Compool Cp3830 Handbuch

Compool

Cp3830 POOL-SPA CONTROL SYSTEM

Installation & Operating Instructions

05/01/98

941-1010

Compool Cp3830

Table of Contents

Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Safety Notice. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Important Safety Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Package Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Plumbing Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Equipment Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

High Voltage Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Power Center with built in Sub-panel. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Power Center without built in Sub-panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

System Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Equipment Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Adding Relays. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Underwater Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Low Voltage Wiring. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

Power Center Circuit Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

Low Voltage Cables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Gas Heater Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Water Temperature Sensors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Freeze Temperature Sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

Control Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

Modular Crimping Tool . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

System Options. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

Spa-side Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

Multiple Control Panels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

Valve Actuator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

Valve Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Heat Pump or Electric Heater. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Solar Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

Solar Booster Pump Control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

Two Speed Spa Filter Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

Two Speed Pool Filter Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

Telephone Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

Dimmer Relay. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

Backwash Control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

Floor Cleaner Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

Configuration Switches. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

FREEZE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

I/L - Interlock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

SYST - System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

2Compool Cp3830

SPC FNCT - Special Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

HI SPD - High Speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

PHONE CONTROLS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

System Start-up. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

Operating Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

Control Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

Equipment Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

Equipment Status Icons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

Equipment Status Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

Heater Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

Cleaner Protection. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

Canceling Heater and Cleaner Protection. . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

Temperature Control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

Fahrenheit/Celsius key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

Programming . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

Programming . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

Programming additional Run Times. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

Programming a Time-out . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

Programming a Once-only . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

Canceling Programs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

Setting the Time of Day . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

Remote Control at Spa key. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

Calibration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33

Power Center. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

Equipment keys. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

3 - Hour Filter Override . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36

Sensor Status. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36

System Options. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

Spa-side Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

Spa-side Heat Boost . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

Telephone Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

2-speed Spa Filter Pump Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

2-speed Pool Filter Pump Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

Spa Waterfall Control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

Freeze Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

Winterizing the System. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

Problem Solving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

Compool Cp3830

Safety Notice

Important Safety Instructions

When installing and using this electrical equipment, basic safety precautions should always be

followed, including the following:

Read and follow all instructions.

To reduce the risk of injury, do not permit children to use this product unless they are

closely supervised at all times.

Water in excess of 100 degrees Fahrenheit may be hazardous to your health.

A terminal bar (marked for equipment ground only) is located inside the high voltage

compartment of the Power Center. To reduce the risk of electric shock, this terminal must

be connected to the grounding means provided in the electrical supply panel with a

continuous copper wire equivalent in size to the circuit conductors supplying this

equipment.

Save these instructions.

4Compool Cp3830

Introduction

Package Contents

The CP3830/S system includes the following components.

CP-3830 Control Panel (w/ cable) (1 qty.).

LX-3830 Power Center (1 qty.).

SNS-KIT3 Sensor Kit (1 qty.).

Compool Cp3830

The CP3830/SL system includes the following components.

CP-3830 Control Panel (w/ cable) (1 qty.).

LX-3830L Power Center (1 qty.).

SNS-KIT3 Sensor Kit (1 qty.).

6Compool Cp3830

Plumbing Requirements

Plumb system in accordance with recommended hydraulic schematic.

1. If a jet booster pump is being used, it is recommended that 1/4 HP per jet be installed. If a

single pump system is being used, it is recommended that 1/2 HP per jet be installed.

2. If a Spa-side Remote is to be used, install a 3” to 6” length of 1.5” Sch. 40 pvc pipe in the

spa wall so that the Spa-side Remote will not be submerged. Positioning the top of the

pipe 1/2” below the coping. The pipe should extend beyond the finished surface and will

be cut back after tile work is completed. Connect a 1/2” conduit and run back to Power

Center. Use sweep elbows for turns.

3. Plumb solar feed and return lines between the filter and heater. Install 3-port solar valve at

the feed line. Use Compool solar valve (model SOL-2T), to allow automatic draining of

panels.

4. Glazed solar panels require a drain valve (model HW-5B) to allow draining of panels. This

prevents damage from overheating water. Install drain valve at solar feed line and connect

to the pool fill line.

5. Plumb solar feed and return lines between the filter and heater. Install 3-port solar valve at

the feed line. Use Compool solar valve (model SOL-2T), to allow automatic draining of

SOLAR

SENSOR

CLEANER

PUMP

CVA-24

HEATER

CVA-24

SOLAR

PUMP

VACUUM

RELIEF

WATER

SENSOR

SKIMMER

FILTER

PUMP FILTER

MAIN

DRAIN

HW-5B

WATERFALL

POOL

LIGHT

POOL

FREEZE

SENSOR

CONTROL PANEL POWER CENTER

SOLAR

SENSOR

HEATER

CVA-24

VACUUM

RELIEF

WATER

SENSOR

FILTER

PUMP FILTER

JET

PUMP

SPA-SIDE

REMOTE

AIR

INTAKE

SPA

LIGHT

SPA

11 46

Compool Cp3830

panels.

6. A solar booster pump should be used when distance to panels exceeds 200’, or panels are

elevated higher than 25’.

7. Plumb cleaner pump after the return valve to the pool return line.

8. A Valve Actuator can be used to direct pool return water to a waterfall. This eliminates the

need for an additional pump.

Equipment Location

With the exception of the Spa-side Remote, all equipment must be located at least 10’ from the

water’s edge. Locate equipment in the following locations.

LX-3830 Power Center - at the equipment site.

CP-3830 Control Panel - inside the house or other weather-protected area.

SNS-KIT3 Water Temperature Sensors - spa and pool filter pump. Freeze

Temperature Sensor - at equipment pad.

8Compool Cp3830

Installation

High Voltage Wiring

Power Center with built in Sub-panel

At the equipment pad, mount the Power Center within

15’ of all the equipment. Provide power from the

Main-panel (located at the house) to Power Center.

Power Center without built in Sub-panel

At the equipment pad, mount a 100 amp

electrical circuit breaker panel (Sub-panel)

within 15’ of all the equipment. Provide

power from Main-panel (located at the

house) to the Sub-panel. Mount the Power

Center next to the Sub-panel.

Inhaltsverzeichnis

Andere Compool Bedienfeld Handbücher

Compool

Compool Cp3400 Handbuch

Beliebte Bedienfeld Handbücher anderer Marken

RDZ

RDZ PC-HRX Bedienungsanleitung

STG-BEIKIRCH

STG-BEIKIRCH MZ3 Technisches Handbuch

Efka

Efka Variocontrol V810 Bedienungsanleitung

Cebora

Cebora 208-10 Bedienungsanleitung

AMX

AMX AutoPatch CP-15 Bedienungsanleitung

Satel

Satel CA-6 KLED-S Bedienungsanleitung

Evolution

Evolution IQ plus 800 Bedienungsanleitung

Fagor

Fagor 8040 TCO CNC Bedienungsanleitung

Trane

Trane ComfortLink II XL950 Control Bedienungsanleitung

AKO

AKO PROCool AKO-17635-2 Bedienungsanleitung

ABB

ABB 6136/30M-101 Bedienungsanleitung

Telikou

Telikou BK-603 Belt Pack Bedienungsanleitung

Mapei

Mapei Mapeheat Thermo Touch Bedienungsanleitung

Bosch

Bosch D9412GV4 Bedienungsanleitung

Mitsubishi Heavy Industries

Mitsubishi Heavy Industries SC-SL4-AE2/1 Bedienungsanleitung

Sminn

Sminn BOX L VF1L EI Bedienungsanleitung

Balboa

Balboa TP600 Bedienungsanleitung

Nice

Nice HSCU1 Technische Daten