FiveStar *TN525-7BW Bedienungsanleitung

INSTALLATION INSTRUCTIONS

PROFESSIONAL RANGE MODELS

48” DUAL FUEL,CONVECTION,SELF-CLEAN WITH OPEN BURNERS**

48” NATURAL GAS MODELS

*TN525-7BW

*TN525-7W

**THESE MODELS ARE FIELD CONVERITBLE FOR LP/PROPANE GAS.**

48” LP/PROPANE GAS MODELS

*PN525-7BW

*PN525-7W

**THESE MODELS ARE FIELD CONVERTIBLE FOR NATURAL GAS.**

IF YOU HAVE QUESTIONS,CALL 800-251-7224, 8AM TO 5PM EASTERN TIME,OR VISIT OUR

WEBSITE,WWW.FIVESTARRANGE.COM.

Installation Instructions

BEFORE YOU BEGIN

CAUTION:

Read these instructions completely and

carefully.

THESE RANGES SHOULD BE INSTALLED IN

CONJUNCTION WITH A SUITABLE

OVERHEAD VENT HOOD. Due to the high heat

capacity of this unit, particular attention should be paid to the hood

• IMPORTANT -Save these instructions for local

duct work installation to assure it meets local building codes.

inspector's use.

• IMPORTANT - Observe all governing codes and

Standard countertop installations:

ordinances.

A 1200 CFM hood is recommended for 48" & 60" ranges.

A 600 CFM hood is recommended for 30" & 36" ranges.

• Note to Installer - Be sure to leave these instructions

with the Consumer.

Hoods should be 24" min. deep and at least the same width as the

cooktop. FiveStar hoods may be installed from 24” to 30” above the

• Note to Consumer - Keep these instructions for future

cooking surface. A minimum of 28” is required when a FiveStar

reference.

Backsplash with warming shelves is used.

• FiveStar recommends this product be installed by a

Check local building codes for the proper method of gas range

licensed professional.

installation. Local codes vary. Installation, electrical connections and

grounding must comply with applicable codes. In the absence of local

• Product failure due to improper installation is not covered

codes, the gas range should be installed in accordance with the

under the Warranty.

National Fuel Gas Code ANSI 223.1, latest edition and National

Electrical Code ANSI/NFPA 70, latest edition.

WARNING:

This appliance must be properly grounded.

CAUTION:

In the Commonwealth of Massachusetts:

These ranges weigh up to 510 pounds. Some

• This product must be installed by a licensed plumber or

gas

disassembly will reduce the weight considerable. Due to

fitter.

the weight and size of the range and to reduce the risk of

personal injury or damage to the produce and/or damage

• When using ball type gas shut-off valves, they shall be T

to the floor, TWO PEOPLE ARE REQUIRE FOR PROPER

handle type.

INSTALLATION.

• A flexible gas connector, when used, must not exceed

Three (3) feet.

INSTALLATION INSTRUCTIONS

Please read these instructions

before attempting to install this

range

Inspection and Unpacking

Check the range carton for visible

damage. If there is damage or even

creases in the carton, contact the

carrier, request an inspection and file

the appropriate freight claim. Do not

refuse shipment. Responsibility for

shipping damage is with the carrier

and the dealer or end user. Cut the

shipping straps, then carefully lift the

carton up from the range. This will

help eliminate possible damage to the

backguard that is packed in the top of

the range carton.

Remove, unwrap and temporarily lay

aside any parts that are not attached

to the range. Make sure no parts are

left in the carton for accidental

disposal. Carefully inspect the range

for damage.

STEP 1

REMOVE PACKAGING

Before moving the range indoors:

Remove outer carton and packing material from the

shipping base. The range is now ready for removal

from the wooden base.

STEP 2

Due to the weight of these ranges, use a dolly with

soft wheels to move this range.

Lift the range onto the dolly and move indoors.

The range should be placed onto sliders to

prevent damage to the floor.

STEP 3

To simplify handling and to reduce the weight of

the range:

Remove the grates and the drawers below the

Knobs (on grill and griddle models).

Remove grill or griddle.

Remove the broiler pans, racks and literature

Package from inside oven(s).

STEP 5

CONNECTING THE RANGE TO ELECTRIC

WARNING:

THIS APPLIANCE MUST BE CONNECTED AS SHOWN IN FIGURE 1 OR 2. IF

A CORD IS UTILIZED IT MUST BE RATED AT 250 VOLTS, 40 AMPERES AND

CERTIFIED FOR USE ON HOUSEHOLD RANGES.

ELECTRICAL REQUIREMENTS FOR DUAL FUEL RANGES:

240 volts, 60 Hz, 35 amps

STEP 7

CONNECTING THE RANGE TO GAS

Because hard piping restricts When using test pressures greater

movement of the range, the use of an than ½psig to pressure test the gas

A.G.A. certified flexible metal supply system of the residence,

appliance connector is recommended disconnect the range and individual

unless local codes require a hard- shut-off valve from the gas supply

piped connection. piping. When using test pressures

of ½psig or less to test the gas

Never use an old connector when supply system, simply isolate the

installing a new range. If the hard range from the gas supply system

piping method is used, you must by closing the individual shut-off

carefully align the pipe; the range valve.

cannot be moved after the connection

is made.

To prevent gas leaks, put pipe joint

compound on, or wrap pipe thread *Teflon: Registered trademark of Dupont.

with Teflon* tape all around male

(external) pipe threads.

7-1. Remove the left most burner pan.

Locate the pressure regulator

Left of the rear burner.

7-2. Install a manual gas shut-off valve

in the gas line in an easily accessed

location outside the range. Make

sure everyone operating the range

knows where and how to shut off the

gas supply to the range.

7-3. Install male ½” flare union adapter

to the ½” NPT internal thread at

inlet of the regulator. Use a backup

wrench on the regulator fitting to

avoid damage.

7-4. Install male ½” or ¾” flare union

adapter to the NPT internal thread

of the manual shut-off valve, taking

care to back-up the shut-off valve

to keep it from turning.

7-5. Connect flexible metal appliance

connector to the adapter on the range.

Position range to permit connection at

the shut-off valve or vise versa.

7-6. When all connections have been made,

make sure all range controls are in the

off position and turn on the main gas

supply valve. Use a liquid leak detector

at all joints and connections to check

for leaks in the system.

STEP 8

LEVEL THE RANGE

1. Remove shipping tape from the leveling

legs.

2. Carefully slide the range into position.

Be careful not to damage the floor or

entangle power cord and gas flexible

tubing.

3. To adjust leveling legs, turn counter-

clockwise to raise the range; clockwise

to lower. “Channel-lock” type pliers are

recommended. Avoid using a pipe wrench

which can scar the legs.

IMPORTANT: The range should always be

installed at countertop height or higher. DO

NOT INSTALL THE RANGE LOWER THAN

ADJACENT COUNTERTOP HEIGHT, DUE

TO RISK OF A FIRE HAZARD

STEP 10

ASSEMBLE SURFACE BURNER COMPONENTS

•Remove shipping screw from each surface burner.

•Remove each surface burner.

•Place drip pan in position under each burner. Locate “dimples”.

•Re-install surface burners.

•Install burner pans.

•Install burner grates.

STEP 11

SURFACE BURNER OPERATION

OPEN SURFACE BURNERS

•Check for proper ignition:

−Push in one control knob and turn 180° counter clock-

wise to LITE position.

−The igniter will spark and the burner will light; the

igniter will continue sparking until the knob is turned

from the light position.

−First test may require some time, while air is flushed

out of the gas line.

−Turn knob to OFF.

−Repeat the procedure for each burner.

•Burner flames should be blue and stable with no

yellow or yellow tips, excessive noise or lifting of the

flame from the burner. If any of these conditions exist,

check that the burner ports are not blocked, and check

the air mixture. If one of these conditions continues,

call for service.

STEP 12

OVEN OPERATION

GAS OVEN

•Turn oven thermostat knob counter clockwise to 350°.

•The oven burner should light within 60 seconds.

ELECTRIC OVEN

•Turn oven thermostat knob counter clockwise to 350°

in bake position. It will take a couple of minutes before

a change in color will occur to the lower element.

•Turn oven thermostat knob to broil position. It will take

a couple of minutes before a change in color will occur

to the upper element.

GRIDDLE OPERATION

•Turn griddle thermostat knob counter clockwise to 350°.

•The griddle burner should light within 60 seconds.

STEP 13

GAS & ELECTRIC SUPPLY

•Turn gas supply “on”.

•Turn electric supply “on”.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere FiveStar Reichweite Handbücher

FiveStar

FiveStar TPN310-7 Installationsanleitung

FiveStar

FiveStar WPN6377W Bedienungsanleitung

FiveStar

FiveStar TTN287-BSW Bedienungsanleitung

FiveStar

FiveStar TPN335-BGW Installationsanleitung

FiveStar

FiveStar TPN4807BW Bedienungsanleitung

FiveStar

FiveStar TTN537-7BSW Bedienungsanleitung

FiveStar

FiveStar TTN275-W Bedienungsanleitung

FiveStar

FiveStar TN-637-7BW Bedienungsanleitung

FiveStar

FiveStar TN537-7BW Series Bedienungsanleitung

FiveStar

FiveStar TN491-7BW Series Bedienungsanleitung

FiveStar

FiveStar TN331-7W Bedienungsanleitung

FiveStar

FiveStar *tn281-7w Bedienungsanleitung

FiveStar

FiveStar TTN531-7BSW Bedienungsanleitung

FiveStar

FiveStar TTN311-7W Bedienungsanleitung

FiveStar

FiveStar TTN510-7BSW Bedienungsanleitung

FiveStar

FiveStar TN331-7BW Bedienungsanleitung

FiveStar

FiveStar TTN331-7BW Bedienungsanleitung

FiveStar

FiveStar TTN311-7BW Bedienungsanleitung

FiveStar

FiveStar TTN281-7BSW Bedienungsanleitung

FiveStar

FiveStar WTN5317W Bedienungsanleitung

FiveStar

FiveStar 36 Installationsanleitung

FiveStar

FiveStar TPN310-7 Bedienungsanleitung

FiveStar

FiveStar *tn281-7bw Bedienungsanleitung

FiveStar

FiveStar 24 Range Montageanleitung

Beliebte Reichweite Handbücher anderer Marken

Samsung

Samsung FCQ321HTUW Bedienungsanleitung

Kenmore

Kenmore 790.45712 Bedienungsanleitung

Wolf

Wolf CHR CHSSR Bedienungsanleitung

Smeg

Smeg Built-in Microwave Oven Bedienungsanleitung

Zanussi

Zanussi ZCG054G Bedienungsanleitung

Whirlpool

Whirlpool 8575985-W Stücklistenhandbuch

Frigidaire

Frigidaire 316000635 Bedienungsanleitung

GE JCSS630 Bedienungsanleitung

Samsung

Samsung NX58M9960P series Bedienungsanleitung

Hotpoint

Hotpoint RB524R Installationsanleitung

Whirlpool

Whirlpool Roper FGP305KW3 Bedienungsanleitung

Amana

Amana ART6610 SERIES Bedienungsanleitung

Maytag

Maytag MERH770WB Bedienungsanleitung

Fulgor Milano

Fulgor Milano SOFIA Bedienungsanleitung

Premier

Premier EF-4358GH Bedienungsanleitung

Kenmore

Kenmore 790.9010 Series Bedienungsanleitung

KitchenAid

KitchenAid KESC300 Bedienungsanleitung

Frigidaire

Frigidaire FFEF3012LS Benutzerhandbuch