Elkay ESRC8 1G Series Installationshandbuch

97759C (REV. E - 7/03)

ESRC8*1G ESRC8*3GJO ESRC13*3GJO ESRDC*C

PAGE 1

With FLEXI-GUARD®

Installation/Care/Use Manual

USES HFC-134A REFRIGERANT

FIG. 1

SEE FIG. 3

SEE DETAIL

ABOVE

8 - See Fig. 4

15, 16

& 17

127

19, 20, 21

3, 4, 5

All manuals and user guides at all-guides.com

all-guides.com

97759C (REV. E - 7/03)

ESRC8*1G ESRC8*3GJO ESRC13*3GJO ESRDC*C

PAGE 2

FIG. 2

* RECOMMENDED HEIGHT FOR ADULTS.

DECREASE HEIGHT FOR CHILDREN.

* ALTURA RECOMENDADA PARA ADULTOS.

REDUZCA PARA LOS NIÑOS.

* HAUTEUR RECOMMANDÉE POUR LES

ADULTES. INSTALLEZ PLUS BAS POUR

LES ENFANTS.

FINISHED FLOOR

PISO ACABADO

PLANCHER FINI

MOUNTING

BOX

SHIPPING POSITION

OF FASTENING CLIP

COOLER BASE

POSITION FASTENING

CLIP AS SHOWN AFTER

COOLER IS HUNG IN

PLACE

DETAIL A

DETAIL B

SEE DETAILS

A & B

MOUNTING BOX

ROUGH-IN

D = ELECTRICAL OUTLET LOCATION

UBICACIÓN DE LA TOMA DE ELECTRICIDAD

EMPLACEMENT DE LA PRISE DE COURANT

E = INSURE PROPER VENTILATION BY MAINTAINING 4" (102mm) (MIN.) CLEARANCE

FROM CABINET LOUVERS TO WALL.

ASEGURE UNA VENTILACIÓN ADECUADA MANTENIENDO UN ESPACIO E 4" (102mm) (MÍN.)

DE HOLGURA ENTRE LAREJILLADE VENTILACIÓN DEL MUEBLE Y LA PARED

ASSUREZ-VOUS UNE BONNE VENTILATION EN GARDANT 4" (102mm) (MIN.)

ENTRE LES ÉVENTS DE LENCEINTE ET LE MUR.

F = POWER CORD 1-1/2FEET (457mm) LONG

CABLE ELÉCTRICO DE 1½ PIE, 457 mm DE LARGO

CORDON DALIMENTATION 1-1/2' (457mm)

LEGEND/LEYENDA/LÉGENDE

A = RECOMMENDED WATER SUPPLY LOCATION 3/8 O.D. UNPLATED COPPER TUBE CONNECT STUB 1-1/2 IN. (38 mm) OUT

FROM WALL SHUT OFF BY OTHERS

SE RECOMIENDA UBICAR EL TUBO CORTO DE CONEXIÓNALTUBO DE COBRE SIN CHAPAR DE 3/8" DE DIÁM. EXT. A1-1/2"

(38 mm) FUERA DE LALLAVE DE PASO EN LA PARED COLOCADA POR TERCEROS.

EMPLACEMENT RECOMMANDÉ D'ALIMENTATION EN EAU PAR TUBE EN CUIVRE NON PLAQUÉ DE 3/8 PO. (9,5 mm) D.E.

CONNECTANT UNE TUYAUTERIE DE 1-1/2 PO. (38 mm) DEPUIS LE ROBINET D'ARRÊT FOURNI PAR D'AUTRES.

B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4 O.D. DRAIN

UBICACIÓN RECOMENDADA PARA EL DRENAJE DE SALIDA DE AGUA, DE 1¼ DE DIÁMETRO.

EMPLACEMENT RECOMMANDÉ POUR LE DRAIN DE D.E. 1-1/4" DE SORTIE DEAU.

C = 1-1/4 TRAP NOT FURNISHED**

PURGADOR DE 1¼ NO PROPORCIONADO**

SIPHON 1-1/4 NON FOURNI**

All manuals and user guides at all-guides.com

97759C (REV. E - 7/03)

ESRC8*1G ESRC8*3GJO ESRC13*3GJO ESRDC*C

PAGE 3

FIG. 3

Stream height is factory set at 35 PSI. If supply pressure varies greatly

from this, remove items 31 and 32 and adjust screw on item 34. Clockwise

adjustment will raise stream and counter-clockwise adjustment will lower

stream. For best adjustment, stream should hit basin approximately 6-1/2"

(165mm) from bubbler.

NOTE:

WHEN INSTALLING REPLACEMENT BUBBLER

AND PEDESTAL, TIGHTEN NUT (ITEM 12) ONLY

TO HOLD PARTS SNUG IN POSITION.

DO NOT OVER TIGHTEN.

BASIN

IMPORTANT

ALL SERVICE TO BE PERFORMED BY AN AUTHORIZED SERVICE PERSON

START UP

Also See General Instructions

8) Replace the front panel and secure by retightening all screws.

FIG. 4

WRAPPER

31 35 36

INSTALLATION OF COOLER AND TRAP

1) Hang the unit from the mounting box by placing tabs from the upper backside of the basin over top of the

upper flange on the mounting box, and mount trap, as shown in Figure 2.

NOTE: Mounting box and trap MUST be supported securely. Add fixture support carrier if wall will not provide adequate support.

IMPORTANT:

2) Secure cooler in place by positioning fastening clips as shown in Figure 2 - Detail B.

3) Install straight valve for 3/8 in. O.D. unplated copper tube.

4) Remove the access panel on the underside of the cooler and set it aside.

5) Connect water inlet line--See Note 4 of General Instructions.

6) Remove the slip nut and gasket from the trap and install them on the cooler waste line making sure that the end of the waste

line fits into the trap. Assemble the slip nut and gasket to the trap and tighten securely.

All manuals and user guides at all-guides.com

97759C (REV. E - 7/03)

ESRC8*1G ESRC8*3GJO ESRC13*3GJO ESRDC*C

PAGE 4

PARTS LIST

ITEM NO. PARTNO. DESCRIPTION

31517C

27321C

30699C

70018C

31490C

70009C

50186C

56073C

40322C

56011C

55997C

75580C

62152C

66202C

50144C

70184C

70418C

36094C

36158C

35768C

35959C

66501C

40041C

40429C

50074C

20593C

20594C

70208C

31513C

66505C

55996C

27239C

40089C

40048C

15005C

61313C

40169C

50986C

See Color Table

40038C

40619C

50105C

27093C

27292C

27331C

27094C

40043C

70817C

15009C

100322740560

31525028

40493C

56092C

Power Cord

Fan Bracket

Fan Blade

Hex Nut - Fan Blade

Fan Motor

Screw (Fan Motor)

Shroud - Fan

Bubbler Assy

Orifice Assy

Housing Assy

Pedestal

Locknut

Condenser

Drier

Grommet - Compressor Mtg.

Hair Pin - Cotter

Washer

Compressor Serv. Pak EMI 70 HNR

Overload

Cover - Relay

Relay

Heat Exchanger

Tailpipe Assy (8 Gal)

Precooler Assy (13 Gal)

Tailpipe Gasket

Basin - Stainless Steel

Basin - Glass Filler

Screw - Basin Mtg.

Cold Control

Evaporator Assembly (8 Gal)

Strainer

Bracket - Precooler

Cover

Button

Retaining Nut

Regulator

Hex Nut

Regulator Holder

Wrapper

Strainer - Beehive

Ferrule - Tailpipe

Tailpipe Gasket

Angle-Front Corner

Bracket-Basin Mounting

Frame-Back/Bottom

Bracket-Front

Locknut

Fitting - Elbow 1/4 Stem

Nipple - Bubbler (GF)

Gasket

O-Ring

Glass Filler

Poly Tubing (Cut to length)

18*

ELKAY MANUFACTURING COMPANY  2222 CAMDEN COURT  OAK BROOK, IL 60523  630.574.8484

PRINTED IN U.S.A.

*INCLUDES RELAY & OVERLOAD. IF UNDER WARRANTY,

REPLACE WITH SAME COMPRESSOR USED IN ORIGINAL

ASSEMBLY.

NOTE: All correspondence pertaining to any of the above

water coolers or orders for repair parts MUST include Model

No. and Serial No. of cooler, name and part number of replace-

ment part.

COLOR TABLE

PANEL COLOR Item No. 37

Part No.

Gray Beige

Almond

Stainless Steel

Sandalwood

Granite

Light Gray

21017C

21481C

21013C

21480C

27208C

27209C

FOR PARTS, CONTACT YOUR LOCAL DISTRIBUTOR OR CALL 1.800.323.0620

220V 60Hz

35827C

31431C

36092C

36174C

36050C

66223C

35826C

Power Cord

Fan Motor

Compressor Serv. Pak

Overload

Relay

Heat Exchanger

Power - Inlet

PART. NO. DESCRIPTIONITEM NO.

18*

48 49 50

FIG. 5

All manuals and user guides at all-guides.com

Dieses Handbuch passt für folgende Modelle

Andere Elkay Wasserspender Handbücher

Elkay

Elkay Space-ette With FLEXI-GUARD WD701-8 1G... Installationshandbuch

Elkay

Elkay OFA25*1D Installationshandbuch

Elkay

Elkay EWC Series Installationshandbuch

Elkay

Elkay Square Front LKFEA8C A Series Installationshandbuch

Elkay

Elkay LVRCGRNTL8 1B Series Installationshandbuch

Elkay

Elkay EZ Series Gebrauchsanweisung

Elkay

Elkay EZH2O VRCGNDWS C Series Installationshandbuch

Elkay

Elkay EZOTL Series Leitfaden

Elkay

Elkay EZS8WS 1G Series Gebrauchsanweisung

Elkay

Elkay VRCGRNTL8 Series Installationshandbuch

Elkay

Elkay LZ Series Gebrauchsanweisung

Elkay

Elkay FLEXI-GUARD EHFRA7C A Series Installationshandbuch

Elkay

Elkay EZTL Series Installationshandbuch

Elkay

Elkay EFW Series Installationshandbuch

Elkay

Elkay EFA Series Installationshandbuch

Elkay

Elkay EFHA8 1K Series Installationshandbuch

Elkay

Elkay EMABFDTL A Series Installationshandbuch

Elkay

Elkay OFA25*2FJO Installationshandbuch

Elkay

Elkay LZ Series Installationshandbuch

Elkay

Elkay EFA25 3C Series Installationshandbuch

Elkay

Elkay VRC Series Installationshandbuch

Elkay

Elkay Swirlflo EDFPA117FPC Installationshandbuch

Elkay

Elkay WD7015 1E Series Installationshandbuch

Elkay

Elkay EZ Series Installationshandbuch

Beliebte Wasserspender Handbücher anderer Marken

Monarch Water

Monarch Water ULTIMATE MINI AQUA HE Bedienungsanleitung

Haier

Haier HLM-109B Bedienungsanleitung

abc

abc Fleck 5600SXT Bedienungsanleitung

GE GXOF18G Betriebsanleitung

Kenmore

Kenmore 625.385560 UltraFilter 650 Bedienungsanleitung

Innova

Innova CEV+ Kurzanleitung

Aries

Aries Hydra DI Handbuch

GE GNCF02H Bedienungsanleitung

ProFlo

ProFlo PFB Series Bedienungsanleitung

A.O. Smith

A.O. Smith FREZYA 300S Bedienungsanleitung

Frakco

Frakco Travelsoft RV 2400HD Bedienungsanleitung

Avanti

Avanti WD31EC Bedienungsanleitung

Avanti

Avanti WD360 Bedienungsanleitung

BRIO

BRIO CLCTTL520 Benutzerhandbuch

3M HCD-1 Bedienungsanleitung

Coway

Coway CHP-671L Bedienungsanleitung

Aqua Essentials

Aqua Essentials Borg & Overström B4 Bedienungsanleitung

KENT

KENT 11063 Handbuch