Hussmann ARV-570 Bedienungsanleitung

ARV-570 &

ARV-1230

Owner’s Manual

P/N 0512887_A

1 October 2009

Beer

Merchandiser

P/N0512887A

These merchandisers are manufactured to meet ANSI / National Sanitation Foundation (NSF®) Standard #7Type II requirements. Proper

installation is required to maintain certification. Near the serial plate, each case carries a label identifying the type of application for which the

case was certified.

ANSI/NSF-7 Type II – Display Refrigerator / Freezer ( Beverage Cooler)

Intended for 80°F / 55%RH Ambient Application

This equipment is intended for the storage and display of nonpotentially hazardous, bottled or canned products only.

Hussmann and Safe-NET are trademarks of Hussmann Corporation

EPH

SAFETY FIRST!

Before installing, read and understand the

operating manual. Any damage caused by

not following directions given in this manual

is out-of-warranty.

Contact

To request technical assistance with your

Hussmann Beer Merchandiser, or to place a

service call, please phone Hussmann’s CALL

CENTER • U.S. or Canada 1-800-922-1919 •

Mexico 1-800-522-1900.

LOCATION

Hussmann Beer Merchandisers are designed

for a protected environment, out of direct sun

or rain. Placing the unit near heat sources

(ovens, grills, etc.) or in direct sun will

adversely affect performance. Unusual ambient

conditions can be handled by changing settings

in the Safe-NET™controller. Temperatures

of 80°F (27°C) and less than 55% R.H. are

considered normal ambient conditions.

The merchandiser may not operate properly in

environments of extreme temperature and

humidity [above 90°F (32°C) and 65% relative

humidity]. Performance issues resulting from

poor local conditions are out-of-warranty.

The merchandiser must have a minimum 5-inch

(13 cm) ventilation space at the back, at the

top, on each side, and below the door in front.

P/N 0512887_A — 1 October 2009

Safe-NET software Version 9.03 or later

ARV-570 & ARV-1230

U.S. & CANADA 1-800-922-1919 • MEXICO 1-800-522-1900 • WWW.HUSSMANN.COM Hussmann Beer Merchandiser

ARV-570 & ARV-1230ARV-570 & ARV-1230ARV-570 & ARV-1230ARV-570 & ARV-1230

To reduce the risk of fire, electrical shock or

injury when using your Hussmann Beer

Merchandiser:

• Always use a dedicated circuit with the

Amperage stated on the unit.

• Plug into an outlet designed for the plug.

• Do not use an adapter.

• Do not overload the circuit.

• Disconnect power before servicing.

• Replace any damaged power cord.

• Never turn off by pulling on the power cord.

• Unit must have electrical ground at all times.

• Never connect the ground wire directly to the

neutral wire or connect to gas, water,

telephone, drain pipe, lightning rod, etc.

• Do not damage the refrigeration system.

• Do not use any mechanical device or other

means to speed the defrost process, except

as recommended by the manufacturer.

• Unplug the Hussmann Beer Merchandiser

before cleaning.

• Do not store or use toxic or dangerous

chemical products inside the case.

• Do not use electrical devices in the

Hussmann Beer Merchandiser unless

recommended by the manufacturer.

• Use two or more people to move a unit.

• Keep packing materials away from children.

CAUTION

We reserve the right to change or revise specifications and product design in

connection with any feature of our products. Such changes do not entitle the

buyer to corresponding changes, improvements, additions or replacements

for equipment previously sold or shipped. 5-inch (13 cm) Required Ventilation Minimum

Condensation may form on external parts

when the merchandiser is used in high relative

humidity. Use a soft cloth to remove moisture.

The floor must be flat to facilitate leveling

and to avoid problems with door sealing or

abnormal noises. The floor must support the

weight of a fully loaded merchandiser.

INSPECTION

All equipment should be thoroughly examined

for shipping damage before and during the

unloading.

Each Hussmann Beer Merchandiser is carefully

inspected at our factory. Any claim for loss or

damage must be made to the carrier. The

carrier will provide any necessary inspection

reports and/or claim forms.

Apparent Loss Or Damage

If there is an obvious loss or damage, it must

be noted on the freight bill or express receipt

and signed by the carrier’s agent; otherwise,

carrier may refuse claim.

Concealed Loss Or Damage

When loss or damage is not apparent until after

equipment is uncrated, retain all packing mate-

rials and submit a written request to the carrier

for inspection, within 15 days.

UNCRATE

Use the appropriate equipment to safely lift

and move the Hussmann Beer Merchandiser to

the preferred location in your business.

Carefully remove the shipping box. Avoid

scratching the Hussmann Beer Merchandiser.

Recycle packing materials whenever possible.

Models with Wheels: ARV models have wheels

that make moving easier. The pallet is held by

lateral tabs which are easily removed.

BUILT-IN BACK SPACERS

The ARV-570 and ARV-1230 have LH and RH

hinged spacers to promote ventilation at the

back of the units. Be sure to unfold each before

placing unit against wall or other structure.

Safe-NET software Version 9.03 or later

1 October 2009 — P/N 0512887_A

ARV-570 & ARV-1230 ARV-570 & ARV-1230

U.S. & CANADA 1-800-922-1919 • MEXICO 1-800-522-1900 • WWW.HUSSMANN.COM

ARV-570 & ARV-1230

P/N 0512887_A — 1 October 2009

Safe-NET software Version 9.03 or later

ARV-570 & ARV-1230

U.S. & CANADA 1-800-922-1919 • MEXICO 1-800-522-1900 • WWW.HUSSMANN.COM Hussmann Beer Merchandiser

ARV-570 & ARV-1230ARV-570 & ARV-1230ARV-570 & ARV-1230ARV-570 & ARV-1230

LEVEL

Merchandisers must be level front-to-back and

side-to-side to operate at peak efficiency.

For Hussmann Beer Merchandisers with

rollers, first lock the front corner wheels by

turning the thumb screws clock-wise.

Carefully lift the unit to insert shims as needed

to prevent the chamber from rolling or tilting.

Thumbscrew locks are packed in an envelope

inside the merchandiser. Be sure to unpack the

thumbscrew locks and insert them into the front

corner wheels to prevent unplanned movement of

the Hussmann Beer Merchandiser.

IMPORTANT:

After leveling, wait at least 30 minutes before

turning on power to the Hussmann Beer

Merchandiser to allow any oil residue to

return to the compressor. Oil not in the

compressor at start up may cause permanent

damage not covered by warranty.

Thumbscrew Lock

Turn Thumbscrew clockwise

until it stops wheel from moving.

Safe-NET software Version 9.03 or later

1 October 2009 — P/N 0512887_A

ARV-570 & ARV-1230 ARV-570 & ARV-1230ARV-570& ARV-1230 ARV-570 & ARV-1230ARV-570 & ARV-1230 ARV-570& ARV-1230

PLUG IN

Put the Hussmann Beer Merchandiser on its

own dedicated electrical circuit with ground.

12AWG is the minimum size wire acceptable.

• The ARV-570 requires a dedicated 15 Amp

circuit with grounded wall receptacle

(NEMA 5-15P)

• The ARV-1230 double door Hussmann Beer

Merchandiser requires a dedicated 20 Amp

circuit with a special wall receptacle

(NEMA 5-20P).

• Do not use extension cords. Never use

adapters.

• If in doubt, call an electrician.

Electrical requirements for the merchandiser

are stated on the serial plate attached to the

unit.

If the power supply oscillates beyond the range

given in the preceding table, install a voltage

regulator:

Light Switch

Hussmann Beer Merchandiser light switches

are located on the top right side of the interior.

INSTALL SHELVES

ARV-570 – Four rows of flat shelves,

OR Five rows of flat wire shelves,

OR Four rows of gravity feed shelves

with product guides.

ARV-1230 – Four rows of flat wire shelves,

OR Five rows of flat wire shelves.

Metal shelf clips fit into slotted strips in the

interior on each side at the front and back of

the cooler. Each shelf requires four shelf clips.

ARV-570 & ARV-1230

U.S. & CANADA 1-800-922-1919 • MEXICO 1-800-522-1900 • WWW.HUSSMANN.COM

NEMA 5-15P

ARV-570

NEMA 5-20P

ARV-1230

ARV-570 ARV-1230

1500 VA 3000 VA

Nominal

Voltage

Minimum

Voltage

Maximum

Voltage

120 108 132

Bottom Shelf

Slotted Strips

Place Clips

on Both Sides

of Chamber

SHELF PART NUMBERS

ARV-570

Flat Shelf (2/pkg) SH.4968432 1

Gravity Feed Shelf (each) SH.7960665

ARV-1230

Flat Shelf - Left (each) SH.4978748

Flat Shelf - Right (each) SH.4978751

Light switches

1. Begin with the first shelf at the bottom of

the Hussmann Beer Merchandiser.

2. Insert one end of the shelf clip into the

upper slot and gently squeeze the clip to insert

into the slot below.

ARV-570: For gravity feed shelves with guides

ONLY, position the rear shelf clips seven slots

above the front shelf clips, according to the

marks on the mounting strips.

For flat wire shelves, position shelf clips at the

same slot in all four mounting strips for each

shelf.

3. Position the wire display shelf on top of the

four shelf clips before beginning the next shelf.

The product stop goes to the rear for flat

shelves. The ARV-1230 shelves have product

stops toward the center of the merchandiser.

4. Use the bracket numbering on each side to

guide placement of shelves. Shelves must be

spaced evenly, allowing a minimum of 2-in.

between the top of bottles and the shelf above

to ensure airflow.

ARV-570 & ARV-1230

P/N 0512887_A — 1 October 2009

Safe-NET software Version 9.03 or later

ARV-570 & ARV-1230

U.S. & CANADA 1-800-922-1919 • MEXICO 1-800-522-1900 • WWW.HUSSMANN.COM Hussmann Beer Merchandiser

ARV-570 & ARV-1230ARV-570 & ARV-1230ARV-570 & ARV-1230ARV-570 & ARV-1230

ARV-1230 Shelves

Front

Left Right

Position

Gravity Feed

Shelf

Offset

to Front

Position

Flat Wire

Shelf On

Shelf Clip

DOOR TORQUE ADJUSTMENT

Check the torque by opening the door 45° then

releasing it. The door must close and seal com-

pletely. If it does not seal, adjust as follows:

1. Place one wrench each on the two lower

support nuts.

2. Loosen the lower nut while holding the

upper nut in place.

3. Once the lower nut is loose, the upper nut

can be rotated away from the hinge to increase

torque or toward the hinge to decrease torque.

4. Once torque is adjusted, hold the upper nut

in place while tightening the lower nut.

AUXILIARY RECEPTACLE

There is an auxiliary 110V plug receptacle

(female) on the back of the unit near the top to

allow retailers to use an auxiliary lighted sign.

This plug is limited to 1A for ARV-1230 and

3A for ARV-570, and should not be used for

anything other than a lighted sign requiring the

stated Amperage or less. The plug is protected

by a separate fuse. The fuse can be replaced

with a like fuse available at hardware stores or

automotive parts retailers, as well as through

Hussmann Service. For access to the fuse

holder, carefully push the cover to the right to

clear the flange, then pull and rotate out.

Safe-NET software Version 9.03 or later

1 October 2009 — P/N 0512887_A

ARV-570 & ARV-1230

U.S. & CANADA 1-800-922-1919 • MEXICO 1-800-522-1900 • WWW.HUSSMANN.COM

ARV-1230

Use 1A fuse only. Use of higher rated fuse

invalidates the warranty and may lead to fire.

ARV-570

Use 3A fuse only. Use of higher rated fuse

invalidates the warranty and may lead to fire.

WARNING

Auxiliary Outlet

Fuse Box and Cover

View from Back of Chamber

Fuse

Outlet

Spacer

SET Safe-NET TIME

Safe-NET is the electronic controller that

regulates the cooling system. Before Safe-NET

can operate correctly, the internal clock must

be set. This will allow it to regulate the system

for defrost at convenient times of the day

around your location’s schedule — when you

are not at the busiest serving times.

The Hussmann Beer Merchandiser’s Safe-NET

comes preset with two defrosts per day. In most

situations this will be enough defrosts unless

the unit is operated in non-air conditioned

environments or high humidity locations.

The Safe-NET on ARV models is located

behind the front grille below the merchandiser

door. Unplug the unit, then lift the grille and

bring it forward off the rivet heads. (The ARV-

570 front grille is held with screws at the side.

The ARV-1230 front grille is held with pins.)

When power is first applied, the Safe-NET dis-

play will show the version of software installed.

The initial scroll is as follows: Safe — -Net

— 9.03(1) (Version) — C570 (Case Model) [OR

C123 FOR TWO DOORS] — 75(2) (temperature of

air entering the evaporator).

(1) The Version will change dependent on

current version installed.

(2) The temperature of air entering the evapo-

rator depends on surrounding ambient

temperature and the amount of time the case

has been running.

• Open the Safe-NET controller using a small

flat blade screwdriver to pop off the oval cover

(this may be tight).

• Plug in the ARV models. Be careful of

moving parts in the compressor compartment.

• You will see three buttons on the control

board as shown in this photo.

The SELECT button is used to view EASY

menu, and to edit/confirm values. Use the UP

or DOWN button to move to the next item in

the menu or change the value of a parameter.

P/N 0512887_A — 1 October 2009

Safe-NET software Version 9.03 or later

ARV-570 & ARV-1230ARV-570 & ARV-1230ARV-570 & ARV-1230ARV-570 & ARV-1230ARV-570 & ARV-1230ARV-570 & ARV-1230

U.S. & CANADA 1-800-922-1919 • MEXICO 1-800-522-1900 • WWW.HUSSMANN.COM Hussmann Beer Merchandiser

ARV-570 & ARV-1230

SELECT

Button

DOWN

Button

ARV-1230

Three Button Rules (Software Version 9.03 or later)

• Always start by pushing and releasing the

SELECT button to display EASy.

• Press and release the SELECT button until

you are in the proper menu. Once in the proper

menu press the UP or DOWN button to enter

the menu and to scroll through the menu.

• Once at the menu item that you want, press

the SELECT button until the item flashes

between the value and the title. You may have

to press the SELECT button more than once

to get the item to flash.

• Then press the UP or DOWN button to

change the item.

• Remember to push the SELECT button to

save the item.

• Pressing the UP and DOWN buttons at the

same time acts as an escape to go back out of

the menus.

Set the Clock

The Safe-NET clock can be adjusted so that

the defrosts are set to avoid the busiest serving

times.

• Press the SELECT button — EASy is

displayed.

• Press the DOWN button until you see

CLOC.

• Press SELECT and the MINUTES begin to

flash.

• With minutes flashing, use the UP or DOWN

button until the correct minutes are displayed,

then press SELECT. The HOURS begin to

flash.

• With hours flashing, use the UP or DOWN

button until the correct hour is displayed

(Safe-NET uses a 24-hour, or military, clock

where 12 is noon).

• Press SELECT and the clock has been set.

• The clock will automatically return to main

display. Hussmann offers an optional real-time

clock which will retain its time setting for at

least one week if unplugged.

Replace the Display Cover.

Important: The clock does not automatically

adjust for Daylight Saving Time. If defrost

times are critical, the clock must be reset

manually.

Safe-NET software Version 9.03 or later

1 October 2009 — P/N 0512887_A

ARV-570 & ARV-1230

U.S. & CANADA 1-800-922-1919 • MEXICO 1-800-522-1900 • WWW.HUSSMANN.COM

Safe-NET software Version 9.03 or later

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Hussmann Kaufmann Handbücher

Hussmann

Hussmann GC Bedienungsanleitung

Hussmann

Hussmann IMPACT C6LRE Bedienungsanleitung

Hussmann

Hussmann M1X-GEP Bedienungsanleitung

Hussmann

Hussmann RI4-E Bedienungsanleitung

Hussmann

Hussmann Specialty Products CR3TO Bedienungsanleitung

Hussmann

Hussmann RED Bedienungsanleitung

Hussmann

Hussmann RI2-E Bedienungsanleitung

Hussmann

Hussmann MWG Bedienungsanleitung

Hussmann

Hussmann SMGT Bedienungsanleitung

Hussmann

Hussmann M1XD-E Bedienungsanleitung

Hussmann

Hussmann Impact D5EE Bedienungsanleitung

Hussmann

Hussmann BEXD Bedienungsanleitung

Hussmann

Hussmann Specialty Products CR3HTO-HTB Bedienungsanleitung

Hussmann

Hussmann Q3-M/FV-EP Bedienungsanleitung

Hussmann

Hussmann Impact C5NLE Bedienungsanleitung

Hussmann

Hussmann Specialty Products CR3HV-F Bedienungsanleitung

Hussmann

Hussmann APT0500 Kurzanleitung

Hussmann

Hussmann DM Bedienungsanleitung

Hussmann

Hussmann M5NX-GEP Bedienungsanleitung

Hussmann

Hussmann Impact C2-XGE Bedienungsanleitung

Hussmann

Hussmann CRFD Bedienungsanleitung

Hussmann

Hussmann MAXI- Bedienungsanleitung

Hussmann

Hussmann FI Bedienungsanleitung

Hussmann

Hussmann D5X-HEP Bedienungsanleitung

Beliebte Kaufmann Handbücher anderer Marken

FRIGOGLASS

FRIGOGLASS Flex 20 HC Bedienungsanleitung

EPTA

EPTA COSTAN RHINO MULTI Bedienungsanleitung

CASCO

CASCO Nano Cube Bedienungsanleitung

True

True GDIM-26 Bedienungsanleitung

Structural Concepts

Structural Concepts Oasis Mobile Series Montageanleitung

Haussmann

Haussmann RL Bedienungsanleitung

Howard McCray

Howard McCray R-CDS32E-4 Bedienungsanleitung

EPTA

EPTA iarp Cool Emotions Delight Lite Bedienungsanleitung

VALERA

VALERA BC 85 Bedienungsanleitung

HL Display

HL Display 3eBin Bedienungsanleitung

Dixie Narco

Dixie Narco DNCB 501E Bedienungsanleitung

APW Wyott

APW Wyott Racer DMXD-30H Bedienungsanleitung

Hoshizaki

Hoshizaki KD-90C Bedienungsanleitung

Summit

Summit SCR1006 Bedienungsanleitung

Delfield

Delfield Shelleyspeed SPM-28E Bedienungsanleitung

EPTA

EPTA iarp Cool Emotions GLEE 40 Bedienungsanleitung

Kysor/Warren

Kysor/Warren GranBering KW Leitfaden

Crane

Crane BevMAX Refresh 6 Media Bedienungsanleitung