Henny Penny EVOLUTION ELITE EEG-242 Bedienungsanleitung

TECHNICAL

MANUAL

Evolution Elite™ Gas Open Fryer

MODEL

EEG-241

EEG-242

EEG-243

EEG-244

Model EEG-241, 242, 243, 244

iAug. 2014

TABLE OF CONTENTS

Section Page

Section 1. TROUBLESHOOTING................................................................................... 3

1-1 Introduction .................................................................................................. 3

1-2 Safety............................................................................................................ 3

1-3 Troubleshooting............................................................................................ 4

1-4 Error Code Table .......................................................................................... 7

Section 2. INFO & FILTER BUTTON STATS................................................................. 10

2-1 INFO Button Stats ........................................................................................ 10

2-2 FILTER Button Stats .................................................................................... 10

Section 3. INFORMATION MODE............................................................................... 11

3-1 Information Mode Details ............................................................................. 11

Section 4. PRODUCT PROGRAM MODE................................................................... 17

4-1 Modifying Product Settings........................................................................... 17

Section 5. LEVEL 2 PROGRAMMING ........................................................................... 20

5-1 Special Program Mode ................................................................................... 20

5-2 Clock Set ........................................................................................................ 29

5-3 Data Logging, Heat Control, Tech, Stat & Filter Control Modes .................. 29

5-4 Tech Mode ...................................................................................................... 30

5-5 Stats Mode...................................................................................................... 36

5-6 Do Not Disturb ............................................................................................... 37

Section 6. MAINTENANCE SECTION...................................................................................... 38

6-1 Introduction.............................................................................................................. 38

6-2 Maintenance Hints ................................................................................................... 38

6-3 Preventive Maintenance........................................................................................... 38

6-4 Control Panel and Menu Card Replacement............................................................ 39

6-5 High Temperature Limit Control ............................................................................. 40

6-6 Main Power switch................................................................................................... 41

6-7 Probe Replacement .................................................................................................. 42

Model EEG-241, 242, 243, 244

iiAug. 2014

Section 6. MAINTENANCE SECTION (Continued)

6-8 Solenoid Valves .............................................................................................. 45

6-9 Filter Pump & Motor...................................................................................... 48

6-10 JIB Pump ........................................................................................................ 50

6-11 Blower Replacement ...................................................................................... 51

6-12 Filter Beacon .................................................................................................. 52

6-13 Air Pressure Switches..................................................................................... 53

6-14 Pilot Replacement .......................................................................................... 54

Section 7. PARTS SECTION

7-1 Parts................................................................................................................ 63

TABLE OF CONTENTS

Section Page

Model EEG-241, 242, 243, 244

3Aug. 2014

This section provides troubleshooting information in the form

of an easy to read table.

If a problem occurs during the rst operation of a new fryer,

recheck the installation per the Installation Section of this

manual.

Before troubleshooting, always recheck the operation

procedures per Section 3 of this manual.

SECTION 1. TROUBLESHOOTING

Where information is of particular importance or safety related,

the words DANGER, WARNING, CAUTION, and NOTICE

are used. Their usage is described below.

SAFETY ALERT SYMBOL is used with DANGER,

WARNING, or CAUTION which indicates a personal

injury type hazard.

NOTICE is used to highlight especially important

information.

CAUTION used without the safety alert symbol indicates a

potentially hazardous situation which, if not avoided, may

result in property damage.

CAUTION indicates a potentially hazardous situation

which, if not avoided, may result in minor or moderate

injury.

WARNING indicates a potentially hazardous situation

which, if not avoided, could result in death or serious

injury.

DANGER INDICATES AN IMMINENTLY

HAZARDOUS SITUATION WHICH, IF NOT

AVOIDED, WILL RESULT IN DEATH OR SERIOUS

INJURY.

1-2. SAFETY

1-1. INTRODUCTION

Model EEG-241, 242, 243, 244

4Aug. 2014

To isolate a malfunction, proceed as follows:

1. Clearly dene the problem (or symptom) and when it

occurs.

2. Locate the problem in the Troubleshooting table.

3. Review all possible causes. Then, one-at-a-time work

through the list of corrections until the problem is solved.

4. Refer to the maintenance procedures in the Maintenance

Section to safely and properly make the checkout and repair

needed.

1-3. TROUBLESHOOTING

If maintenance procedures are not

followed correctly, injuries and/or

property damage could result.

Model EEG-241, 242, 243, 244

5Aug. 2014

Problem Cause Correction

POWER switch ON

but fryer completely

inoperative

• Open circuit • Plug fryer in

• Check breaker or fuse at supply box

“E-10” • Hight limit Let unit cool down (15-20 minutes),

push up on metal reset button under

right side of the controls; if high limit

does not reset, high limit must be

replaced

Vat is under-lled • JIB is low or empty

• JIB oil line is clogged or

collapsed

• Filter pan needs cleaned

• Fill the JIB

• Check JIB line

• Clean lter pan and change paper or

pad

7-1. TROUBLE SHOOTING

(Continued)

Model EEG-241, 242, 243, 244

6Aug. 2014

Problem Cause Correction

Oil foaming or boiling over

top of vat

• Water in oil

• Improper or bad oil

• Improper ltering

• Improper rinsing after

cleaning the vat

• Drain and clean oil

• Use recommended oil

• Refer to ltering procedures

• Clean and rinse vat and then dry thoroughly

Oil will not drain from vat • Drain valve clogged with

crumbs

• Drain trough clogged

• Open valve, force cleaning brush through

drain

• Remove right side panel and remove plug

from end of trough and clean trough

Filter motor runs but pumps

oil slowly

• Filter line connections loose

• Filter paper or pad clogged

• Filter not reassembled

correctly

• Tighten all lter line connections

• Change lter paper or pad

• Refer to assembly instructions on inside door

Bubbles in oil during entire

ltering process

• Filter pan not completel

engaged

• Filter pan clogged

• Damaged O-ring on lter line

receiver on fryer

• Make sure lter pan return line is pushed

completely into the receiver on the fryer

• Clean pan and change paper or pad

• Change O-ring

Filter motor will not run • The thermal reset button on

the rear of the pump motor is

tripped

• Allow time for the motor to cool and

then, using a screwdriver, press hard

against the button until it clicks

To prevent burns caused by

splashing shortening, turn

the unit’s POWER switch

to the OFF position before

resetting the lter pump

motor’s manual reset

protection device.

7-1. TROUBLE SHOOTING

(Continued)

Model EEG-241, 242, 243, 244

7Aug. 2014

1-4. ERROR CODES In the event of a control system failure, the digital display

shows an error message. The message codes are shown in the

DISPLAY column below. A constant tone is heard when an er-

ror code is displayed, and to silence this tone, press any button.

DISPLAY CAUSE CORRECTION

“E-4” • Control board

overheating

Turn switch to OFF position, then turn switch back

to ON; if display shows “E-4”, the control board is

getting too hot; check the louvers on each side of

the unit for obstructions

“E-5” • Oil overheating Turn switch to OFF position, then turn switch back

to ON; if display shows “E-5”, the heating circuits

and temperature probe should be checked

“E-6A” • Temperature probe

open

Turn switch to OFF position, then turn switch back

to ON; if display shows “E-6A”, the temperature

probe should be checked

“E-6B” • Temperature probe

shorted

Turn switch to OFF position, then turn switch back

to ON; if display shows “E-6B”, the temperature

probe should be checked

“E-10” • Hight limit Let unit cool down (15-20 minutes), push up on

metal reset button under right side of the controls;

if high limit does not reset, high limit must be

replaced

“E-15” • Drain switch Make sure drain knob is completely pushed-in; if E-15

persists, have drain switch checked

“E-18-A”

“E-18-B”

“E-18-C”

• LH level sensor open

• RH level sensor open

• Both sensors open

Turn switch to OFF position, then turn switch back to

ON; if display still indicates a failed sensor, have the

connectors checked at the control board; have sensor

checked & replace if necessary

Model EEG-241, 242, 243, 244

8Aug. 2014

“E-20-A”

“FAN SENSOR

STUCK

CLOSED”

• Pressure Switch

failure

• Wiring problem

• I/O board failure

• If fan is not running, have pressure switch

checked; should be open circuit if no air

pressure

• If fan is running, wiring error, or relay on I/O board

closed

“E-20-B”

“NO DRAFT”

“CHECK FAN”

• Pressure switch

failure/ hose loose

• Draft fan failure/ low

voltage

• Flue or hood

obstruction

• Press power button to vat off and back on again,

if E-20-B persists, have pressure switch checked;

should be open circuit if no air pressure; make sure

hose is connected to fan and pressure switch

• Have draft fan checked; low voltage going to fan

• Check the fryer ue and hood system for obstructions

“E-20-D”

“IGNITION”

“FAILURE”

• Failure to ignite/ no

ame sense

• Plugged atmospheric

equalization hole

in regulator cap

resulting in pilot

ame slowly fading

• Press power button to vat off and back on again, if

E-20-D persists, check gas line connections; check

gas shutoff valve; check ignition module; check gas

valve; check ame sensor gap; check gas valve, and

check ignition module wiring

• Clear obstruction from hole

“E-21” • Slow heat recovery • Have a certied service technician check the fryer for

correct voltage to the unit; have heat circuit checked;

have unit checked for loose or burnt wire

“E-22”

“NO HEAT”

“CHECK GAS

VALVE”

• Burner not igniting • Have gas valve and heat circuit checked

“E-41 “ / “E-46” • Programming failure • Press power button to vat off and back on again,

if any of the error codes, have the controls re-

initialized; if error code persists, have the control

board replaced

“E-47” • Analog converter

chip or 12 volt

supply failure

• Press power button to vat off and back on again,

if “E-47” persists, have the I/O board, or the

PC board replaced; if speaker tones are quiet,

probably I/O board failure; have the I/O board

replaced

“E-48” • Input system error • Have PC board replaced

“E-54-C” • Temperature input

error

• Turn switch to OFF, then back to ON; have

control PC board replaced if “E-54C” persists

1-4. ERROR CODES (Continued)

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Henny Penny Fritteuse Handbücher

Henny Penny

Henny Penny OFE-341 Bedienungsanleitung

Henny Penny

Henny Penny OFG-341 Bedienungsanleitung

Henny Penny

Henny Penny COMPUTRON 7000 Bedienungsanleitung

Henny Penny

Henny Penny LOV LVE-100 Series Bedienungsanleitung

Henny Penny

Henny Penny PFG-600 Bedienungsanleitung

Henny Penny

Henny Penny OFE-324 Bedienungsanleitung

Henny Penny

Henny Penny F5 Bedienungsanleitung

Henny Penny

Henny Penny OFE-290 Bedienungsanleitung

Henny Penny

Henny Penny OFE-322 Bedienungsanleitung

Henny Penny

Henny Penny 301 Bedienungsanleitung

Henny Penny

Henny Penny PFE-590 Bedienungsanleitung

Henny Penny

Henny Penny LOV LVG-100 Series Leitfaden

Henny Penny

Henny Penny LOV LVG-102 Bedienungsanleitung

Henny Penny

Henny Penny FM03-681 Bedienungsanleitung

Henny Penny

Henny Penny OFE-292 Bedienungsanleitung

Henny Penny

Henny Penny 291 Bedienungsanleitung

Henny Penny

Henny Penny 600 Bedienungsanleitung

Henny Penny

Henny Penny Evolution Elite Bedienungsanleitung

Henny Penny

Henny Penny OFE-341 Betriebsanleitung

Henny Penny

Henny Penny none Bedienungsanleitung

Henny Penny

Henny Penny Evolution Elite EEE-153 Bedienungsanleitung

Henny Penny

Henny Penny F5 Bedienungsanleitung

Henny Penny

Henny Penny PFE-590 Bedienungsanleitung

Henny Penny

Henny Penny LOV LVE-200 Series Bedienungsanleitung

Beliebte Fritteuse Handbücher anderer Marken

Innsky

Innsky 55SA1US Bedienungsanleitung

Falcon

Falcon G350/11 Benutzerhandbuch

GoWISE USA

GoWISE USA GW22612 Bedienungsanleitung

Wolf

Wolf IF15/S Bedienungsanleitung

Electrolux

Electrolux Thermetic 9CHG583284 Kurzanleitung

Gourmia

Gourmia GAF799 Bedienungsanleitung

DeLonghi

DeLonghi D677UX Bedienungsanleitung

SEVERIN

SEVERIN DEEP FRYER - Benutzerhandbuch

Toastmaster

Toastmaster TMFG18-NAT Bedienungsanleitung

Domo

Domo DO465FR Bedienungsanleitung

Farberware

Farberware FBW FT 43721 B Bedienungsanleitung

GERMANICA

GERMANICA GEAF5L3LD Bedienungsanleitung

Roller Grill

Roller Grill MF 120 R Bedienungsanleitung

Philips

Philips HD9211 Bedienungsanleitung

Linea 2000

Linea 2000 Domo DO536FR Bedienungsanleitung

Lakeland

Lakeland 31796 Bedienungsanleitung

Dash

Dash Tasti-Crisp DFAF755 Bedienungsanleitung

Fagor

Fagor F-200 Bedienungsanleitung