Honeywell MM14CCS Bedienungsanleitung

220-240V 50Hz

MM14CCS

Important points on service, and flow chart

for inspecting and repairing the unit ...............

Troubleshooting .............................................

Appearance and unit dimensional ...................

Operation ....................................................

Technical specifications ..............................

Refrigerator system and schematic wiring

diagrams ........................................................

Exploded view ................................................

Parts list ..................................................

This ma nual is for the use of technical personnel entrusted

with ma intenance.

Air tek reserves the right to change this por table air

conditioner’s casing, circuit and par ts without notice.

MM14CCS_SM_ENG_1

Date: 06/02/2014

SERVICE MANUAL

4-5

9-11

STOP

Portable Air Conditioner

14,000BTU

Cooling

LCD display

Single hose

IMPORTANT POINTS ON SERVICE OPERATING SAFETY

Please follow these instructions carefully :

FLOW CHART FOR INSPECTING AND REPAIRING THE UNIT

- 1 -

Unplug the unit to avoid any danger from electric shock before disassembling the unit for

repair.

If there is any sound of the refrigerant circulating when in operation, avoid touching the

cooling coils.

If you need to perform any welding or soldering, be sure you are in a well ventilated area.

Only a qualified professional should perform any welding on the unit.

When repairing the unit, the specifications listed in this manual must be strictly adhered

to when replacing any components.

When replacing any electrical components they should be factory approved units.

Be sure that any electrical components are properly wired and in place.

PLUG AND SOCKET

ARE LOOSE

RE-PLUGING THE

POWER SUPPLY CORD

AIR CONDITIONER

WON'T COOL

PROPERLY

AIR CONDITIONER

WON'T START

COMPRESSOR WON'T

START

TIMER FAILURE

CHANGE THE

PROTECTOR

RUNNING TEST

RE-CONNECTING

NO POWER

PROTECTOR FAILURE

USE OXYACETYLENE AND PLUS 5%

SILVER SOLDER TO WELD THE

CRACKED POINTS

WIRING IS LOOSE

CAPACITOR FAILURE

CHANGE THE SWITCH

CHANGE THE

CAPACITOR

TESTING BY

ELECTROSCOPE

POWER TRIPPED CHECK THE POWER

SWITCH

REFRIGERANT

LEAKAGE

TROUBLE SHOOTING

THE SYSTEM

RUNNING THE VACUUM

EVACUATION FOR MORE

THAN 15 MINUTES

CHANGE COOLANT AND

PROCEED RUNNING TEST

CHANGE THE AIR CONDITIONER WITH 15 KG/CM 2

NITROGEN GAS FROM LOW-PRESSURE SIDE AND

DETECT THE LEAKING POINT BY SOAP

TROUBLESHOOTING

Problem

- 2 -

Analysis

Does not run

·If the protector trip or fuse is blown.

·Please wait for 3 minutes and start again, protector

device may be preventing unit to work.

·If batteries in the remote controller exhausted.

·If the plug is not properly plugged.

Run a short while

only

Run but not cool

Do not run and water

full indicator lights

·If the set temperature is close to

you can low the set temperature.

·Air outlet be blocked by obstacle.

Take the obstacle away.

room temperature,

·If the door or window open.

·If there is other heater appliance work,

like heater or lamp, etc...

·The air filter is dirty, please clean it.

·Air outlet or intake be blocked.

·Set temperature is too high.

·Drain the water into a prepared container by the drainage

pipe on the rear panel of the unit.

If still doesn't work, please consult a qualified technician.

APPEARANCE

- 3 -

Control panel

Wheels

Air exhaust for air to be

cooled/filtered

Front Panel

Handles

Air inlet for air to

be cooled / filtered

Air outlet

Air filter

Electricity cable Water drain

Air inlet

UNIT DIMENSIONAL

506.6 401.6

864.3

Water

outlet drain

OPERATION

- 4 -

CONTROL PANEL

Power Control

Mode Control

Timer

Timer / Temp

Set Controls

Power Control

The power control turns the unit on and off.

Mode Control

The Mode Control has 3 settings:

● Cool ● Dehumidify ● Fan

The settings are adjusted with Mode Control button.

A light will indicate which setting is currently being

used.

Cooling Mode

During the cooling mode the air is cooled and hot air

is exhausted to the outside through the exhaust tube.

Adjust fan speed and air temperature to suit your desired

comfort level. Temperature setting range is 16℃ ~ 32℃.

Note : The air exchange hoses must vent outside the

room when using cool mode.

Dehumidify Mode

When dehumidify mode is selected, the indicator light will

shine . Air is dehumidified as it passes through the unit,

without being in full cooling mode If room temperature is

higher than 25 degree Celsius, fan speed can be adjusted;

otherwise fan speed is fixed to " LOW ".

Note : If the unit will be used mainly as dehumidifier,

do not connect the exhaust hose and let the warm air

return in the room. Continuous drainage is then

necessary and more efficient.

Fan Mode

When fan mode is selected the indicator light will shine.

Air is circulated throughout the room with no cooling.

Note: unit does not need to be vented in Fan mode

Fan Speed Control

The Fan Speed Control has 3 settings: High, Medium,

and Low.

Timer

Auto turn off :

With machine in running mode, press timer button to

select number of hours you would like the unit to run in

air conditioning mode until it automatically shuts off.

Auto turn on :

With machine in stand by mode, press timer button to

select number of hours until you would like the unit to

automatically start running in air conditioning mode.

Timer / Temp set controls

● Used for adjusting the timer and thermostat.

● The default display is room temperature.

● In cooling mode, when “ “ or “ “ button is pressed,

the set temperature is displayed and may be adjusted.

After 10 seconds the display will revert back to room

temperature. Temperature is only adjustable in cool

mode. The time is adjustable between 1~24 hours.

Note : By pressing both “ “ / “ “ set buttons

at the same time, the display will toggle

between Celsius and Fahrenheit.

Warning Light

Condensed water may accumulate in the unit. If the

internal tank becomes full, the Warning Light will shine

and the unit will not operate until the unit has been

drained.

STOP

Cooling mode

Dehumidify mode

Fan only mode

High fan sp eed

Med fan sp eed

Low fan sp eed

Display se t

temperature

Warni ng light

machine will stop run ning

the

Display timer setting

of auto sw itch on/off

Indication symbols on LCD :

Fan Speed Control

OPERATION

CONTROL PANEL

- 5 -

Air Conditioner Remote Control

The functions work the same as your air conditioner's touch controls.

Batteries : Remove the cover on the back of the remote controller and insert the batteries with the

( + ) and ( - ) poles pointing in the proper direction.

CAUTION

Use only AAA or IEC R03 1.5V batteries.

Remove the batteries if the remote controller is not used for a month or longer.

Do not attempt to recharge the supplied batteries

All batteries should be replaced at the same time.

Do not dispose of the batteries in a fire as they may explode.

！

Fan Speed Key

Timer / Temperature Buttons

Power Key

On / Off

On / Off Timer Key

In running mode :

Auto switch off

In standby mode:

Auto switch on

:LOW :HIGH :MED

● Used for adjusting the timer and

thermostat.

● The default display is room temperature.

● When " " or " " button is pressed,

the set temperature is displayed and

may be adjusted. After 10 seconds the

display will revert back to room

temperature.

cooling mode

lamp is on when in

Set-up of Function key

: lamp is on when in

fan mode

dehumidification mode

lamp is on when in

TIMER MODE

SPEED

ON/OFF

DOWN UP

TECHNICAL SPECIFICATIONS

- 6 -

ITEM UNIT

OUTER DIMENSION

RATED VOLTAGE

COOLING CAPACITY

DEHUMIDIFYING

CAPACITY

POWER

CONSUMPTION

INDOOR AIR VOLUME

COMPRESSOR

MODEL

Specification

OPERATING

CYCLE

PROTECTOR

MODEL

INPUT

POWER

TURBINE

FAN MOTOR

CAPILLARY

CONDENSER

REFRIGERANT

WEIGHT

REFERENTIAL USING

AREA

506.6W*506.6H*401.6D

220-240 / 50

1400

420

1160

35/400

RSH6870S1

DC12V 0.09A

4/450

2.2(O.D.)*1.0(I.D.)*700(L)

(2+3)R20S19FPI

MM14CCS

14000

12~21

1.9

35.5

OPERATING

CYCLE

MODEL

OUTPUT

POWER

INDOOR

MOTOR

LS-23D3-4P

2/450

OPERATING

CYCLE

MODEL

OUTPUT

POWER

OUTDOOR

MOTOR

LS-53D1-4P

EVAPORATOR 3R14S19FPI

V/Hz

B.T.U.

L/H

M /hr

uF/V

R410A/g

uF/V

44N110-A1-BEAD

Containing

850

- 7 -

REFRIGERATOR SYSTEM DIAGRAM

EVAPORATOR

CONDENSOR

COMPRESSOR

CAPILLARY

FILTER

SCHEMTIC WIRING DIAGRAM

EXPLODED VIEW

- 8 -

Date : 2014/02/21 Version : 1.0

19 21

11 13 14

ACCESSORIES

62 63 64 65 66 67

58 59

70 71

PARTS LIST MM14CCS

- 9 -

MATERIAL CODE PARTS NAME QUANTITY

PRICE

A4805-22H-A-11

A7402-020

A5408-250-H-11

A5408-230-H-11

A5405-110-H-11

A5404-090

A2506-040

A5812-630-X-11

A3020-630

A5311-030-A-11

A3202-900

A5600-170

A6209-270

A6228-300

A3423-120

D6202-210

A6212-190

A5301-610-AB-22

A5304-470-I-11

A3002-460

A5301-620-AB -22

A2509-640

A2510-200

A6101-920-AF-11

A6101-800-AF-11

A5825-050-AF-11

A5702-080-A-22

A3419-341

A5301-590-A-22

A5304-310-A-22

A3001-760

A5301-600-A-22

A7204-040

A2509-120

A6101-510-AF-11

BASE PAN

TURNING WHEEL

DRAIN BUCKET COVER-B

DRAIN BUCKET COVER-A

TANK LID

FLOAT

MICRO SWITCH

FIX TURE

WATER MOTOR(WT-15D1-03)

BLADE

COMPRESSOR ASS'Y(44N110-A1)

RUBBER

DISCHARGE PIPE

SUCTION PIPE

CONDENSER ASS'Y

CAPILLARY TUBE

Y TUBE

FAN CASING

BLOWER WHEEL

FAN MOTOR(LS-53D1-4P)

FAN CASING

CAPACITOR(4uF/450V FOR FAN MOTOR(20))

CAPACITOR( 35uF/400V FOR COMPRESSOR(11))

COVER

FIX TURE

PLATE

EVAPORATOR ASS'Y

FAN CASING

BLOWER WHEEL

FAN MOTOR(LS-23D3-4P)

FAN CASING

SCREEN

CAPACITOR(2uF/450V FOR FAN MOTOR(31)

COVER

Andere Handbücher für MM14CCS

Inhaltsverzeichnis

Andere Honeywell Klimaanlage Handbücher

Honeywell

Honeywell HW-QUICK12E Bedienungsanleitung

Honeywell

Honeywell CL201AE Bedienungsanleitung

Honeywell

Honeywell HM0CESAWK6 Bedienungsanleitung

Honeywell

Honeywell MN14 Series Bedienungsanleitung

Honeywell

Honeywell MM Series Bedienungsanleitung

Honeywell

Honeywell MM14CHCS Bedienungsanleitung

Honeywell

Honeywell CL48PM Bedienungsanleitung

Honeywell

Honeywell EH1682 Leitfaden

Honeywell

Honeywell CL30XC Bedienungsanleitung

Honeywell

Honeywell TC09PE Bedienungsanleitung

Honeywell

Honeywell MM14CCS Bedienungsanleitung

Honeywell

Honeywell CL20AE Bedienungsanleitung

Honeywell

Honeywell HT09CESAWK Bedienungsanleitung

Honeywell

Honeywell CL60PM Series Bedienungsanleitung

Honeywell

Honeywell TC09PM Bedienungsanleitung

Honeywell

Honeywell CS074AE Bedienungsanleitung

Honeywell

Honeywell CL152 Bedienungsanleitung

Honeywell

Honeywell TC30PCE Bedienungsanleitung

Honeywell

Honeywell R-MM14CCS Bedienungsanleitung

Honeywell

Honeywell CL30XC Bedienungsanleitung

Honeywell

Honeywell CL610PE Bedienungsanleitung

Honeywell

Honeywell CS074AEKK Bedienungsanleitung

Honeywell

Honeywell CL70PE Bedienungsanleitung

Honeywell

Honeywell CS071AE Bedienungsanleitung

Beliebte Klimaanlage Handbücher anderer Marken

Panasonic

Panasonic CS-E12HKEW Bedienungsanleitung

nedis

nedis ACMB1WT7 Bedienungsanleitung

Daikin

Daikin FCFV50A Bedienungsanleitung

Fujitsu

Fujitsu Inverter ASBA30JFC Bedienungsanleitung

Toshiba

Toshiba RAS-M10SMUV-E Bedienungsanleitung

Daikin

Daikin FXLQ20MAVE Bedienungsanleitung

CIAT

CIAT Magister 2 Series Leitfaden

Bestron

Bestron AAC6000 Bedienungsanleitung

Frigidaire

Frigidaire FFRE0533S1E0 Bedienungsanleitung

Samsung

Samsung AS09HM3N Bedienungsanleitung

Frigidaire

Frigidaire CRA073PU11 Betriebsanleitung

Soleus Air

Soleus Air GB-PAC-08E4 Bedienungsanleitung

McQuay

McQuay MCK020A Bedienungsanleitung

Webasto

Webasto Frigo Top 25 DS Bedienungsanleitung

Frigidaire

Frigidaire FAZ12ES2A Bedienungsanleitung

Mitsubishi Electric

Mitsubishi Electric MSC-GE20VB Bedienungsanleitung

Mitsubishi Electric

Mitsubishi Electric PLA-M100EA Bedienungsanleitung

Daikin

Daikin Split Sensira R32 Bedienungsanleitung