Elkay VRC8FR 1C Series Installationshandbuch

VRC8FR*1C

Page 1 98966C (Rev. B - 2/13)

Uses HFC-134A refrigerant

VRC Series Barrier-Free Water Coolers

INSTALLATION, CARE & USE MANUAL

2, 3, 5

23, 61, 62

24, 30

See Fig. 4

9, 12, 13

1, 4

6, 7, 22, 41

See Fig. 3

38, 39

59, 60

Fig. 1

VRC8FR*1C

Page 298966C (Rev. B - 2/13)

Fig. 2

REDUCE HEIGHT BY 3” FOR INSTALLATION OF CHILDRENS ADA COOLER

ADAREQUIREMENT

LEGEND/LEYENDA/LÉGENDE

A = RECOMMENDED WATER SUPPLY LOCATION. SHUT OFF VALVE (NOT FURNISHED) TO ACCEPT 3/8” O.D. UNPLATED

COPPER TUBE.

B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4” O.D. DRAIN

C = 1-1/4 TRAP NOT FURNISHED**

D = ELECTRICAL SUPPLY (3) WIRE RECESSED BOX

E = INSURE PROPER VENTILATION BY MAINTAINING 6" (152 mm) (MIN.) CLEARANCE FROM CABINET LOUVERS TO WALL.

F = 7/16 BOLT HOLES FOR FASTENING UNIT TO WALL

VRC8FR*1C

Page 3 98966C (Rev. B - 2/13)

Fig. 3

VANDAL RESISTANT BUBBLER DETAIL

DETALLE DEL GRIFO RESISTENTE AL VANDALISMO

DESCRIPTION DU BARBOTEUR RESISTANT AU VANDALISME

Basin

Estanque

Bassin

IMPORTANT

ALL SERVICE TO BE PERFORMED BY

AN AUTHORIZED SERVICE PERSON

HANGER BRACKETS & TRAP

INSTALLATION

1) Remove hanger bracket fastened to back of cooler by removing one (1)

screw.

2) Mount the hanger bracket and trap as shown in Figure 2.

NOTE: Hanger Bracket MUST be supported securely. Add fixture support

carrier if wall will not provide adequate support.

IMPORTANT:

y6 1/4 in. (159mm) dimension from wall to centerline of trap must be

maintained for proper fit.

yAnchor hanger securely to wall using all five (5) 1/4 in. dia. mounting

holes.

3) Install straight valve for 3/8" O.D. tube.

INSTALLATION OF COOLER

4) Hang the cooler on the hanger bracket. Be certain the hanger bracket is

engaged properly in the slots on the cooler back as shown in Figure 2.

5) Loosen the two (2) screws holding the lower front panel at the bottom of

cooler base and two (2) screws at the top (Use torx bits sold separately).

Remove the front panel and set aside.

6) Connect water inlet line--See Note 4 of General Instructions.

7) Remove the slip nut and gasket from the trap and install them on the cooler

waste line making sure that the end of the waste line fits into the trap.

Assemble the slip nut and gasket to the trap and tighten securely. Recom-

mend fastening cooler to wall using 7/16 bolt holes. (see fig.2, "F")

START UP

Also See General Instructions

8) Stream height is factory set at 45-50 PSI. If supply pressure varies

greatly from this, adjust screw using the access hole in the pushbutton

(insert screwdriver). CW adjustment will raise stream and CCW adjust-

ment will lower stream. For best adjustment, stream should hit basin

approximately 6-1/2” (165mm) from bubbler.

Stainless Steel

PANEL COLOR

COLOR TABLE Item No. 37

Part No.

Item No. 32

Part No. Item No. 33

Part No. Item No. 34

Part No. Item No. 35

Part No. Item No. 36

Part No.

28525C 28519C 28516C

28528C 28522C 22955C

VRC8FR*1C

Page 498966C (Rev. B - 2/13)

Fig. 4

45 (8)

53 31

48 40 44

14,17,18

47 (4)

27 28

46 46

45 (6)

VRC8FR*1C

Page 5 98966C (Rev. B - 2/13)

Fig. 5

Thermostat Installation Detail

Fig. 6

Heater Strip Detail

WARNING!

This unit is frost resistant down to 0° F with no wind.

Prevailing winds can reduce the ability of the heater

element to prevent light freezing. If the ambient air

temperature will drop below 0° F, the cooler needs to

be drained of all water by blowing out all water lines,

evaporator (item 20), and the drain trap. A heater

strip is used to heat the unit and will begin to cycle

at 40° +/- 5° F. A check at this temperature will

ensure the heater is working and the unit is resis-

tant to light freezing.

ALSO, MAKE SURE THERE ARE NO PLASTIC OR

FLAMMABLE COMPONENTS DIRECTLY ABOVE

THE HEATER STRIP. Wiring Diagram

VRC8FR*1C

Page 698966C (Rev. B - 2/13)

PRINTED IN U.S.A.

IMPRESO EN LOS E.E.U.U.

IMPRIMÉ AUX É.-U.

FOR PARTS, CONTACT YOUR LOCAL DISTRIBUTOR OR CALL 1.800.323.0620

ELKAY MANUFACTURING COMPANY • 2222 CAMDEN COURT • OAK BROOK, IL 60523 • 630.574.8484

REPAIR SERVICE INFORMATION TOLL FREE NUMBER 1.800.260.6640

56305C

100806740570

101474551730

15009C

19037000

30664C

31490C

35839C

35768C

35870C

36322C

36173C

36167C

50986C

45866C

56092C

15005C

61313C

66703C

66810C

70002C

70009C

600985451640

56121C

28963C

22897C

45662C

45737C

75672C

100147140560

28596C

See Color Table

66743C

56237C

40045C

70018C

75524C

55996C

45736C

75570C

75661C

70864C

56033C

66576C

45930C

27124C

55931C

28617C

35906C

35907C

35909C

70432C

75506C

75588C

75589C

110868642550

160270508640

75583C

75520C

75523C

28551C

Gasket - Bubbler

Grommet - Compressor Mtg.

Stud - Compressor Mtg.

Nipple - Bubbler

Clip - Compressor Mtg.

Fan Blade

Fan Motor

Cold Control

Cover - Relay

Power Cord

Compressor Serv. Pak EMI 70

Overload

Relay

Holder - Regulator

Bubbler Assy.

Tubing - Poly (Cut To length)

Retaining Nut

Regulator

Drier

Evaporator Assembly

Screw - #10 x 1/2” Lg. HHSM

Screw - Fan Motor

Drain Plug 1-1/2

Elbow - Drain

Basin - Stainless Steel

Panel - Bottom Dispenser

Button - Push

Sleeve - Push Button

Cap Screw

Gasket - Drain

Panel - Screen

Panel - RH Rear

Panel - LH Rear

Panel - RH Dispenser Side

Panel - LH Dispenser Side

Panel - Dispenser Front

Panel - Front Lower

Condenser

Shroud Fan

Hex Nut

Hex Nut - Fan Blade

Clip (Front & Rear Panels)

Strainer (See “General Instructions”)

Half Nut - Regulator

Screw - #10 x .50 Pinned Torx

Screw - #8 x .50 Pinned Torx

Screw - #8 x .62 Torx/Slot

Washer

Heat Exchanger

Tube - Drain

Cover - Cold Control

Cover - Dispenser Bottom

Screen - VR

Heater Strip

Switch - Rocker

FR Thermostat Assy.

Screw - 8-32 x .38 THTC

Screw - #10 x .75 HHSM

Nut - 1-1/4” Slip Joint

Gasket

Screw - #10-24 x .75 Socket Hd.

Strainer - Bright

Elbow - 5/16” x 1/4”

Torx Tool - T25

Torx Tool - T20

Hanger Bracket

PART NO. DESCRIPTION

*REPLACE WITH SAME COMPRESSOR USED

IN ORIGINAL ASSEMBLY.

NOTE: All correspondence pertaining to any of the

above water coolers or orders for repair parts MUST

include Model No. and Serial No. of cooler, name and

part number of replacement part.

Sold Separate

ITEM NO.

115V PARTS LIST

Dieses Handbuch passt für folgende Modelle

Andere Elkay Wasserspender Handbücher

Elkay

Elkay VRCTL Series Installationshandbuch

Elkay

Elkay EFA Series Installationshandbuch

Elkay

Elkay LZS8WS 2FQ Series Installationshandbuch

Elkay

Elkay VRCD Series Installationshandbuch

Elkay

Elkay EFHA14 1J Series Installationshandbuch

Elkay

Elkay EFA8 1L Series Installationshandbuch

Elkay

Elkay EZO8WS 1A Series Gebrauchsanweisung

Elkay

Elkay DSBWCB1 Installationshandbuch

Elkay

Elkay EFHFA8_2CJO Installationshandbuch

Elkay

Elkay EZSDWS 1F Series Installationshandbuch

Elkay

Elkay ezH2O LZWSM8 Series Installationshandbuch

Elkay

Elkay VRCHDTL8 1B Series Installationshandbuch

Elkay

Elkay EZO4 1B Series Installationshandbuch

Elkay

Elkay VRCTLFR Series Installationshandbuch

Elkay

Elkay EFY8*1B Installationshandbuch

Elkay

Elkay EFHA8 1M Series Installationshandbuch

Elkay

Elkay EHOA8*2D Installationshandbuch

Elkay

Elkay EIOA4 1B Series Installationshandbuch

Elkay

Elkay EZSTL8GL Leitfaden

Elkay

Elkay OFAVR14*1 Installationshandbuch

Elkay

Elkay VRC Series Installationshandbuch

Elkay

Elkay EMABF8TL Series Installationshandbuch

Elkay

Elkay Space-ette FD700-3 1J Series Installationshandbuch

Elkay

Elkay LVRC8-BAC Series Installationshandbuch

Beliebte Wasserspender Handbücher anderer Marken

Monarch Water

Monarch Water ULTIMATE MINI AQUA HE Bedienungsanleitung

Haier

Haier HLM-109B Bedienungsanleitung

abc

abc Fleck 5600SXT Bedienungsanleitung

GE GXOF18G Betriebsanleitung

Kenmore

Kenmore 625.385560 UltraFilter 650 Bedienungsanleitung

Innova

Innova CEV+ Kurzanleitung

Aries

Aries Hydra DI Handbuch

GE GNCF02H Bedienungsanleitung

ProFlo

ProFlo PFB Series Bedienungsanleitung

A.O. Smith

A.O. Smith FREZYA 300S Bedienungsanleitung

Frakco

Frakco Travelsoft RV 2400HD Bedienungsanleitung

Avanti

Avanti WD31EC Bedienungsanleitung

Avanti

Avanti WD360 Bedienungsanleitung

BRIO

BRIO CLCTTL520 Benutzerhandbuch

3M HCD-1 Bedienungsanleitung

Coway

Coway CHP-671L Bedienungsanleitung

Aqua Essentials

Aqua Essentials Borg & Overström B4 Bedienungsanleitung

KENT

KENT 11063 Handbuch