Champion Power Equipment 100742 Bedienungsanleitung

OPERATOR'S MANUAL

MODEL #100742

2 IN. (5 CM) SEMI-TRASH PUMP

Made in China - REV 20200520 Champion Power Equipment, Inc., Santa Fe Springs, CA USA

or visit championpowerequipment.com

READ AND SAVE THIS MANUAL. This manual contains important safety precautions which should be read and understood before operating the product. Failure to

do so could result in serious injury. This manual should remain with the product.

Speciﬁcations, descriptions and illustrations in this manual are as accurate as known at the time of publication, but are subject to change without notice.

at championpowerequipment.com

100742 - 2 IN. (5 CM) SEMI-TRASH PUMP TABLE OF CONTENTS

TABLE OF CONTENTS

Introduction................................................... 3

Safety Deﬁnitions .......................................... 3

Important Safety Instructions....................... 4

Fuel Safety .........................................................6

Safety and Dataplate Labels.......................................7

Safety Symbols.....................................................8

Operation Symbols ............................................... 10

Quickstart Label Symbols........................................ 10

Controls and Features ................................. 11

Parts Included .................................................... 12

Assembly ..................................................... 13

Remove the Water Pump from the Shipping Carton ............ 13

Install Wheels and Support Legs ................................ 13

Add Engine Oil.................................................... 13

Add Fuel .......................................................... 14

Operation..................................................... 15

Water Pump Location ............................................ 15

Connecting a Hose Kit ........................................... 16

Priming the Pump ................................................ 20

Before Starting the Engine....................................... 21

Starting the Engine............................................... 21

Stopping the Engine.............................................. 22

Operation at High Altitude ....................................... 22

Maintenance ................................................ 23

Cleaning the Water Pump ........................................ 23

Changing the Engine Oil ......................................... 23

Cleaning and Adjusting the Spark Plug(s) ....................... 24

Cleaning the Air Filter ............................................ 24

Cleaning the Spark Arrestor ..................................... 24

Adjusting the Governor........................................... 25

Maintenance Schedule........................................... 25

Storage ........................................................ 25

Water Pump Storage ............................................. 25

Short Term Engine Storage (Up to 30 Days) .................... 25

Mid Term Engine Storage ( 30 Days – 1 year) .................. 25

Long Term Storage............................................... 26

Speciﬁcations.............................................. 27

Water Pump Speciﬁcations ...................................... 27

Engine Speciﬁcations ............................................ 27

Engine Oil Speciﬁcations......................................... 27

Fuel Speciﬁcations ............................................... 27

Spark Plug Speciﬁcations........................................ 27

Valve Speciﬁcations.............................................. 27

Important Message About Temperature......................... 27

Parts Diagram - Frame and Engine ............................. 28

Parts List ......................................................... 29

Engine Parts Diagram............................................ 31

Engine Parts List ................................................. 32

Troubleshooting........................................... 34

100742 - 2 IN. (5 CM) SEMI-TRASH PUMP INTRODUCTION

INTRODUCTION

Congratulations on your purchase of a Champion Power Equipment

(CPE) product. CPE designs, builds, and supports all of our

products to strict speciﬁcations and guidelines. With proper

product knowledge, safe use, and regular maintenance, this

product should bring years of satisfying service.

Every effort has been made to ensure the accuracy and

completeness of the information in this manual at the time of

publication, and we reserve the right to change, alter and/or

improve the product and this document at any time without prior

notice.

Since CPE highly values how our products are designed,

manufactured, operated and are serviced, and also highly value

your safety and the safety of others, we would like you to take the

time to review this product manual and other product materials

thoroughly and be fully aware and knowledgeable of the assembly,

operation, dangers and maintenance of the product before use.

Fully familiarize yourself, and make sure others who plan on

operating the product fully familiarize themselves too, with the

proper safety and operation procedures before each use. Please

always exercise common sense and always err on the side

of caution when operating the product to ensure no accident,

property damage, or injury occurs. We want you to continue to use

and be satisﬁed with your CPE product for years to come.

When contacting CPE about parts and/or service, you will need to

supply the complete model and serial numbers of your product.

Transcribe the information found on your product’s nameplate

label to the table below

CPE TECHNICAL SUPPORT TEAM

1-877-338-0999

MODEL NUMBER

100742

SERIAL NUMBER

DATE OF PURCHASE

PURCHASE LOCATION

SAFETY DEFINITIONS

The purpose of safety symbols is to attract your attention to

possible dangers. The safety symbols, and their explanations,

deserve your careful attention and understanding. The safety

warnings do not by themselves eliminate any danger.

The instructions or warnings they give are not substitutes for

proper accident prevention measures.

DANGER

DANGER indicates a hazardous situation which, if not avoided,

will result in death or serious injury.

WARNING

WARNING indicates a hazardous situation which, if not

avoided, could result in death or serious injury.

CAUTION

CAUTION indicates a hazardous situation which, if not avoided,

could result in minor or moderate injury.

NOTICE

NOTICE indicates information considered important, but not

hazard-related (e.g., messages relating to property damaged).

100742 - 2 IN. (5 CM) SEMI-TRASH PUMP IMPORTANT SAFETY INSTRUCTIONS

IMPORTANT SAFETY INSTRUCTIONS

WARNING

Cancer and Reproductive Harm – www.P65Warnings.ca.gov

DANGER

Water pump engine exhaust contains carbon monoxide,

a colorless, odorless, poison gas. Breathing carbon monoxide

will cause nausea, dizziness, fainting or death.

If you start to feel dizzy or weak, get to fresh air immediately.

OPERATE THE WATER PUMP OUTDOORS ONLY IN A WELL

VENTILATED AREA AND POINT EXHAUST AWAY.

DO NOT operate the water pump inside any building, including

garages, basements, crawlspaces and sheds, enclosure

or compartment, including the storage compartment of a

recreational vehicle.

DO NOT allow exhaust fumes to enter a conﬁned area through

windows, doors, vents or other openings.

DANGER

Using an engine indoors CAN KILL YOU IN MINUTES. Engine

exhaust contains carbon monoxide. This is a poison you cannot

see or smell.

NEVER use inside a home or garage, EVEN IF doors and

windows are open.

ONLY use OUTSIDE and far away from windows, doors,

and vents.

Install battery-operated carbon monoxide alarms or plug-in

carbon monoxide alarms with battery back-up according to the

manufacturer’s instructions.

DANGER

Rotating parts can entangle hands, feet, hair, clothing and/or

accessories. Traumatic amputation or severe laceration can

result.

Keep hands and feet away from rotating parts.

Tie up long hair and remove jewelry.

Operate equipment with guards in place.

DO NOT wear loose-ﬁtting clothing, dangling drawstrings or

items that could become caught.

WARNING

Spark from removed spark plug wire can result in ﬁre or

electrical shock.

When servicing the water pump:

Disconnect the spark plug wire and place it where it cannot

contact the plug or any other metal object.

DO NOT check for spark with the plug removed.

Use only approved spark plug testers.

WARNING

Contact with electrical power source can cause electric shock

or burn.

NEVER spray in the direction of or near a power source/

electrical outlet.

WARNING

Running engines produce heat. Severe burns can occur on

contact. Combustible material can catch ﬁre on contact.

DO NOT touch hot surfaces.

Avoid contact with hot exhaust gases.

Allow equipment to cool before touching.

Maintain at least 3 ft. (91.4 cm) of clearance on all sides to

ensure adequate cooling.

Maintain at least 5 ft. (1.5 m) of clearance from combustible

materials.

DANGER

DO NOT pump gasoline, fuel, fuel-oil mixtures, detergents,

acids, chemicals, beverages, pesticides, fertilizers or any other

ﬂammable liquid or corrosive.

100742 - 2 IN. (5 CM) SEMI-TRASH PUMP IMPORTANT SAFETY INSTRUCTIONS

WARNING

DO NOT immerse the water pump in water.

DANGER

The water pump develops powerful force.

DO NOT move the water pump when it is in use.

DO NOT use hoses or connectors that are worn, damaged or

frayed.

DO NOT allow children or unqualiﬁed persons to operate or

service the water pump.

DO NOT open top plug or drain plug.

WARNING

Rapid retraction of the starter cord will pull hand and arm

towards the engine faster than you can let go. Unintentional

startup can result in entanglement, traumatic amputation or

laceration. Broken bones, fractures, bruises or sprains could

result.

When starting engine, pull the starter cord slowly until

resistance is felt and then pull rapidly to avoid kickback.

WARNING

DO NOT pump salt, sludge, sewer, sea, or any other type of

water containing solid material.

CAUTION

Exceeding the pump speciﬁcation for total head can damage

the pump and/or hose kits connected to it.

DO NOT modify the pump in any way. DO NOT attempt to

exceed the rated ﬂow. Attempting to increase the rated ﬂow

may damage the unit and/or shorten its life.

NOTICE

DO NOT run the pump dry.

Running the pump dry can destroy the pump seals and will

void the warranty. If the pump was running while dry, stop

the engine and allow it to cool thoroughly before ﬁlling the

chamber with water.

CAUTION

Improper treatment or use of the water pump can damage it,

shorten its life and void your warranty.

Use the water pump only for intended uses.

Operate only on level surfaces.

DO NOT expose water pump to excessive moisture, dust,

or dirt.

DO NOT allow any material to block the cooling slots.

DO NOT use the engine if:

–Equipment sparks, smokes or emits ﬂames

–Equipment vibrates excessively

WARNING

Use of this water pump can create wet, slippery walking

surfaces.

–Use only on a level surface.

–Make sure there is proper drainage to dissipate water.

100742 - 2 IN. (5 CM) SEMI-TRASH PUMP IMPORTANT SAFETY INSTRUCTIONS

Fuel Safety

DANGER

GASOLINE AND GASOLINE VAPORS ARE HIGHLY

FLAMMABLE AND EXPLOSIVE.

Fire or explosion can cause severe burns or death.

Gasoline and gasoline vapors:

–Gasoline is highly ﬂammable and explosive.

–Gasoline can cause a ﬁre or explosion if ignited.

–Gasoline is a liquid fuel but its vapors can ignite.

–Gasoline is a skin irritant and needs to be cleaned up

immediately if spilled on skin or clothes.

–Gasoline has a distinctive odor, this will help detect potential

leaks quickly.

–In any petroleum gas ﬁre, ﬂames should not be extinguished

unless by doing so the fuel supply valve can be turned OFF.

This is because if a ﬁre is extinguished and a supply of fuel is

not turned OFF, then an explosion hazard could be created.

–Gasoline expands or contracts with ambient temperatures.

Never ﬁll the gasoline tank to full capacity, as gasoline needs

room to expand if temperatures rise.

When adding or removing gasoline:

DO NOT light or smoke cigarettes.

Turn the engine off and let it cool for at least two minutes before

removing the gasoline cap. Loosen the cap slowly to relieve

pressure in the tank.

Only ﬁll or drain gasoline outdoors in a well-ventilated area.

DO NOT pump gasoline directly into the engine at the gas station.

Use an approved container to transfer the fuel to the engine.

DO NOT overﬁll the gasoline tank.

Always keep gasoline away from sparks, open ﬂames, pilot lights,

heat and other sources of ignition.

When starting the engine:

DO NOT attempt to start a damaged engine.

Make certain that the gasoline cap, air ﬁlter, spark plug, fuel lines

and exhaust system are properly in place.

Allow spilled gasoline to evaporate fully before attempting to start

the engine.

Make certain that the water pump is resting ﬁrmly on level ground.

When operating the water pump:

DO NOT move or tip the water pump during operation.

DO NOT tip the water pump or allow fuel or oil to spill.

When transporting or servicing the water pump:

Make certain that the fuel valve is in the OFF position, the gasoline

tank is empty.

Disconnect the spark plug wire.

When storing the water pump:

Store away from sparks, open ﬂames, pilot lights, heat and other

sources of ignition.

Do not store water pump or gasoline near furnaces, water heaters,

or any other appliances that produce heat or have automatic

ignitions.

WARNING

NEVER use a gasoline container, gasoline tank, or any other

fuel item that is broken, cut, torn or damaged.

100742 - 2 IN. (5 CM) SEMI-TRASH PUMP IMPORTANT SAFETY INSTRUCTIONS

Side Side

Safety and Dataplate Labels

These labels warn you of potential hazards that can cause serious injury. Read them carefully.

If a label comes off or becomes hard to read, contact Technical Support Team for possible replacement.

LABEL DESCRIPTION

2012-L-OP-a

DaNGER PELIGRO DaNGER

2012-L-OP-a

K109 485 --- ---

ColorsLPN 2012-L-OP

Rev A

Size Spec’d by CPEC

Artwork Notes

2mm safe margin;

to be pr inted on w hite substrate

Revision Changes

---

This ar twork belongs to Champion Power Equipment. The contents are conﬁdential and privileged and shall not be disclosed to or used by or for

outside parties without the explicit consent of Champion Power Equipment.

Safety Symbols/

CO Danger

UNLEADED FUEL ONLY. Minimum octane

rating of 87. Maximum 10% ethanol.

GASOLINA REGULAR SOLAMENTE.

87 octanos como mínimo. Máximo de

etanol de 10%.

ESSENCE SANS PLOMB

SEULEMENT. Indice d’octane

minimal de 87. Maximum

10 % d'éthanol.

2011-L-OP-a

K376 --- --- ---

ColorsLPN 2011- L- OP

Rev A

Size 38 x 3 8 mm

Artwork Notes

2mm safe margin;

to be pr inted on white su bstrate

Revision Changes

---

This ar twork belongs to Champion Power Equipment. The contents are conﬁdential and privileged and shall not be disclosed to or used by or for

outside parties without the explicit consent of Champion Power Equipment.

Fuel

WaRNING

DO NOT TOUCH!

Exhaust gases, mufﬂer

and engine components

are extremely HOT and

cause burns.

Operation of this equipment may create sparks that can start

ﬁres around dry vegetation. A spark arrestor may be

required. The operator should contact local ﬁre agencies for

laws and regulations relating to ﬁre p revention requirements.

If installed, clean every 100 hour s or every season.

aDVERTENCIa

¡NO TOCAR! Los gases de

escape, el silenciador y los

compnonentes del motor están

extremadamente CALIEN TES y

causan quemaduras.

La operación de este equipo puede p roducir chispas que pueden provocar

incendios alrededor de la vegetación seca. Un supresor de chispas puede que

sea necesario. El operador debe comunicarse con las agencias locales de

bomberos para las leyes y reglamentos relativos a los requisitos deprevención

de incendios . Si está instalado, limp ie cada 100 horas o cada tem porada.

aVERTISSEmENT

NE PAS TOUCHER! Les gaz

d’échappement, le silencieux

et les pièces du moteur sont

extrêmeme nt CHAUDS et

peuvent causer des brûlures.

Cet équipem ent peut créer des étince lles et provoquer un incend ie dans la

végétation sèche. Un pare-ét incelles peut être requis. L’utilisateur doit

communiquer avec le service d’incendie local pour connaître les lois et

les règlements en matière de prévention des incendies. Si elle est

installée, nettoyez la génératrice toutes les 100 heures ou chaque saison.

1035-L-SF-C

ColorsLPN 1035-L-SF

Rev C

Size 369 x 2 6 mm

Artwork Notes

3mm corner radius; 2mm safe margin

Revision Changes

C: updated some FR translation words.

This artw ork belongs to Champio n Power Equipment. Th e contents are conﬁ dential and privileg ed and shall not be disclo sed to or used by or for

outside par ties without th e explicit consent o f Champion Power Equip ment.

K485 152 --- ---

Hot Surface

CHAMPION POWER EQUIPMENT, INC.

12039 SMITH AVENUE

SANTA FE SPRINGS, CA 90670

USA / É.-U.

1-877-338-0999

WWW.CHAMPIONPOWEREQUIPMENT.COM

MADE IN CHINA / FABRIQUÉ EN CHINE

MODEL

MODÈLE

MANUFACTURE DATE

DATE DE FABRICATION

FLOW (GPM / LPM)

DÉBIT (GPM / LPM)

INLET DIAMETER

DIAMÈTRE D'ENTRÉE

2172-L-PR-a

100742 158 / 598

2 IN.

5 CM

SERIAL NO. / N° DE SÉRIE

XXXX XXXXXXXXXXXX

K--- --- --- ---

ColorsLPN 2172-L-PR

Rev A

Size 123 x 40 mm

Artwork Notes

3mm corner radius; 2mm safe margin

Revision Changes

---

This ar twork belongs to Champion Power Equipment. The contents are conﬁdential and privileged and shall not be disclosed to or used by or for

outside parties without the explicit consent of Champion Power Equipment.

Dataplate

100742 - 2 IN. (5 CM) SEMI-TRASH PUMP IMPORTANT SAFETY INSTRUCTIONS

Safety Symbols

Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these

symbols will allow you to more safely operate the product.

SYMBOL MEANING

Read Operator’s Manual. To reduce the risk of injury, user must read and understand operator’s

manual before using this product.

Eye and Ear Protection. Always wear safety goggles or safety glasses with side shields, and as

necessary a full face-shield as well as full ear protection when operating this product.

Footwear. Always wear safety shoes or heavy boots when operating the machine.

Gloves. Always wear nonslip, heavy-duty protective gloves when operating this product.

Safety Alert. Precautions that involve your safety.

Risk of Fire. Fuel and its vapors are extremely ﬂammable and explosive. Fire can cause severe

burns or death. Do not add fuel while the product is operating or still hot.

Hot Surface. To reduce the risk of injury or damage, avoid contact with any hot surface

Open Flame alert. Fuel and its vapors are extremely flammable and explosive. Keep fuel away

from smoking, open flames, sparks, pilot lights, heat, and other ignition sources.

100742 - 2 IN. (5 CM) SEMI-TRASH PUMP IMPORTANT SAFETY INSTRUCTIONS

SYMBOL MEANING

Toxic Fumes. The engine exhaust from this product contains chemicals known to the state of

California to cause cancer and birth defects and other reproductive harm.

Risk of Asphyxiation. This engine emits carbon monoxide, an odorless, colorless poison gas.

Breathing carbon monoxide can cause nausea, fainting or death. Use only in a well ventilated

area.

Clearance. Keep all objects including others at least 10 feet (3m) from this machine.

Only one person should operate the water pump and load the logs

100742 - 2 IN. (5 CM) SEMI-TRASH PUMP IMPORTANT SAFETY INSTRUCTIONS

Operation Symbols

Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these

symbols will allow you to more safely operate the product.

Quickstart Label Symbols

Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these

symbols will allow you to more safely operate the product.

Starting the Engine

DANGER

Move water pump outside and far away from windows,

doors and intake ventilation covers.

1. Check oil level. Recommended oil is 10W-30.

2. Check fuel level.

3. Connect inlet and outlet hoses

4. Connect inlet ﬁlter

5. Prime the water pump

6. Move the fuel valve to the “ON” position.

7. Move the choke lever to the “CHOKE” position by pulling out.

8. Move throttle to “FAST” position.

9. Press engine switch to “ON” position.

SYMBOL MEANING

Choke. Pull choke knob to “CHOKE”

position.

Run. Push choke knob to “RUN”

position.

Fuel/Gasoline Valve On/Off

Fuel Gauge: Full

Fuel Gauge: Empty

SYMBOL MEANING

Stop or Off

Throttle Lever - Fast

Throttle Lever - Slow

10. Pull the starter cord slowly until resistance is felt and then

pull rapidly.

11. As engine warms up, move the choke to “RUN” by pushing in

and adjust the throttle as needed

Stopping

1. Move the fuel valve to the “OFF” position.

2. Press the engine switch to the “OFF” position.

3. Disconnect inlet and outlet hoses for storage.

4. Remove drain plug (bottom) before storage.

2174-L-OP-a

10W-30



6 73 54

1 42 3119 10

K376 485 152 300 186CG1CG7

ColorsLPN 2174 -L-OP

Rev A

Size Spec’d by CPEC

Artwork Notes

3mm corner radius; 2mm safe margin; to be printed

on white substrate.

Revision Changes

---

This ar twork belongs to Champion Power Equipment. The contents are conﬁdential and privileged and shall not be disclosed to or used by or for

outside parties without the explicit consent of Champion Power Equipment.

Inhaltsverzeichnis

Andere Champion Power Equipment Wasserpumpe Handbücher

Champion Power Equipment

Champion Power Equipment 66520 Bedienungsanleitung

Champion Power Equipment

Champion Power Equipment 66520 Bedienungsanleitung

Champion Power Equipment

Champion Power Equipment 66526 Systemhandbuch

Champion Power Equipment

Champion Power Equipment C40940 Bedienungsanleitung

Champion Power Equipment

Champion Power Equipment C44025 Handbuch

Champion Power Equipment

Champion Power Equipment C44020 Handbuch

Champion Power Equipment

Champion Power Equipment 100113 Bedienungsanleitung

Champion Power Equipment

Champion Power Equipment 100166 Bedienungsanleitung

Beliebte Wasserpumpe Handbücher anderer Marken

Neptun

Neptun NPHW 5500 Bedienungsanleitung

Sensidyne

Sensidyne Gilian BDX-II Montage- und Bedienungsanleitung

Draper

Draper 47808 Bedienungsanleitung

Trolla

Trolla 12820 Bedienungsanleitung

Sunfab

Sunfab SVH Series Bedienungsanleitung

WilTec

WilTec 50740 Bedienungsanleitung

Fieldmann

Fieldmann FVC 5015 EK Bedienungsanleitung

Everbilt

Everbilt EFSUB5-122HD Bedienungsanleitung

Graco

Graco Husky 3300e Bedienungsanleitung

esotec

esotec 101018 Bedienungsanleitung

Becker

Becker BASIC VASF 2.80/1-0.AC230 Bedienungsanleitung

Sykes AmeriPumps

Sykes AmeriPumps GP100M Fehlerbehebungshandbuch

DUROMAX

DUROMAX XP WX Series Bedienungsanleitung

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Bedienungsanleitung

Franklin Electric

Franklin Electric IPS Bedienungsanleitung

Xylem

Xylem e-1532 Series Bedienungsanleitung

Milton Roy

Milton Roy PRIMEROYAL Bedienungsanleitung

STA-RITE

STA-RITE ST33APP Bedienungsanleitung