Edelbrock 5721 Bedienungsanleitung

Brochure #63-5721

Catalog #5721

Rev. 12/07 - AJ/mc Page 1 of 1

EDELBROCK CAT-BACK EXHAUST SYSTEM

For 2007-2008 Toyota FJ Cruiser 2WD & 4WD

Catalog #5721

INSTALLATION INSTRUCTIONS

Please study these instructions carefully before installing your new Edelbrock Cat-Back Exhaust System. If you have any

questions, please contact our Technical Hotline at: 1-800-416-8628 , 7am - 5pm, Monday-Friday, Pacific Standard

Time or e-mail us at [email protected].

Suggested Tools for Installation:

❑3/8" ratchet and metric sockets ❑14mm, 15mm, and 17mm Wrenches

❑Jack and jackstands ❑Liquid penetrant and rubber lubricant

DISASSEMBLY

1. Raise and support vehicle.

2. Remove factory exhaust system from the flange

located behind the catalytic converter.

ASSEMBLY

1. Disconnect the fuel vapor return line from the vapor

canister located just above the rear-end housing. Place

the heat shield sleeve over return line and reconnect it

to the canister. NOTE: Since fuel lines contain harmful

vapors, this procedure should be done in a well

ventilated area clear of any open flames or extreme

heat. Safety glasses should also be worn when

performing this action.

2. Using the supplied 10mm bolts, lock washers, and flat

washers from the kit, install the I-pipe assembly #25-

3285 placing the hangers in the rubber isolators.

3. Using a 2-1/2” band clamp and hanger clamp assembly

#23-4107 from the kit, install muffler #25-55742.

NOTE: Only snug all clamps at this time for adjusment

later.

4. Install overaxle pipe assembly #25-3286.

WARNING!!!

Exhaust gas contains carbon monoxide, a deadly

invisible gas. Correct any leaks before driving!

IMPORTANT NOTE:

Proper installation is the responsibility of the installer. Improper installation will void warranty and may

result in poor performance and engine or vehicle damage.

KIT CONTENTS

Catalog #5716

Qty.Part # Description

❑1 25-3285 I-Pipe Assembly

❑1 25-3286 Overaxle Assembly

❑1 25-3298 Tailpipe Assembly

❑1 25-5582 Tailpipe Tip (Polished)

❑1 22-5721 Installation Kit

❑1 25-55742 Muffler

5. Using a 2-1/2” band clamp, install tailpipe assembly

#25-3298 placing the hanger in the rubber isolator.

6. Using a 2-1/2” band clamp, install tailpipe tip #25-

5582.

7. Working from the front of the system to the rear, adjust,

align, and tighten all the band clamps. Give adequate

clearance for fuel lines, brake lines, electrical wiring,

and the spare tire.

Edelbrock Corporation, 2700 California St., Torrance, CA 90503

Tech Line: (800) 416-8628 Office: (310) 781-2222

E-Mail: [email protected]

Inhaltsverzeichnis

Andere Edelbrock Automobilteil Handbücher

Edelbrock

Edelbrock 75284 Bedienungsanleitung

Edelbrock

Edelbrock E-TEC 170 Bedienungsanleitung

Edelbrock

Edelbrock 770769 Bedienungsanleitung

Edelbrock

Edelbrock 2103 Gebrauchsanweisung

Edelbrock

Edelbrock 1903 Bedienungsanleitung

Edelbrock

Edelbrock 5226 Bedienungsanleitung

Edelbrock

Edelbrock 25-9213 Bedienungsanleitung

Edelbrock

Edelbrock 3811 Bedienungsanleitung

Edelbrock

Edelbrock 6719 Bedienungsanleitung

Edelbrock

Edelbrock 5419 Bedienungsanleitung

Edelbrock

Edelbrock 4803 Bedienungsanleitung

Edelbrock

Edelbrock 68722 Bedienungsanleitung

Edelbrock

Edelbrock 65003 Bedienungsanleitung

Edelbrock

Edelbrock 5486 Bedienungsanleitung

Edelbrock

Edelbrock 5220 Bedienungsanleitung

Edelbrock

Edelbrock 72285 Bedienungsanleitung

Edelbrock

Edelbrock 15008 Bedienungsanleitung

Edelbrock

Edelbrock 65052 Bedienungsanleitung

Edelbrock

Edelbrock Russell R09430 Bedienungsanleitung

Edelbrock

Edelbrock 63-0181 Bedienungsanleitung

Edelbrock

Edelbrock Camaro 5290 Bedienungsanleitung

Edelbrock

Edelbrock 5658 Bedienungsanleitung

Edelbrock

Edelbrock 6876 Bedienungsanleitung

Edelbrock

Edelbrock Russell R09392S Bedienungsanleitung

Beliebte Automobilteil Handbücher anderer Marken

Dakota Digital

Dakota Digital 650277 Bedienungsanleitung

bosal

bosal 037031 Bedienungsanleitung

Vintage Air

Vintage Air 571063 Bedienungsanleitung

GFB

GFB EX38 Bedienungsanleitung

bosal

bosal 028091 Bedienungsanleitung

Dodge

Dodge 8W-43 Kurzanleitung

ICI

ICI Magnum FBM10DGN Bedienungsanleitung

Volant Perfomance

Volant Perfomance 19435 Bedienungsanleitung

BENDIX

BENDIX GEN 4 GEN 5 ABS Bedienungsanleitung

Vintage Air

Vintage Air 571065 Bedienungsanleitung

Rugged Ridge

Rugged Ridge 11503.13 Bedienungsanleitung

BENDIX

BENDIX CYCLONE DURADRAIN TRAILER WATER Bedienungsanleitung

Porsche

Porsche 968 - ASSEMBLY INSPECTION PROCEDURE AND MAINTENANCE... Leitfaden

Sumitomo

Sumitomo FINE CYCLO FC-A 15 G Bedienungsanleitung

Toshiba

Toshiba 48-1250 A Bedienungsanleitung

aldes

aldes EHT2 Bedienungsanleitung

Go Rhino

Go Rhino 24371T Bedienungsanleitung

BBK

BBK 18950 Bedienungsanleitung