Elkay VRCTL Series Installationshandbuch

Page 1 1000002232 (Rev. D - 01/19)

VRCTL8*2CQ, LVRCTL8*2CQ

INSTALLATION, CARE & USE MANUAL

VRCTL™ Series Barrier-Free Water Coolers

NOTE: Non-refrigerated units do not include all electrical and refrigeration components

shown above.

Other components and rough-in are the same as shown.

6, 42, 43

1, 4

See Fig. 5

See Fig. 3

44 12

40 (TL)

44 35 8

38 (TL)

7, 39, 41

16 3, 23,

30,13

1, 4

3, 23, 30, 13

FIG. 1

USES HFC-134A REFRIGERANT

Note: Danger! Electric shock hazard. Disconnect power before servicing unit.

VRCTL8*2CQ, LVRCTL8*2CQ

Page 2

1000002232 (Rev. D - 01/19)

2 7/16"

63mm

10"

254mm

127mm

1 1/2"

38mm

37 1/2"

952mm

6 1/2"

166mm

ORIFICE

HEIGHT

ALTURA DEL

ORIFICIO

HAUTEUR DE

L'ORIFICE

ORIFICE

HEIGHT

ALTURA DEL

ORIFICIO

HAUTEUR DE

L'ORIFICE

1 3/8"

35mm 1 3/8"

35mm

5 3/4"

146mm 5 3/4"

146mm

1 3/8"

35mm 1 3/8"

35mm

5 3/4"

146mm 5 3/4"

146mm

18 1/16"

459mm

FINISHED FLOOR

PISO ACABADO

PLANCHER FINI

5/16" (8mm) DIA. (10 HOLES)

8mm (10 AGUJEROUS)

8mm (10 TROUS)

20 1/8"

511mm

4 1/2"

114mm

6 1/4"

159mm

18 3/4"

476mm

25 1/8"

638mm

3 1/2"

89mm

RIM HEIGHT

ALTURA DEL

ORIFICIO

HAUTEUR DE

L 'ORIFICE

18 5/8"

474mm

12 5/16"

312mm

4 3/4"

121mm

27"

686mm

31 7/8"

810mm

32 15/16"

837mm

39 1/2"

1003mm

2 5/8"

67mm

203mm

13 7/8"

351mm

20 3/8"

518mm

HANGER BRACKET

FIJADOR DE SUSPENSION

SUPPORT DE SUSPENSION

*6 3/4"

173mm

LEGEND/LEYENDA/LÉGENDE

A = RECOMMENDED WATER SUPPLY LOCATION 3/8 O.D. UNPLATED COPPER TUBE CONNECT STUB WITH SHUT OFF (BY OTHERS) 3 IN. (76mm) MAXIMUM OUT FROM WALL

B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/2” O.D. DRAIN STUB 2 IN. OUT FROM WALL

C = 1-1/2 TRAP NOT FURNISHED

D = ELECTRICAL SUPPLY (3) WIRE RECESSED BOX

E = INSURE PROPER VENTILATION BY MAINTAINING 6” (152 mm) (MIN.) CLEARANCE FROM CABINET LOUVERS TO WALL.

F = 7/16 BOLT HOLES FOR FASTENING UNIT TO WALL

FIG. 2

*REDUCE HEIGHT BY 3” FOR INSTALLATION OF CHILDREN’S ADA COOLER

** *

ADA REQUIREMENT

REQUISITO DE A.D.A.

EXIGENCE ADA

Page 3 1000002232 (Rev. D - 01/19)

VRCTL8*2CQ, LVRCTL8*2CQ

IMPORTANT

ALL SERVICE TO BE PERFORMED BY AN

AUTHORIZED SERVICE PERSON

HANGER BRACKETS & TRAP

INSTALLATION

1) Remove hanger bracket fastened to back of

cooler by removing one (1) screw.

2) Mount the hanger bracket and trap as shown

in Figure 2.

NOTE: Hanger Bracket MUST be supported

securely. Add xture support carrier if wall will

not provide adequate support.

IMPORTANT:

• 4 3/4 in. (121mm) dimension from wall to

centerline of trap must be maintained for proper

t.

• Anchor hanger securely to wall using all ve

(5) 1/4 in. dia. mounting holes.

3) Install straight valve for 3/8” O.D. tube.

INSTALLATION OF COOLER

4) Hang the cooler on the hanger bracket. Be

certain the hanger bracket is engaged properly

in the slots on the cooler back as shown in Figure

5) Loosen the two (2) screws holding the lower

front panel at the bottom of cooler base and

two (2) screws at the top (Use torx bits sold

separately). Remove the front panel and set

aside.

6) Connect water inlet line--See Note 4 of General

Instructions.

7) Remove the slip nut and gasket from the trap

and install them on the cooler waste line mak-

ing sure that the end of the waste line ts into

the trap. Assemble the slip nut and gasket to

the trap and tighten securely. Recommend

fastening cooler to wall using 7/16 bolt holes.

(See Fig. 2 “F”)

START UP

Also See General Instructions

8) Stream height is factory set at 45-50 PSI. If

supply pressure varies greatly from this, adjust

screw using the access hole in the pushbutton

(insert screwdriver). CW adjustment will raise

stream and CCW adjustment will lower stream.

For best adjustment, stream should hit basin

approximately 6-1/2” (165mm) from bubbler.

Fig. 3

VANDAL RESISTANT BUBBLER DETAIL

DETALLE DEL GRIFO RESISTENTE AL VANDALISMO

DESCRIPTION DU BARBOTEUR RESISTANT AU VANDALISME

ITEM

NO.

Filter Assy-1,500 Gal.

Kit-Filter Head Fittings, includes

John Guest 3/8” elbow tting

Assy-Filter & Bracket includes

Fltr Head/Mtg Bkt/John Guest

Fittings/Screws

51299C

98926C

0000000746

DESCRIPTION

PART

NO.

FILTER PARTS LIST

(See Fig. 4)

Fig. 4

2 2

BASIN

VRCTL8*2CQ, LVRCTL8*2CQ

Page 4

1000002232 (Rev. D - 01/19)

Fig. 5

(Refrigerated side shown)

44 (8)

40 (TL)

(Items 31 & 24 also

used on the LH unit)

313

Page 5 1000002232 (Rev. D - 01/19)

VRCTL8*2CQ, LVRCTL8*2CQ

97446C

0000000256

160270508640

1000001602

1000001994

0000000245

56121C

98773C

1000004447

35827C

1000002194

1000002195

110868642550

98530C

55931C

56092C

98778C

45929C

66703C

97824C

70002C

27124C

600985451640

28617C

0000000966

22897C

1000001906

75524C

55996C

100147140560

28596C

28519C

28522C

28516C

22955C

28525C

28528C

28539C

75588C

28536C

75588C

66743C

56237C

75570C

75661C

70864C

35826C

75520C

75523C

28551C

Kit - VR Bubbler

Kit - Compr Mtg Hardware

Strainer - Bright

Kit - Elbow 5/16” x 1/4” (3 Pack)

Kit - Tee 1/4” (3 Pack)

Kit - Fan Mtr/Blade/Nut/Screws

Elbow - Drain

Kit - Cold Control/Screw

Kit - Drain Tube Assy.

Internal Power Cord

Compressor Serv. Pak

Kit - Elect/Relay/Cover/Overload

Screw - #10-24 x .75 Socket Hd.

Kit - Regulator/Holder/Nut

Cover - Dispenser Bottom

Tubing - Poly (Cut To length)

Kit - Heat Exchanger/Drier

Tube - Drain

Drier

Kit - Evaporator Assembly

Screw - #10 x 1/2” Lg. HHSM

Cover - Cold Control

Drain Plug 1-1/2

Screen - VR

Kit - Basin - Replacement SS

Panel - Bottom Dispenser

Kit - Push Button Assy (VR)

Clip (Front & Rear Panels)

Strainer (See “General Instructions”)

Gasket - Drain

Panel - Screen

Panel - RH Dispenser Side

Panel - LH Dispenser Side

Panel - Dispenser Front

Panel - Front Lower

Panel - RH Rear

Panel - LH Rear

Panel - RH Rear TL

Nut - 1-1/4” Slip Joint

Panel - LH Rear TL

Gasket

Kit - Condenser/Drier

Shroud Fan

Screw - #10 x .50 Pinned Torx

Screw - #8 x .50 Pinned Torx

Screw - #8 x .62 Torx/Slot

Power Inlet

Torx Tool - T25

Torx Tool - T20

Hanger Bracket

PART NO. DESCRIPTION

*11

Sold Separate

ITEM NO.

220V-240V/50Hz ITEMIZED PARTS LIST

*REPLACE WITH SAME COMPRESSOR USED IN

ORIGINAL ASSEMBLY.

NOTE: All correspondence pertaining to any of the above water cool-

ers or orders for repair parts MUST include Model No. and Serial No.

of cooler, name and part number of replacement part.

PRINTED IN U.S.A. FOR PARTS, CONTACT YOUR LOCAL DISTRIBUTOR OR CALL 1.800.834.4816

ELKAY MANUFACTURING COMPANY • 2222 CAMDEN COURT • OAK BROOK, IL 60523 • 630.574.8484 • www.elkay.com

REPAIR SERVICE INFORMATION TOLL FREE NUMBER 1.800.260.6640

Fig. 6

220V/240V Detail

Fig. 7

Filter Installation Detail

NS = NOT SHOWN

Andere Handbücher für VRCTL Series

Dieses Handbuch passt für folgende Modelle

Andere Elkay Wasserspender Handbücher

Elkay

Elkay ezH2O Liv LBWD00 C Series Installationshandbuch

Elkay

Elkay EIOA8 1E Series Installationshandbuch

Elkay

Elkay EZTL Series Installationshandbuch

Elkay

Elkay VRCTLFR Series Installationshandbuch

Elkay

Elkay EFA25*2DJO Installationshandbuch

Elkay

Elkay VRCD B Series Installationshandbuch

Elkay

Elkay LZSG8WS 1B Series Gebrauchsanweisung

Elkay

Elkay EFHA14 1J Series Installationshandbuch

Elkay

Elkay EMABFDTL C Series Installationshandbuch

Elkay

Elkay EFA25 3C Series Installationshandbuch

Elkay

Elkay OFA25*2FJO Installationshandbuch

Elkay

Elkay FLEXI-GUARD EFW Deluxe Installationshandbuch

Elkay

Elkay ezH2O LBWD06BKK Bedienungsanleitung

Elkay

Elkay EFHFA8_2CJO Installationshandbuch

Elkay

Elkay EHFSA8 1K Series Installationshandbuch

Elkay

Elkay DSBWCT1 Installationshandbuch

Elkay

Elkay EFA25 3C Series Installationshandbuch

Elkay

Elkay EZF8 1F Series Installationshandbuch

Elkay

Elkay VRCGRN8 Series Gebrauchsanweisung

Elkay

Elkay ezH2O Liv Pro Bedienungsanleitung

Elkay

Elkay EMABFTL8 Series Installationshandbuch

Elkay

Elkay LBWD00XXC Installationshandbuch

Elkay

Elkay ezH2O LZWSM8 Series Installationshandbuch

Elkay

Elkay SWIRLFLO ERPB2-8C Installationshandbuch

Beliebte Wasserspender Handbücher anderer Marken

Monarch Water

Monarch Water ULTIMATE MINI AQUA HE Bedienungsanleitung

Haier

Haier HLM-109B Bedienungsanleitung

abc

abc Fleck 5600SXT Bedienungsanleitung

GE GXOF18G Betriebsanleitung

Kenmore

Kenmore 625.385560 UltraFilter 650 Bedienungsanleitung

Innova

Innova CEV+ Kurzanleitung

Aries

Aries Hydra DI Handbuch

GE GNCF02H Bedienungsanleitung

ProFlo

ProFlo PFB Series Bedienungsanleitung

A.O. Smith

A.O. Smith FREZYA 300S Bedienungsanleitung

Frakco

Frakco Travelsoft RV 2400HD Bedienungsanleitung

Avanti

Avanti WD31EC Bedienungsanleitung

Avanti

Avanti WD360 Bedienungsanleitung

BRIO

BRIO CLCTTL520 Benutzerhandbuch

3M HCD-1 Bedienungsanleitung

Coway

Coway CHP-671L Bedienungsanleitung

Aqua Essentials

Aqua Essentials Borg & Overström B4 Bedienungsanleitung

KENT

KENT 11063 Handbuch