Graco RoadLazer Husky 515 Bedienungsanleitung

308796

Rev. E

INSTRUCTIONS–PARTS LIST

INSTRUCTIONS

This manual contains important

warnings and information.

READ AND KEEP FOR REFERENCE.

RoadLazertHuskyt515 Transfer Kit

Model 239934, Series A

100 psi (7 bar, 0.7 MPa) Maximum Working Pressure

Pressure Relief Procedure

WARNING

INJECTION HAZARD

The system pressure must be manually

relieved to prevent the system from

starting or spraying accidentally. Fluid

under high pressure can be injected through the

skin and cause serious injury. To reduce the risk of

an injury from injection, splashing fluid, or moving

parts, follow the Pressure Relief Procedure

whenever you

DAre instructed to relieve the pressure

DStop spraying

DCheck or service any of the system equipment

DInstall or clean the spray tip

1. Set hydraulic bypass valve to BYPASS position.

2. Stop engine by turning key to OFF position.

3. Place empty pail under paint guns to catch

drainage.

4. Relieve hose pressure: Use Programmable

Skipline Controller to trigger each gun for at least 3

seconds.

5. Close paint gun ball valves.

6. Place empty pail under paint drain valves to catch

drainage.

7. Open all drain valves one at a time.

8. Close valves immediately to prevent paint from

drying in system.

9. Relieve beads system pressure by turning bead

system valve to OFF position

If you suspect that the spray gun or hose is clogged, or

that pressure has not been fully relieved after following

the steps above, very slowly loosen the hose end

coupling, and relieve pressure gradually. Then loosen it

completely. Then clear the valve or hose.

Installation

1. Follow Pressure Relief Procedure at left.

2. Install Auxiliary Air Kit 240496 per manual 308831.

3. Mount Husky 515 pump with syphon on drum.

Refer to manual 308981 and Fig. 1.

Fig. 1 TI0246

4. Install air line fitting (11) on Husky pump.

5. Connect coupled air hose (9) to fitting (11).

6. Connect end of coupled air hose to RoadLazer

quick disconnect fitting (16).

Operation

1. Follow Pressure Relief Procedure at left.

2. Turn on RoadLazer per manual 308611.

3. Control fluid transfer with ball valve (3).

4. Turn off RoadLazer per manual 308611.

5. Relieve pressure in hose by opening ball valve.

Cleaning

1. Follow Pressure Relief Procedure at left.

2. Clean pump per manual 308981.

GRACO INC. P.O. BOX 1441 MINNEAPOLIS, MN 55440–1441

Graco Inc. is registered to I.S. EN ISO 9001

Parts

Ref Part

No. No. Description Qty.

1 191627 HOSE, suction 1

2 113607 BARB, 1 in. 1

3 512486 VALVE, ball 1

4 114304 ELBOW, street, 90_1

5 183423 TUBE, intake 1

6 101818 CLAMP, hose 2

7 D51331 PUMP, 515, Husky 1

8 221094 KIT, 55-gallon drum mount 1

9 109132 HOSE, coupled, 25 ft 1

10 169967 FITTING, line, air 1

11 169970 FITTING, line, air 1

12 208536 COUPLER, line, air 1

13 159842 BUSHING, 1/4(m) x 1/2(f) npt 1

14 150287 COUPLING 1

15 114419 BARB, 1 in. 1

16 240496 KIT, air, auxiliary 1

17 119400 SEALANT, pipe (not shown) 1

18 111386 ELBOW, street 1

RoadLazer Husky 515 Transfer Kit

Model 239934, Series A

2308796

Parts

All written and visual data contained in this document reflect the latest product information available at the time of publication.

Graco reserves the right to make changes at any time without notice.

Sales Offices: Minneapolis

International Offices: Belgium, Korea, Hong Kong, Japan

GRACO INC. P.O. BOX 1441 MINNEAPOLIS, MN 55440–1441

www.graco.com

PRINTED IN USA 308796 03/1998, Revised 10/2004

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Graco Wasserpumpe Handbücher

Graco

Graco BULLDOG 204-287, Series K Instructions-parts... Bedienungsanleitung

Graco

Graco 246388 Bedienungsanleitung

Graco

Graco Hydra-Clean 1040 Gebrauchs- und Pflegehandbuch

Graco

Graco Husky 15120 Gebrauchs- und Pflegehandbuch

Graco

Graco Bulldog Bedienungsanleitung

Graco

Graco Husky 1050HP Gebrauchs- und Pflegehandbuch

Graco

Graco Core E1 Gebrauchs- und Pflegehandbuch

Graco

Graco Husky 2200 Bedienungsanleitung

Graco

Graco Dura-Flo 1200 Bedienungsanleitung

Graco

Graco LW075S Gebrauchs- und Pflegehandbuch

Graco

Graco Hydra-Cat A Series Bedienungsanleitung

Graco

Graco Husky 2150 Bedienungsanleitung

Graco

Graco 260549 Bedienungsanleitung

Graco

Graco Series A Bedienungsanleitung

Graco

Graco SaniForce 24E836 Stücklistenhandbuch

Graco

Graco President 218747 Bedienungsanleitung

Graco

Graco 226040 Bedienungsanleitung

Graco

Graco Mongoose Series Stücklistenhandbuch

Graco

Graco Dura-Flo 2400 Datenblatt

Graco

Graco Husky 715 Bedienungsanleitung

Graco

Graco KING D Series Bedienungsanleitung

Graco

Graco Series A Betriebsanleitung

Graco

Graco DYNAMITE 190 A Series Bedienungsanleitung

Graco

Graco SaniForce STU Series Bedienungsanleitung

Beliebte Wasserpumpe Handbücher anderer Marken

Neptun

Neptun NPHW 5500 Bedienungsanleitung

Sensidyne

Sensidyne Gilian BDX-II Montage- und Bedienungsanleitung

Draper

Draper 47808 Bedienungsanleitung

Trolla

Trolla 12820 Bedienungsanleitung

Sunfab

Sunfab SVH Series Bedienungsanleitung

WilTec

WilTec 50740 Bedienungsanleitung

Fieldmann

Fieldmann FVC 5015 EK Bedienungsanleitung

Everbilt

Everbilt EFSUB5-122HD Bedienungsanleitung

esotec

esotec 101018 Bedienungsanleitung

Becker

Becker BASIC VASF 2.80/1-0.AC230 Bedienungsanleitung

Sykes AmeriPumps

Sykes AmeriPumps GP100M Fehlerbehebungshandbuch

DUROMAX

DUROMAX XP WX Series Bedienungsanleitung

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Bedienungsanleitung

Franklin Electric

Franklin Electric IPS Bedienungsanleitung

Xylem

Xylem e-1532 Series Bedienungsanleitung

Milton Roy

Milton Roy PRIMEROYAL Bedienungsanleitung

STA-RITE

STA-RITE ST33APP Bedienungsanleitung

GÜDE

GÜDE HWW 900 GC Bedienungsanleitung