

3. If the boiler stays off, contact your

service engineer for advice.

POWER OFF:

POWER INDICATOR (3) OFF.

1. Ensure there is power supplied to the

boiler.

2. Check that the power switch (1) has

not been turned off.

3. If the power indicator (3) stays off,

contact your service engineer for

advice.

TIPS ON ENERGY SAVING GREENSTAR DANESMOOR WALL MOUNTED OIL 12/18 & 18/25

8 718 681 135a (08.08)

ENERGY

SAVING

TIPS ON ENERGY SAVING

Heating economically:

The boiler is designed to provide a high level of comfort while keeping oil

consumption and the resulting environmental effect as low as possible.

The temperature control on the boiler should be set as low as possible while still

maintaining a comfortable room temperature.

The temperature of each room can be set individually using the thermostatic radiator

valves (except the primary room with the room thermostat).

Roof insulation:

Around 30% of the heat loss from a property is through the roof. Replace any old

insulation with new insulation, preferably to a minimum thickness of 200mm.

Window frames:

Single glazed windows, particularly those with steel frames, can lose a great deal of

heat.

Consideration should be given to replacement with PVCu or wooden framed double

glazed units.

Curtains:

Lined curtains, or heavier full length curtains can provide excellent insulation.

However, always ensure that the curtains do not drape over radiators.

Draughts:

Try to ensure that draughts around doors, windows, letterboxes and keyholes etc.,

are reduced by using a suitable draught excluder.

Warning: do not block or seal any air vents that are installed to ensure the

central heating boiler (or other appliance) operate safely.

Room thermostats:

Reducing the setting of the room thermostat by 1°C can reduce fuel consumption

by up to 10%.

New control systems:

Upgrade your heating control system with the latest equipment available. The

minimum level of control for a heating system is a programmer/timer, interlocking

room thermostat and thermostatic radiator valves.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Bosch Kessel Handbücher

Bosch

Bosch GC 7000 WP Bedienungsanleitung

Bosch

Bosch TR4000 18 EB Bedienungsanleitung

Bosch

Bosch CONDENS 5000W Bedienungsanleitung

Bosch

Bosch WORCESTER benchmark Greenstar 24i Bedienungsanleitung

Bosch

Bosch Singular 4000 Bedienungsanleitung

Bosch

Bosch Condens 7000 F Bedienungsanleitung

Bosch

Bosch Tronic 4000 T Series Bedienungsanleitung

Bosch

Bosch WORCESTER Greenstar Heatslave II 12/18 Benutzerhandbuch

Bosch

Bosch Condens 2000 W Bedienungsanleitung

Bosch

Bosch Greenstar FS Series Bedienungsanleitung

Bosch

Bosch 47 311 67 Bedienungsanleitung

Bosch

Bosch WH17 Bedienungsanleitung

Bosch

Bosch WORCESTER GREENSTAR FS 30CDi REGULAR GC Bedienungsanleitung

Bosch

Bosch W 500-1000-5 Series Bedienungsanleitung

Bosch

Bosch SSB120 Betriebsanleitung

Bosch

Bosch W 120-5 P Series Bedienungsanleitung

Bosch

Bosch Tronic 2500 TO Bedienungsanleitung

Bosch

Bosch Worcester GREENSTAR HEATSLAVE EXTERNAL 12/18 Bedienungsanleitung

Bosch

Bosch ZSB18 - 2A Benutzerhandbuch

Bosch

Bosch Worcester Greenstar 350 Combi Betriebsanleitung

Bosch

Bosch Buderus SB625WS Bedienungsanleitung

Bosch

Bosch Tronic 1000 T Betriebsanleitung

Bosch

Bosch Greenstar combi 100 p Betriebsanleitung

Bosch

Bosch W 300-5 P Series Bedienungsanleitung

Beliebte Kessel Handbücher anderer Marken

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Bedienungsanleitung

Radijator

Radijator BIO max 23.1 Bedienungsanleitung

Brunner

Brunner BSV 20 Bedienungsanleitung

Buderus

Buderus Logamax GB062-24 KDE H V2 Bedienungsanleitung

Potterton

Potterton 50e Datenblatt

UTICA BOILERS

UTICA BOILERS TriFire Bedienungsanleitung

Joannes

Joannes LADY Series Handbuch

ECR International

ECR International UB90-125 Gebrauchsanweisung

Froling

Froling P4 Pellet 8 - 105 Bedienungsanleitung

Froling

Froling FHG Turbo 3000 Bedienungsanleitung

U.S. Boiler Company

U.S. Boiler Company K2 Bedienungsanleitung

Henrad

Henrad C95 FF Bedienungsanleitung

NeOvo

NeOvo EcoNox EF 36 Bedienungsanleitung

Potterton

Potterton PROMAX SL 12 Bedienungsanleitung

Eco Hometec

Eco Hometec EC 25 COMPACT Bedienungsanleitung

Viessmann

Viessmann VITODENS 200 Leitfaden

Baxi

Baxi Prime 1.24 Bedienungsanleitung

REXNOVA

REXNOVA ISA 20 BITHERMAL Bedienungsanleitung