Curtis TP15T10A1100 Bedienungsanleitung

Service & Sales

1-800-421-6150 www.wilburcurtis.com

TROUBLESHOOTING GUIDE

THERMOPRO BREWERS

MODELS: TP15T10A1100, TP15S10A1500

Service & Sales

1-800-421-6150 www.wilburcurtis.com

Service & Sales

1-800-421-6150 www.wilburcurtis.com

PART # DESCRIPTION

TP15S10A1500 SINGLE BREWER PARTS IDENTIFICATION

1. WC- 844-101 VALVE, ADJ BY-PASS

2. WC-39444 LABEL, UCM OVERLAY TP2S 3-BATCH

3. WC-39417 LABEL, UCM OVERLAY TP2S 1-BATCH

4. WC-39416 LABEL, UCM OVERLAY TP2S 2-BATCH

5. WC-29050 SPRAYHEAD ASSY, ADVANCED FLOW

6. WC- 847 VALVE, WATER INLET 2GPM 120V 10W

7. WC-1501 FUSE HOLDER W/5A FUSE

8. WC-37122 KIT, DUMP VALVE BREW RIGHT

9. WC-1825 FAUCET ASSY, HOT WATER TP2S/2T

10. WC-8559 RELAY, SOLID STATE 40A W/HEAT SINK

11. WC-5350 TUBE, ½ ID x 1/8W SILICONE

12. WC-5502-01 KIT, PROBE, ASSY WATER LEVEL

13. WC-5310 TUBING, 5/16” ID X 1/8” W SILICONE

PART # DESCRIPTION

14. WC- 904-04 ELEMENT, HEATING 1.6KW 120V W/JAM NUTS

15. WC- 906-04 ELEMENT, HEATING 2KW 220V W/JAM NUTS

16. WC- 522 THERMOSTAT, RESET

17. WC- 103 SWITCH, TOGGLE 25A 125/250VAC RST

18. WC-1438-101 SENSOR, HEATING TANK

19. WC- 723 CONTROL MODULE, 120V TP2S/TP2T

20. WC-43062 GASKET, TANK LID

21.

WC-2977-101K

KIT, SPRAYHEAD FITTING ULTEM

22. WC-37317 9MM STRAIGHT FITTING

23. WC-37357 12MM STRAIGHT FITTING

24. WC-37365 INLET FITTING

25. WC-37266 OVERFLOW FITTING

C11

17 19

Service & Sales

1-800-421-6150 www.wilburcurtis.com

Service & Sales

1-800-421-6150 www.wilburcurtis.com

PART # DESCRIPTION

TP15T10A1100 TWIN BREWER PARTS IDENTIFICATION

1. WC- 844-101 VALVE, ADJ BY-PASS

5. WC-29050 SPRAYHEAD ASSY, ADVANCED FLOW

6. WC- 847 VALVE, WATER INLET 2GPM 120V 10W

8. WC-37122 KIT, DUMP VALVE BREW RIGHT

9. WC-1825 FAUCET ASSY, HOT WATER TP2S/2T

10. WC-8559 RELAY, SOLID STATE 40A W/HEAT SINK

11. WC-5350 TUBE, ½ ID x 1/8W SILICONE

13. WC-5310 TUBING, 5/16” ID X 1/8” W SILICONE

16. WC- 522 THERMOSTAT, RESET

18. WC-1438-101 SENSOR, HEATING TANK

19. WC- 723 CONTROL MODULE, 120V TP2S/TP2T

PART # DESCRIPTION

20. WC-43062 GASKET, TANK LID

21.

WC-2977-101K

KIT, SPRAYHEAD FITTING ULTEM

26. WC- 37121 KIT, DUMP VALVE BREW LEFT

27. WC-39442 LABEL, UCM OVERLAY TP2T TWIN 3-BATCH

28. WC-39415 LABEL, UCM OVERLAY TWIN 2-BATCH

29. WC-39414 LABEL, UCM OVERLAY TWIN 1-BATCH

30. WC-37008 KIT, TANK LID ROUND

31. WC- 934-04 ELEMENT, HEATING 2.5 KW 220V W/JAM NUTS

32. WC- 102 SWITCH, TOGGLE 125/250 VAC RESISTIVE

33. WC-37176 KIT, UCM & LABEL INSTRUCTIONS THERMOPRO



2





2

Service & Sales

1-800-421-6150 www.wilburcurtis.com

Service & Sales

1-800-421-6150 www.wilburcurtis.com

PART # DESCRIPTION

TXSG1501S600 THERMAL SERVER PARTS IDENTIFICATION

34. WC-37387 KIT, CAP, TETHER & SCREW TXSG

35. WC-2025 GLASS, GAUGE 8” TLXSG10

36. WC-2063 BRACKET, GAGE GLASS RING

37. WC-1939-101 NUT, FLANGED

38. WC-1938 SHANK, PLASTIC

39. WC-2005 WASHER, SHIELD CAP 1/8”

40. WC-1903 NUT, UNI0N SHANK

PART # DESCRIPTION

41. WC-1906 C’ RING .917 x .760 x .090

42. WC-3705 KIT, FAUCET REPAIR

43. WC-1841 FAUCET, ESP BLACK LOCKING

44. WC-2456 ELBOW, SILICONE STRT SIDE SRV

45. WC-36076 BRUSH, GAGE GLASS

46. WC-37396 KIT, GLASS GAUGE 10” 3PK TXSG15

47. WC-37395 KIT, GAUGE ASSY 10” BLK TXSG15

41 42

Service & Sales

1-800-421-6150 www.wilburcurtis.com

PARTS IMAGES

WC- 844-101

VALVE, ADJ BY-PASS

WC-39444

LABEL, UCM OVERLAY TP2S 3-BATCH

WC-39417

LABEL, UCM OVERLAY TP2S 1-BATCH

WC-39416

LABEL, UCM OVERLAY TP2S 2-BATCH

WC-29050

SPRAYHEAD ASSY, ADVANCED FLOW

WC- 847

VALVE, WATER INLET 2GPM 120V 10W

WC-1501

FUSE HOLDER W/5A FUSE

WC-37122

KIT, DUMP VALVE BREW RIGHT

WC-1825

FAUCET ASSY, HOT WATER TP2S/2T

WC-8559

RELAY, SOLID STATE 40A W/HEAT SINK

WC-5350

TUBE, ½ ID x 1/8W SILICONE

WC-5502-01

KIT, PROBE, ASSY WATER LEVEL

WC-5310

TUBING, 5/16” ID X 1/8” W SILICONE

WC- 904-04

ELEMENT, HEATING 120V W/JAM NUTS

WC- 906-04

ELEMENT, HEATING 220V W/JAM NUTS

WC- 522

THERMOSTAT, RESET

WC- 103

SWITCH, TOGGLE RST

WC-1438-101

SENSOR, HEATING TANK

WC- 723

CONTROL MODULE, 120V TP2S/TP2T

WC-43062

GASKET, TANK LID

WC-2977-101K

KIT, SPRAYHEAD FITTING ULTEM

WC-37317

9MM STRAIGHT FITTING

WC-37357

12MM STRAIGHT FITTING

WC-37365

INLET FITTING

Service & Sales

1-800-421-6150 www.wilburcurtis.com

PARTS IMAGES

WC-37266

OVERFLOW FITTING

WC- 37121

KIT, DUMP VALVE BREW LEFT

WC-39442

LABEL, UCM TP2T TWIN 3-BATCH

WC-39415

LABEL, UCM OVERLAY TWIN 2-BATCH

WC-39414

LABEL, UCM OVERLAY TWIN 1-BATCH

WC-37008

KIT, TANK LID ROUND

WC- 934-04

ELEMENT, HEATING W/JAM NUTS

WC- 102

SWITCH, TOGGLE RESISTIVE

WC-37176

KIT, UCM & LABEL

WC-37387

KIT, CAP, TETHER & SCREW TXSG

WC-2025

GLASS, GAUGE 8” TLXSG10

WC-2063

BRACKET, GAGE GLASS RING

WC-1939-101

NUT, FLANGED

WC-1938

SHANK, PLASTIC

WC-2005

WASHER, SHIELD CAP 1/8”

WC-1903

NUT, UNI0N SHANK

WC-1906

C’ RING .917 x .760 x .090

WC-3705

KIT, FAUCET REPAIR

WC-1841

FAUCET, ESP BLACK LOCKING

WC-2456

ELBOW, SILICONE STRT SIDE SRV

WC-36076

BRUSH, GAGE GLASS

WC-37396

KIT, GLASS GAUGE 10” 3PK TXSG15

WC-37395

KIT, GAUGE ASSY 10” BLK TXSG15

Service & Sales

1-800-421-6150 www.wilburcurtis.com

LCD reads “Heating” LCD reads “Heating”

Verify that the resistance on the Temperature

Sensor is less than 10k ohms with a hot tank

(200+ degrees) If no, verify correct mounting and

that the walls of the tank are free of mineral de-

posits. If yes, bypass the sensor using a jumper

with a 5k ohm resistor. If the LCD reads “ready”

and the unit stops heating, replace the tempera-

ture sensor, if not, replace the UCM.

LCD reads “Ready to Brew”

Check the A.C. side of the SSR for continuity. if

continuity is present, replace the SSR, if no

continuity, replace UCM.

TROUBLESHOOTING INSTRUCTIONS

HEATING ISSUES

Verify 220 volts between L1-L2 on the

power block. If yes, proceed to #2. If no,

verify that the unit is plugged in correctly,

and that the panel breaker is turned on.

Verify 220 volts between #2 & #4 on the

Manual Reset Thermostat.

If yes, proceed to #3, if no, reset or

replace the Manual Reset Thermostat.

Verify 220 volts across the Toggle Switch.

If yes, proceed to #4. If no, replace the

toggle switch.

Verify 220 volts across the Heating

Elements. If yes, proceed to #5. If no,

verify 5 VDC on the SSR. If yes, replace the

Solid State Relay, if no, replace the UCM.

Verify 19 ohm across each active Heating

Element, and replace any Heating

Element that reads “OPEN”

Not heating: Overheating:

Is the water turned on?

Yes:

No:

Yes:

No:

TANK FILLING ISSUES

Overlling:Not lling:

Verify 120 volts at inlet valve coil.

Replace Inlet Valve

Remove Orange wire from the Water

Level Probe. Does the Tank Fill?

Replace Water Level Probe.

Replace UCM

Does the tank continue to fill after the

toggle switch has been turned off ?

Yes:

No:

Yes:

No:

Replace Water Inlet Valve.

Remove the Orange wire from the Water

Level Probe and connect it to ground.

Does the tank stop lling?

Replace the Water Level Probe

Replace the UCM

TROUBLESHOOTING INSTRUCTIONS - continued

BREWING ISSUES

LCD does not read “Brewing”

If the LCD reads “Ready to Brew” and no

response when Brew Button is pressed, replace

the UCM.

LCD reads “Brewing”

No water ow from the sprayhead:

Does water ow from the hot water faucet?

If yes, verify 120 volts at the dump valve coil.

If voltage is present at the dump valve coil,

replace the dump valve.

If 120 volts is not present at the dump valve

coil, conrm continuety of wiring between molex

connector and Dump Valve.

If okay, replace the UCM. (Verify the resistance

on the dump valve coil to be open in one direc-

tion, and under 2k ohm in the other direction

BEFORE REPLACING THE UCM).

If water does not ow from the hot water faucet,

replace the Water Level Probe.

*Ensure correct alignment of the sprayhead

tting and that the tubing is routed properly to

allow for maximum water ow.

*Ensure that the sprayhead is free of mineral

deposits, in good repair, and properly conected.

Short Pots:

Verify that the Dump Valve outlet tting on the

tank, the tubing between the tank outlet and the

Sprayhead tting, the Sprayhead, and Dump

Valve are clear of obstructions.

Ensure correct alignment of the sprayhead

tting and that the tubing is routed properly to

allow for maximum water ow.

Verify that the Hot Water Tank is lling correctly.

If not, replace the Water Level Probe.

If all the above are okay, replace the Dump

Valve.

Overowing the Pots:

Ensure that the Sprayhead has not been

removed. Replace as needed.

Ensure that the Hot Water Tank is not overowing

(See Tank Filling Issues).

Ensure Cold Brew Lock is set to 5 degrees.

Ensure that Lime / Debis are not a factor If all

the above are okay, replace the Dump Valve.

JUNE/2014 M54_TS_WC_TP_revNC

Wilbur Curs Co., Inc.

6913 Acco Street, Montebello CA 90640

Customer Service: 800.421.6150 | 323.837.2300

csrassistance@wilburcurs.com

Tech Support: 800.995.0417

www.wilburcurs.com

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Curtis Spender Handbücher

Curtis

Curtis ThermoPro G4 Bedienungsanleitung

Curtis

Curtis Thermopro Airpot Bedienungsanleitung

Curtis

Curtis TFT1G3040 Konfigurationshandbuch

Curtis

Curtis IntelliFresh FreshTrac GEM3XN Bedienungsanleitung

Curtis

Curtis GemX IntelliFresh FreshTrac Satellite Bedienungsanleitung

Curtis

Curtis TCC2N Bedienungsanleitung

Curtis

Curtis CBHT Bedienungsanleitung

Curtis

Curtis TCN Series Datenblatt

Curtis

Curtis PCGT6 Bedienungsanleitung

Curtis

Curtis TCC1 Bedienungsanleitung

Curtis

Curtis TC Series Datenblatt

Curtis

Curtis MIS2200 Bedienungsanleitung

Curtis

Curtis TCT Bedienungsanleitung

Curtis

Curtis EXPR10 Bedienungsanleitung

Curtis

Curtis THERMAL FRESHTRAC TFT64 Konfigurationshandbuch

Curtis

Curtis Primo Cappuccino 6 Station Bedienungsanleitung

Curtis

Curtis Cafe Primo Cappuccino 3 Bedienungsanleitung

Curtis

Curtis TLP10 Bedienungsanleitung

Curtis

Curtis WB5N Bedienungsanleitung

Curtis

Curtis FreshTrac TFT Series Bedienungsanleitung

Curtis

Curtis CBHT Bedienungsanleitung

Curtis

Curtis Primo Cappuccino PCGT3700 Bedienungsanleitung

Curtis

Curtis GEMX IntelliFresh FreshTrac GEM3XIFT Bedienungsanleitung

Curtis

Curtis TCN Datenblatt

Beliebte Spender Handbücher anderer Marken

Silver King

Silver King Majestic SK12MAJ Kurzanleitung

Franke

Franke F3Dn Twin Bedienungsanleitung

STIEBEL ELTRON

STIEBEL ELTRON UltraHot Plus Bedienungsanleitung

DAN DRYER

DAN DRYER 282 Bedienungsanleitung

Essity

Essity Tork 473208 Bedienungsanleitung

CBS

CBS SD300BU-88 Einrichtungshandbuch

Sealey

Sealey MK77 Bedienungsanleitung

Fluid Management

Fluid Management Accutinter 1600 Bedienungsanleitung

Franke

Franke DVS SD99-010 Bedienungsanleitung

Graco

Graco Dispensit 1053-10C Fehlerbehebungshandbuch

ITALTINTO

ITALTINTO i50 Bedienungsanleitung

Coca-Cola

Coca-Cola FREESTYLE 9000 Bedienungsanleitung

Graco

Graco ProMix 2KE Bedienungsanleitung

TECHCON SYSTEMS

TECHCON SYSTEMS TS1251 Bedienungsanleitung

clarsen

clarsen H133 Bedienungsanleitung

PicoBrew

PicoBrew Zymatic Bedienungsanleitung

BOWMAN

BOWMAN BP-007 Bedienungsanleitung

HURAKAN

HURAKAN HKN-MT1 Bedienungsanleitung