Greenheck XG-5700 Bedienungsanleitung
Installation, Operation and Maintenance Manual
Ceiling Diffuser
Ceiling Diffuser2
®
®
Ceiling Diffuser
Installation, Operation and Maintenance Manual
Please read and save these instructions for future reference. Read carefully before attempting to assemble, install,
operate or maintain the product described. Protect yourself and others by observing all safety information. Failure
to comply with these instructions will result in voiding of the product warranty and may result in personal injury
and/or property damage.
Getting Started/Model Nomenclature
1. Before starting, inspect all shipping boxes for
visible damage. If any visible damage is found, note
it on the BOL and contact your local Greenheck
Representative.
2. If you decide to keep the shipment, take all diffusers
out of the shipping boxes and inspect for any
manufacturing flaws or hidden damage. If anything is
found, contact your local Greenheck Representative.
Table of Contents
Getting Started. . . . . . . . . . . . . . . . . . . . . 2
Installation:
Lay-in (-6 Border) Installation . . . . . . . . . . . . . 3
Baffle Installation for Cone Diffusers
(XG-5700 and XG-5800 models only) . . . . . . . . 4
Blank-Off Installation for Plaque Diffusers
(XG-5750 model only) . . . . . . . . . . . . . . . . 5
Maintenance:
General Maintenance . . . . . . . . . . . . . . . . . 6
Ceiling Diffuser 3
®
Installation Instructions for Lay-In Diffusers (-6 Border)
This section applies to all Greenheck diffuser models that are available in a -6 Lay-In Border Frame style.
A. Locate the lay-in location in which the diffuser will be
installed. This could be a plaster frame used in a hard
surface ceiling, or a standard T-Bar grid system.
B. Turn the diffuser on its side and push it up through
the opening diagonally. Take care not to impact any
side of the diffuser to avoid scratching or damaging
the diffuser – see Figure 1.
C. Once the diffuser is above the ceiling opening, lay
the product into the plaster frame or T-Bar grid – see
Figure 2.
D. Attach ductwork to the neck of the diffuser if using
flexible duct. This can be done from an adjacent
ceiling grid if T-Bar application is used – see Figure 3.
Figure 1 (Step B)
Figure 2 (Step C)
Figure 3 (Step D)
Ceiling Diffuser4
®
B. Place the core with legs facing upwards. Locate the baffle and S-clips provided with the baffles. Install the S-clips
onto the baffle – see Figure 5.
C. Once both S-clips have been installed onto the baffle, install the baffle onto the inner core of the diffuser by sliding
the S-clips on each leg – see Figure 6.
D. After installing the baffle on the core, reinstall the inner core onto the diffuser by hooking the legs into the diffuser
backpan and securing each latch – see Figure 7.
Figure 5 (Step B)
Figure 6 (Step C)
S-clips installed
on the leg
Figure 7 (Step D)
Baffle Installation for Cone Diffusers
This section applies to the accessory installation of baffles for Greenheck models XG-5700 and XG-5800 only.
Baffles are used to block air from being distributed through one side of a diffuser. Multiple baffles can be used on the
same diffuser to reach the desired direction of airflow.
A. Place the diffuser face up on a flat surface. Locate
the plastic latches on each leg of the inner core. Twist
the latches and remove the core from the backpan –
see Figure 4.
Figure 4 (Step A) – XG-5700 Shown, XG-5800 Similar
Latches on core
Ceiling Diffuser 5
®
Blank-Off Installation for Plaque Diffusers
This section applies to the accessory installation of a Blank-Off for Greenheck model XG-5750 only. Blank-Offs are
used to block air from being distributed through one side of a plaque diffuser. Multiple Blank-Offs can be used on the
same diffuser to reach the desired direction of airflow.
A. Place the diffuser face up on a flat surface. Locate the plastic latches on each leg of the inner plaque face. Twist
the latches and remove the plaque face from the backpan – see Figure 8.
B. Place the plaque face with legs facing upwards. Locate the Blank-Off and two S-clips provided with the Blank-Off.
Install the S-clips onto the Blank-Off – see Figure 9.
C. Once both S-clips have been installed onto the Blank-Off, install the Blank-Off onto the plaque face of the diffuser
by sliding the S-clips on each leg – see Figure 10.
D. After installing the Blank-Off on the core, reinstall the plaque face onto the diffuser by hooking the legs into the
diffuser backpan and securing each latch – see Figure 11.
Figure 8 (Step A)
Figure 9 (Step B)
Figure 10 (Step C)
Figure 11 (Step D)
Ceiling Diffuser, Rev. 1, January 2023 Copyright 2023 © Greenheck Fan Corporation6
As a result of our commitment to continuous improvement, Greenheck reserves the right to change specifications
without notice.
Product warranties can be found online at Greenheck.com, either on the specific product page or in the literature
section of the website at Greenheck.com/Resources/Library/Literature.
®
Phone: 715.359.6171 • Fax: 715.355.2399 • Parts: 800.355.5354 • E-mail: [email protected] • Website: www.greenheck.com
Our Commitment
General Maintenance
Diffusers are basically maintenance free. Most Greenheck diffuser models have removable faces to allow for cleaning
of dust buildup within the duct or on the internal damper when included. The face of most diffusers can be cleaned
with water and mild detergent if dirt and dust begin to build up.
Dieses Handbuch passt für folgende Modelle
1
Inhaltsverzeichnis
Andere Greenheck Lüfter Handbücher
Greenheck
Greenheck G Series Bedienungsanleitung
Greenheck
Greenheck 468769 Betriebsanleitung
Greenheck
Greenheck GRSI Bedienungsanleitung
Greenheck
Greenheck SESMDR-501 Bedienungsanleitung
Greenheck
Greenheck SP-AP0511W Bedienungsanleitung
Greenheck
Greenheck FSD-312 Bedienungsanleitung
Greenheck
Greenheck DFD-M150 Bedienungsanleitung
Greenheck
Greenheck ASSURE-120S-S1 Bedienungsanleitung
Greenheck
Greenheck Vektor ERS-MD Bedienungsanleitung
Greenheck
Greenheck ERV-251ERV-361 Bedienungsanleitung
Greenheck
Greenheck FumeJet FJ-M Bedienungsanleitung
Greenheck
Greenheck Combination Fire Smoke Damper FSD-211 Bedienungsanleitung
Greenheck
Greenheck AER-M Bedienungsanleitung
Greenheck
Greenheck BIDW Bedienungsanleitung
Greenheck
Greenheck RSF Bedienungsanleitung
Greenheck
Greenheck PVE-20 Bedienungsanleitung
Greenheck
Greenheck ERVe Series Bedienungsanleitung
Greenheck
Greenheck FSD-212 Bedienungsanleitung
Greenheck
Greenheck GJ Bedienungsanleitung
Greenheck
Greenheck VFCD Bedienungsanleitung
