COBHAM SAILOR XTR Ku Bedienungsanleitung

SAILOR XTR Ku

Installation manual

98-175665-C i

SAILOR XTR Ku

Quick guide

Installation wizard

This quick guide is for experienced service personnel who have installed the SAILOR XTR Ku system

before. It lists the minimum configuration tasks you have to make before the system can be used on-air

on a satellite.

1. Connect a PC to the front LAN connector of the Below Deck Unit (BDU).

2. Open an Internet Browser and type the default IP address of the SAILOR XTR Ku: https://192.168.0.1.

3. Bypass the admin password by pressing the left arrow key on the BDU for 5 seconds.

4. After opening the web interface for the first time after power up you can step through the installation

wizard.

5. Enter the necessary data on each page and click Next.

6. On the last screen click Finish to activate the VSAT profile.

For more detailed information about the setup tasks see chapter 4, Setup of the antenna.

SAILOR XTR Ku

Installation manual

Document number: 98-175665-C

Release date: 2 March 2022

98-175665-C iii

Disclaimer

Any responsibility or liability for loss or damage in connection with the use of this product and the

accompanying documentation is disclaimed by Thrane & Thrane A/S. The information in this manual is

provided for information purposes only, is subject to change without notice and may contain errors or

inaccuracies. Manuals issued by Thrane & Thrane A/S are periodically revised and updated. Anyone

relying on this information should acquire the most current version e.g. from www.cobhamsatcom.com,

Cobham SYNC Partner Portal, or from the distributor.Thrane & Thrane A/S is not responsible for the

content or accuracy of any translations or reproductions, in whole or in part, of this manual from any

other source. In the event of any discrepancies, the English version shall be the governing text.

Thrane & Thrane A/S is trading as Cobham SATCOM.

Company address

Thrane & Thrane A/S, Lundtoftegårdsvej 93D, DK-2800, Kgs. Lyngby, Denmark

Trademark acknowledgements

• Some product and company names mentioned in this manual may be trademarks or trade names of

their respective owners.

Disposal

Old electrical and electronic equipment marked with this symbol can contain substances

hazardous to human beings and the environment. Never dispose these items together with

unsorted municipal waste (household waste). In order to protect the environment and

ensure the correct recycling of old equipment as well as the re-utilization of individual

components, use either public collection or private collection by the local distributor of old

electrical and electronic equipment marked with this symbol.

Contact the local distributor for information about what type of return system to use.

GPL notification

The software included in this product contains copyrighted software that is licensed under the GPL/LGPL.

The verbatim licenses can be found online at:

http://www.gnu.org/licenses/old-licenses/gpl-2.0.html

http://www.gnu.org/licenses/old-licenses/lgpl-2.1.html

For the parts of our software that fall under the GPL/LGPL licenses, you may obtain the complete

corresponding source code from us for a period of three years after our last shipment of this product,

which will be no earlier than 2027, by sending a money order or check for DKK 50 to:

SW Technology/GPL Compliance,

Cobham SATCOM (Thrane & Thrane A/S),

Lundtoftegaardsvej 93D

2800 Lyngby

DENMARK

Write "source for product SAILOR XTR Ku" in the memo line of your payment. This offer is valid to anyone

in receipt of this information.

https://www.cobhamsatcom.com/legal/free-and-open-source-software-foss/

98-175665-C iv

Safety summary

The following general safety precautions must be observed during all phases of operation,

service and repair of this equipment. Failure to comply with these precautions or with specific

warnings elsewhere in this manual violates safety standards of design, manufacture and

intended use of the equipment. Thrane & Thrane A/S assumes no liability for the customer's

failure to comply with these requirements.

Microwave radiation hazards

During transmission the Above Deck Unit (antenna) in this system radiates Microwave

Power.This radiation may be hazardous to humans close to the Above Deck Unit. During

transmission, make sure that nobody gets closer than the recommended minimum safety

distance.

SAILOR 1000 XTR Ku

The minimum safety distance to the

Above Deck Unit reflector on the focal

line is 30 m for SAILOR 1000 XTR Ku 8W

and 47 m for SAILOR 1000 XTR Ku 16W,

based on a radiation level of 10 W/m2.

No hazard exists >20° below the Above

Deck Unit’s mounting plane. Refer to the

drawing below

MICROWAVE RADIATION

No personnel within safety distance

20°

98-175665-C v

SAILOR 800 XTR Ku

The minimum safety distance to the

Above Deck Unit reflector on the focal

line is 24 m for SAILOR 800 XTR Ku 8W

and 47 m for SAILOR 800 XTR Ku 16W,

based on a radiation level of 10 W/m2.

No hazard exists >20° below the Above

Deck Unit’s mounting plane. Refer to the drawing below.

2°

MICROWAVE RADIATION

No personnel within safety distance

98-175665-C vi

SAILOR 600 XTR Ku

The minimum safety distance to the Above Deck Unit reflector

on the focal line is 17 m, based on a radiation level of 10 W/m2.

No hazard exists >20° below the Above Deck Unit’s mounting

plane. Refer to the drawing below.

No-transmit zones

In order to protect personnel no-transmit zones can be programmed. For further information

see Blocking zones – azimuth and elevation on page 2-5.

Distance to other equipment

Do not move the Above Deck Unit closer to radars than the minimum safe distance specified in

section Interference from radar, GPS/GNSS, L-band and other transmitters on page 2-17 — it

may cause damage to the Above Deck Unit.

Compass Safe Distance:

SAILOR 1000 XTR Ku 8W and SAILOR 1000 XTR Ku 16W antenna or ADU (Above Deck Unit):

min. 170 cm (IEC 60945).

SAILOR 800 XTR Ku 8W and SAILOR 800 XTR Ku 16W antenna or ADU (Above Deck Unit): min.

100 cm (IEC 60945).

SAILOR 600 XTR Ku 6 W antenna or ADU (Above Deck Unit): min. 100 cm (IEC 60945).

SAILOR 7516A BDU (Below Deck Unit): min. 30 cm (IEC 60945)

Service

User access to the interior of the BDU is prohibited. Only a technician authorized by Cobham

SATCOM may perform service - failure to comply with this rule will void the warranty. Access to

the interior of the Above Deck Unit is allowed. Replacement of certain modules and general

service may only be performed by a technician authorized by Cobham SATCOM.

Grounding, cables and connections

To minimize shock hazard and to protect against lightning, the equipment chassis and cabinet

MICROWAVE RADIATION

No personnel within safety distance

20°

98-175665-C vii

must be connected to an electrical ground. The BDU must be grounded to the ship. For further

grounding information see the respective sections and appendix in this manual.

Do not extend the cables beyond the lengths specified for the equipment. The cable between

the BDU and Above Deck Unit can be extended if it complies with the specified data

concerning cable losses etc.

Rx and Tx cables for the system are shielded and should not be affected by magnetic fields.

However, try to avoid running cables parallel to high power and AC/RF wiring as it might cause

malfunction of the equipment.

Power supply

SAILOR 7516A BDU: Voltage range 100-240 VAC. The ADU is powered by the BDU.

Do not operate in an explosive atmosphere

Do not operate the equipment in the presence of flammable gases or fumes. Operation of any

electrical equipment in such an environment constitutes a definite safety hazard.

Keep away from live circuits

Operating personnel must not remove equipment covers. Component replacement and internal

adjustment must be made by qualified maintenance personnel. Do not replace components

with the power cable connected. Under certain conditions, dangerous voltages may exist even

with the power cable removed. To avoid injuries, always disconnect power and discharge

circuits before touching them.

Failure to comply with the rules above will void the warranty!

98-175665-C viii

VSAT restrictions

Modification restrictions

This device is granted pursuant to the Japanese Radio Law ( 電波法 ).

This device should not be modified (otherwise the granted designation number will become invalid).

Note

There are restrictions in use of the frequency band 13.75 to 14 GHz in the

following countries. Other countries may have restrictions, consult your airtime

provider or relevant authorities for information.

•Belgium

•Hungary

•Latvia

•Malta

•Portugal

•Slovakia

Contact the VSAT modem provider for local setup.

98-175665-C ix

About this manual

Intended readers

This is an installation manual for the SAILOR XTR Ku system (100 cm and 60 cm) intended for installers of

the system and service personnel. Personnel installing or servicing the system must be properly trained

and authorized by Cobham SATCOM. It is important that you observe all safety requirements listed in the

beginning of this manual, and install the system according to the guidelines in this manual.

SAILOR XTR Ku variants in this manual

The following variants of the SAILOR XTR Ku system are described in this manual:

• SAILOR 1000 XTR Ku 8W BUC

• SAILOR 1000 XTR Ku 16W BUC

•SAILOR800XTRKu8WBUC

•SAILOR800XTRKu16WBUC

• SAILOR 600 XTR Ku 6W BUC

Manual overview

This manual has the following chapters:

•Introduction

•Installation

•Interfaces

•Setup of the antenna

•Installation check lists

•Service

This manual has the following appendices:

•Technical specifications

•Dual antenna solution

•VSAT modem settings

•Command line interface

•DVB-S satellites

•Grounding and RF protection

•Event messages

•Approvals

Software version

The manual covers the software version 3.03.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere COBHAM Antenne Handbücher

COBHAM

COBHAM Sea Tel 9711-56 IMA C Band Bedienungsanleitung

COBHAM

COBHAM EXPLORER 6075LX Leitfaden

COBHAM

COBHAM SAILOR 900 Ka Bedienungsanleitung

COBHAM

COBHAM SAILOR 1000 XTR Ku 8W Bedienungs- und Sicherheitshinweise

COBHAM

COBHAM SAILOR 1000 XTR Ku 8W Gebrauchs- und Pflegehandbuch

COBHAM

COBHAM Saailor Fleet One Bedienungsanleitung

COBHAM

COBHAM Sea Tel 6011-4 Bedienungsanleitung

COBHAM

COBHAM Sea Tel Bedienungsanleitung

COBHAM

COBHAM SAILOR 1000 XTR Ku 8W Bedienungsanleitung

COBHAM

COBHAM Sailor 150 FleetBroadband Bedienungsanleitung

COBHAM

COBHAM SAILOR 60 GX-R2 4.5 W Bedienungsanleitung

COBHAM

COBHAM SAILOR 600 VSAT Ka Bedienungsanleitung

COBHAM

COBHAM SAILOR 100 GX Bedienungsanleitung

COBHAM

COBHAM SAILOR 60 GX Bedienungsanleitung

COBHAM

COBHAM SAILOR 1000 XTR Ku 8W Gebrauchs- und Pflegehandbuch

COBHAM

COBHAM SAILOR 800 VSAT Gebrauchs- und Pflegehandbuch

COBHAM

COBHAM EXPLORER 8100 Leitfaden

COBHAM

COBHAM SAILOR XTR GX-R2 Bedienungsanleitung

COBHAM

COBHAM Sea Tel Bedienungsanleitung

COBHAM

COBHAM SEA TEL 9711IMA-70 Bedienungsanleitung

COBHAM

COBHAM EXPLORER 5075GX Bedienungsanleitung

COBHAM

COBHAM SAILOR 600 Viasat Ka Bedienungsanleitung

COBHAM

COBHAM Sailor 150 FleetBroadband Bedienungsanleitung

COBHAM

COBHAM Sailor 900 VSAT Bedienungsanleitung

Beliebte Antenne Handbücher anderer Marken

Alfa Network

Alfa Network APA-L01 Bedienungsanleitung

Naval

Naval PR-422CA Bedienungsanleitung

Feig Electronic

Feig Electronic ID ISC.ANTH200/200 Series Bedienungsanleitung

TERK Technologies

TERK Technologies TV44 Bedienungsanleitung

Directive Systems & Engineering

Directive Systems & Engineering DSE2324LYRMK Bedienungsanleitung

HP J8999A Bedienungsanleitung

MobilSat

MobilSat MSP-S Bedienungsanleitung

Steren

Steren ANT-UHF 13 Bedienungsanleitung

Novatel

Novatel 600-G Bedienungsanleitung

Radio Shack

Radio Shack Amplified VHF/UHF/FM Indoor Antenna Bedienungsanleitung

TRENDnet

TRENDnet TEW-AO12O Bedienungsanleitung

Radio Shack

Radio Shack 15-1837 Bedienungsanleitung

CommScope

CommScope CMAX-OMFX-43M-I53 Bedienungsanleitung

Ramsey Electronics

Ramsey Electronics DAP25 Bedienungsanleitung

Trango Systems

Trango Systems AD900-9 Bedienungsanleitung

Steren

Steren ANT-100 Bedienungsanleitung

Proxim

Proxim 5054-PA-23 Bedienungsanleitung

IWCS

IWCS iriBelt II Einrichtungshandbuch