Hoshizaki KM-40B Bedienungsanleitung

(1/13)

Models : KM-40B, KM-55B, KM-80B

- Don't pull the gasket extremely while attach

- If the length of gasket is long, please cut it properly to adjust

No. Figure Note

*Open the Door and Remove the shipping

tapes for taking off the Water Tank

*Remove the Drain Pipe

*Take off the Water Tank by snapping off and

lifting off

*To take off the Water Tank, it should be slid

towards you and lifted down

*Disconnect the Hose to the Pump Motor

outlet

*Cut the cable tie to disconnect the Hose

*Don't cut the Hose

HOW TO REPLACE THE GASKETS

Rework Time : Approx. 35min

(2/13)

Models : KM-40B, KM-55B, KM-80B

- Don't pull the gasket extremely while attach

- If the length of gasket is long, please cut it properly to adjust

No. Figure Note

HOW TO REPLACE THE GASKETS

Rework Time : Approx. 35min

*Disconnect the Hose to the Pump Motor

outlet

*Take off the Bin Control Sw to slide it

towards you

*Bin Control Sw is snapped in on both sides

*Put the Bin Control Sw in the Bin

temporarily

*Close the Door

*Loosen the 2 screws to take off the Top

Panel

*Remove the 5 screws to take off the Rear

Top Panel

(3/13)

Models : KM-40B, KM-55B, KM-80B

- Don't pull the gasket extremely while attach

- If the length of gasket is long, please cut it properly to adjust

No. Figure Note

HOW TO REPLACE THE GASKETS

Rework Time : Approx. 35min

*Remove the 1 screw securing the Pipe Cover

*Remove the Pipe Cover

*Top side is secured by snapping in

*The tab of left bottom side is behind the

front sheet metal

*Take off the Grommet to the Pipe Cover for

Water Supply Tube

*Disconnect the connector of Pump Motor

*Cut the cable tie bundling the wires

(4/13)

Models : KM-40B, KM-55B, KM-80B

- Don't pull the gasket extremely while attach

- If the length of gasket is long, please cut it properly to adjust

No. Figure Note

HOW TO REPLACE THE GASKETS

Rework Time : Approx. 35min

*Cut the cable tie bundling the wires

*Disconnect the connector of Bin Control Sw

*Remove the 1 screw securing the Pump

Motor

*To access the screw, move the refrigeration

pipe above it towards you

*After removing the screw, slide the Pump

Motor in the right side, then lift it up towards

you to take off

*Remove the 2 screws securing the Water

Valve

*To access the bottom screw, the elbow of

the Water Supply Pipe should be slightly

rotated towards you

*Too much rotation would cause water leak

(5/13)

Models : KM-40B, KM-55B, KM-80B

- Don't pull the gasket extremely while attach

- If the length of gasket is long, please cut it properly to adjust

No. Figure Note

HOW TO REPLACE THE GASKETS

Rework Time : Approx. 35min

*Remove the 2 screws securing the Back Side

L shaped Wall

*Remove the 2 screws securing the

Evaporator Brackets

*Snap off the Back Side L shaped Wall on the

top of both sides

*Move the whole Back Side L shaped Wall

towards you

*Remove the lead wire of Bin Control Sw

from the rubber Grommet

(6/13)

Models : KM-40B, KM-55B, KM-80B

- Don't pull the gasket extremely while attach

- If the length of gasket is long, please cut it properly to adjust

No. Figure Note

HOW TO REPLACE THE GASKETS

Rework Time : Approx. 35min

*Remove the Spray Tube

*Move the Water Supply Tube

*Slide off the Evaporator Brackets from the

Back Side L shaped Wall

*Lift up the whole Evaporator Assembly to

reach the Back Side L shaped Wall

*Holding the whole Evaporator Assembly,

then slide up and take off the Back Side L

shaped Wall completely

(7/13)

Models : KM-40B, KM-55B, KM-80B

- Don't pull the gasket extremely while attach

- If the length of gasket is long, please cut it properly to adjust

No. Figure Note

HOW TO REPLACE THE GASKETS

Rework Time : Approx. 35min

GASKETS on the Back Side L shaped Wall

2 pieces

GASKETS on the Bin

1 piece

*Put the whole Evaporator Assembly into the

Bin temporarily

*Remove the Gaskets from the Back Side L

shaped Wall and attach the new Gaskets on

the Back Side L shaped Wall in their original

correct position firmly

*Before removing the gaskets, better to apply

and measure the new gaskets length for

er installation

*Remove the aluminum tape around the top

of the Pipe Cover

(8/13)

Models : KM-40B, KM-55B, KM-80B

- Don't pull the gasket extremely while attach

- If the length of gasket is long, please cut it properly to adjust

No. Figure Note

HOW TO REPLACE THE GASKETS

Rework Time : Approx. 35min

*Remove the Gasket on the Bin and attach

the new Gasket on the Bin in its original

correct position firmly

*Holding the whole Evaporator Assembly,

then slide in and install the Back Side L

shaped Wall in its correct original position

*Move and Place the whole Evaporator

Assembly at the front of the Back Side L

shaped Wall

*Place the top tabs of the both side of the

Back Side L shaped Wall to the Bin

*Secure the 2 screws to install the Back Side

L shaped Wall

(9/13)

Models : KM-40B, KM-55B, KM-80B

- Don't pull the gasket extremely while attach

- If the length of gasket is long, please cut it properly to adjust

No. Figure Note

HOW TO REPLACE THE GASKETS

Rework Time : Approx. 35min

*Install the Pump Motor with the 1 screw in

its original correct position in the reverse

order of the removal procedure

*Put the rubber Grommet under the Pipe

*Install and slide in the Evaporator Brackets

to the Back Side L shaped Wall in its original

correct position in the reverse order of the

removal procedure

*Secure the 2 screws to secure the

Evaporator Brackets

*Relocate the rubber Grommet for Pipe and

lead wire on both side

(10/13)

Models : KM-40B, KM-55B, KM-80B

- Don't pull the gasket extremely while attach

- If the length of gasket is long, please cut it properly to adjust

No. Figure Note

HOW TO REPLACE THE GASKETS

Rework Time : Approx. 35min

*Relocate the Water Supply Tube in its

original correct position

*Reroute the lead wires of Float Sw & Bin

Control Sw

*Connect the connectors of Bin Control Sw &

Pump motor

*Install the Water Valve in its original correct

position in the reverse order of the removal

procedure

*Bundle the lead wires of Bin Control Sw &

Pump Motor

Andere Handbücher für KM-40B

Dieses Handbuch passt für folgende Modelle

Andere Hoshizaki Eiswürfelbereiter Handbücher

Hoshizaki

Hoshizaki DCM-240BAF Bedienungsanleitung

Hoshizaki

Hoshizaki KM-520MAJ-E Bedienungsanleitung

Hoshizaki

Hoshizaki KM-2400SRF3 Bedienungsanleitung

Hoshizaki

Hoshizaki FM-1000ALE Bedienungsanleitung

Hoshizaki

Hoshizaki FS-1001MLH Bedienungsanleitung

Hoshizaki

Hoshizaki KM-901MAH Bedienungsanleitung

Hoshizaki

Hoshizaki KM-901MAH50 Bedienungsanleitung

Hoshizaki

Hoshizaki F-450MAJ-C Bedienungsanleitung

Hoshizaki

Hoshizaki F-1000MAB Bedienungsanleitung

Hoshizaki

Hoshizaki KM-1301SAJ Bedienungsanleitung

Hoshizaki

Hoshizaki KML-450MAF Bedienungsanleitung

Hoshizaki

Hoshizaki C-100BAF-AD Bedienungsanleitung

Hoshizaki

Hoshizaki F-500BAJ Bedienungsanleitung

Hoshizaki

Hoshizaki IM-51BAE Bedienungsanleitung

Hoshizaki

Hoshizaki KM-520MAJ-E Bedienungsanleitung

Hoshizaki

Hoshizaki FD-1001MLH(-C) Bedienungsanleitung

Hoshizaki

Hoshizaki F-450BAB Bedienungsanleitung

Hoshizaki

Hoshizaki KM-630MAE Bedienungsanleitung

Hoshizaki

Hoshizaki KM-1300MAF Bedienungsanleitung

Hoshizaki

Hoshizaki KM-1300SAH Bedienungsanleitung

Hoshizaki

Hoshizaki KMD-210AB-HC Bedienungsanleitung

Hoshizaki

Hoshizaki C-100BAE-AD Bedienungsanleitung

Hoshizaki

Hoshizaki F-450BWB Bedienungsanleitung

Hoshizaki

Hoshizaki KM-500MAE Bedienungsanleitung

Beliebte Eiswürfelbereiter Handbücher anderer Marken

Sub-Zero

Sub-Zero 315I Gebrauchsanweisung

Kenmore

Kenmore 2217402A Bedienungsanleitung

Cornelius

Cornelius WM600 Betriebsanleitung

GE XPIO43SCSS Bedienungsanleitung

Whynter

Whynter FIM-450HA Bedienungsanleitung

U-Line

U-Line UMCR014-SC01A Installationshandbuch

Andrew James

Andrew James AJ000522 Bedienungsanleitung

Scotsman

Scotsman CME1356 Bedienungsanleitung

Scotsman

Scotsman ACM 25 Bedienungsanleitung

Kärcher

Kärcher IP 120 Bedienungsanleitung

U-Line

U-Line SS1095 Bedienungsanleitung

Maytag

Maytag MIM1554WRS - Ice Maker Bedienungsanleitung

Princess

Princess Yonanas Bedienungsanleitung

Unold

Unold 48946 Bedienungsanleitung

Electrolux

Electrolux E15IM60GP Bedienungsanleitung

Cornelius

Cornelius UC150 ICE ONLY Bedienungsanleitung

Wessamat

Wessamat CombiLine W80 EL Bedienungsanleitung

Summit

Summit BIM68OSGDR Bedienungsanleitung