Heatilator FL92 Bedienungsanleitung

1Heatilator•FL92InstallationManual•4012-081•RevC•10/03/13

Installationandserviceofthisreplaceshouldbe

performedbyqualiedpersonnel.Hearth&Home

TechnologiesrecommendsNFIcertiedprofes-

sionals,ortechnicianssupervisedbyan

NFIcertiedprofessional.

WOODBURNING FIREPLACE

Fire Risk.

WARNING

Forusewithsolidwoodfuelonly.

Otherfuelsmayoverreandgenerate

poisonousgases(i.e.carbonmonoxide).

Model(s):

Installation Manual

Installation and Fireplace Setup

WARNING

HOT SURFACES!

Glassandothersurfacesarehotduring

operationANDcooldown.

Hot glass will cause burns.

• DO NOTtouchglassuntilitiscooled

• NEVERallowchildrentotouchglass

• Keepchildrenaway

• CAREFULLY SUPERVISE children in same room as

replace.

• Alertchildrenandadultstohazardsofhightemperatures.

Hightemperaturesmayigniteclothingorotherammable

materials.

• Keep clothing, furniture, draperies and other ammable

materialsaway.

INSTALLER: Leave this manual with party responsible for use and operation.

OWNER: Retain this manual for future reference.

FL92

NOTICE: DO NOT discard this manual!

• DO NOTstoreorusegasolineorotheram-

mablevaporsandliquidsinthevicinityofthis

oranyotherappliance.

• DO NOToverre.Overring will void your

warranty.

• Complywithallminimumclearancestocom-

bustiblesasspecied.Failuretocomplymay

causehousere.

WARNING: If the information in these

instructionsisnotfollowedexactly,are

or explosion may result causing property

damage, personal injury, or death.

2Heatilator • FL92 Installation Manual • 4012-081 • Rev C • 10/03/13

Safety Alert Key:

• DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury.

• WARNING!Indicatesahazardoussituationwhich,ifnotavoidedcouldresultindeathorseriousinjury.

• CAUTION! Indicatesahazardoussituationwhich,ifnotavoided,couldresultinminorormoderateinjury.

• NOTICE:Indicatespracticeswhichmaycausedamagetothereplaceortoproperty.

Table of Contents

1 ProductSpecic&ImportantSafetyInformation

A.FireplaceCertication 4

B.Non-CombustibleMaterials 4

C.CombustibleMaterials 4

2 Getting Started

A.TypicalFireplaceSystem 5

B.DesignandInstallationConsiderations 6

1.SelectingFireplaceLocations 6

2.LocatingFireplace&Chimney 7

C.ToolsandSuppliesNeeded 8

D.InspectFireplaceandComponents 8

E.FireplaceSystemRequirements 8

3 Framing and Clearances

A.FireplaceDimensions 9

B.Clearances 10

MinimumClearancestoCombustibles 10

C.ConstructtheChase 11

D.FrametheFireplace 12

E.SecureandLeveltheFireplace 12

F. ProtectiveMetalHearthStrips 13

G.InstallOutsideAirKit 14

AK14/AK18Installation 14

4 Chimney and Termination Requirements

A.ChimneyRequirements 15

B.Offsets/Returns 16

C.TerminationRequirements 17

5 Chimney Installation

A.TypicalChimneySystem 18

B.AssembleChimneySections 19

C.InstallChimneyAirKit(optional) 19

D.SecureOffset/Return 20

E.InstallCeilingFirestops 20

F. InstallAtticInsulationShield 21

G.RoofPenetration 22

H.InstallChase/ChaseTop 22

I. TerminationCapRequirements 23

J. InstallTerminationCap 23

6 Shrouds

A.RadiationShield 25

B.FieldConstructedShrouds 25

1.OpenTopShroud 25

2.MailboxStyleShroud 26

3.RoofedStyleShroud 26

7 Finishing

A.FinishingMaterial 27

B.HearthExtension,BuildingandFinishing 28

1.FireplaceInstalledFlushontheFloor

 andHearthExtensionRaisedtoBottomof

 FireboxOpening 29

2.RaisedHearthExtensionandRaisedFireplace 30

3.FireplaceOpeningandHearthExtensionFlush

 withtheFloor 30

C.Non-CombustibleSealantMaterial 31

D.MantelandWallProjections 31

E.Sidewalls/Surrounds 31

8 Fireplace Setup

A.GasLog/LighterProvision 32

B.WoodBurningInserts 32

C.GlassDoors(required) 32

9 Reference Materials

A.ChimneyComponents 33

B.OptionalComponents 36

►

Heatilator • FL92 Installation Manual • 4012-081 • Rev C • 10/03/13

Customer:

Lot/Address

Model (circle one):

FL92

YES IF NO, WHY?

Shrouds Section 6 (Pg. 25)

Shroudisinstalledproperlyperinstructions.

Fi i hi

S ti 7 (P 27)

Protectivehearthstripsinstalledpermanualrequirements.(Pg.13)

Fireplace Install

Outsideairkitinstalled.(Pg.14)

ChimneySection4&5(Pg.15)

Atticinsulationshieldinstalled.

ATTENTION INSTALLER:

Follow this Standard Work Checklist

Thisstandardworkchecklististobeusedbytheinstallerinconjuctionwith,notinsteadof,theinstructionscontainedinthisinstallation

manual.

Date Installed:

Location of Fireplace:

Installer:

Dealer/Distributor Phone #

Serial #:

Roofflashinginstalled.

Terminationinstalled.

WARNING! Risk of Fire or Explosion! Failure to install fireplace acording to these instructions can lead to a fire or

explosion.

Verifiedthatthechaseisinsulatedandsealed.(Pg.11)

Verifiedclearancestocombustibles.(Pg.10)

Fireplaceisleveledandsecured.(Pg.12)

Hearthextensionsize/heightdecided.(Pg.28)

Chimneyconfigurationcomplieswithdiagrams.

Chimneyinstalled,lockedandsecuredinplacewithproperclearance.

Chimneyairkitinstalled.

Firestopsinstalled.

Hearth&HomeTechnologiesrecommendsthefollowing:

Commentscommunicatedtopartyresponsible

4012-082•RevA•06/040/13

Finishing Section 7 (Pg. 27)

Hearthextensioninstalledpermanualrequirements.

Fireplace Setup Section 8 (Pg. 32)

Verifiedallclearancesmeetinstallationmanualrequirements.

Mantelsandwallprojectionscomplywithinstallationmanualrequirements.

•Photographingtheinstallationandcopyingthischecklistforyourfile.

Combustiblematerialsnotinstalledinnon-combustibleareas.

__________________________by______________________on_________

(Builder/Gen.Contractor)(Installer)(Date)

Comments:Furtherdescriptionoftheissues,whoisresponsible(Installer/Builder/OtherTrades,etc.)andcorrectiveactionneeded:

Manualbagandallofitscontentsareremovedfromthefireplaceandgiventotheparty

responsibleforuseandoperation.

•Thatthischecklistremainvisibleatalltimesonthefireplaceuntiltheinstallationiscomplete.

Allpackagingandprotectivematerialsremoved.

Doorsproperlyinstalled.

Moldedbrickpanelsinstalledcorrectly.

Grateisproperlyinstalled.

Firescreenproperlyinstalled.

4Heatilator • FL92 Installation Manual • 4012-081 • Rev C • 10/03/13

WARNING! Risk of Fire! Hearth & Home Technologies

disclaims any responsibility for, and the warranty and

agency listing will be voided by the following actions.

DO NOT:

• installoroperatedamagedreplace

• modifyreplace

• install other than as instructed by Hearth & Home

Technologies

• operate the fireplace without fully assembling all

components

• overre

• installunventedgaslogset

• installanycomponentnotapprovedbyHearth&Home

Technologies

• installpartsorcomponentsnotListedorapproved

Improper installation, adjustment, alteration, service or

maintenance can cause injury or property damage. For

assistance or additional information, consult a qualied

installer, service agency or your dealer.

B. Non-Combustible Materials

• Materialswhich willnot igniteand burn,composed of

anycombinationofthefollowing:

- Steel - Iron

- Brick - Tile

- Concrete - Slate

- Glass - Plasters

• MaterialsreportedaspassingASTM E 136, Standard

Test Method for Behavior of Metals, in a Vertical Tube

Furnace at 750° C

C. Combustible Materials

• Materialsmadeoforsurfacedwithanyofthefollowing

materials:

- Wood - Compressedpaper

- Plantbers - Plastic

- Plywood/OSB - Sheetrock(drywall)

• Anymaterialthatcanigniteandburn;ameproofedor

not,plasteredorun-plastered

1 ProductSpecic&ImportantSafetyInformation

A.FireplaceCertication

ThisreplacemaybeinstalledinsleepingroomsEX-

CEPTinmanufacturedhomes.Ifinstalledwithagaslog

set,provisionsfortheNationalFuelGasCodemustbe

met.

Thisreplacehasbeentestedandlistedforusewith

theoptionalcomponentsspeciedinthismanual.These

optionalcomponentsmaybepurchasedseparatelyand

installedatalaterdate.Anoutsideairkit,gasinsert,gas

logsetorgaslog-lightershouldbeinstalledatthetimeof

replaceinstallation.

HeatilatorisaregisteredtrademarkofHearth&Home

Technologies.

Thisreplacesystemhasbeentestedandlistedinaccor-

dancewithUL127standardsbyUnderwritersLaborato-

riesInc.forinstallationandoperationintheUnitedStates.

Heatilator • FL92 Installation Manual • 4012-081 • Rev C • 10/03/13

2 Getting Started

A. Typical Fireplace System

Figure 2.1 Typical Fireplace System

)

))

)

Non-combustible

roof flashing maintains

minimum clearance

around chimney

Additional lateral

support for chimney

above roof (or enclosed

in chase) if needed

Ceiling firestop

on floor of attic

Support straps

on rafter support

chimney (not shown)

Termination cap

Chimney penetrates roof

preferably without affecting

roof rafters

Offset & Return (with hanger straps)

Framing headed off

in ceiling joists

Enclosed space above

and around fireplace

Mantel and surround

Decorative facing

and trim

Hearth extension

Factory-built fireplace

Protective metal

hearth strip(s)

Outside

combustion air

Combustible framing/header

on top of V-shaped standoffs

Chimney system

Attic insulation shield (not shown)

must be used here to keep

insulation away from chimney

if attic is insulated

Storm Collar

Chimney Air Kit

Outlet must be

no less than

4 ft. (1.22 m) off

ground level.

6Heatilator • FL92 Installation Manual • 4012-081 • Rev C • 10/03/13

16 in.

(406 mm)

56 in.

(1422 mm)

12 in. (305 mm)

from opening of

fireplace

64 in.

(1626 mm)

62 in.

(1575 mm)

HEARTH

EXTENSION

(shaded)

1/2 in. min. (13 mm)

distance from fireplace to

combustible materials.

Note:

Figure 2.2 Fireplace Locations

NOTICE:

• Illustrationsandphotosreecttypicalinstallationsand

are FORDESIGNPURPOSESONLY.

• Illustrations/diagramsarenotdrawntoscale.

• Actualinstallation/appearancemayvaryduetoindividual

design preference.

• Hearth&HomeTechnologiesreservestherighttoalter

its products.

NOTICE: In addition to these framing dimensions, also

reference the following section:

• Clearances (Section 3).

NOTICE:

Aminimum1/2in.airclearanceatthebackofthe

replaceassemblymustbemaintained.

Chimneysectionsatanylevelrequirea2in.mini-

mum air space clearance between the framing

and chimney sections.

B. Design and Installation Considerations

NOTICE: Checkbuildingcodespriortoinstallation.

• InstallationMUSTcomplywithlocal,regional,stateand

nationalcodesandregulations.

• Consultinsurancecarrier,localbuildinginspector,re

ofcialsorauthoritieshavingjurisdictionoverrestrictions,

installationinspectionandpermits.

• Before installing,determinethefollowing:

- Wherethereplaceistobeinstalled.

- Theventsystemcongurationtobeused.

- Gassupplypiping.

- Electricalwiring.

- Framingandnishingdetails.

1. Selecting Fireplace Locations

Thisreplacemaybeusedasaroomdivider,installed

alongawall,acrossacornerorusedinanexteriorchase.

SeeFigure2.2.

Locatingthereplaceinabasementshouldbeavoided.

Locatingnearfrequentlyopeneddoors,centralheat

outletsorreturns,orotherlocationsofconsiderableair

movementcanaffecttheperformance.

Outsideairmustbeusedforcombustion.Thisreplace

comesequippedwithanoutsideairinlettofeedcombus-

tionairfromoutsidethehome,alongwithanoutsideair

terminationcap;therigidmetalductisrequiredbutnot

supplied.Considerationshouldbegiventothesefactors

beforedecidingonalocation.

Heatilator • FL92 Installation Manual • 4012-081 • Rev C • 10/03/13

2. LocatingFireplace&Chimney

Locationofthereplaceandchimneywillaffectperfor-

mance.

• Installwithinthewarmairspaceenclosedbythebuilding

envelope.Thishelpstoproducemoredraft,especially

duringlightinganddie-downofthere.

• Installingthereplaceinabasementisnotrecommended.

• Penetratethehighestpart oftheroof.Thisminimizes

theeffectsofwindloading.

• Locate termination cap away from trees, adjacent

structures,unevenrooflinesandotherobstructions.

• Minimizetheuseofchimneyoffsets.

• Considerthereplacelocationrelativetooorandceiling

andatticjoists.

• Takeintoconsiderationtheterminationrequirementsin

Sections4and5.

Marginal Location:

• Below peak

Location NOT recommended:

• Not the highest point of the roof

• Wind loading possible

Multi-level Roofs

Windward

Leeward

Recommended Location:

• Above peak

Recommended:

• Insulated exterior chase

in cooler climates

Recommended Location:

• Above peak

• Inside heated space

Location NOT recommended:

• Too close to tree

• Below adjacent structure

• Lower roof line

• Avoid outside wall

Marginal Location:

• Wind loading possible

Figure 2.3 Recommended Chimney Locations

• Installtheoutsideairkitwiththeintakefacingprevailing

windsduringtheheatingseason.

• Ensure adequate outdoor air for all combustion

appliancesandexhaustequipment.

• Ensurefurnaceandairconditioningreturnventsarenot

locatedintheimmediatevicinityofthereplace.

• Avoidinstallingthereplaceneardoors,walkwaysor

smallisolatedspaces.

• Recessedlightingshouldbea“sealedcan”design.

• Attichatchesweatherstrippedorsealed.

• Atticmountedductworkandairhandlerjointsandseams

tapedorsealed.

8Heatilator • FL92 Installation Manual • 4012-081 • Rev C • 10/03/13

C. Tools and Supplies Needed

Beforebeginningtheinstallationbesurethefollowing

toolsandbuildingsuppliesareavailable:

Reciprocatingsaw Framingmaterial

Pliers Non-combustiblesealant

Hammer Gloves

Phillipsscrewdriver Framingsquare

Flatbladescrewdriver Electricdrillandbits

Plumbline Safetyglasses

Level Tapemeasure

1/2-3/4in.length,#6or#8self-drillingscrews

Misc.screwsandnails

D. Inspect Fireplace and Components

WARNING! Risk of Fire and/or Explosion! Damaged

parts could impair safe operation. DO NOT install dam-

aged,incompleteorsubstitutecomponents.Keepre-

place dry.

• Removereplaceandcomponentsfrompackagingand

inspectfordamage.

• Vent system components and doors are shipped in

separatepackages.

• Reporttoyourdealeranypartsdamagedinshipment.

• Read all the instructions before starting the

installation. Follow these instructions carefully

during the installation to ensure maximum safety

andbenet.

E. Fireplace System Requirements

TheHeatilatorreplacesystemrequirementsconsistof

thefollowing:

• Fireplace

- Refractory(includedwithreplace)

- Firescreen(includedwithreplace)

- Grate(includedwithreplace)

- HearthExtension(required,soldseparately)

• OutsideAirSystem

- AirInletHood(includedwithreplace)

- Flex(required,soldseparately)

• ChimneySystem

- AtticInsulationShield(includedwithreplace)

- Chimneyterminationcap(required,soldseparately)

• Non-combustiblenishmaterial

• Doors/endpanel(required,soldseparately)

Heatilator • FL92 Installation Manual • 4012-081 • Rev C • 10/03/13

3 Framing and Clearances

A. Fireplace Dimensions

9-1/2 in.

(241 mm)

3 in.

(76 mm)

7 in.

(178 mm)

5-3/8 in.

(137 mm)

Gas

Knockout

Outside Air

Cover Plate

Electrical

Knockout

12 in.

(305 mm)

44 in.

(1118 mm)

47-1/8 in.

(1197 mm)

8-1/4 in.

(206 mm)

42-1/2 in.

(1080 mm)

36 in.

(914 mm)

40 in.

(1016 mm)

22-1/2 in.

(572 mm)

5-3/4 in.

(146 mm)

12 in.

(305 mm)

24 in.

(610 mm)

20 in.

(508 mm)

11 in.

(279 mm)

20 in.

(508 mm)

Figure 3.1 Fireplace Dimensions

10 Heatilator • FL92 Installation Manual • 4012-081 • Rev C • 10/03/13

B. Clearances

WARNING! Risk of Fire!

You must comply with all minimum air space clearances

tocombustiblesasspeciedinFigure3.2.DO NOTpack

required air spaces with insulation or other materials.

Framing or nishing material used on the front of, or in

frontof,thereplacecloserthantheminimumslistedmust

be constructed entirely of non-combustible materials (i.e.,

steel studs, concrete board, etc.). Failure to comply may

causere.

Figure 3.2 Clearances to Combustible Materials

Minimum Clearances to Combustibles

WITHIN ENCLOSURE AREA

Fireplacetobackwall 1/2in.(13mm)

Topstandoffstoheader 0in.(0mm)

Dooropeningtosidewall 26in.(660mm)

MANTEL

Mantelminimumheight 421/2in.(1080mm)

Maximummanteldepth 12in.(305mm)

(insulation)

0 in. to level

of standoffs

Attic

Insulation

Shield

(ceiling)

(roof)

(attic)

(ceiling)

Ceiling Firestop

Offset/Return (secured

with hanger straps)

Storm Collar

Roof Flashing

1/2 in. (13 mm) to

back of appliance

Must have 2 in. (51 mm)

minimum clearance

to header

0 in.

to floor

2 in. (51 mm) min.

Shaded areas

represent

2 in. (51 mm) min.

air space clearance

required around pipe

Combustible Object

48 in.

1219 mm

Andere Handbücher für FL92

Inhaltsverzeichnis

Andere Heatilator Kamin im Innenbereich Handbücher

Heatilator

Heatilator BIR42-B Bedienungsanleitung

Heatilator

Heatilator SC60 Benutzerhandbuch

Heatilator

Heatilator SILH20E-B Bedienungsanleitung

Heatilator

Heatilator MEL36 Bedienungsanleitung

Heatilator

Heatilator CL36D Bedienungsanleitung

Heatilator

Heatilator Direct Vent & B-Vent Gas Fireplace Caliber Bedienungsanleitung

Heatilator

Heatilator ST42A Bedienungsanleitung

Heatilator

Heatilator SILH30E-B Bedienungsanleitung

Heatilator

Heatilator CNXT4236IT-C Bedienungsanleitung

Heatilator

Heatilator GC300 series Bedienungsanleitung

Heatilator

Heatilator CL36D Bedienungsanleitung

Heatilator

Heatilator I80 Montageanleitung

Heatilator

Heatilator GC200 Handbuch

Heatilator

Heatilator Direct Vent Gas Appliance EDV3633 Bedienungsanleitung

Heatilator

Heatilator Wood Burning Fireplace I100 Bedienungsanleitung

Heatilator

Heatilator Gas Fireplace GDST3831I Bedienungsanleitung

Heatilator

Heatilator I60 Bedienungsanleitung

Heatilator

Heatilator HEIR36H Bedienungsanleitung

Heatilator

Heatilator ION-V7 Bedienungsanleitung

Heatilator

Heatilator HEIR36H-IFT Bedienungsanleitung

Heatilator

Heatilator Wood Burning Fireplace EL42 Series Bedienungsanleitung

Heatilator

Heatilator FireBrick Gas Insert ADI-ZCFB-S Bedienungsanleitung

Heatilator

Heatilator GC421 Handbuch

Heatilator

Heatilator CALIBER DESIGNER DIRECT VENT Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch