Heat & Glo NORTHSTAR-BK Bedienungsanleitung

Installationandserviceofthisreplaceshouldbe

performedbyqualiedpersonnel.Hearth&Home

TechnologiesrecommendsNFIcertiedprofes-

sionals,ortechnicianssupervisedbyan

NFIcertiedprofessional.

EPA CERTIFIED WOODBURNING

FIREPLACE

Fire Risk.

WARNING

Forusewithsolidwoodfuelonly.

Otherfuelsmayoverreandgenerate

poisonousgases(i.e.carbonmonoxide).

O-T L

Tested and

Listed by

Portland

Oregon USA

OMNI-Test Laboratories, Inc.

CUS

Model(s):

Installation Manual

Installation and Fireplace Setup

WARNING

HOT SURFACES!

Glassandothersurfacesarehotduring

operationANDcooldown.

Hot glass will cause burns.

• DO NOTtouchglassuntilitiscooled

• NEVERallowchildrentotouchglass

• Keepchildrenaway

• CAREFULLY SUPERVISE children in same room as

replace.

• Alertchildrenandadultstohazardsofhightemperatures.

High temperatures may ignite clothing or other  ammable

materials.

• Keep clothing, furniture, draperies and other ammable

materialsaway.

INSTALLER: Leave this manual with party responsible for use and operation.

OWNER: Retain this manual for future reference.

NORTHSTAR-BK

NORTHSTAR-GT

NORTHSTAR-NT

NOTICE: DO NOT discard this manual!

• DO NOTstoreorusegasolineorotheram-

mablevaporsandliquidsinthevicinityofthis

oranyotherappliance.

• DO NOT overre.Overringwillvoidyour

warranty.

• Complywithallminimumclearancestocom-

bustiblesasspecied.Failuretocomplymay

causehousere.

WARNING: If the information in these

instructions is not followed exactly, a  re

or explosion may result causing property

damage, personal injury, or death.

Pourdemanderunexemplaire

enfrançaisdeceManuel

dupropriétaire,visitezwww.

heatnglo.com/translations.

Heat&Glo•NORTHSTAR•480-2360InstallationManual•RevH•8/20/14

Safety Alert Key:

• DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury.

• WARNING!Indicatesahazardoussituationwhich,ifnotavoidedcouldresultindeathorseriousinjury.

• CAUTION! Indicatesahazardoussituationwhich,ifnotavoided,couldresultinminorormoderateinjury.

• NOTICE:Indicatespracticeswhichmaycausedamagetothereplaceortoproperty.

Table of Contents

1 Product Specic & Important Safety Information

A.FireplaceCertication 4

B.GlassSpecications 4

C.Non-CombustibleMaterials 4

D.CombustibleMaterials 4

E.ElectricalCodes 5

2 Getting Started

A.TypicalFireplaceSystem 6

B.DesignandInstallationConsiderations 7

1.SelectingFireplaceLocations 7

2.LocatingFireplace&Chimney 8

C.ToolsandSuppliesNeeded 9

D.InspectFireplaceandComponents 9

E.FireplaceSystemRequirements 9

3 Framing and Clearances

A.FireplaceDimensions 10

B.Clearances 11

1.MinimumClearances 12

C.ConstructtheChase 13

D.FrametheFireplace 14

E.SecureandLeveltheFireplace 14

F. ProtectiveMetalHearthStrips 15

G.FacingMaterial 15

H.OutsideAirKit 16

I. HeatZoneKit(Optional) 18

4 Electrical Wiring

5 Chimney and Termination Requirements

A.ChimneyRequirements 22

B.Offsets/Returns 23

C.TerminationRequirements 24

6 Chimney Installation

A.TypicalChimneySystem 25

B.AssembleChimneySections 26

C.InstallChimneyAirkit(CAK4A) 26

D.SecureOffset/Return 28

E.InstallCeilingFirestops 28

F. InstallAtticInsulationShield 29

G.RoofPenetration 30

H.ManufacturedHomeInstallation 30

I. InstallChase/ChaseTop 31

J. TerminationCapRequirements 32

K.InstallTerminationCap 32

7 Finishing

A.Template 34

B FinishtheWall 34

1.Stone,BrickFinish 34

2.Tile,Granite,MarbleFinish 34

C.MantelandWallProjections 35

D.FinishingtheHearthExtension 35

E.Non-CombustibleSealantMaterial 37

8 Fireplace Setup

A.FirebrickPlacement 38

B.BafeandBlanketPlacement 39

9 Reference Materials

A.ChimneyComponents 40

B.Accessories 44

MESH-HHTFirescreen 44

2Heat & Glo • NORTHSTAR • 480-2360 Installation Manual • Rev H • 8/20/14

►

Customer:

Lot/Address

Model (circle one): NORTHSTAR-BK NORTHSTAR-NT

NORTHSTAR-GT

Fireplace Install YES IF NO, WHY?

Verifiedthatthechaseisinsulatedandsealed.(Pg.13)

Requirednon-combustibleboardisinstalled.(Pg.15)

Verifiedclearancestocombustibles.(Pg.11)

Fireplaceisleveledandsecured.(Pg.14)

Hearthextensionsize/heightdecided.(Pg.14&37)

Outsideairkitinstalled.(Pg.16)

OptionalHeatZonehasbeeninstalledbyaqualifiedservicetechnician.(Pg.18)

Chimne

Section 5 (Pg. 22)

Chimneyconfigurationcomplieswithdiagrams.

Chimneyinstalled,lockedandsecuredinplacewithproperclearance.

Chimneyairkitinstalled.

Firestopsinstalled.

Atticinsulationshieldinstalled.

Roofflashinginstalledandsealed.

Terminationsinstalledandsealed.

Electrical Section 4 (Pg. 21)

Switchwiresproperlyinstalled.

Finishing Section 7 (Pg. 34)

Combustible materials not installed in non-combustible areas

Dealer/Distributor Phone #

Serial #:

WARNING! Risk of Fire or Explosion! Failure to install fireplace acording to these instructions can lead to a fire or

explosion.

ATTENTION INSTALLER:

Follow this Standard Work Checklist

Thisstandardworkchecklististobeusedbytheinstallerinconjuctionwith,notinsteadof,theinstructionscontainedinthis installation

manual.

Date Installed:

Location of Fireplace:

Installer:

Combustible materials not installed in non

combustible areas

Verifiedallclearancesmeetinstallationmanualrequirements.

Mantelsandwallprojectionscomplywithinstallationmanualrequirements.

Protectivehearthstripsandhearthextensioninstalledpermanualrequirements.

Fireplace Setup Section 8 (Pg. 38)

Allpackagingandprotectivematerialsremoved.

Firebrick,baffleandceramicblanketinstalledcorrectly.

Faciaanddoorsproperlyinstalled.

Allpackagingmaterialsareremovedfrominside/underthefireplace.

Hearth & Home Technologies recommends the following:

•Photographingtheinstallationandcopyingthischecklistforyourfile.

•Thatthischecklistremainvisibleatalltimesonthefireplaceuntiltheinstallationiscomplete.

Commentscommunicatedtopartyresponsible

Part4017-256•RevB•1/29/13

__________________________by______________________on_________

(Builder/Gen.Contractor)(Installer)(Date)

Comments:Furtherdescriptionoftheissues,whoisresponsible(Installer/Builder/OtherTrades,etc.)andcorrectiveactionneeded:

_________________________________________________________________________________________________

Manualbagandallofitscontentsareremovedfrominside/underthefireplaceand

giventothepartyresponsibleforuseandoperation.

________________________________________________________________________________________________________

Heat & Glo • NORTHSTAR • 480-2360 Installation Manual • Rev H • 8/20/14

1 Product Specic & Important Safety Information

A. Fireplace Certication

Thisreplacesystemhasbeentestedandlistedinac-

cordancewithUL127andULC-S610-M87and(UM)84-

HUDstandardsforinstallationandoperationintheUnited

StatesandCanadaasdescribedinthismanual.

Checkwithyourlocalbuildingcodeagencybeforeyou

beginyourinstallationtoensurecompliancewithlocal

codes,includingtheneedforpermitsandfollow-upin-

spections.Besurelocalbuildingcodesdonotsupersede

ULspecicationsandalwaysobtainabuildingpermitso

thatinsuranceprotectionbenetscannotbeunexpectedly

cancelled.

Heat&GloisaregisteredtrademarkofHearth&Home

Technologies.

C. Non-Combustible Materials

• Materialswhichwillnotigniteand burn, composed of

anycombinationofthefollowing:

- Steel - Iron

- Brick - Tile

- Concrete - Slate

- Glass - Plasters

• MaterialsreportedaspassingASTM E 136, Standard

Test Method for Behavior of Metals, in a Vertical Tube

Furnace at 750° C

B. Glass Specications

Thisreplaceisequippedwith5mmceramicglass.Re-

placeglassonlywith5mmceramicglass.Pleasecontact

yourdealerforreplacementglass.

NOTICE: This installation must conform with local codes. In the

absence of local codes you must comply with the UL127, (UM)

84-HUD and NFPA211 in the U.S.A. and the ULC 610-M87

and CAN/CSA-B365 Installation Codes in Canada.

WARNING! Risk of Fire! Hearth & Home Technologies

disclaims any responsibility for, and the warranty and agen-

cy listing will be voided by the following actions.

DO NOT:

• installoroperatedamagedreplace

• modifyreplace

• install other than as instructed by Hearth & Home

Technologies

• operate the fireplace without fully assembling all

components

• overre

• installanygaslogset

• installanycomponentnotapprovedbyHearth&Home

Technologies

• installpartsorcomponentsnotListedorapproved

Improper installation, adjustment, alteration, service or

maintenance can cause injury or property damage. For

assistance or additional information, consult a qualied

installer, service agency or your dealer.

Model: NorthstarEPACertied

WoodburningFireplace

Laboratory: OMNITestLaboratories,Inc.

Report No: 061-S-50-2

Type: WoodFireplace

Standard: UL127andULC-S610-M87and

(UM)84-HUD,Manufactured

HomeApproved.

EPA# and Original Date: #5714-1-03

EPA Certied:

3.25gramsper

hour

Efciency: upto77.8%

BTU Output

with EPA test fuel: 51,400/hr.

with Cord Wood: 70,000/hr.

Heating Capacity: upto3,500sqft

Chimney Size: 8inches

HHT SL300Series

DuraVent DuraPlus

Max Wood Length: 24inches

Fuel: CordWood

Shipping Weight: 650lbs

Firebox Size 2.7cubicfeet

WARNING! Risk of Fire!

Hearth & Home Technologies is not responsible for

discoloration, cracking or other material failures of

nishingmaterialsduetoheatexposureorsmoke.

 • Choosenishingmaterialscarefully.

4Heat & Glo • NORTHSTAR • 480-2360 Installation Manual • Rev H • 8/20/14

E. Electrical Codes

NOTICE: This replace must be electrically wired and

grounded in accordance with local codes or, in the

absence of local codes, with National Electric Code ANSI/

NFPA 70-latest edition or the Canadian Electric Code

CSA C22.1.

• A110-120VACcircuitforthisproductmustbeprotected

with ground-fault circuit-interrupter protection, in

compliancewiththeapplicableelectricalcodes,when

itisinstalledindamplocations.

WARNING! Improper installation, adjustment, alteration,

service or maintenance can cause injury or property dam-

age.

D. Combustible Materials

• Materialsmadeoforsurfacedwithanyofthefollowing

materials:

- Wood - Compressedpaper

- Plantbers - Plastic

- Plywood/OSB - Sheetrock(drywall)

• Anymaterialthatcanigniteandburn;ameproofedor

not,plasteredorun-plastered

Heat & Glo • NORTHSTAR • 480-2360 Installation Manual • Rev H • 8/20/14

2 Getting Started

A. Typical Fireplace System

Non-combustible

roof flashing maintains

minimum clearance

around chimney

Additional lateral

support for chimney

above roof (or enclosed

in chase) if needed

Enclosed space above

and around fireplace

Support straps

on rafter supports

chimney (not shown)

Outside

combustion air

Outside

combustion air

Termination Cap

Chimney penetrates roof

preferably without affecting

roof rafters

Storm Collar

Offset/Return

(with hanger straps)

Attic insulation shield

must be used here to

keep insulation away

from chimney if

attic is insulated

Framing headed

off in ceiling joists

Mantel

Decorative facing

and trim

Factory-built fireplace

Chimney system

Combustible

framing/header

on top of V-shaped

standoffs (spacers)

Hearth extension

Protective metal

hearth strip(s)

Chimney Air kit required for

SL chimney

Figure 2.1 Typical Fireplace System

6Heat & Glo • NORTHSTAR • 480-2360 Installation Manual • Rev H • 8/20/14

In an exterior chase

or projecting into a

garage

Across a corner

Along a wall

As a

room

divider

24 in.

(610mm)

24 in.

(610mm)

24 in.

(610mm)

48 in.

(1219mm)

24 in.

(610mm)

Figure 2.2 Fireplace Locations

NOTICE:

• Illustrationsandphotosreecttypicalinstallationsand

are FOR DESIGN PURPOSES ONLY.

• Illustrations/diagramsarenotdrawntoscale.

• Actualinstallation/appearancemayvaryduetoindividual

design preference.

• Hearth&HomeTechnologiesreservestherighttoalter

its products.

NOTICE: In addition to these framing dimensions, also

reference the following section:

• Clearances (Section 3).

NOTICE:

A minimum 1 in. air clearance at the back and a

minimum 1 in. air clearance to the sides of the

replaceassemblymustbemaintained.

Chimney sections at any level require a 2 in. mini-

mum air space clearance between the framing

and chimney sections.

B. Design and Installation Considerations

NOTICE: Check building codes prior to installation.

• InstallationMUSTcomplywithlocal,regional,stateand

nationalcodesandregulations.

• Consultinsurancecarrier,localbuildinginspector,re

ofcialsorauthoritieshavingjurisdictionoverrestrictions,

installationinspectionandpermits.

1. Selecting Fireplace Locations

Thisreplacemaybeusedasaroomdivider,installed

alongawall,acrossacornerorusedinanexteriorchase.

SeeFigure2.2.

Locatingthereplaceinabasement,nearfrequently

openeddoors,centralheatoutletsorreturns,orother

locationsofconsiderableairmovementcanaffectthe

performance.

Outsideairmustbeusedforcombustion.TheNorthStar

comesequippedwithanoutsideairinlettofeedcombus-

tionairfromoutsidethehome,alongwithanoutsideair

terminationcap;therigidmetalductisrequiredbutnot

supplied.Considerationshouldbegiventothesefactors

beforedecidingonalocation.

Model # A B C D E F G H I

NorthStar(dimensions

fornishedwalls)

in. 41-7/8 16 89-1/2 63-5/16 22-7/16 44-3/4 14-1/16 55-15/16 50-7/8

mm 1063 406 2273 1608 570 1137 357 1421 1292

Heat & Glo • NORTHSTAR • 480-2360 Installation Manual • Rev H • 8/20/14

2. Locating Fireplace & Chimney

Locationofthereplaceandchimneywillaffectperfor-

mance.

• Installwithinthewarmairspaceenclosedbythebuilding

envelope.Thishelpstoproducemoredraft,especially

duringlightinganddie-downofthere.

• Penetratethehighestpartoftheroof.Thisminimizes

theeffectsofwindloading.

• Locate termination cap away from trees, adjacent

structures,unevenrooflinesandotherobstructions.

• Minimizetheuseofchimneyoffsets.

• Considerthereplacelocationrelativetooorandceiling

andatticjoists.

• Takeintoconsiderationtheterminationrequirementsin

Sections5and6.

Marginal Location:

• Below peak

Location NOT recommended:

• Not the highest point of the roof

• Wind loading possible

Multi-level Roofs

Windward

Leeward

Recommended Location:

• Above peak

Recommended:

• Insulated exterior chase

in cooler climates

Recommended Location:

• Above peak

• Inside heated space

Location NOT recommended:

• Too close to tree

• Below adjacent structure

• Lower roof line

• Avoid outside wall

Marginal Location:

• Wind loading possible

Figure 2.3 Recommended Chimney Locations

• Installtheoutsideairkitwiththeintakefacingprevailing

windsduringtheheatingseason.

• Ensure adequate outdoor air for all combustion

appliancesandexhaustequipment.

• Ensurefurnaceandairconditioningreturnventsarenot

locatedintheimmediatevicinityofthereplace.

• Avoidinstallingthereplaceneardoors,walkwaysor

smallisolatedspaces.

• Recessedlightingshouldbea“sealedcan”design.

• Attichatchesweatherstrippedorsealed.

• Atticmountedductworkandairhandlerjointsandseams

tapedorsealed.

8Heat & Glo • NORTHSTAR • 480-2360 Installation Manual • Rev H • 8/20/14

C. Tools and Supplies Needed

Beforebeginningtheinstallationbesurethefollowing

toolsandbuildingsuppliesareavailable:

Reciprocatingsaw Framingmaterial

Pliers Non-combustiblesealant

Hammer Gloves

Phillipsscrewdriver Framingsquare

Flatbladescrewdriver Electricdrillandbits

Plumbline Safetyglasses

Level Tapemeasure

1/2-3/4in.length,#6or#8self-drillingscrews

Misc.screwsandnails

D. Inspect Fireplace and Components

WARNING! Risk of Fire and/or Explosion! Damaged

parts could impair safe operation. DO NOT install dam-

aged,incompleteorsubstitutecomponents.Keepre-

place dry.

• Removereplaceandcomponentsfrompackagingand

inspectfordamage.

• Vent system components and doors are shipped in

separatepackages.

• Reporttoyourdealeranypartsdamagedinshipment.

• Read all the instructions before starting the

installation. Follow these instructions carefully

during the installation to ensure maximum safety

and benet.

E. Fireplace System Requirements

Thereplacesystemrequirementsconsistofthefollow-

ing:

• Fireplace

- Firebrick(includedwithreplace)

- Door(includedwithreplace)

- Non-combustible facing material (included with

replace)

- HearthExtension

• OutsideAir System (hood and collars included with

replace)

• Fascia(includedwithreplace)

• ChimneySystem

- Chimneyairkit(includedwithreplace,requiredwith

SL300serieschimney)

- AtticInsulationShield(includedwithreplace)

- Chimneyterminationcap

• Non-combustiblenishmaterial

Optionalcomponentsinclude:

• Firescreen

• LintelBar

• HeatZoneKit

Heat & Glo • NORTHSTAR • 480-2360 Installation Manual • Rev H • 8/20/14

3 Framing and Clearances

A. Fireplace Dimensions

Fan Electrical Access

(right side of fireplace)

(283 mm)

(587 mm)

(25 mm)

(89 mm)

(1111 mm)

(1022 mm)

(791 mm)

(149 mm)

(743 mm)

(940 mm)

(1016 mm)

(1066 mm)

(422 mm)

(305 mm)

(25 mm) (248 mm)

(175 mm)

Figure 3.1 Fireplace Dimensions

►

10 Heat & Glo • NORTHSTAR • 480-2360 Installation Manual • Rev H • 8/20/14

Andere Handbücher für NORTHSTAR-BK

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Heat & Glo Kamin im Innenbereich Handbücher

Heat & Glo

Heat & Glo MEZZO48-B Bedienungsanleitung

Heat & Glo

Heat & Glo 6000C-IPI Bedienungsanleitung

Heat & Glo

Heat & Glo TRUE-36G-IFT Bedienungsanleitung

Heat & Glo

Heat & Glo SOHO24B Bedienungsanleitung

Heat & Glo

Heat & Glo STS-42 Handbuch

Heat & Glo

Heat & Glo SL-5 Bedienungsanleitung

Heat & Glo

Heat & Glo 6000TRSI-AUC Bedienungsanleitung

Heat & Glo

Heat & Glo EM41 Handbuch

Heat & Glo

Heat & Glo EXCLAIM-36 Bedienungsanleitung

Heat & Glo

Heat & Glo 8000TR-OAK Bedienungsanleitung

Heat & Glo

Heat & Glo Soho-N-AU Montageanleitung

Heat & Glo

Heat & Glo Wood Burning Fireplace HST-42D Bedienungsanleitung

Heat & Glo

Heat & Glo Cyclone-Cust Bedienungsanleitung

Heat & Glo

Heat & Glo 6000TV Bedienungsanleitung

Heat & Glo

Heat & Glo ESCAPE-I35-F Bedienungsanleitung

Heat & Glo

Heat & Glo Escape-42DV Bedienungsanleitung

Heat & Glo

Heat & Glo 7000XLT Montageanleitung

Heat & Glo

Heat & Glo SL-750TRS-C Montageanleitung

Heat & Glo

Heat & Glo ST-550TM-IPI Bedienungsanleitung

Heat & Glo

Heat & Glo JADE32IN Bedienungsanleitung

Heat & Glo

Heat & Glo Twilight II Bedienungsanleitung

Heat & Glo

Heat & Glo LUX42 Bedienungsanleitung

Heat & Glo

Heat & Glo SLR-C (COSMO) Bedienungsanleitung

Heat & Glo

Heat & Glo BAY-40 Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch