Ducati 620 SPORT Bedienungsanleitung

Owner’s manual

DUCATI620Sport

Hearty welcome among Ducati fans! Please accept our

best compliments for choosing a Ducati motorcycle. We

think you will ride your Ducati motorcycle for long

journeys as well as short daily trips. Ducati Motor Holding

S.p.A. wishes you smooth and enjoyable riding.

We are steadily doing our best to improve our “Technical

Assistance” service. For this reason, we recommend you

to strictly follow the indications given in this manual,

especially for motorcycle running-in. In this way, your

Ducati motorbike will surely give you unforgettable

emotions. Please contact our authorised service centres

to have your motorcycle repaired or if you simply need

advice.

Enjoy your ride!

Note

Ducati Motor Holding S.p.A. declines any liability

whatsoever for any mistakes incurred in drawing up this

manual. The information contained herein is valid at the

time of going to print. Ducati Motor Holding S.p.A.

reserves the right to make any changes required by the

future development of the above-mentioned products.

For your safety, as well as to preserve the warranty,

reliability and worth of your motorcycle, use original

Ducati spare parts only.

Warning

This manual forms an integral part of the

motorcycle and - in the event the motorcycle is resold -

must always be handed over to the new owner.

TABLE OF CONTENTS

General 6

Warranty 6

Symbols 6

Useful information for safe riding 7

Carrying the maximum load allowed 8

Identification data 9

Controls 10

Position of motorcycle controls 10

Instrument panel 11

The immobilizer system 14

Keys 14

Code card 15

Procedure to disable immobilizer engine block through

trottle twistgrip 16

Duplicate keys 17

Ignition swich and steering lock 18

Left switch 19

Clutch lever 20

Cold start lever 21

Right switch 22

Throttle twistgrip 23

Front brake lever 23

Rear brake pedal 24

Gear change pedal 24

Setting the gear change and rear brake pedals 25

Main components and devices 26

Location 26

Tank filler plug 27

Seat catch and helmet hooks 28

Side stand 29

Shock absorber adjusters 30

Shock absorber 31

Directions for use 32

Running-in recommendations 32

Pre-ride checks 33

Starting the engine 34

Moving off 36

Braking 37

Stopping the motorcycle 37

Parking 38

Refuelling 38

Tool kit and accessories 39

Main maintenance operations 40

Removing the fairing 40

Lifting the fuel tank 43

Changing the air filter 44

Checking brake and clutch fluid level 45

Checking brake pads for wear 47

Lubricating joints 48

Throttle cable adjustment 49

Charging the battery 50

Chain adjustment 51

Chain lubrication 52

Replacing bulbs 53

Beam setting 57

Tyre pressures 58

Checking engine oil level 60

Cleaning and replacing the spark plugs 61

Cleaning the motorcycle 62

Storing the bike away 63

Important notes 63

Technical data 64

Overall dimensions 64

Weights 64

Top-ups 65

Engine 66

Timing system 66

Performance data 67

Brakes 67

Transmission 68

Frame 69

Wheels 69

Tyres 69

Spark plugs 69

Suspensions 70

Available colors 70

Electric system 71

For United States of America version only 75

Routine maintenance record 84

GENERAL

Warranty

In your own interest, and in order to guarantee product

reliability, you are strongly advised to refer to a Ducati

Dealer or Authorised Workshop for any servicing

requiring particular technical expertise. Our highly skilled

staff have access to the implements required to perform

any servicing job at best, and use Ducati original spare

parts only as the best guarantee for full

interchangeability, smooth running and long life.

All Ducati motorcycles come with a “Warranty Card”.

The warranty does not apply to the motorcycles used in

competitions. No motorcycle part may be tampered with,

altered, or replaced with parts other than original Ducati

spare parts during the warranty period, or the warranty

will be automatically invalidated.

Symbols

Ducati Motor Holding S.p.A. advises you to read this

booklet carefully so as to become familiar with your

motorcycle. In case of any doubts, please call a Ducati

Dealer or Authorised Workshop. The information

contained herein will prove useful on your trips - and

Ducati Motor Holding S.p.A. wishes you smooth,

enjoyable riding - and will help you keep the performance

of your motorcycle unchanged for a long time.

Warning

Failure to comply with these instructions may put

you at risk and lead to severe injury or death.

Important

Possibility of damaging the motorcycle and/or its

components.

Note

Additional information on the job being carried out.

The terms right and left are referred to the motorcycle

viewed with respect to the direction of travel.

Useful information for safe riding

Warning

Read this section before riding your motorcycle.

Accidents are frequently due to inexperience. Always

make sure you have your licence with you when riding;

you need a valid licence to be entitled to ride your

motorcycle.

Do not lend your motorcycle to inexperienced riders or

who do not hold a valid licence.

Both rider and pillion passenger must always wear a

safety helmet.

Wear proper clothing, with no loose items or accessories

that may become tangled in the controls or limit your

zone of vision.

Never start or run the engine indoors. Exhaust gases are

poisonous and may lead to loss of consciousness or even

death within a short time.

Both rider and pillion passenger should keep their feet on

the footpegs when the motorcycle is in motion.

Always hold the handlebars firmly with both hands so

you will be ready for sudden changes of direction or in

the road surface. The pillion passenger should always

hold on to the suitable grab handle at the rear seat with

both hands.

Ride within the law and observe national and local rules.

Always respect speed limits where these are posted.

However, always adjust your speed to the visibility, road

and traffic conditions you are riding in.

Always signal your intention to turn or pull to the next

lane in good time using the suitable turn indicators.

Be sure you are clearly visible and do not ride within the

blind spot of vehicles ahead.

Be very careful when tackling road junctions, or when

riding in the areas near exits from private grounds, car

parks or on slip roads to access motorways.

Always turn off the engine when refuelling.

Be extremely careful not to spill fuel on the engine or on

the exhaust pipe when refuelling.

Do not smoke when refuelling.

While refuelling, you may inhale noxious fuel vapours.

Should any fuel drops be spilled on your skin or clothing,

immediately wash with soap and water and change your

clothing.

Always remove the key when you leave your motorcycle

unattended.

The engine, exhaust pipes, and mufflers stay hot for a

long time.

Warning

The exhaust system might be hot, even after

engine is switched off; pay particular attention not to

touch exhaust system with any body part and do not park

the vehicle next to inflammable material (wood, leaves

etc.).

Park your motorcycle where no one is likely to hit it and

use the side stand.

Never park on uneven or soft ground or your motorcycle

may fall over.

Carrying the maximum load allowed

Your motorcycle is designed for long-distance riding,

carrying the maximum load allowed in full safety.

Even weight distribution is critical to preserving these

safety features and avoiding trouble when performing

sudden manoeuvres or riding on bumpy roads.

Information about carrying capacity

The total weight of the motorcycle in running order

including rider, pillion passenger, luggage and additional

accessories should not exceed 385 Kg.

Arrange your luggage or heavy accessories in the lowest

possible position and close to motorcycle centre.

Be sure to secure the luggage to the supports provided

on the motorcycle as firmly as possible. Improperly

secured luggage may affect stability.

Never fix bulky or heavy objects to the handlebar or to

the front mudguard as this would affect stability and

cause danger.

Do not insert any objects you may need to carry into the

gaps of the frame as these may foul moving parts.

Make sure the tyres are inflated to the proper pressure

indicated at page 58 and that they are in good condition.

Identification data

All Ducati motorcycles have two identification numbers,

for frame (fig. 1) and engine (fig. 2).

Frame number

Engine number

Note

These numbers identify the motorcycle model and

should always be indicated when ordering spare parts.

fig. 2

fig. 1

CONTROLS

Warning

This section details the position and function of all

the controls you need to drive your motorcycle. Be sure

to read this information carefully before you use the

controls.

Position of motorcycle controls (fig. 3)

1) Instrument panel.

2) Key-operated ignition switch and steering lock.

3) Left switch.

4) Clutch lever.

5) Cold start lever.

6) Right switch.

7) Throttle twistgrip.

8) Front brake lever.

9) Gear change pedal.

10) Rear brake pedal.

fig. 3

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Ducati Motorrad Handbücher

Ducati

Ducati Multistrada 1000ds Gebrauchsanweisung

Ducati

Ducati Diavel 2014 Bedienungsanleitung

Ducati

Ducati sport 100 2006 Bedienungsanleitung

Ducati

Ducati Monster 795 ABS Bedienungsanleitung

Ducati

Ducati MONSTER 1200 s Bedienungsanleitung

Ducati

Ducati 998R Bedienungsanleitung

Ducati

Ducati Superbike 749R 2006 Betriebsanleitung

Ducati

Ducati MONSTER Bedienungsanleitung

Ducati

Ducati SPORT TOURING ST3 Bedienungsanleitung

Ducati

Ducati Multistrada 1200 2016 Bedienungsanleitung

Ducati

Ducati ST4S ABS Bedienungsanleitung

Ducati

Ducati hipermotard 2016 Bedienungsanleitung

Ducati

Ducati Hypermotard 950 Bedienungsanleitung

Ducati

Ducati DIAVEL V4 2024 Bedienungsanleitung

Ducati

Ducati Scrambler 800 Desert Sled 2019 Bedienungsanleitung

Ducati

Ducati 999R 2006 Betriebsanleitung

Ducati

Ducati Diavel Carbon Bedienungsanleitung

Ducati

Ducati Monster 796 Gebrauchsanweisung

Ducati

Ducati SPORT TOURING ST3 Bedienungsanleitung

Ducati

Ducati SPORT TOURING ST3 Bedienungsanleitung

Ducati

Ducati 250 GT 1965 Technisches Datenblatt

Ducati

Ducati HyperMotard 698 MONO 2024 Bedienungsanleitung

Ducati

Ducati SUPERSPORT CR-SP 900 desmodue Bedienungsanleitung

Ducati

Ducati 998S Bedienungsanleitung

Beliebte Motorrad Handbücher anderer Marken

OHVALE

OHVALE GP-0 Stücklistenhandbuch

Yamaha

Yamaha Star XV19CTSZ 2009 Bedienungsanleitung

KTM

KTM 350 XCF-W USA Bedienungsanleitung

HYOSUNG

HYOSUNG ST7 Bedienungsanleitung

Husqvarna

Husqvarna FC 250 2016 Bedienungsanleitung

APRILIA

APRILIA ETV MILLE CAPONORD - PART1 02-2001 Bedienungsanleitung

Yamaha

Yamaha 2006 YZF-R1V Bedienungsanleitung

KTM

KTM Freeride E-XC 2021 Bedienungsanleitung

Fantic

Fantic Enduro 125 Bedienungsanleitung

MV Agusta

MV Agusta 2008 F4 312RR 1078 Gebrauchsanweisung

Yamaha

Yamaha XVS650A Bedienungsanleitung

Yamaha

Yamaha YZF-R6T(C) Handbuch

ATK

ATK 1988 250 Bedienungsanleitung

Excelsior-HENDERSON

Excelsior-HENDERSON 1999 HCX Bedienungsanleitung

Triumph

Triumph Thunderbird Bedienungsanleitung

Yamaha

Yamaha 2006 FJR1300A Bedienungsanleitung

BMW

BMW MOTORRAD K 1200 R Sport Installations- und Wartungshandbuch

Yamaha

Yamaha MTN690-U Bedienungsanleitung