COBHAM SAILOR 600 Viasat Ka Bedienungsanleitung

Cobham Public

SAILOR 600 Viasat Ka

Installation and operation manual

SAILOR 600 Viasat Ka

Quick guide

Configuration tasks (minimum)

This quick guide aims at experienced service personnel who have installed the SAILOR 600 Viasat Ka system

and connected power. It lists the minimum configuration tasks you have to make before the system can be

used on-air on a satellite.

1. Switch on the pTRIA Interface Unit.

2. Switch on the Antenna Control Unit.

3. Connect a PC to the LAN2 connector at the rear of the pTRIA Interface Unit.

4. Open Mozilla Internet browser to access the web interface of the SAILOR 600 Viasat Ka using the IP

address: https://192.168.100.1.

5. On the navigation bar, click Antenna to access the web interface of the antenna and proceed with tasks in

the table below.

6. The system goes automatically into tracking mode. It is preconfigured from the factory with a modem

profile and a satellite profile.

7. Verify that the SAILOR 600 Viasat Ka acquires the satellite. Check that the ACU display shows

ACQUISITION.

8. Verify that the system is operational. Check that the status in the ACU display shows TRACKING.

98-166784-A

Configuration

task What to do and where to find more information

Heading input Configure the heading input to External under SETTINGS > Navigation. For more

information see Select the desired heading input, see the following table. on page 6-8.

Connect the ship’s heading (NMEA0183, RS-422/RS-232) to the NMEA 0183 multi-

connector. For more information see NET-H (NMEA 0183 connector, for future use) on

page 4-2.

Azimuth

calibration

Make an azimuth calibration under SERVICE > Calibration to ensure that the antenna

can point and receive a signal from the satellite. For more information see Calibration on

page 6-10.

SAILOR 600 Viasat Ka

Installation and operation manual

Document number: 98-166784-A

Release date: 8 November 2019

ii 98-166784-A

Disclaimer

Any responsibility or liability for loss or damage in connection with the use of this product and the

accompanying documentation is disclaimed by Thrane & Thrane A/S. The information in this manual is

provided for information purposes only, is subject to change without notice and may contain errors or

inaccuracies. Manuals issued by Thrane & Thrane A/S are periodically revised and updated. Anyone

relying on this information should acquire the most current version e.g. from www.cobham.com/satcom,

Cobham SYNC Partner Portal, or from the distributor.Thrane & Thrane A/S is not responsible for the

content or accuracy of any translations or reproductions, in whole or in part, of this manual from any

other source. In the event of any discrepancies, the English version shall be the governing text.

Thrane & Thrane A/S is trading as Cobham SATCOM.

Manufacturer address

Thrane & Thrane A/S, Lundtoftegaardsvej 93 D, DK-2800, Kgs. Lyngby, Denmark

Trademark acknowledgements

• Some product and company names mentioned in this manual may be trademarks or trade names of

their respective owners.

GPL notification

The software included in this product contains copyrighted software that is licensed under the GPL/LGPL.

The verbatim licenses can be found online at:

http://www.gnu.org/licenses/old-licenses/gpl-2.0.html

http://www.gnu.org/licenses/old-licenses/lgpl-2.1.html

You may obtain the complete corresponding source code from us for a period of three years after our last

shipment of this product, which will be no earlier than 2021, by sending a money order or check for DKK

50 to:

SW Technology/GPL Compliance,

Cobham SATCOM (Thrane & Thrane A/S),

Lundtoftegaardsvej 93D

2800 Lyngby

DENMARK

Write "source for product SAILOR 600 Viasat Ka" in the memo line of your payment. This offer is valid to

anyone in receipt of this information.

http://www.cobham.com/communications-and-connectivity/satcom/free-and-open-source-software-

foss/

98-166784-A iii

Safety summary

The following general safety precautions must be observed during all phases of operation,

service and repair of this equipment. Failure to comply with these precautions or with specific

warnings elsewhere in this manual violates safety standards of design, manufacture and

intended use of the equipment. Thrane & Thrane A/S assumes no liability for the customer's

failure to comply with these requirements.

Microwave radiation hazards

During operation the Above Deck Unit (antenna) in this

system radiates Microwave Power.This radiation may be

hazardous to humans close to the Above Deck Unit. Make

sure to turn off the power to the ADU before removing the

radome and working on the antenna.

Distance to other equipment

Do not move the Above Deck Unit closer to radars than the

minimum safe distance specified in section Interference from radar, GPS, L-band and other

transmitters on page 3-12 – it may cause damage to the Above Deck Unit.

Compass Safe Distance:

SAILOR 600 Viasat Ka and Antenna (ADU): min. 140 cm (IEC 60945).

SAILOR 7016C Antenna Control Unit (ACU): min. 30 cm (IEC 60945).SAILOR 7024A pTRIA

Interface Unit (PIU): min. 40 cm (IEC 60945).

Service

User access to the interior of the ACU or the PIU is not allowed. Only a technician authorized by

Cobham SATCOM may perform service - failure to comply with this rule will void the warranty.

Access to the interior of the Above Deck Unit is allowed. Replacement of certain modules and

general service may only be performed by a technician authorized by Cobham SATCOM.

Grounding, cables and connections

To minimize shock hazard and to protect against lightning, you must connect the equipment

chassis and cabinet to an electrical ground. Ground the ACU and the PIU to the ship. For further

details see Appendix B, Ground and RF protection.

Do not extend the cables beyond the lengths specified for the equipment. The cable between

the PIU and Above Deck Unit can be extended if it complies with the specified data concerning

cable losses etc.

Antenna cables for the SAILOR 600 Viasat Ka system are shielded and should not be affected

by magnetic fields. However, try to avoid running cables parallel to high power and AC/RF

wiring as this might cause malfunction of the equipment.

Power supply

SAILOR 7016C Antenna Control Unit: voltage range 100-240 VAC.

The ACU provides power for the Above Deck Unit and the pTRIA Interface Unit.

Do not operate in an explosive atmosphere

Do not operate the equipment in the presence of flammable gases or fumes. Operation of any

electrical equipment in such an environment constitutes a definite safety hazard.

iv 98-166784-A

Keep away from live circuits

Operating personnel must not remove equipment covers. Component replacement and internal

adjustment must be made by qualified maintenance personnel. Do not replace components

with the power cable connected. Under certain conditions, dangerous voltages may exist even

with the power cable removed. To avoid injuries, always disconnect power and discharge

circuits before touching them.

Failure to comply with the rules above will void the warranty!

After installation make this manual available to the user for further reference.

98-166784-A v

Record of Revisions

Rev. Description Release Date Initials

A Original document November 2019 UFO

vi 98-166784-A

98-166784-A xiii

Table of contents

Chapter 1 About this manual

1.1 Intended readers ..............................................................................................................1-1

1.2 Manual overview ...............................................................................................................1-1

1.3 Software version ...............................................................................................................1-1

1.4 Typography ...........................................................................................................................1-2

1.5 Precautions ............................................................................................................................1-2

Chapter 2 Introduction

2.1 SAILOR 600 Viasat Ka system ................................................................................2-1

2.2 Part numbers and options .........................................................................................2-8

Chapter 3 Installation

3.1 What’s in the box .............................................................................................................3-1

3.2 Site preparation .................................................................................................................3-3

3.3 Installation of the ADU ............................................................................................3-16

3.4 Installation of the ACU ............................................................................................3-22

3.5 Installation of the PIU ............................................................................................3-23

3.6 To connect the ADU, ACU and PIU ................................................................3-24

Chapter 4 Interfaces

4.1 Interfaces of the ACU ..................................................................................................4-1

4.2 Interfaces of the PIU ....................................................................................................4-5

Chapter 5 Power and start up

5.1 Power-up procedure .......................................................................................................5-1

Chapter 6 Configuration

6.1 Introduction to the built-in web interface ..................................................6-1

6.2 Heading input and position system ...................................................................6-8

6.3 Calibration ..........................................................................................................................6-10

6.4 Configuration with the web interface ...........................................................6-12

6.5 Satellite/modem profiles and blocking zones .........................................6-16

6.6 Keypad and menus of the ACU ..........................................................................6-23

Chapter 7 Installation check

7.1 Installation check list: Antenna ............................................................................7-2

Table of contents

xiv 98-166784-A

7.2 Installation check list: ACU and PIU, connectors and wiring .......7-3

7.3 Installation check list: Functional test in harbor ....................................7-4

Chapter 8 Service

8.1 To get support ....................................................................................................................8-2

8.2 Software update ................................................................................................................8-8

8.3 Status signalling with LEDs and status messages ................................8-11

8.4 Removal and replacement of the ACU .........................................................8-12

8.5 Removal and replacement of ADU modules ............................................8-13

8.6 Troubleshooting basics .............................................................................................8-15

8.7 To return units for repair ........................................................................................8-15

Appendix A Technical specifications

A.1 SAILOR 600 Viasat Ka system components ................................................A-1

A.2 Outline drawings ...............................................................................................................A-4

Appendix B Ground and RF protection

B.1 Why is a ground connection required? ............................................................B-1

B.2 Recommendations ...........................................................................................................B-2

B.3 Alternative ground for steel hulls ........................................................................B-4

B.4 Alternative ground for aluminum hulls ...........................................................B-6

B.5 Alternative ground for fibre glass hulls ...........................................................B-7

B.6 Separate ground cable ..................................................................................................B-8

B.7 RF interference ................................................................................................................B-10

B.8 Jumper cable for grounding ...................................................................................B-11

Appendix C System messages

C.1 Event messages – overview ......................................................................................C-1

C.2 List of ADU events ...........................................................................................................C-2

C.3 List of ACU events ...........................................................................................................C-7

Appendix D Command line interface

D.1 Introduction ........................................................................................................................ D-1

D.2 Supported commands .................................................................................................. D-2

Appendix E Approvals

E.1 CE (RED) ................................................................................................................................... E-1

Glossary ..............................................................................................................................................................Glossary-1

Index ....................................................................................................................................................................Index-1

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere COBHAM Antenne Handbücher

COBHAM

COBHAM Sailor 150 FleetBroadband Bedienungsanleitung

COBHAM

COBHAM SAILOR 800 VSAT Gebrauchs- und Pflegehandbuch

COBHAM

COBHAM EXPLORER 8100 Bedienungsanleitung

COBHAM

COBHAM EXPLORER 540 Bedienungsanleitung

COBHAM

COBHAM Sea Tel 4010W-33 Bedienungsanleitung

COBHAM

COBHAM 3.8m Offset Antenna Bedienungsanleitung

COBHAM

COBHAM EXPLORER 6100 Ku Bedienungsanleitung

COBHAM

COBHAM Explorer 3075 Bedienungsanleitung

COBHAM

COBHAM SAILOR 1000 XTR Ku 8W Bedienungs- und Sicherheitshinweise

COBHAM

COBHAM EXPLORER 8100 GX Bedienungsanleitung

COBHAM

COBHAM SEA TEL 9711IMA-70 Bedienungsanleitung

COBHAM

COBHAM SAILOR XTR Ku Bedienungsanleitung

COBHAM

COBHAM EXPLORER 5075GX Bedienungsanleitung

COBHAM

COBHAM EXPLORER 6075LX Bedienungsanleitung

COBHAM

COBHAM Sea Tel 4010W-17 Bedienungsanleitung

COBHAM

COBHAM Sea Tel Bedienungsanleitung

COBHAM

COBHAM S-67-175992 Gebrauchs- und Pflegehandbuch

COBHAM

COBHAM EXPLORER 3075GX Leitfaden

COBHAM

COBHAM EXPLORER 8100 Bedienungsanleitung

COBHAM

COBHAM Explorer 710 Bedienungsanleitung

COBHAM

COBHAM SAILOR 1000 XTR Ku 8W Gebrauchs- und Pflegehandbuch

COBHAM

COBHAM Saailor Fleet One Bedienungsanleitung

COBHAM

COBHAM EXPLORER 6075LX Leitfaden

COBHAM

COBHAM EXPLORER 8100 Leitfaden

Beliebte Antenne Handbücher anderer Marken

Alfa Network

Alfa Network APA-L01 Bedienungsanleitung

Naval

Naval PR-422CA Bedienungsanleitung

Feig Electronic

Feig Electronic ID ISC.ANTH200/200 Series Bedienungsanleitung

TERK Technologies

TERK Technologies TV44 Bedienungsanleitung

Directive Systems & Engineering

Directive Systems & Engineering DSE2324LYRMK Bedienungsanleitung

HP J8999A Bedienungsanleitung

MobilSat

MobilSat MSP-S Bedienungsanleitung

Steren

Steren ANT-UHF 13 Bedienungsanleitung

Novatel

Novatel 600-G Bedienungsanleitung

Radio Shack

Radio Shack Amplified VHF/UHF/FM Indoor Antenna Bedienungsanleitung

TRENDnet

TRENDnet TEW-AO12O Bedienungsanleitung

Radio Shack

Radio Shack 15-1837 Bedienungsanleitung

CommScope

CommScope CMAX-OMFX-43M-I53 Bedienungsanleitung

Ramsey Electronics

Ramsey Electronics DAP25 Bedienungsanleitung

Trango Systems

Trango Systems AD900-9 Bedienungsanleitung

Steren

Steren ANT-100 Bedienungsanleitung

IWCS

IWCS iriBelt II Einrichtungshandbuch

Labgear

Labgear LABHG32T Bedienungsanleitung