Harman CW-30 Montageanleitung

CW-30 “Harman E” Repair Guide 1

Disassembling Instructions and Parts Identication

There are quite a few of the CW-30 stoves still in use out there.

This guide will help you to identify parts and pieces while also providing instruction for replacing

gaskets and/or other various components.

What better way to learn about a stove than to take it apart and put it back together?

CW-30 “Harman E” Repair Guide 2

To begin dismantling the stove, remove the Harman Logo plate from the center of the top.

This will expose a nut which secures the cast iron top to the stove.

Using a ½” socket or wrench, loosen and remove the nut. Then lift the top off of the stove.

CW-30 “Harman E” Repair Guide 3

The under side of the cast iron top is gasketed, mostly to prevent rattles of metal to metal

contact. This is ⅜” low density rope gasket (3-44-00888) attached with gasket cement.

Now you’ll see the inner top, which is held down with (6) ½” nuts and washers. Remove the

nuts and washers to lift the inner top.

CW-30 “Harman E” Repair Guide 4

Looking into the top of the rebox, you’ll see the wafe as shown below. Find a bolt or

screw to t the hole size (3/8” thread) and thread it into a hole near the center of the wafe.

This will provide a handle with which to manipulate the wafe. Lift up on the wafe and tilt

it back to drop it down and out.

Ceramic Fiber Wafe

Item # 3-40-00471

CW-30 “Harman E” Repair Guide 5

With the inner top removed, you’ll now see the damper (Damper Weldment # 1-10-00465)

and the combustion package. (Ceramic Fiber Combustion Package # 3-40-00472)

Pull forward and lift the combustion package out of the top of the stove. Use extra care

when handling the combustion package, as it does become brittle after burning.

CW-30 “Harman E” Repair Guide 6

This view shows the underside of the combustion package. Note the holes and the indents

for the damper frame bolts.

With the Package removed, you’ll see the top of the Pyrolite Ignitor Tunnel. You can also

now see the top of the damper and the damper frame ller plate.

Air Flow Holes, be

sure they are not

blocked.

Indents for damper

frame bolts.

CW-30 “Harman E” Repair Guide 7

Damper Frame Filler Plate

Damper Plate

Damper Frame Mounting Bolts

Front Of Stove

Damper open

Using a ½” wrench and socket, remove the (4) bolts which hold the damper frame up in the

top of the rebox. Be sure to secure the frame from below, as it will drop upon removal of

the last bolt.

CW-30 “Harman E” Repair Guide 8

This is the damper frame assembly (# 1-10-00641) and ller plate (# 1-10-00734) as it is

removed from the rebox.

Close up view of the

damper lift arm.

Front Of Stove

To remove the damper, loosen the two bolts and clips at the ends of the damper plate. The

damper lift arm can be removed by rst removing the external brass elbow. Then pull the

damper lift arm in through the stove wall. (Damper Arm Weldment # 1-10-00638)

CW-30 “Harman E” Repair Guide 9

Damper Frame Assembly Item # 1-10-00641

and Damper Filler Plate Item # 1-10-00734

Note how the ller plate lays in the damper

frame channel, with the end tabs inside.

3/8” Rope # 3-44-00888

1/4” rope # 3-44-108636

CW-30 “Harman E” Repair Guide 10

Remove the Arch Brick (cast iron or refractory) by lifting up slightly then pull the bottom

toward the front of the stove.

Next would be the side bricks. Note the insulation panel on the back side of the side bricks.

There are two side bricks on each side of the rebox.

Arch Brick Item

# 3-40-00615

Right Support Brick

Item # 3-40-00468-2

Left Support Brick

Item # 3-40-00468-1

Ramp Brick

Item # 3-40-

00470

Side Brick (4 total)

Item # 3-40-00469

and insulation backer

Inhaltsverzeichnis

Andere Harman Herd Handbücher

Harman

Harman P43 Bedienungsanleitung

Harman

Harman Absolute43-C Bedienungsanleitung

Harman

Harman TLC 2000 Bedienungsanleitung

Harman

Harman XXV-TC Bedienungsanleitung

Harman

Harman Absolute63 Bedienungsanleitung

Harman

Harman P43 Bedienungsanleitung

Harman

Harman Super-Magnum Coal Stoker Stove Sicherheitsleitfaden

Harman

Harman Oakleaf Wood Stove Bedienungsanleitung

Harman

Harman Super Magnum Coal Stoker Betriebsanleitung

Harman

Harman Mark I Bedienungsanleitung

Harman

Harman FireLuxe Direct Vent Montageanleitung

Harman

Harman P43 Bedienungsanleitung

Harman

Harman XXV Bedienungsanleitung

Harman

Harman XXV-TC Bedienungsanleitung

Harman

Harman Allure50 Bedienungsanleitung

Harman

Harman P43 Bedienungsanleitung

Harman

Harman P43 Bedienungsanleitung

Harman

Harman XXV Bedienungsanleitung

Harman

Harman Magnafire MARK I Bedienungsanleitung

Harman

Harman TLC 2000 Montageanleitung

Harman

Harman Accentra Montageanleitung

Harman

Harman P42i-TC Bedienungsanleitung

Harman

Harman DVC-500 Montageanleitung

Harman

Harman XXV Bedienungsanleitung

Beliebte Herd Handbücher anderer Marken

Arada

Arada Cassette Stove Bedienungsanleitung

Parmco

Parmco FS 600 Bedienungsanleitung

MCZ

MCZ SUITE AIR 10 M2 Bedienungsanleitung

HearthStone

HearthStone Stowe DV 8321 Fehlerbehebungshandbuch

Cattara

Cattara FAMILY Bedienungsanleitung

Stanley

Stanley Argon F500 OVAL Bedienungsanleitung

Avalon

Avalon B-VENT Bedienungsanleitung

Nordpeis

Nordpeis Vega Bedienungsanleitung

Exquisit

Exquisit EKC601-5 Bedienungsanleitung

Stanley

Stanley Oisin Oil MK II Betriebsanleitung

Thermocet

Thermocet Brookfield S/CC Bedienungsanleitung

HASE

HASE delhi Bedienungsanleitung

Vermont Castings

Vermont Castings Intrepid 2 Bedienungsanleitung

Italiana Camini

Italiana Camini CLASSICA Kurzanleitung

Avalon

Avalon Vashon Avanti DVS FS Bedienungsanleitung

Spartherm

Spartherm ambiente a1 Bedienungsanleitung

Dimplex

Dimplex MCFSTV12AU Bedienungsanleitung

Warmlite

Warmlite WL46040 Bedienungsanleitung