Fujitsu PRIMERGY S60 Bedienungsanleitung

Primergy

PRIMERGY S60

Storage Subsystem

Xenia Fierley

Fujitsu Siemens Computers GmbH cognitas PS

81730 München

e-mail: email:[email protected]

Tel.: (089) 61001-157

Fax: 0 700 / 372 00000

U41221-J-Z156-1-74

Sprachen: En

Edition September 2001

This manual is printed on

paper treated with

chlorine-free bleach.

Comments…Suggestions…Corrections…

The User Documentation Department would like to know

your opinion on this manual. Your feedback helps us to

optimize our documentation to suit your individual needs.

Fax forms for sending us your comments are included at the

back of the manual.

There you will also find the addresses of the relevant User

Documentation Department

Delivery subject to availability; right of technical modifications reserved.

All hardware and software names used are trademarks of their respective manufacturers.

This manual was produced by

cognitas. Gesellschaft für Technik-Dokumentation mbH

www.cognitas.de

German

English

U41221-J-Z156-1-74

Contents

1Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

1.1 Target Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

1.2 Notation Conventions . . . . . . . . . . . . . . . . . . . . . . . 2

1.3 Structure of the Manual . . . . . . . . . . . . . . . . . . . . . . 3

1.4 Technical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

2 Important Notes . . . . . . . . . . . . . . . . . . . . . . . . . 7

2.1 Notes on Safety . . . . . . . . . . . . . . . . . . . . . . . . . . 7

2.2 Electrostatic Sensitive Device Label . . . . . . . . . . . . . . . . 9

2.3 CE certificate . . . . . . . . . . . . . . . . . . . . . . . . . . 10

2.4 RFI Suppression . . . . . . . . . . . . . . . . . . . . . . . . . 10

2.5 FCC notices (Federal Communications Commission) . . . . . . 10

2.6 Notes on the Rack Model . . . . . . . . . . . . . . . . . . . . 11

2.7 Notes on Transportation . . . . . . . . . . . . . . . . . . . . . 11

2.8 Environmental Protection . . . . . . . . . . . . . . . . . . . . 12

3 Operating and Indicator Elements . . . . . . . . . . . . . . 15

3.1 The Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

3.1.1 Meaning of the S60 Operating Status LEDs . . . . . . . . . . . 16

3.1.2 The Control LEDs for the Hard Disk Drives . . . . . . . . . . . 18

3.2 The Rear Side . . . . . . . . . . . . . . . . . . . . . . . . . . 20

3.2.1 FFx-RAID Controller Module LEDs . . . . . . . . . . . . . . . 20

3.2.2 Power Supply Unit LEDs . . . . . . . . . . . . . . . . . . . . . 21

3.2.3 Power Switch . . . . . . . . . . . . . . . . . . . . . . . . . . 22

3.3 Fan LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

4 Floorstand Model . . . . . . . . . . . . . . . . . . . . . . . . 25

4.1 Open the Housing . . . . . . . . . . . . . . . . . . . . . . . . 25

4.1.1 Removing and Mounting the door . . . . . . . . . . . . . . . . 25

4.1.2 Removing/Mounting the left Side Cover . . . . . . . . . . . . . 26

5PowerSupply. . . . . . . . . . . . . . . . . . . . . . . . . . 29

5.1 Power Supply Units . . . . . . . . . . . . . . . . . . . . . . . 29

5.1.1 Replacing the Power Supply Unit . . . . . . . . . . . . . . . . 30

6 Fan Module . . . . . . . . . . . . . . . . . . . . . . . . . . . 33

6.1 Installing/Removing the Fan Module . . . . . . . . . . . . . . . 34

U41221-J-Z156-1-74

Contents

7 FC Hard Disk Drives . . . . . . . . . . . . . . . . . . . . . . . 37

7.1 Handling Hard Disk Drives/HDD Modules . . . . . . . . . . . . 37

7.2 Installing/Removing HDD/Dummy Module . . . . . . . . . . . . 38

7.3 Hot Swap for FC HDD Modules . . . . . . . . . . . . . . . . . . 42

7.4 Identification Marks and Loop Addresses . . . . . . . . . . . . . 43

8 Plug-in Board Modules . . . . . . . . . . . . . . . . . . . . . 45

8.1 The FFx-RAID Controller Module . . . . . . . . . . . . . . . . . 45

8.1.1 Indicators and Connectors . . . . . . . . . . . . . . . . . . . . 46

8.1.2 Switches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50

8.1.3 Installing/removing the FFx-RAID controller module . . . . . . . 52

8.1.4 Adding a Second FFx-RAID Controller Module . . . . . . . . . . 54

8.1.5 The FFx-BBU (Battery Backup Unit) Module . . . . . . . . . . . 55

9 Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . 57

9.1 Fibre Channel (FC) Connection . . . . . . . . . . . . . . . . . . 58

9.2 Mains Connection . . . . . . . . . . . . . . . . . . . . . . . . . 58

9.3 Mains Connection with Phase Redundancy . . . . . . . . . . . 59

9.4 Power connection via UPS . . . . . . . . . . . . . . . . . . . . 60

10 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61

10.1 Installation Steps . . . . . . . . . . . . . . . . . . . . . . . . . 61

10.2 Unpacking the Storage Subsystem . . . . . . . . . . . . . . . . 62

10.3 Setting Up the Floorstand Model . . . . . . . . . . . . . . . . . 62

10.4 Mounting the Rack Model . . . . . . . . . . . . . . . . . . . . 63

10.4.1 Preparing the Slide Rails . . . . . . . . . . . . . . . . . . . . . 64

10.4.2 Mounting Slide Rails . . . . . . . . . . . . . . . . . . . . . . . 65

10.4.3 Mounting the Subsystem . . . . . . . . . . . . . . . . . . . . . 65

10.4.4 Routing the Cables . . . . . . . . . . . . . . . . . . . . . . . . 66

10.5 Connecting and Disconnecting Cables . . . . . . . . . . . . . . 68

10.6 Switching the Storage Subsystem ON/OFF . . . . . . . . . . . 69

11 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . 71

11.1 Problem Solutions and Tips . . . . . . . . . . . . . . . . . . . . 71

11.1.1 Power Supply Status Indicator (Front) . . . . . . . . . . . . . . 71

11.1.1.1 Power supply status indicator remains dark . . . . . . . . . . . 71

11.1.1.2 Power supply status indicator lights yellow . . . . . . . . . . . . 72

11.1.1.3 Power supply status indicator lights orange . . . . . . . . . . . 72

11.1.2 Cooling Status . . . . . . . . . . . . . . . . . . . . . . . . . . 73

11.1.2.1 Cooling status LED lights yellow . . . . . . . . . . . . . . . . . 73

11.1.2.2 Cooling status LED lights orange . . . . . . . . . . . . . . . . . 73

U41221-J-Z156-1-74

Contents

11.1.3 Server Management Status . . . . . . . . . . . . . . . . . . . 74

11.1.3.1 Server Management Status LED lights permanently . . . . . . 74

11.1.4 Storage Subsystem Switches OFF . . . . . . . . . . . . . . . 75

11.1.5 System will not boot after Installation of New HDD Modules . . 75

11.1.6 HDD READY Indicator does not light up . . . . . . . . . . . . . 75

11.1.7 Hard Disk Drives“ dead” on System Start . . . . . . . . . . . . 76

11.1.8 Controller reports Added Hard Disk Drive as defective . . . . . 76

Abbreviations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77

Related publications . . . . . . . . . . . . . . . . . . . . . . . . . . . 81

Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83

U41221-J-Z156-1-74 1

1 Introduction

The functionality, mechanics and design of the PRIMERGY S60 storage

subsystem are optimally adapted to the PRIMERGY Nxxx server compute-

nodes. It can be used as rack or as floorstand model. In the 19-inch rack, the

S60 subsystem occupies three height units.

The PRIMERGY S60 storage subsystem use the fiber-channel technology and

can accommodate up to fourteen 1-inch hard disk drives.

The use of fiber-channel technology ensures high transmission speeds over

long distances, using a very uncomplicated infrastructure.

Components such as fans, power supply units, hard disk drives and FFx-RAID

controller modules (dual controller configuration only) can be replaced with the

system running. Redundancy is provided for central components, offering a

high degree of data security and reliability.

Server Management/ServerView

For the first step the server management for the PRIMERGY S60 storage

subsystem will be ensured by SES (SCSI Enclosure Service).

A optional Remote Service Board (RSB) with more functions can be installed.

In this case remote diagnosis is available to the customer or service provider for

analysis, remote system configuration and a remote restart - even if the

operating system or the hardware fails.

The RSB-module is board which includes a completely independent system. It

has a separate operating system with web server and SNMP agents, and can

be driven by an external power supply.

The board is installed in the storage subsystem and connected to the HDD

backplane.

Further informations is provided in the documentation for the Remote Service

Board (see “Related publications” on page 81).

ServerView and the related agents are set up within the group of servers and

storage subsystems being monitored. The received information are evaluated

by ServerView and processed for display or forwarding to the administrator

(manager).

2 U41221-J-Z156-1-74

Target Group Introduction

IWhen installing PRIMERGY S60 storage subsystems in connection with

ServerView please install the ServerStart CD version 4.06 or higher on

each of the connected servers.

See ServerView documentation for notes concerning installing and update (see

also “Related publications” on page 81).

1.1 Target Group

The operating instructions are intended for the person responsible for installing

the hardware and correctly operating the system. The operating manual contain

all the descriptions which are of importance for commissioning your

PRIMERGY S60 storage subsystem in so far as they do not form part of the

publication of your server system.

To understand the different expansion options it is necessary to have a

knowledge of hardware and data transmission, as well as basic knowledge of

the operating system used.

1.2 Notation Conventions

Italics identifies commands and entries in flow text

Bold highlights text

“Quotation marks” indicates references to other chapters or manuals

Êidentifies an operation that you have to perform.

Iindicates additional information, notes and tips

VCAUTION! indicates warnings, which, if ignored, will endanger

your health, the operability of your server or the

security of your data

Inhaltsverzeichnis

Andere Fujitsu Server Handbücher

Fujitsu

Fujitsu PRIMEQUEST 2000 Series Bedienungsanleitung

Fujitsu

Fujitsu FW-S Series SERVIS Bedienungsanleitung

Fujitsu

Fujitsu SPARC Enterprise T5440 Server Bedienungsanleitung

Fujitsu

Fujitsu PRIMERGY BX600 S3 Bedienungsanleitung

Fujitsu

Fujitsu Primergy RX100 S4 Bedienungsanleitung

Fujitsu

Fujitsu FUTRO S930 Bedienungsanleitung

Fujitsu

Fujitsu PRIMERGY RX600 S6 Bedienungsanleitung

Fujitsu

Fujitsu PRIMERGY 10/40GbE Connection Blade 18/8+2 Stücklistenhandbuch

Fujitsu

Fujitsu M10 Series Bedienungsanleitung

Fujitsu

Fujitsu PRIMERGY TX1310 M1 Bedienungsanleitung

Fujitsu

Fujitsu FUTRO S940 Bedienungsanleitung

Fujitsu

Fujitsu Primergy RX300 S3 Leitfaden

Fujitsu

Fujitsu PRIMERGY CX2560 M4 Bedienungsanleitung

Fujitsu

Fujitsu PRIMERGY B900 Bedienungsanleitung

Fujitsu

Fujitsu PRIMERGY TX100 S3 Bedienungsanleitung

Fujitsu

Fujitsu PRIMERGY RX330 S1 Betriebsanleitung

Fujitsu

Fujitsu PRIMERGY H200 Bedienungsanleitung

Fujitsu

Fujitsu PRIMEQUEST 2800B3 Bedienungsanleitung

Fujitsu

Fujitsu SPARC Enterprise M3000 Bedienungsanleitung

Fujitsu

Fujitsu Primergy RX100 S3 Leitfaden

Fujitsu

Fujitsu PRIMERGY RX1330 M4 Bedienungs- und Montageanleitung

Fujitsu

Fujitsu PRIMERGY TX200 S6 Bedienungsanleitung

Fujitsu

Fujitsu PRIMERGY RX100 S6 Bedienungsanleitung

Fujitsu

Fujitsu BS2000 SE Series Bedienungsanleitung

Beliebte Server Handbücher anderer Marken

HP AlphaServer ES47 Bedienungsanleitung

Dell

Dell PowerEdge R410 Bedienungsanleitung

PowerNAS

PowerNAS CMA Bedienungsanleitung

Supero

Supero FatTwin F617R3-FT Bedienungsanleitung

MSI

MSI P1-109N-L70 Bedienungsanleitung

Dell

Dell PowerEdge XE9640 Handbuch

Dell

Dell PS4100 Montageanleitung

EtroVISION

EtroVISION EV3151 Bedienungsanleitung

NEC

NEC Express5800/T110j Bedienungsanleitung

HP ProLiant Gen9 Bedienungsanleitung

Compaq

Compaq ProLiant 3000 Handbuch

Dell

Dell PowerEdge 3YPMN Bedienungsanleitung

iRobo

iRobo IPC2U Bedienungsanleitung

Nortel

Nortel 1000 Con?guration guide Bedienungsanleitung

Asus

Asus AP7500 Bedienungs- und Wartungshandbuch

Avid Technology

Avid Technology AirSpeed 5000 Bedienungsanleitung

HP Integrity rx2600 Installationsanleitung

Milestone

Milestone Husky IVO 350T Bedienungsanleitung