Heatilator ST42A Bedienungsanleitung

1Heatilator•ST42AInstallationManual•4012-051•RevC•10/03/13

Installationandserviceofthisreplaceshouldbe

performedbyqualiedpersonnel.Hearth&Home

TechnologiesrecommendsNFIcertiedprofes-

sionals,ortechnicianssupervisedbyan

NFIcertiedprofessional.

WOODBURNING FIREPLACE

Fire Risk.

WARNING

Forusewithsolidwoodfuelonly.

Otherfuelsmayoverreandgenerate

poisonousgases(i.e.carbonmonoxide).

Model(s):

Installation Manual

Installation and Fireplace Setup

WARNING

HOT SURFACES!

Glassandothersurfacesarehotduring

operationANDcooldown.

Hot glass will cause burns.

• DO NOTtouchglassuntilitiscooled

• NEVERallowchildrentotouchglass

• Keepchildrenaway

• CAREFULLY SUPERVISE children in same room as

replace.

• Alertchildrenandadultstohazardsofhightemperatures.

Hightemperaturesmayigniteclothingorotherammable

materials.

• Keep clothing, furniture, draperies and other ammable

materialsaway.

INSTALLER: Leave this manual with party responsible for use and operation.

OWNER: Retain this manual for future reference.

ST42A

NOTICE: DO NOT discard this manual!

• DO NOTstoreorusegasolineorotheram-

mablevaporsandliquidsinthevicinityofthis

oranyotherappliance.

• DO NOToverre.Overringwillvoidyour

warranty.

• Complywithallminimumclearancestocom-

bustiblesasspecied.Failuretocomplymay

causehousere.

WARNING: If the information in these

instructionsisnotfollowedexactly,are

or explosion may result causing property

damage, personal injury, or death.

2Heatilator • ST42A Installation Manual • 4012-051 • Rev C • 10/03/13

Safety Alert Key:

• DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury.

• WARNING!Indicatesahazardoussituationwhich,ifnotavoidedcouldresultindeathorseriousinjury.

• CAUTION! Indicatesahazardoussituationwhich,ifnotavoided,couldresultinminorormoderateinjury.

• NOTICE:Indicatespracticeswhichmaycausedamagetothereplaceortoproperty.

Table of Contents

1 ProductSpecic&ImportantSafetyInformation

A.FireplaceCertication 4

B.Non-CombustibleMaterials 4

C.CombustibleMaterials 4

2 Getting Started

A.TypicalFireplaceSystem 5

B.DesignandInstallationConsiderations 6

1.SelectingFireplaceLocations 6

2.LocatingFireplace&Chimney 7

C.ToolsandSuppliesNeeded 8

D.InspectFireplaceandComponents 8

E.FireplaceSystemRequirements 8

3 Framing and Clearances

A.FireplaceDimensions 9

B.Clearances 10

MinimumClearancestoCombustibles 10

C.ConstructtheChase 11

D.FrametheFireplace 12

E.SecureandLeveltheFireplace 12

F. ProtectiveMetalHearthStrips 13

G.OutsideAirKit 14

AK17Installation 14

4 Chimney and Termination Requirements

A.ChimneyRequirements 15

B.Offsets/Returns 16

C.TerminationRequirements 17

5 Chimney Installation

A.TypicalChimneySystem 18

B.AssembleChimneySections 19

C.InstallChimneyAirKit 19

D.SecureOffset/Return 20

E.InstallCeilingFirestops 20

F. InstallAtticInsulationShield 21

G.RoofPenetration 22

H.InstallChase/ChaseTop 22

I. TerminationCapRequirements 23

J. InstallTerminationCap 23

6 Shrouds

A.RadiationShield 25

1.OpenTopShroud 25

2.MailboxStyleShroud 26

3.RoofedStyleShroud 26

7 Finishing

A.FinishingMaterial 27

B.HearthExtension,BuildingandFinishing 28

1.FireplaceInstalledFlushontheFloor

 andHearthExtensionRaisedtoBottom

 ofFireboxOpening 29

2.RaisedHearthExtensionandRaisedFireplace 30

C.Non-CombustibleSealantMaterial 31

D.MantelandWallProjections 32

E.Sidewalls/Surrounds 33

8 Fireplace Setup

A.GasLog/LighterProvision 34

9 Reference Materials

A.ChimneyComponents 35

B.OptionalComponents 39

►

Heatilator • ST42A Installation Manual • 4012-051 • Rev C • 10/03/13

Customer:

Lot/Address

Model (circle one): ST42A

YES IF NO, WHY?

WARNING! Risk of Fire or Explosion! Failure to install fireplace acording to these instructions can lead to a fire or

explosion.

Verifiedthatthechaseisinsulatedandsealed.(Pg.11)

Verifiedclearancestocombustibles.(Pg.10)

Fireplaceisleveledandsecured.(Pg.12)

Hearthextensionsize/heightdecided.(Pg.28)

Chimneyconfigurationcomplieswithdiagrams.

Chimneyinstalled,lockedandsecuredinplacewithproperclearance.

Chimneyairkitinstalled.

Firestopsinstalled.

ATTENTION INSTALLER:

Follow this Standard Work Checklist

Thisstandardworkchecklististobeusedbytheinstallerinconjuctionwith,notinsteadof,theinstructionscontainedinthisinstallation

manual.

Date Installed:

Location of Fireplace:

Installer:

Dealer/Distributor Phone #

Serial #:

Roofflashinginstalled.

Terminationinstalled.

Protectivehearthstripsinstalledpermanualrequirements.(Pg.13)

Fireplace Install

Outsideairkitinstalled.(Pg14)

ChimneySection4&5(Pg.15)

Atticinsulationshieldinstalled.

Shrouds Section 6 (Pg. 25)

Shroudisinstalledproperlyperinstructions.

Fi i hi

S ti 7 (P 27)

Hearth&HomeTechnologiesrecommendsthefollowing:

Commentscommunicatedtopartyresponsible

4012-052•RevA•05/06/13

Allpackagingandprotectivematerialsremoved.

Optionaldoorsproperlyinstalled.

Moldedbrickpanelsinstalledcorrectly.

Grateisproperlyinstalled.

Firescreenproperlyinstalled.

__________________________by______________________on_________

(Builder/Gen.Contractor)(Installer)(Date)

Comments:Furtherdescriptionoftheissues,whoisresponsible(Installer/Builder/OtherTrades,etc.)andcorrectiveactionneeded:

Manualbagandallofitscontentsareremovedfromthefireplaceandgiventotheparty

responsibleforuseandoperation.

•Thatthischecklistremainvisibleatalltimesonthefireplaceuntiltheinstallationiscomplete.

•Photographingtheinstallationandcopyingthischecklistforyourfile.

Combustiblematerialsnotinstalledinnon-combustibleareas.

Finishing Section 7 (Pg. 27)

Hearthextensioninstalledpermanualrequirements.

Fireplace Setup Section 8 (Pg. 34)

Verifiedallclearancesmeetinstallationmanualrequirements.

Mantelsandwallprojectionscomplywithinstallationmanualrequirements.

4Heatilator • ST42A Installation Manual • 4012-051 • Rev C • 10/03/13

WARNING! Risk of Fire! Hearth & Home Technologies

disclaims any responsibility for, and the warranty and

agency listing will be voided by the following actions.

DO NOT:

• installoroperatedamagedreplace

• modifyreplace

• install other than as instructed by Hearth & Home

Technologies

• operate the fireplace without fully assembling all

components

• overre

• installunventedgaslogset

• installanycomponentnotapprovedbyHearth&Home

Technologies

• installpartsorcomponentsnotListedorapproved

Improper installation, adjustment, alteration, service or

maintenance can cause injury or property damage. For

assistance or additional information, consult a qualied

installer, service agency or your dealer.

B. Non-Combustible Materials

• Materialswhich willnot igniteand burn,composed of

anycombinationofthefollowing:

- Steel - Iron

- Brick - Tile

- Concrete - Slate

- Glass - Plasters

• MaterialsreportedaspassingASTM E 136, Standard

Test Method for Behavior of Metals, in a Vertical Tube

Furnace at 750° C

C. Combustible Materials

• Materialsmadeoforsurfacedwithanyofthefollowing

materials:

- Wood - Compressedpaper

- Plantbers - Plastic

- Plywood/OSB - Sheetrock(drywall)

• Anymaterialthatcanigniteandburn;ameproofedor

not,plasteredorun-plastered

1 ProductSpecic&ImportantSafetyInformation

A.FireplaceCertication

ThisreplacemaybeinstalledinsleepingroomsEX-

CEPTinmanufacturedhomes.Ifinstalledwithagaslog

set,provisionsfortheNationalFuelGasCodemustbe

met.

Thisreplacehasbeentestedandlistedforusewith

theoptionalcomponentsspeciedinthismanual.These

optionalcomponentsmaybepurchasedseparatelyand

installedatalaterdate.Anoutsideairkit,gasinsert,gas

logsetorgaslog-lightershouldbeinstalledatthetimeof

replaceinstallation.

HeatilatorisaregisteredtrademarkofHearth&Home

Technologies.

Thisreplacesystemhasbeentestedandlistedinaccor-

dancewithUL127andULC-S610standardsbyUnder-

writersLaboratoriesInc.forinstallationandoperationin

theUnitedStatesandCanada.

Heatilator • ST42A Installation Manual • 4012-051 • Rev C • 10/03/13

2 Getting Started

A. Typical Fireplace System

Figure 2.1 Typical Fireplace System

)

))

)

Non-combustible

roof flashing maintains

minimum clearance

around chimney

Additional lateral

support for chimney

above roof (or enclosed

in chase) if needed

Ceiling firestop

on floor of attic

Support straps

on rafter support

chimney (not shown)

Termination cap

Chimney penetrates roof

preferably without affecting

roof rafters

Offset & Return (with hanger straps)

Framing headed off

in ceiling joists

Enclosed space above

and around fireplace

Mantel and surround

Decorative facing

and trim

Hearth extension

Factory-built fireplace

Protective metal

hearth strip(s)

Outside

combustion air

Combustible framing/header

on top of V-shaped standoffs

Chimney system

Attic insulation shield (not shown)

must be used here to keep

insulation away from chimney

if attic is insulated

Storm Collar

Chimney Air Kit

Required in

Canada. Outlet

must be no

less than 4 ft.

(1.322 m) off

ground level.

6Heatilator • ST42A Installation Manual • 4012-051 • Rev C • 10/03/13

1/2 in. (13 mm)

all configurations

66 in.

(1676 mm)

42 in.

(1067 mm)

20 in. (508 mm)

(hearth

extension)

64 in.

(1626 mm)

12 in. (305 mm)

min. to

perpendicular

wall.

Figure 2.2 Fireplace Locations

NOTICE:

• Illustrationsandphotosreecttypicalinstallationsand

are FORDESIGNPURPOSESONLY.

• Illustrations/diagramsarenotdrawntoscale.

• Actualinstallation/appearancemayvaryduetoindividual

design preference.

• Hearth&HomeTechnologiesreservestherighttoalter

its products.

NOTICE: In addition to these framing dimensions, also

reference the following section:

• Clearances (Section 3).

NOTICE:

Aminimum1/2in.airclearanceatthebackand

sidesofthereplaceassemblymustbemain-

tained.

Chimneysectionsatanylevelrequirea2in.mini-

mum air space clearance between the framing

and chimney sections.

B. Design and Installation Considerations

NOTICE: Checkbuildingcodespriortoinstallation.

• InstallationMUSTcomplywithlocal,regional,stateand

nationalcodesandregulations.

• Consultinsurancecarrier,localbuildinginspector,re

ofcialsorauthoritieshavingjurisdictionoverrestrictions,

installationinspectionandpermits.

• Before installing,determinethefollowing:

- Wherethereplaceistobeinstalled.

- Theventsystemcongurationtobeused.

- Gassupplypiping.

- Electricalwiring.

- Framingandnishingdetails.

- Whetheroptionalaccessories-devicessuchasa

fan,wallswitchorremotecontrol-aredesired.

1. Selecting Fireplace Locations

Thisreplacemaybeusedasaroomdivider,installed

alongawall,acrossacornerorusedinanexteriorchase.

SeeFigure2.2.

Locatingthereplaceinabasementshouldbeavoided.

Locatingnearfrequentlyopeneddoors,centralheat

outletsorreturns,orotherlocationsofconsiderableair

movementcanaffecttheperformance.

Outsideairmustbeusedforcombustion.Thisreplace

comesequippedwithanoutsideairinlettofeedcombus-

tionairfromoutsidethehome,alongwithanoutsideair

terminationcap;therigidmetalductisrequiredbutnot

supplied.Considerationshouldbegiventothesefactors

beforedecidingonalocation.

Heatilator • ST42A Installation Manual • 4012-051 • Rev C • 10/03/13

2. LocatingFireplace&Chimney

Locationofthereplaceandchimneywillaffectperfor-

mance.

• Installwithinthewarmairspaceenclosedbythebuilding

envelope.Thishelpstoproducemoredraft,especially

duringlightinganddie-downofthere.

• Installingthereplaceinabasementisnotrecommended.

• Penetratethehighest partoftheroof.Thisminimizes

theeffectsofwindloading.

• Locate termination cap away from trees, adjacent

structures,unevenrooflinesandotherobstructions.

• Minimizetheuseofchimneyoffsets.

• Considerthereplacelocationrelativetooorandceiling

andatticjoists.

• Takeintoconsiderationtheterminationrequirementsin

Sections4and5.

Marginal Location:

• Below peak

Location NOT recommended:

• Not the highest point of the roof

• Wind loading possible

Multi-level Roofs

Windward

Leeward

Recommended Location:

• Above peak

Recommended:

• Insulated exterior chase

in cooler climates

Recommended Location:

• Above peak

• Inside heated space

Location NOT recommended:

• Too close to tree

• Below adjacent structure

• Lower roof line

• Avoid outside wall

Marginal Location:

• Wind loading possible

Figure 2.3 Recommended Chimney Locations

• Installtheoutsideairkitwiththeintakefacingprevailing

windsduringtheheatingseason.

• Ensure adequate outdoor air for all combustion

appliancesandexhaustequipment.

• Ensurefurnaceandairconditioningreturnventsarenot

locatedintheimmediatevicinityofthereplace.

• Avoidinstallingthereplaceneardoors,walkwaysor

smallisolatedspaces.

• Recessedlightingshouldbea“sealedcan”design.

• Attichatchesweatherstrippedorsealed.

• Atticmountedductworkandairhandlerjointsandseams

tapedorsealed.

8Heatilator • ST42A Installation Manual • 4012-051 • Rev C • 10/03/13

C. Tools and Supplies Needed

Beforebeginningtheinstallationbesurethefollowing

toolsandbuildingsuppliesareavailable:

Reciprocatingsaw Framingmaterial

Pliers Non-combustiblesealant

Hammer Gloves

Phillipsscrewdriver Framingsquare

Flatbladescrewdriver Electricdrillandbits

Plumbline Safetyglasses

Level Tapemeasure

1/2-3/4in.length,#6or#8self-drillingscrews

Misc.screwsandnails

D. Inspect Fireplace and Components

WARNING! Risk of Fire and/or Explosion! Damaged

parts could impair safe operation. DO NOT install dam-

aged,incompleteorsubstitutecomponents.Keepre-

place dry.

• Removereplaceandcomponentsfrompackagingand

inspectfordamage.

• Vent system components and doors are shipped in

separatepackages.

• Reporttoyourdealeranypartsdamagedinshipment.

• Read all the instructions before starting the

installation. Follow these instructions carefully

during the installation to ensure maximum safety

andbenet.

E. Fireplace System Requirements

TheHeatilatorreplacesystemrequirementsconsistof

thefollowing:

• Fireplace

- Refractory(includedwithreplace)

- Firescreen(includedwithreplace)

- Grate(includedwithreplace)

- HearthExtension(required,soldseparately)

• OutsideAirSystem

- AirInletHood(includedwithreplace)

- Flex(required,soldseparately)

• ChimneySystem

- AtticInsulationShield(includedwithreplace)

- Chimneyairkit(requiredinCanada,soldseparately)

- Chimneyterminationcap(required,soldseparately)

• Non-combustiblenishmaterial

Heatilator • ST42A Installation Manual • 4012-051 • Rev C • 10/03/13

3 Framing and Clearances

A. Fireplace Dimensions

Gas

Knockout

Outside

Air

58-7/8 in.

(1496 mm)

(effective height)

38-3/8 in.

(975 mm)

11-3/4 in.

(298 mm)

8-5/8 in.

(219 mm)

13 in.

[330 mm]

dia.

42 in.

(1067 mm)

23 in.

(585 mm)

7-1/2 in.

(192 mm)

39-1/8 in.

(995 mm)

Gas

Knockout

8-3/8 in.

(213 mm)

14 in.

(356 mm)

8-3/8 in.

(213 mm)

14 in.

(356 mm)

47 in.

(1194 mm)

28 in.

(711 mm)

23-1/2 in.

(597 mm)

14 in.

(356 mm)

5-7/8 in.

(149 mm)

Figure 3.1 Fireplace Dimensions

10 Heatilator • ST42A Installation Manual • 4012-051 • Rev C • 10/03/13

B. Clearances

WARNING! Risk of Fire!

You must comply with all minimum air space clearances

tocombustiblesasspeciedinFigure3.2.DO NOTpack

required air spaces with insulation or other materials.

Framing or nishing material used on the front of, or in

frontof,thereplacecloserthantheminimumslistedmust

be constructed entirely of non-combustible materials (i.e.,

steel studs, concrete board, etc.). Failure to comply may

causere.

Figure 3.2 Clearances to Combustible Materials

Minimum Clearances to Combustibles

WITHIN ENCLOSURE AREA

Fireplacetobackwall 1/2in.(13mm)

Fireplacetosidewall 1/2in.(13mm)

Topstandoffstoheader 0in.(0mm)

Dooropeningtosidewall 12in.(305mm)

MANTEL

Mantelminimumheight 421/2in.(1079mm)

Maximummanteldepth 12in.(305mm)

(roof)

(insulation)

0 in. to level

of standoffs

Attic

Insulation

Shield

(ceiling)

(attic)

(ceiling)

Offset/Return (secured

with hanger straps)

Storm Collar

Roof Flashing

3/4 in. (19 mm) to back &

sides of appliance

(except at nailing flanges

where it is 1/2 in. [13 mm])

Must have 2 in. (51 mm)

minimum clearance

to header

0 in.

to floor

2 in. (51 mm) min.

Shaded areas

represent

2 in. (51 mm) min.

air space clearance

required around pipe

Combustible Object

48 in.

1219 mm

Adapter

Ceiling Firestop

Note: Chimneyairkit and11-10

in./279-254 mm adapter are

not shown, but are required in

Canada.

Andere Handbücher für ST42A

Inhaltsverzeichnis

Andere Heatilator Kamin im Innenbereich Handbücher

Heatilator

Heatilator GDST5244I Bedienungsanleitung

Heatilator

Heatilator Wood Burning Fireplace ST36D Bedienungsanleitung

Heatilator

Heatilator LM42 Bedienungsanleitung

Heatilator

Heatilator Fi36S Handbuch

Heatilator

Heatilator NASIM Bedienungsanleitung

Heatilator

Heatilator Novus NDV3630 Bedienungsanleitung

Heatilator

Heatilator BIR36-B Bedienungsanleitung

Heatilator

Heatilator HST-42D Bedienungsanleitung

Heatilator

Heatilator Novus ND3630 Handbuch

Heatilator

Heatilator CONSTITUTION C-40 Bedienungsanleitung

Heatilator

Heatilator NEVO4236I Bedienungsanleitung

Heatilator

Heatilator BIR42-B Bedienungsanleitung

Heatilator

Heatilator Gas Fireplace GDFL4136I Bedienungsanleitung

Heatilator

Heatilator Wood Burning Fireplace A36C Bedienungsanleitung

Heatilator

Heatilator GDST5244I Bedienungsanleitung

Heatilator

Heatilator GC100 Bedienungsanleitung

Heatilator

Heatilator GDCH60 Series Bedienungsanleitung

Heatilator

Heatilator Wood Burning Fireplace EL36 Series Bedienungsanleitung

Heatilator

Heatilator Birmingham BIR50 Bedienungsanleitung

Heatilator

Heatilator RAVE3012I Bedienungsanleitung

Heatilator

Heatilator CRAVE4836-C Bedienungsanleitung

Heatilator

Heatilator BH42A Bedienungsanleitung

Heatilator

Heatilator Wood Burning Fireplace ST36D Bedienungsanleitung

Heatilator

Heatilator NDV3630I-B Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch