Evikon PluraSens E2670-PID Bedienungsanleitung

PluraSens®

Flameproof

Solvent Vapor Detector-Transmitter

E2670-PID

User Manual

E2670-PID Rev 10.05.2023

Table of contents

Acetone 4

Benzene 5

Ethanol 6

Ethyl acetate 7

Toluene 8

Xylene 9

Speciﬁcations 10

Product description 12

Safety requirements 12

Operating conditions 13

Installation guidelines 13

Mounting dimensions 15

Electrical connections 16

Correct and incorrect cabling for 24 VAC 18

Operation 19

Properties of VOC: ionization energy, the correction factor 20

Calibration and maintenance 29

Delivery set 33

Order code for E2670-PID options 33

Conﬁguring 34

Return to default settings 34

Modbus RTU Communication 35

RS485 communication interface 35

Communication parameters 35

E2670-PID Rev 10.05.2023

Modbus holding registers 35

Warranty 40

Manufacturer contacts 40

E2670-PID Rev 10.05.2023

Acetone

A colorless organic solvent with a characteristic pungent odor that is volatile and

ﬂammable with the chemical formula (CH3)2CO.

Synonyms/Trade Names: Dimethyl ketone, Ketone propane, 2-Propanone.

Chemical formula

(CH3)2CO

Molar weight

Relative gas density (to air)

2.0

Conversion*

1 ppm = 2.38 mg/m3

Boiling point

56.11 °C

Low explosive limit (LEL), % vol. in air

2.5

Upper explosive limit (UEL), % vol. in air

12.8

Odor

Characteristic pungent smell

Hazards

Highly ﬂammable.

Slightly toxic in normal use. Irritant causing mild skin

irritation and moderate to severe eye irritation. At high

vapor concentrations, it may depress the CNS.

Exposure limits

8 hours

(2000/39/EC)

1900 mg/m3/ 500 ppm

NIOSH REL TWA

590 mg/m3/250 ppm

IDLH (NIOSH)

2500 ppm [10%LEL]

E2670-PID Rev 10.05.2023

Benzene

A colorless liquid with an aromatic odor that is highly ﬂammable with the molecular

formula C6H6.

Synonyms/Trade Names: Benzol, Phenyl hydride.

Chemical formula

C6H6

Molar weight

Relative gas density (to air)

2.69

Conversion*

1 ppm = 3.19 mg/m3

Boiling point

80 °C

Low explosive limit (LEL), % vol. in air

1.2

Upper explosive limit (UEL), % vol. in air

7.8

Odor

Hyacinth-like odor

Hazards

Highly ﬂammable.

Irritant. Carcinogen.

May cause dizziness; headache, nausea, staggering

gait; anorexia, lassitude.

Target organs: eyes, skin, respiratory system, blood,

central nervous system, bone marrow.

Exposure limits

(NIOSH REL)

Ca TWA

0.319 mg/m3/0.1 ppm

STEL

15 minutes

1 ppm

Ca IDLH

500 ppm

E2670-PID Rev 10.05.2023

Ethanol

A clear colorless liquid with a faintly sweet odor and pungent taste.

Synonyms/Trade Names: ethyl, alcohol.

Chemical formula

CH3CH2OH

Molar weight

Relative gas density (to air)

1,59

Conversion*

1 ppm = 1.89 mg/m3

Boiling point

78.37°C

Low explosive limit (LEL), % vol. in air

3 - 3.3

Upper explosive limit (UEL), % vol. in air

Odor

The characteristic smell of alcohol

Hazards

Highly ﬂammable.

Gas/air mixtures are explosive.

Inhalation of vapors leads to cough, headache, fatigue,

and drowsiness. High concentrations may damage the

fetus. Repeated high exposure may affect the liver and

the nervous system.

Exposure limits

according to

Commission

Directive 2006/15/EC

TWA

8 hours

1210 mg/m3/ 1000 ppm

STEL

15 minutes

E2670-PID Rev 10.05.2023

Ethyl acetate

A colorless organic compound with a sweet pear-like smell that is highly ﬂammable.

Synonyms/Trade Names: ethyl ester, acetic ester, EA, EtOAc.

Chemical formula

C4H8O2

Molar weight

Conversion*

1 ppm = 3.60 mg/m3

Boiling point

77.1 °C

Low explosive limit (LEL), % vol.

in air

Upper explosive limit (UEL), %

vol. in air

11.5

Odor

Sweet “pear” smell

Hazards

Flammable.

Short-term exposure to high levels of ethyl acetate results ﬁrst in

irritation of the eyes, nose, and throat, followed by headache,

nausea, vomiting, sleepiness, and unconsciousness.

Exposure limits

(NIOSH)

TWA

8 hours

1400 mg/m3/400 ppm

IDLH

2000 ppm [10%LEL]

E2670-PID Rev 10.05.2023

Toluene

A clear, colorless liquid with a sweet smell that is highly ﬂammable.

Synonyms/Trade Names: methylbenzene, phenylmethane.

Chemical formula

C6H5CH3

Molar weight

Conversion*

1 ppm = 3.77 mg/m3

Boiling point

110.7°C

Low explosive limit (LEL), % vol.

in air

1.1 - 1.27

Upper explosive limit (UEL), %

vol. in air

6.75–7.1

Odor

Characteristic “chemical” smell

Hazards

Highly ﬂammable.

Gas/air mixtures are explosive.

Inhalation possible effects: irritation eyes, nose; lassitude

(weakness, exhaustion), confusion, euphoria, dizziness,

headache; dilated pupils, lacrimation (discharge of tears); anxiety,

muscle fatigue, insomnia; paraesthesia; dermatitis; liver, kidney

damage

Exposure limits

according to

Commission

Directive

2006/15/EC

TWA

192 mg/mm3/ 50 ppm

STEL

384 mg/mm3/ 100 ppm

E2670-PID Rev 10.05.2023

Xylene

A colorless, ﬂammable liquid with a chemical smell. Xylenes are produced by the

methylation of toluene and benzene.

The term is used for any of three isomers of dimethylbenzene, or a combination thereof.

Synonyms/Trade Names: xylol, dimethylbenzene.

Chemical formula

C6H4(CH3)2

Isomers

ortho-xylene meta-xylene para-xylene

Molar weight

106

Conversion*

1 ppm = 4.34 mg/m3

Boiling point

144.4 °C

139 °C

138.35 °C

Low explosive limit (LEL), % vol.

in air

0.9 - 1.1

Upper explosive limit (UEL), % vol.

in air

6.0–7.0

Odor

Characteristic “chemical” smell

Hazards

Flammable.

Inhaling can cause dizziness, headache, drowsiness, and nausea.

Exposure limits

according to

Commission

Directive

2000/39/EC

TWA

8 hours

221 mg/mm3/ 50 ppm

STEL

15 minutes

442 mg/mm3/ 100 ppm

Conversion of ppm to mg/m3is calculated for 25°C and 1 atm.

E2670-PID Rev 10.05.2023

Speciﬁcations

Detected gases

VOCs with ionisation potential < 10.6 eV

Sampling method

Diffusion

Sensor type

Photoionization detector

Calibration

Isobutylene

Order code

E2670-PID-40

E2670-PID-200

Typical detection range

0...40 ppm (isobutylene)

0...200 ppm (isobutylene)

Resolution / digital unit

0,01 ppm

1 ppm

Response time T90

< 3 s

Sensor lifetime

5 years

Calibration interval

Monthly or more frequently depending on operating conditions

Signal update

Every 1 second

Load resistance

RL< (Us - 2 V) / 22 mA for 4-20 mA

RL> 250 kOhm for 0-10 V mode

Digital interface

RS485, Modbus RTU protocol

No galvanic isolation

Power supply

12...36 VDC (default),

24 VAC or 230 VAC as options

Power consumption

< 2 VA

Analog outputs

2 × 4-20 mA / 0-10 V, user settable

Relay outputs

2 × SPST, max 5 A, 30 VDC / 250 VAC

Outputs assignment

OUT1 2 gas; OUT2 2 gas

Outputs scale width

> 10 × resolution

Recommended: 20-100% of the detection range

Cable connections

Screwless spring-loaded terminals

Enclosure

Grey die-cast aluminum, wall mount, protection class IP65

Dimensions

H155 × W145 × D110 mm

H155 × W155 × D110 mm (with one cable gland)

H155 × W165 × D110 mm (with two cable glands)

Protection

Flameproof, ATEX: II 3G Ex d IIC T6 Gc

II 3D Ex tb IIIB Ip65 T85°C Dc

ATEX Approvals

Enclosure:

Inhaltsverzeichnis

Andere Evikon Sender Handbücher

Evikon

Evikon PluraSens E2638-Cl2 Bedienungsanleitung

Evikon

Evikon PluraSens E2648-HFC Bedienungsanleitung

Evikon

Evikon PluraSens E2670-O2 Bedienungsanleitung

Evikon

Evikon PluraSens E2608-NO Bedienungsanleitung

Evikon

Evikon PluraSens E2638-O3 Bedienungsanleitung

Evikon

Evikon PluraSens E2638-NH3-E Bedienungsanleitung

Evikon

Evikon PluraSens E2418DP Bedienungsanleitung

Evikon

Evikon PluraSens E2608-C2H4 Bedienungsanleitung

Evikon

Evikon PluraSens E2660-CO-NO Bedienungsanleitung

Evikon

Evikon PluraSens E2618-NO Bedienungsanleitung

Evikon

Evikon PluraSens E2618-LEL Bedienungsanleitung

Evikon

Evikon PluraSens E2618 Series Bedienungsanleitung

Evikon

Evikon PluraSens E2670-NO2 Bedienungsanleitung

Evikon

Evikon PluraSens E2611-HFC Bedienungsanleitung

Evikon

Evikon PluraSens E2648-ETO Bedienungsanleitung

Evikon

Evikon PluraSens E2608-PID Bedienungsanleitung

Evikon

Evikon PluraSens E2618-C2H4 Bedienungsanleitung

Evikon

Evikon PluraSens E2670-LEL Bedienungsanleitung

Evikon

Evikon PluraSens E2618 Series Bedienungsanleitung

Evikon

Evikon PluraSens E2648-H2S Bedienungsanleitung

Evikon

Evikon PluraSens E2648-NH3-E Bedienungsanleitung

Evikon

Evikon PluraSens E2618-SO2 Bedienungsanleitung

Evikon

Evikon PluraSens E2611-NH3 Bedienungsanleitung

Evikon

Evikon E2618-NH3 Bedienungsanleitung

Beliebte Sender Handbücher anderer Marken

NIVELCO

NIVELCO EasyTREK SCA-300 Series Betriebsanleitung

Honeywell

Honeywell 5816WMBR Bedienungsanleitung

Kamstrup

Kamstrup READy MTU Betriebsanleitung

Omega

Omega ZW Series Bedienungsanleitung

ABB

ABB Field 264H Leitfaden

Alinco

Alinco DJ-V17T Bedienungsanleitung

Dejero

Dejero EnGo 3x Bedienungsanleitung

Rosemount

Rosemount 4600 Bedienungsanleitung

Speaka Professional

Speaka Professional 2342740 Bedienungsanleitung

trubomat

trubomat GAB 1000 Bedienungsanleitung

Teledyne Analytical Instruments

Teledyne Analytical Instruments LXT-380 Bedienungsanleitung

Rondish

Rondish UT-11 Bedienungsanleitung

MG 10JRE Bedienungsanleitung

Burkert

Burkert 8177 Bedienungsanleitung

Firetide

Firetide HotPort 3203 Handbuch

Tele Radio

Tele Radio T9-02 Bedienungsanleitung

Rotronic

Rotronic HygroFlex HF3 Series Bedienungsanleitung

Jamara

Jamara FCX6 Pro Tel Bedienungsanleitung