Empire Comfort Systems BDB34BL Fehlerbehebungshandbuch

44026-1-0723 Page 1

Empire Comfort Systems Inc. • Belleville, IL

FOR USE WITH:

(A)BVD34FP, (A)BVD36FP AND (A)BVP42FP FIREPLACE MODEL SERIES

BIFOLD GLASS DOOR MODELS

BDB34BL BDB36BL BDB42BL

(For Use With (A)BVD34FP

Fireplace Model Series)

(For Use With (A)BVD36FP

Fireplace Model Series)

(For Use With (A)BVP42FP

Fireplace Model Series)

WARNING

Please read these instructions carefully before starting the installation. Failure to follow these

installation instructions may result in a possible re hazard and will void the warranty. These

instructions must be left with the appliance for future reference.

IMPORTANT NOTICES

1. Be sure these instructions become the

property of, and are reviewed by, all future

users of the replace to encourage proper

installation and operation of the glass doors.

2. Read these instructions entirely before

beginning the installation. Save the

instructions for future reference.

3. All parts used with the replace system

must be installed in accordance with these

installation instructions. Failure to do so

may be hazardous and will void the warranty.

4. Check to make sure all parts are included

prior to assembly. See parts list on page 4

for reference.

5. Tools needed for installation includes

standard and Phillips screwdrivers, and a

5/16" nutdriver.

6. CAUTION: Sharp edges. Wear gloves and

safety glasses when installing the glass

door

components.

7. Decorative non-combustible trim or nishing

materials must not extend beyond the rebox

side openings. Any materials that extend

past the rebox side opening will interfere

with the operation of the glass doors.

Bifold doors must be in the fully open

position when operating the replace.

INSTALLATION INSTRUCTIONS

AND OPERATION MANUAL

GAS-FIRED

UL FILE NO.

MH45034

44026-1-0723Page 2 Empire Comfort Systems Inc. • Belleville, IL

INSTALLATION

Pre-install the two glass door spring clips at each end

of the top door track as shown in Figure 1. Use four

#8 x 1/2" Ph Hd screws to attach the clips, but do not

fully tighten.

SPRING CLIP

#8x½” PH. TRUSS HD.

NOTE: Door track illustrated upside down for clarity.

Figure 1

Install the Upper Door Track to the replace as shown in

Figure 2 using two #8 x 1/2" Ph Truss Hd screws at each

end. Match up the holes in the track end tabs with the pilot

holes in the sides of the replace. See Figure 2.

UPPER DOOR TRACK

Figure 2

3. Install the Canopy by rst removing the upper louver

assembly (if applicable). Flush face replace models will

have a 3/8" high opening just above the rebox that will

accept the canopy’s rear tabbed ange. With the canopy

tilted slightly upward, insert the canopy so that the rear

locator tabs lock into the slots located in the rebox top.

Rotate the canopy downward and install one #10 x 1/2"

Hex Hd screw at the center of the canopy. This screw

will be installed from inside the rebox. The location is

midway between the two rescreen rods at the center of

the replace. Secure the canopy with this screw, but do

not overtighten. See gure 3.

PLACE REAR TABS ON

CANOPY INTO SLOTS

IN FIREBOX TOP

CANOPY

#10x½” HEX HD. SCREW

TOP DOOR TRACK

Figure 3

4. Install the decorative handles to the Right and Left Bifold

Glass door assemblies as shown by the exploded parts

view, Figure 8. To install the door handles, place a #6

at washer on each handle screw, then insert four #8 x

7/8" screws from the rear of the door trim and secure

into the handles. Do not overtighten.

UPPER

DOOR

TRACK

#8 x 1/2" PH.

TRUSS HD.

SPRING

CLIP

#10 x 1/2"

HEX HD.

SCREW

CANOPY

TOP

DOOR

TRACK

PLACE REAR TABS ON

CANOPY INTO SLOTS

IN FIREBOX TOP

44026-1-0723 Page 3

Empire Comfort Systems Inc. • Belleville, IL

INSTALLATION

5. Install the Right Bifold Door assembly as shown in

Figure 4. With the door folded up, insert the bottom

door pivot pin into the receiving hole located in the

rebox bottom return ange. Swing the top of the door

assembly outward and engage the top pivot pin into the

hole located in the spring clip. Adjust the spring clip left

or right with the door in the open position, then snug the

spring clip screws as necessary to check door alignment

with the upper track. The gap above the door should be

equal across the top for proper door operation. Once

adjusted as desired, gently open doors, then tighten

screws to secure spring clips.

Figure 4

6. Repeat step 5 to install the Left hand Bifold Door

assembly. Make adjustments as necessary on the bifold

doors to achieve the best alignment and operation.

Figure 5 shows the completed installation of the bifold

doors and canopy.

Figure 5

DOOR OPERATION

OPERATE THE FIREPLACE WITH THE BIFOLD GLASS DOORS IN ONLY THE FULLY OPEN POSITION.

NOTE: Always close the mesh rescreens when operating the replace with the glass doors open.

FULLYOPEN DOORS

CORRECT DOOR POSITION WHEN

OPERATING THE FIREPLACE

Figure 6

PARTIALLYOPEN DOORS.

INCORRECT DOOR POSITION WHEN

OPERATING THE FIREPLACE

Figure 7

WARNING

DO NOT operate the replace with the doors partially

open or closed. Operating the replace with the doors

partially open or closed creates a hazardous situation.

PARTIALLYOPEN DOORS.

INCORRECT DOOR POSITION WHEN

OPERATING THE FIREPLACE

PARTIALLYOPEN DOORS.

INCORRECT DOOR POSITION WHEN

OPERATING THE FIREPLACE

44026-1-0723Page 4

MAINTENANCE

www.empirecomfort.com

Empire Comfort Systems Inc.

Belleville, IL

If you have a general question

about our products, please e-mail

us at [email protected].

If you have a service or repair

question, please contact your dealer.

•

Do not use abrasive cleaners on the glass, trim, or canopy

components. Abrasive cleaners will harm the nish and

could weaken the tempering qualities of the glass.

•

When cleaning is necessary, use only a soft cloth, mild soap

and water. Painted surfaces should only be cleaned with

a soft, damp cloth. Always let the glass doors completely

cool prior to cleaning.

•

Repair or replacement parts are available through

your dealer. Refer to the exploded parts illustration for

identication.

EXPLODED VIEW AND PARTS LIST

INDEX

NUMBER

PART NUMBER DESCRIPTION QUANTITY

BDB34BL BDB36BL BDB42BL

1 44017 44019 44021 Bifold Door Assembly, Left 1

2 44016 44018 44022 Bifold Door Assembly, Right 1

3 19483 19495 19500 Door Track 1

4 19842 19494 19499 Canopy 1

5 R7882 R7882 R7882 Handle 2

6 R8112 R8113 R8114 Glass Panel 4

7 R10165 R10165 R10165 Screw M4 x 16mm 4

8 R8119 R8119 R8119 Clip, Door Spring 2

9 R3580 R3580 R3580 Screw #8-18 x 1/ 2 " 8

10 R2737 R2737 R2737 Screw #10 x 1/2" 1

11 R8126 R8126 R8126 Clip, Glass Retainer 16

12 R8118 R8118 R8118 Door Pin 6

13 R8161 R8161 R8161 Screw 6

14 R8162 R8162 R8162 Nut 6

N/S R11514 R11514 R11514 Washer, Flat #6 4

Dieses Handbuch passt für folgende Modelle

Andere Empire Comfort Systems Kaminzubehör Handbücher

Empire Comfort Systems

Empire Comfort Systems DF362NB-1 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems DVP20CCKR-1 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems LS40STB Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems DVP32NKR Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems BDO36SS Fehlerbehebungshandbuch

Empire Comfort Systems

Empire Comfort Systems DVVK-4FV Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems LS-24-1 EF Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems 37506 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems LS18WRS-1 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems LK7-1 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems DVP1SKR-1 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems EBL74TK Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems DVVK4F-1 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems EBL34TK Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems LS18CD-1 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems LK6-2 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems LS48THF-1 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems HMFATV-1 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems DVP50PFB Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems EMBF-1S-C-1 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems 41052 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems MFL-48UH-1 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems DFB20CCBL-1 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems ADVANTAGE Series Service-Handbuch

Beliebte Kaminzubehör Handbücher anderer Marken

Valor

Valor L2 1700K Bedienungsanleitung

Exodraft

Exodraft Xzense Bedienungsanleitung

Whalen

Whalen Ruso MNFP62BF23-6 Bedienungsanleitung

Lopi

Lopi Hearthview 864 Bedienungsanleitung

Woodstock Soapstone

Woodstock Soapstone Fireview 201 Bedienungsanleitung

EdilKamin

EdilKamin SERBATOIO 250 Kurzanleitung

Bronpi

Bronpi KIT-1 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150051 Bedienungsanleitung

Travis Industries

Travis Industries 33 DVI Bedienungsanleitung

Superior

Superior ASD3628-TI Bedienungsanleitung

pleasant hearth

pleasant hearth OFP28WG Bedienungsanleitung

IHP

IHP Astria Series Bedienungsanleitung

Firegear

Firegear FG-H-2110SS Bedienungsanleitung

Nibe

Nibe Contura C i31 Bedienungsanleitung

kozy heat

kozy heat KZK-052 Bedienungsanleitung

SimpliFire

SimpliFire SF-WM36 Bedienungsanleitung

Bluegrass Living

Bluegrass Living BC18NR Kurzanleitung

pleasant hearth

pleasant hearth IRIS SCROLL Bedienungsanleitung