Dell IP4700 Montage- und Wartungsanleitung

EMC Enterprise Storage

EMC Corporation 171 South Street, Hopkinton, MA 01748-9103

Corporate Headquarters: (508) 435-1000, (800) 424-EMC2 Fax: (508) 435-5374 Service: (800) SVC-4EMC

IP4700

INSTALLATION AND SERVICE GUIDE

P/N 014003002-03

IP4700 Installation and Service Guide

Printed May, 2001

No part of this publication may be reproduced or distributed in any form or by any means, or stored in a

database or retrieval system, without the prior written consent of EMC Corporation.

The information contained in this document is subject to change without notice. EMC Corporation assumes

no responsibility for any errors that may appear.

All computer software programs, including but not limited to microcode, described in this document are

furnished under a license, and may be used or copied only in accordance with the terms of such license.

EMC either owns or has the right to license the computer software programs described in this document.

EMC Corporation retains all rights, title and interest in the computer software programs.

EMC Corporation makes no warranties, expressed or implied, by operation of law or otherwise, relating to

this document, the products or the computer software programs described herein. EMC CORPORATION

DISCLAIMS ALL IMPLIED WARRANTIES OF MERCHANTIBILITY AND FITNESS FOR A PARTICULAR

PURPOSE. In no event shall EMC Corporation be liable for (a) incidental, indirect, special, or consequential

damages or (b) any damages whatsoever resulting from the loss of use, data or profits, arising out of this

document, even if advised of the possibility of such damages.

Trademark Information

EMC2, EMC, MOSAIC:2000, CLARiiON, and Navisphere are registered trademarks and EMC Enterprise Storage, The Enterprise Storage Company, The

EMC Effect, Connectrix, Access Logix, EDM, SDMS, SRDF, Timefinder, PowerPath, InfoMover, FarPoint, EMC Enterprise Storage Network, EMC

Enterprise Storage Specialist, EMC Storage Logic, Universal Data Tone, E-Infostructure, Celerra, Access Logix, MirrorView, and SnapView are

trademarks of EMC Corporation.

All other trademarks mentioned herein are the property of their respective owners.

IP4700 Installation and Service Guide

iii

Regulatory Notices

This device complies with Part 15 of the FCC rules. Operation is subject to the following two conditions:

(1) this device may not cause harmful interference, and (2) this device must accept any interference received,

including interference that may cause undesired operation.

Testing was done with shielded cables. Therefore, in order to comply with the FCC regulations, you must use

shielded cables with your installation. Changes or modifications to this unit not expressly approved by the party

responsible for compliance could void the user's authority to operate the equipment.

This equipment has been tested and found to comply with the limits for a Class A digital device, pursuant to Part 15

of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a

commercial environment. This equipment generates, uses, and can radiate radio frequency energy and, if not

installed and used in accordance with the instruction manual, may cause harmful interference to radio

communications. Operation of this equipment in a residential area is likely to cause harmful interference in which

case the user will be required to correct the interference at his own expense.

This Class A digital apparatus complies with Canadian ICES-003

Cet appareil numérique de la classe A est conforme à la norme NMB-003 du Canada

Manufacturer’s Declaration of Conformity - CE mark

This equipment has been tested and found to comply with the requirements of European Community Council

Directives 89/336/EEC, 73/23/EEC, and 98/68/EEC relating to electromagnetic compatibility and product safety

respectively.

This product complies with EN55022, CISPR22 and AS/NZS 3548 Class A.

IP4700 Installation and Service Guide

Preface..............................................................................................................................ix

Warnings and Cautions.......................................................................................... xiii

Chapter 1 The IP4700

About the IP4700...............................................................................1-2

IP4700 Components..........................................................................1-4

Customer-Replaceable Units (CRUs).............................................1-4

High-Availability Features ..............................................................1-5

Enclosure............................................................................................1-6

Front Panel..................................................................................1-7

Front Door...................................................................................1-9

Midplane.....................................................................................1-9

Storage Processors ..........................................................................1-10

Link Control Cards (LCCs)............................................................1-12

Disk Modules...................................................................................1-13

Disk Drives ...............................................................................1-13

Drive Carrier ............................................................................1-13

Power Supplies................................................................................1-14

SPS (Standby Power Supply) ........................................................1-16

Drive Fan Pack ................................................................................1-17

Storage Processor Fan Pack ...........................................................1-18

Chapter 2 Installing an IP4700

Requirements.....................................................................................2-2

Site Requirements......................................................................2-2

Cabling Requirements...............................................................2-2

Addressing Requirements........................................................2-6

Contents

IP4700 Installation and Service Guide

Contents

Installing an IP4700 in a Cabinet....................................................2-7

Connecting Cables............................................................................2-9

LAN Connectors........................................................................2-9

Management Console .............................................................2-12

SCSI Cable ................................................................................2-12

Link Control Card Connectors ..............................................2-14

Attaching the Power Cords and Powering Up the IP4700 .......2-16

Powering Down the IP4700...........................................................2-21

Abnormal Powerdown ..................................................................2-23

Chapter 3 Servicing and Upgrading an IP4700

Monitoring IP4700 Status ................................................................3-2

Handling CRUs.................................................................................3-5

Power Issues and CRUs............................................................3-5

Avoiding Electrostatic Discharge (ESD) Damage .................3-6

Replacing or Adding a Disk Module.............................................3-8

Replacing the Storage Processor Fan Pack..................................3-13

Replacing a Storage Processor ......................................................3-15

Installing a Storage Processor................................................3-16

Replacing a Link Control Card.....................................................3-17

Replacing the Drive Fan Pack.......................................................3-20

Replacing a Power Supply Module .............................................3-23

Replacing an SPS.............................................................................3-28

Chapter 4 The Standby Power Supply (SPS)

About the SPS....................................................................................4-2

Installing an SPS in a Rackmount Tray..........................................4-5

Replacing an SPS in a Rackmount System..................................4-12

Appendix A Technical Specifications and Operating Limits

IP4700 Technical Specifications .....................................................A-2

AC Power Requirements.........................................................A-2

Size and Weight ........................................................................A-3

Drive Type .................................................................................A-3

LCC Copper Cabling................................................................A-3

Ethernet Cabling.......................................................................A-3

Standards Certification and Compliance..............................A-3

Safety Standards .......................................................................A-4

EMI Standards...........................................................................A-4

Fibre Channel Related Standards...........................................A-5

Operating Limits .............................................................................A-6

vii

IP4700 Installation and Service Guide

Contents

Shipping and Storage Requirements ........................................... A-7

SPS Technical Specifications ......................................................... A-8

SPS Interface ............................................................................. A-8

Power Specifications................................................................ A-8

Power Consumption ............................................................... A-8

Operating Limits ...................................................................... A-9

Non-Operating Limits (Shipping and Storing) ................... A-9

Dimensions and Battery Information.................................... A-9

Glossary.........................................................................................................................g-1

Index ................................................................................................................................i-1

IP4700 Installation and Service Guide

viii

Contents

IP4700 Installation and Service Guide

Preface

This manual explains how to install the IP4700, install or replace the

Standby Power Supply (SPS), and how to replace

customer-replaceable units (CRUs). It is intended for technical

personnel and system administrators who will install and maintain

the IP4700 system hardware.

Most rackmount systems are fully assembled, with the storage

systems installed in a cabinet. If you intend to install the IP4700 in a

rackmount cabinet already on site, we assume that you have installed

the appropriate mounting tray and rails as described in the

instructions that accompany the mounting kit.

If you will install and service the IP4700, you should read this

manual. After reading it, you will be able to

• install an IP4700

• upgrade an IP4700 by adding disk modules and disk-array

enclosures (DAEs)

•replace failed CRUs

•install, service, and use the DC Standby Power Supply (DC SPS)

IP4700 Installation and Service Guide

Preface

Here is an overview of where information is located in this manual:

Chapter 1 introduces the IP4700’s components.

Chapter 2 explains requirements and describes how to install the

IP4700 and cable it to the LAN and to Disk Array Enclosures (DAEs).

Chapter 3 describes how to replace CRUs such as disk modules.

Chapter 4 introduces the Standby Power Supply (SPS) and explains

how to install and connect cables to them. In addition, it explains how

to replace the SPS.

Appendix A lists the IP4700 and SPS technical specifications.

Glossary defines terms used in the Fibre Channel environment.

Documentation Other related manuals include:

•EMC Fibre Channel Disk Array Enclosure (DAE) Rackmount Model

Hardware Reference (014002591)

•IP4700 Administrator’s Guide (069701169)

•IP4700 Quick Start Guide (069701170)

•IP4700 Release Notes (085600156)

Conventions Used in

This Manual EMC uses the following conventions for notes, cautions, warnings,

and danger notices.

CAUTION

A caution contains information essential to avoid damage to the

system or equipment. The caution may apply to hardware or

software.

WARNING

A warning contains information essential to avoid a hazard that can

cause severe personal injury, death, or substantial property damage

if you ignore the warning.

DANGER

A danger notice contains information essential to avoid a hazard

that will cause severe personal injury, death, or substantial property

damage if you ignore the warning.

Inhaltsverzeichnis

Andere Dell Server Handbücher

Dell

Dell PowerEdge R420xr Bedienungsanleitung

Dell

Dell PowerEdge R360 Handbuch

Dell

Dell PowerApp .cache 100 Technisches Handbuch

Dell

Dell PowerEdge R510 Technisches Handbuch

Dell

Dell PowerEdge R300 Bedienungsanleitung

Dell

Dell PowerEdge 1650 Bedienungsanleitung

Dell

Dell PowerEdge R630 Bedienungsanleitung

Dell

Dell PowerEdge 2970 Technisches Handbuch

Dell

Dell PowerEdge R610 Bedienungsanleitung

Dell

Dell PowerEdge R620 Bedienungsanleitung

Dell

Dell S5000 Series Bedienungsanleitung

Dell

Dell PowerEdge M420 Bedienungsanleitung

Dell

Dell PowerEdge R630 Bedienungsanleitung

Dell

Dell External OEMR T610 Kurzanleitung

Dell

Dell PowerEdge R630 Bedienungsanleitung

Dell

Dell VxRail P670F Handbuch

Dell

Dell 6100 Montageanleitung

Dell

Dell PowerEdge 2410 Bedienungsanleitung

Dell

Dell PowerEdge M820 Systems Bedienungsanleitung

Dell

Dell PowerEdge FD332 Bedienungsanleitung

Dell

Dell PowerEdge T410 Bedienungsanleitung

Dell

Dell PowerEdge 2450 Technisches Handbuch

Dell

Dell PowerEdge 2450 Bedienungsanleitung

Dell

Dell EMC PowerEdge R650xs Handbuch

Beliebte Server Handbücher anderer Marken

HP AlphaServer ES47 Bedienungsanleitung

PowerNAS

PowerNAS CMA Bedienungsanleitung

Supero

Supero FatTwin F617R3-FT Bedienungsanleitung

EtroVISION

EtroVISION EV3151 Bedienungsanleitung

HP ProLiant Gen9 Bedienungsanleitung

Compaq

Compaq ProLiant 3000 Handbuch

iRobo

iRobo IPC2U Bedienungsanleitung

Nortel

Nortel 1000 Con?guration guide Bedienungsanleitung

Asus

Asus AP7500 Bedienungs- und Wartungshandbuch

Avid Technology

Avid Technology AirSpeed 5000 Bedienungsanleitung

HP Integrity rx2600 Installationsanleitung

Milestone

Milestone Husky IVO 350T Bedienungsanleitung

Planet

Planet NAS-7410 Bedienungsanleitung

Lenovo

Lenovo ThinkSystem SR635 V3 Bedienungsanleitung

Fujitsu

Fujitsu PRIMERGY BX900 Bedienungsanleitung

Asus

Asus RS700DA-E6 PS4 Bedienungsanleitung

Vertiv

Vertiv Avocent ACS6000 Montage- und Wartungsanleitung

A & T Internationale

A & T Internationale Xserve Service-Handbuch