Grundfos MAGNA3 25-100 (N) Bedienungsanleitung

GRUNDFOS INSTRUCTIONS

MAGNA3

Safety instructions and other important information

Installation and operating instructions

http://net.grundfos.com/qr/i/98091805

English (GB)

English (GB) Safety instructions

Original safety instructions

These safety instructions give a quick

overview of the safety precautions to be

taken in connection with any work on this

product.

Observe these safety instructions during

handling, installation, operation,

maintenance, service and repair of this

product.

These safety instructions are a

supplementary document, and all safety

instructions will appear again in the relevant

sections of the installation and operating

instructions.

Keep these safety instructions at the

installation site for future reference.

General warning

Read this document and the quick

guide before installing the product.

Installation and operation must comply

with local regulations and accepted

codes of good practice.

English (GB)

Type key

This appliance can be used by

children aged from 8 years and above

and persons with reduced physical,

sensory or mental capabilities or lack

of experience and knowledge if they

have been given supervision or

instruction concerning use of the

appliance in a safe way and

understand the hazards involved.

Children shall not play with the

appliance. Cleaning and user

maintenance shall not be made by

children without supervision.

CodeExample (D) 32 -40 (F) (N) 220

Type range

MAGNA3

Single-head pump

Twin-head pump

Nominal diameter

(DN) of suction and

discharge ports [mm]

Maximum head [dm]

English (GB)

Lifting the pump

Installing the product

Pipe connection

Threaded

Flange

Pump housing material

Cast iron

Stainless steel

Port-to-port length [mm]

Observe local regulations concerning

limits for manual lifting or handling.

Do not lift the pump head by the

control box, i.e. the red area of the

pump.

CAUTION

Pressurised system

Minor or moderate personal injury

- Pay special attention to any

escaping vapour when loosening

the clamp.

CodeExample (D) 32 -40 (F) (N) 220

English (GB)

CAUTION

Crushing of feet

Minor or moderate personal injury

- Do not drop the pump head when

loosening the clamp.

Fit and tighten the screw that holds the

clamp to 8 Nm ± 1 Nm. Do not apply

more torque than specified even

though water is dripping from the

clamp. The condensed water is most

likely coming from the drain hole under

the clamp.

Check the position of the clamp before

you tighten the clamp. Incorrect

position of the clamp will cause

leakage from the pump and damage

the hydraulic parts in the pump head.

Do not insulate the control box or

cover the operating panel.

8Nm!

English (GB)

Electrical installation

WARNING

Electric shock

Death or serious personal injury

- Before starting any work on the

product, make sure that the power

supply has been switched off. Lock

the main switch in position 0. Type

and requirements as specified in EN

60204-1, 5.3.2.

English (GB)

WARNING

Electric shock

Death or serious personal injury

- Connect the pump to an

external main switch with a

minimum contact gap of 3 mm in

all poles.

- Use earthing or neutralisation

for protection against indirect

contact.

- If a plug-connected pump is

connected to an electric

installation where an electrical

circuit breaker (voltage sensing

ELCB, residual-current device

RCD or residual-current circuit

device RCCB) is used as an

additional protection, this circuit

breaker must be marked with

the first or both of the symbols

shown below.

If the pump is

terminal-connected, the circuit

breaker must be marked with

both of the symbols below.

English (GB)

Product introduction

Radio communication

The radio part of this product is a class 1

device and can be used anywhere in the EU

member states without restrictions.

Intended use

This pump incorporates a radio for remote

control.

Make sure that the fuse is

dimensioned according to the

nameplate and local legislation.

Connect all cables in accordance with

local regulations.

Make sure that all cables are

heat-resistant up to 75 °C.

Install all cables in accordance with

EN 60204-1 and EN 50174-2:2000.

Do not pump aggressive liquids.

Do not pump flammable, combustible

or explosive liquids.

English (GB)

The pump can communicate with Grundfos

GO and with other MAGNA3 pumps of the

same type via the built-in radio.

Control functions

WARNING

Electric shock

Minor or moderate personal injury

- Separate wires connected to supply

terminals, outputs NC, NO, C and

start-stop input from each other and

from the supply by reinforced

insulation.

Make sure that all cables are

heat-resistant up to 75 °C.

Install all cables in accordance with

EN 60204-1 and EN 50174-2:2000.

Connect all cables in accordance with

local regulations.

English (GB)

Setting the product

WARNING

Electric shock

Death or serious personal injury

- Separate input voltages from

external equipment from live parts

by reinforced insulation.

CAUTION

Hot surface

Minor or moderate personal injury

- At high liquid temperatures, the

pump housing may be so hot that

only the control panel should be

touched to avoid burns.

Set the operating mode to "Normal"

before you enable a control mode.

Andere Handbücher für MAGNA3 25-100 (N)

Inhaltsverzeichnis

Andere Grundfos Wasserpumpe Handbücher

Grundfos

Grundfos CMBE Bedienungsanleitung

Grundfos

Grundfos KPL Bedienungsanleitung

Grundfos

Grundfos SCALA2 Bedienungsanleitung

Grundfos

Grundfos MQ Bedienungsanleitung

Grundfos

Grundfos Unilift AP12 Bedienungsanleitung

Grundfos

Grundfos Home Booster 4.5 Handbuch

Grundfos

Grundfos SMART Digital XL DDA Bedienungsanleitung

Grundfos

Grundfos EB 20503-2 Sicherheitsleitfaden

Grundfos

Grundfos MSS Series Bedienungsanleitung

Grundfos

Grundfos Unilift KP 150 Bedienungsanleitung

Grundfos

Grundfos UPM3 Bedienungsanleitung

Grundfos

Grundfos EN 12050-1 Bedienungsanleitung

Grundfos

Grundfos DDI 222 Bedienungsanleitung

Grundfos

Grundfos ALPHA1 B Bedienungsanleitung

Grundfos

Grundfos 72 Betriebsanleitung

Grundfos

Grundfos DPK Series Bedienungsanleitung

Grundfos

Grundfos CR Series Bedienungsanleitung

Grundfos

Grundfos HYDRO SOLO-E Bedienungsanleitung

Grundfos

Grundfos CRN 16 B Betriebsanleitung

Grundfos

Grundfos COMFORT PM B Bedienungsanleitung

Grundfos

Grundfos ALPHA series Bedienungsanleitung

Grundfos

Grundfos AP51 Series Bedienungsanleitung

Grundfos

Grundfos CR Bedienungsanleitung

Grundfos

Grundfos MTH Series Bedienungsanleitung

Beliebte Wasserpumpe Handbücher anderer Marken

Neptun

Neptun NPHW 5500 Bedienungsanleitung

Sensidyne

Sensidyne Gilian BDX-II Montage- und Bedienungsanleitung

Draper

Draper 47808 Bedienungsanleitung

Trolla

Trolla 12820 Bedienungsanleitung

Sunfab

Sunfab SVH Series Bedienungsanleitung

WilTec

WilTec 50740 Bedienungsanleitung

Fieldmann

Fieldmann FVC 5015 EK Bedienungsanleitung

Everbilt

Everbilt EFSUB5-122HD Bedienungsanleitung

Graco

Graco Husky 3300e Bedienungsanleitung

esotec

esotec 101018 Bedienungsanleitung

Becker

Becker BASIC VASF 2.80/1-0.AC230 Bedienungsanleitung

Sykes AmeriPumps

Sykes AmeriPumps GP100M Fehlerbehebungshandbuch

DUROMAX

DUROMAX XP WX Series Bedienungsanleitung

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Bedienungsanleitung

Franklin Electric

Franklin Electric IPS Bedienungsanleitung

Xylem

Xylem e-1532 Series Bedienungsanleitung

Milton Roy

Milton Roy PRIMEROYAL Bedienungsanleitung

STA-RITE

STA-RITE ST33APP Bedienungsanleitung