Hussmann IMPACT D5RRI Kurzanleitung

HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.

P/N 0435047

January, 2003

D5RRI and D5RRIS

Rear Roll-in Dairy

Joining Instruction

Merchandisers

PARTS LIST

Item Quantity Description

D5RRI D5RRIS

1. 1 1 Gasket 1/2x 1/2x 60 (1524 mm)

2. 1 1 Gasket 1/2x 15/8x 120 (3048 mm)

3. 9 5 Cap Screw 5/16 -18 x 11/4

4. 9 5 Lock Washer 5/16

5. 9 5 Flat Washer 5/16

6. 1 1 Threaded Rod 1/2-16 x 12 (305 mm)

7. 2 2 Flat Washer 1/2

8. 2 2 Hex Nut 1/2-16

9. 1 1 Silicone Sealer

Note: Nut retainers are factory installed in the left end, and alignment pins are factory installed in

the right end of each merchandiser.

NOTES:

• Be sure merchandisers have been

leveled according to the installation

instructions.

• Be sure factory-installed nut

retainers and alignment pins are in

place.

• Install optional shelf kits after all

merchandisers have been joined.

1Remove front air grille and

honeycomb from the right end

as shown in Figure 1.

Right Front

Air Grille

Right Front

Honeycomb

Figure 1. Remove Air Grille and Honeycomb

D5RRI

D5RRIS

2Verify that nut retainers and

alignment pins are installed in

the right-hand end of the left

case in the locations shown in

Figure 2.

P/N 0435047

Merchandisers

2HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.

Alignment Pins

Figure 2. Verify Nut Retainer and Alignment Pin Installation

3Apply Gasket – 1 along the

center of the lower assembly.

Apply Gasket – 2 to cover

foam-to-metal gap at rear and

across top as shown in Figure 3.

Lap gaskets at lower corners.

Check that there are no gaps

between gasket and case.

• Do not stretch gasket,

especially around corners.

• Do not butt gaskets; always lap

joints.

• Remove paper backing after

gasket is applied.

Joining Instruction for D5RRI and D5RRIS

Rear Roll-in Dairy Merchandisers P/N 0435047

HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.

Optional

Low Front

Standard

Note: Case To Be

Sealed And

Gasketed As Shown

11/2in. x 1/2x 60

1/2in. x 15/8x 120

Figure 3. Apply Gaskets

Optional

Low Front Standard Front

D5RRI

D5RRIS

4Move second merchandiser

against first, mating alignment

pins with corresponding holes.

5Fasten fronts together using

Cap Screw – 3,

Flat Washers – 4, and

LockWashers – 5 as shown in

Figure 4. Tighten only until front

panels touch. Do not tighten

fully.

6Use Cap Screws – 3 with

Flat Washers – 4 and

Lock Washers – 5 to draw

merchandisers together at rear.

Start at the bottom, then middle,

then top; tighten until gaskets are

compressed.

P/N 0435047

Merchandisers

4HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.

Alignment

Pins

Nut Retainer

9 Places for D5RRI and

5 Places for D5RRIS

Figure 4. Joining Ends

7Draw canopies together using

Rod – 6 through top shoe, and

Washers – 7, and Nuts – 8

on each end of rod as illustrated

in Figure 5. Stop when canopies

touch.

8Apply a bead of Silicone – 9

to the joined merchandisers as

shown in Figure 6. When dry,

replace honeycomb.

Joining Instruction for D5RRI and D5RRIS

Rear Roll-in Dairy Merchandisers P/N 0435047

HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.

876

Silicone Gun

Silicone Gun Apply Silicone Bead

Apply Silicone Bead

D5RRI

D5RRIS

Figure 5. Canopy Joining

Figure 6. Applying Silicone

Andere Handbücher für IMPACT D5RRI

Dieses Handbuch passt für folgende Modelle

Andere Hussmann Kaufmann Handbücher

Hussmann

Hussmann Impact Excel B3XC-LEP Bedienungsanleitung

Hussmann

Hussmann impact Excel C2X-LGE Bedienungsanleitung

Hussmann

Hussmann IMPACT Excel D6X-ULEP Bedienungsanleitung

Hussmann

Hussmann C2X-XEP Bedienungsanleitung

Hussmann

Hussmann C2-LE Bedienungsanleitung

Hussmann

Hussmann VR3-M Series Bedienungsanleitung

Hussmann

Hussmann Impact PW 12 Bedienungsanleitung

Hussmann

Hussmann JVMRS Bedienungsanleitung

Hussmann

Hussmann FW Bedienungsanleitung

Hussmann

Hussmann Impact Excel C6X-EP Bedienungsanleitung

Hussmann

Hussmann DSF Bedienungsanleitung

Hussmann

Hussmann RGD Bedienungsanleitung

Hussmann

Hussmann NDD5 Bedienungsanleitung

Hussmann

Hussmann IMPACT LWG Bedienungsanleitung

Hussmann

Hussmann SMG Bedienungsanleitung

Hussmann

Hussmann C4XRO-E Bedienungsanleitung

Hussmann

Hussmann D5X-HEP Bedienungsanleitung

Hussmann

Hussmann IMPACT Excel B1X-GE Bedienungsanleitung

Hussmann

Hussmann NEBCH Bedienungsanleitung

Hussmann

Hussmann NAV-4 Bedienungsanleitung

Hussmann

Hussmann IMPACT LWU Bedienungsanleitung

Hussmann

Hussmann RL2W Bedienungsanleitung

Hussmann

Hussmann IMPACT P2NE Bedienungsanleitung

Hussmann

Hussmann GC Bedienungsanleitung

Beliebte Kaufmann Handbücher anderer Marken

FRIGOGLASS

FRIGOGLASS Flex 20 HC Bedienungsanleitung

EPTA

EPTA COSTAN RHINO MULTI Bedienungsanleitung

CASCO

CASCO Nano Cube Bedienungsanleitung

True

True GDIM-26 Bedienungsanleitung

Structural Concepts

Structural Concepts Oasis Mobile Series Montageanleitung

Haussmann

Haussmann RL Bedienungsanleitung

Howard McCray

Howard McCray R-CDS32E-4 Bedienungsanleitung

EPTA

EPTA iarp Cool Emotions Delight Lite Bedienungsanleitung

VALERA

VALERA BC 85 Bedienungsanleitung

HL Display

HL Display 3eBin Bedienungsanleitung

Dixie Narco

Dixie Narco DNCB 501E Bedienungsanleitung

APW Wyott

APW Wyott Racer DMXD-30H Bedienungsanleitung

Hoshizaki

Hoshizaki KD-90C Bedienungsanleitung

Summit

Summit SCR1006 Bedienungsanleitung

Delfield

Delfield Shelleyspeed SPM-28E Bedienungsanleitung

EPTA

EPTA iarp Cool Emotions GLEE 40 Bedienungsanleitung

Kysor/Warren

Kysor/Warren GranBering KW Leitfaden

Crane

Crane BevMAX Refresh 6 Media Bedienungsanleitung